Reynolds Building Systems Best Barns Springfield Safety guide

!"#$%&'()'*%#$%+,-./#0"1234%5(32/%1"2%+,-./#0"1%*'6$7%1"#$%&'()'*
&'.%(,1%82%+,-#237%#(%6",*2%,/%#(%-'/17%6#1",)1%+,($2(1%9/,&%:2.(,*3$
;)#*3#(0%<.$12&$7%=(+4 >%%?,-./#0"1%@ABC
the Springfield
Revised March 05, 2021
Assembly Book
Best Barns USA
;)#*3#(0%<#D2
B@E%F%@GE
Manufactured by Reynolds Building Systems, Inc.
205 Arlington Drive Greenville, PA 16125

Tongue Edge
LAP Edge
800-245-1577%H%I,(%H%J/#%CKI%H%LMI%N<!
724-866-4357%H%K912/%",)/$%'(3%622O2(3$
Email%H%P)2$1#,($Q8'/(O#1$4+,&
IMPORTANT INFORMATION ABOUT YOUR KIT
!"'(O%.,)%9,/%-)/+"'$#(0%,)/%O#14%M*2'$2%/2'3%1"2%9,**,6#(0%#(9,/&'1#,(%829,/2%820#((#(0%+,($1/)+1#,(4
K*6'.$%+"2+O%6#1"%.,)/%*,+'*%RSK%,/%8)#*3#(0%+,32%,99#+2%9,/%'(.%/2P)#/2&2(1$%,/%/2$1/#+1#,($4
!,,*$%:2P)#/23T R'(3%,/%?#/+)*'/%<'6
?,/3*2$$%U/#**
R'&&2/
M2(+#*
V2W2*
I2'$)/#(0%!'-2
XEHCE%V'332/Y$Z
<'921.%[*'$$2$
U)$1%I'$O
M"#**#-$%<+/263/#W2/
J/'&#(0%<P)'/2
Always wear safety glasses when cutting or nailing!
K33#1#,('*%I'12/#'*$%H%Not included in kit:
:2P)#/23T <"#(0*2$%,/%&21'*%/,,9#(07%U/#-%N3027%:,,9#(0%\'#*$%,/%<+/26$7%M'#(1
S-1#,('*T ?')*O7%:#302%]2(1
J*,,/T ^,,3%9*,,/#(0%#$%$,*3%,-1#,('**.4%_,)%&'.%+",,$2%1,%8)#*3%.,)/%,6(%,/%-,)/%'%+2&2(1%-'34
!2/&#(,*,0.T
<P)'/2%H%?,(9#/&%+,/(2/$%'/2%'1%`A%320/22$
M*)&8%H%?,(9#/&%6'**$%'(3%1/)$$2$%'/2%$1/'#0"1%W2/1#+'**.
^'**%M*'12%H%!,-%'(3%8,11,&%@FG$%)$23%1,%9/'&2%6'**$
!#2%M*'12%H%@FG$%+,((2+1#(0%6'**%$2+1#,($%1,021"2/
R2'32/%H%<-'($%1,-%,9%3,,/%,-2(#(0
S<;%H%S/#2(123%<1/'(3%;,'/3
VKM%H%N302%,9%$#3#(0%1"'1%,W2/*'-$%!,(0)2
!,(0)2%H%N302%,9%$#3#(0%1"'1%#$%,W2/*'--23
S/0'(#D2T
5(-'+O%'**%#12&$%a%,/0'(#D2%'++,/3#(0%1,%$#D2%'(3%1.-24%!"#$%6#**%&'O2%#12&$%2'$#2/%1,%9#(3
6"2(%#($1/)+1234
:2W#26%1"2%-'/1$%*#$1%,(%1"2%8'+O%-'024%<",)*3%1"2/2%82%&#$$#(0%#12&$%,/%$)8H-'/%&'12/#'*
+,(1'+1%;2$1%;'/($%?)$1,&2/%<2/W#+24
US%\S!%3#$+'/3%'(.%&'12/#'*%#(+*)3#(0%1"2%-'**21%)(1#*%.,)/%-/,b2+1%#$%+,&-*2124
K$$2&8*.T
:2W#26%'**%#($1/)+1#,($%829,/2%.,)%820#(4%M*2'$2%9,**,6%$12-$%+'/29)**.%'(3%#(%$2P)2(+2%9,/
$)++2$$9)*%/2$)*1$4
=9%.,)%"'W2%'(.%P)2$1#,($%62%'/2%"'--.%1,%'$$#$1%.,)4%M*2'$2%+,(1'+1%)$%'1T
Primed Siding Detail

@4 ?)1%YBAZ%12(%@FGHB@E%9*,,/%b,#$1%1,%BBEH`c4%Treated lumber may be thicker than 1-1/2". Take this
into account when cutting the length of floor joists. Shorten the joist measurements if necessary
to obtain 12'-0" building width.
d4 M*'+2%GFGHB@E%1/2'123%1#&82/$%,(%1"2%0/,)(34%?)1%Y@Z%16,%@FGHCE%8,'/3$%#(1,%@E%*,(0%8*,+O$%1,
$2+)/2%1"2%GFG$%6"2/2%1"2.%8)11%1,021"2/4
Assembly Instructions for Rear Floor Section
XXXX
XXXX
X
X
G4 =($1'**%1"2%9*,,/%b,#$1$%+)1%'8,W2%821622(%1"2%B@E%b,#$1%"2'32/$4%<2+)/2%6#1"%BX3%0'*W4%32+O%('#*$4
L4 M*'+2%9*,,/%$2+1#,($%,W2/%1"2%GFG$4%<P)'/2%9*,,/4%I2'$)/2%1"2%9*,,/%3#'0,('**.%Y+,/(2/%1,%+,/(2/Z4
!"2$2%&2'$)/2&2(1$%6#**%82%1"2%$'&2%#9%1"2%9*,,/%#$%$P)'/2%Y@AdHLeCcZ4%!,%O22-%1"2%@FG%9/'&2
9/,&%&,W#(07%1,2('#*%9/'&2%1,%1"2%GFG%/)((2/$4
4x4-12' Treated
Runner
4x8 Flooring
2x4-12' Joist Header
4x4-12' Treated
Runner
Foundation size is 12'-0" x 24'-0".%?"2+O%*,+'*%8)#*3#(0%+,32$%#(%.,)/%'/2'7%1"2%+,($1/)+1#,(%&'.
"'W2%1,%+"'(024%J,/%'%+,(+/212%$*'87%#($1'**%$#**%$2'*2/%'$%'%&,#$1)/2%8'//#2/%821622(%1"2%+,(+/212%'(3
1"2%6'**%-*'12$4%J,'&%$#**%$2'*2/%+'(%82%-)/+"'$23%'1%",&2%+2(12/$%#(%/,**$%dHBe@c%,/%6#32/4
B4 ?)1%Y@Z%16,%@FGHB@E%1,%'%*2(01"%,9%B@E%HAc4%!"2.
6#**%82%)$23%9,/%1"2%b,#$1%"2'32/$4%V'.,)17%9/,&
1"2%*2917%9,/%BXc%,(%+2(12/%b,#$1%$-'+#(04%!"2%EfE
&'/O$%6"2/2%9*,,/%b,#$1%6#**%82%-*'+234
X4 :2-2'1%$12-%()&82/%B%'(3%@%'8,W2%'(3%'$$2&8*2
'(,1"2/%9*,,/%$2+1#,(4
g4 =($1'**%1"#$%$2+1#,(%'0'#($1%1"2%9/,(1%9*,,/%$2+1#,(4
\'#*%1,021"2/%6#1"%BX3%0'*W4%32+O%('#*$4
C4 =($1'**%GFC%9*,,/#(0%,W2/%1"2%@FG$4%5$2%C3%0'*W4
$-#/'*%('#*$4
Details for Optional Deluxe Floor System
Material Description 12' x 24'
@FG ;*,+O$ @%-+$4 CE
@FG h,#$1%R2'32/$ G%-+$4 B@E
@FG J*,,/%h,#$1 @A%-+$4 B@E
GFG !/2'123%:)((2/$ C%-+$4 B@E
J*,,/#(0%%%%LeCc%,/%deGc `%-+$4 GFC
<+/26%J*,,/%\'#*$ G%*84 C3
['*W4%;,F%\'#*$ L%*84 BX3
2x4-2' Treated
Blocks
Front Floor Section
15-1/4" 16" 16" 16"

X
X
X
X
X
X
X
X
Depending on your location pre-cut wall studs vary in
length from 92-1/4" to 93". This doesn't affect construction.
Step 1 Assemble 12' Back Wall
LAP
Edge
d4 <P)'/2%6'**%9/'&24%I2'$)/2%1"2%6'**%3#'0,('**.%Y+,/(2/%1,%+,/(2/Z4%!"2(%&2'$)/2
1"2%,--,$#12%+,/(2/$4%!"2$2%&2'$)/2&2(1$%6#**%82%1"2%$'&2%#9%1"2%6'**%#$%$P)'/24
24"
23-1/4"
BGGc Wall Plate
24"
144" Wall Plate
Pre-Cut Wall Studs
@4 =($1'**%YgZ%$2W2(%-/2H+)1%6'**%$1)3$%821622(%1"2%1,-%a%8,11,&%-*'12$4
\'#*%$1)3$%1,%6'**%-*'12$%6#1"%BA3%$#(O2/$7%Y@Z%16,%('#*$%,(%2'+"%2(34!
L4 =($1'**%Y@Z%16,%&,/2%$#3#(0%-'(2*$4%=9%(2+2$$'/.
+)1%1"2%*'$1%-'(2*%9*)$"%6#1"%1"2%2(3%,9%1"2%9/'&24
G4 =($1'**%1"2%9#/$1%$#3#(0%-'(2*%6#1"%1"2%EVKME%2302%9*)$"%6#1"
1"2%2(3%,9%1"2%6'**4%<#3#(0%6#**%2F12(3%deGc%82*,6%1"2%8,11,&
-*'124%\'#*%$#3#(0%6#1"%X3%0'*W4%('#*$7%$-'+23%Cc%'-'/14
Tip: use a 1x4 trim board as a gauge.
Siding Extends 3/4" Below Plate
Siding Flush
B4 ?)1%Y@Z%16,%@FGHB@E%1,%'%*2(01"%,9
BGGc4%M,$#1#,(%1"2%8,'/3$%1,021"2/%'(3
#(3#+'12%6#1"%EfE%%&'/O$%6"2/2%1"2
6'**%$1)3$%6#**%82%*,+'1234

T
T
T
T
T
T
XX
XX
X
X
C
X
X
Stud Spacing
Step 3 Assemble Door Header
76-1/2" Long 2x8
48" OSB Filler
Cut OSB to fit
B4 V,+'12%Y@Z%16,%@FCHCE%8,'/3$4%?)1%1"2$2%8,'/3$%1,%'%*2(01"%,9%gXHBe@c4
@4 K$$2&8*2%1"2%3,,/%"2'32/%)$#(0%@FC%8,'/3$%'(3%Y@Z%16,%gHBeGc%F%GCc%S<;%9#**2/%#(+*)323%#(
,)/%O#14%K--*.%6,,3%0*)2%1,%8,1"%$#32$%,9%S<;%'(3%#($1'**%YBZ%,(2%9#**2/%1,%,(2%2(34%?)1%1,%9#1
$2+,(3%S<;%9#**2/4%\'#*%1,021"2/%6#1"%YB@Z%162*W2%BA3%$#(O2/$%$-'+23%2W2(*.%,(%2'+"%$#324
Step 2 Assemble 140-1/2" Side Walls
G4 :2-2'1%1,%'$$2&8*2%YdZ%1"/22%&,/2%BGAHBe@c%*,(0%6'**%9/'&2$4%!"2%$#3#(0%6#**%82%'--*#23%'912/
1"2%6'**$%'/2%$21%,(%1"2%9*,,/4
d4 =($1'**%YgZ%$2W2(%-/2H+)1%6'**%$1)3$
821622(%1"2%1,-%a%8,11,&%-*'12$
6#1"%BA3%$#(O2/$4
%BGAHBe@c Wall Plates
24"
19-3/4" 24"
Top Wall Plate
Bottom Plate
C
140-1/2" Wall Plate
Pre-Cut
Wall Studs
B4 ?)1%Y@Z%16,%@FGHB@E%1,%'%*2(01"%,9%BGAHBe@c4%M,$#1#,(%1"2%8,'/3$%1,021"2/%'(3%#(3#+'12%6#1"%EfE
&'/O$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234
@4 I'/O%'%E?E%'(.6"2/2%821622(%9#/$1%16,%$1)3%&'/O$4%!"#$%#$%/292/2(+23%#(%'%*'12/%$12-4

X
X
X
X
X
X
X
X
X
X
X
X
Step 4 Assemble Front Wall Frame
C4 =($1'**%'%9)**%6#31"%$#3#(0%-'(2*%,(%1"2%/#0"1%$#32%,9
1"2%6'**%-'(2*4%?)1%$#3#(0%'$%-/2W#,)$*.%#($1/)+1234
X4 M*'+2%'%9)**%6#31"%$#3#(0%-'(2*%6#1"%1"2%EVKME%2302%9*)$"%6#1"%*291%$#32%,9%6'**%9/'&24%<#3#(0
$",)*3%2F12(3%deGc%82*,6%8,11,&%-*'124%;29,/2%('#*#(0%$#3#(07%+)1%1"2%$#3#(0%9*)$"%6#1"%1"2%$#32
,9%1"2%3,,/%,-2(#(0%'(3%deGc%82*,6%1"2%3,,/%"2'32/4
g4 =($1'**%'%@AcFGCc%$#3#(0%-'(2*%'8,W2%1"2%3,,/%,-2(#(04%!"#$%$#3#(0%&)$1%2F12(3%deGc%82*,6%1"2
3,,/%"2'32/4%!,-%,9%$#3#(0%&#0"1%(,1%82%2W2(%6#1"%*291%,/%/#0"1%$#3#(04
Cut Siding Flush
With Door Opening
Siding Extends 3/4"
Below Header
Siding Extends 3/4" Below Plate
2x8 Door Header
75-1/2" Header Support
nail nail
B4 ?)1%Y@Z%16,%@FGHB@E%8,'/3$%1,%'%*2(01"%,9%BGGc%9,/%6'**%-*'12$4%M,$#1#,(%1"2%8,'/3$%1,021"2/%'(3
#(3#+'12%6#1"%EfE%I'/O$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234
d4 ?)1%Y@Z%16,%-/2H+)1%$1)3$%1,
'%*2(01"%,9%gLHBe@c%'(3%#($1'**
'$%"2'32/%$)--,/1$4%\'#*%1,
$1)3$%6#1"%BA3%$#(O2/$4
G4 =($1'**%1"2%3,,/%"2'32/%,(%1"2
@FG%"2'32/%$)--,/1$4%\'#*%1,
1"2%$1)3%6#1"%BA3%$#(O2/$4
L4 :2&,W2%'%@FG%$+/2623%1,%1"2
-'**214%I2'$)/2%$-'+2%821622(
"2'32/%'(3%1,-%-*'124%?)1%YGZ
9,)/%-#2+2$%1,%1"#$%*2(01"4
NW2(*.%$-'+2%-#2+2$%'(3%('#*
1"/,)0"%1,-%-*'12%'(3%1,2('#*
1,%"2'32/4%5$2%BA3%$#(O2/$4
Install these Studs Centered
2x4 Blocks
@4 =($1'**%YXZ%$#F%-/2H+)1%6'**%$1)3$%821622(%1"2%6'**%-*'12$%6"2/2%$",6(4
32-1/4" 32-1/4"
73-1/2" Between Header Supports

Temporary Nails
EndMarked 'C'
EndMarked 'C'
End Marked 'C'
Tip:%%If you are erectingbuilding on a wood floor insert
nails between the 3/4" floor sheathing and the 2x4 floor
frame. Rest the siding on the nails while nailing to frame.
B4 N/2+1%8'+O%6'**%'(3%BGAHBe@c%$#32%6'**$4%IMPORTANTT%=($1'**%1"2%$#32%6'**%9/'&2$%6#1"%1"2
E?E%&'/O$%,/#2(123%'0'#($1%1"2%8'+O%'(3%9/,(1%6'**%+,/(2/$4%<2+)/2%6'**$%1,021"2/%'1%1"2%+,/(2/$4
5$2%YGZ%9,)/%BA3%$#(O2/$%-2/%+,/(2/4%;/'+2%$#32%6'**$%6#1"%-/2H+)1%6'**%$1)3$%1,%",*3%6'**$%$2+)/2
'(3%-*)&84
@4 ?)1%'%$#3#(0%-'(2*%#(%"'*9%*2(01"6'.$4%<2*2+1%1"2%-'(2*%6#1"%1"2%E1,(0)2E%23024%=($1'**%1"#$%-'(2*
6#1"%1"2%+)1%2302%9*)$"%6#1"%1"2%$#3#(0%,(%1"2%8'+O%6'**4%<#3#(0%$",)*3%2F12(3%deGc%82*,6%8,11,&
-*'124%\'#*%$#3#(0%1,%8'+O%6'**%'(3%'**%@FG$%)$#(0%X3%0'*W4%('#*$%$-'+23%Cc%'-'/14
Step 5 Set Walls
d4 =($1'**%YLZ%9#W2%9)**%6#31"%$#3#(0%-'(2*$4%=($1'**
@Gc%6#32%$#3#(0%1,%9#(#$"4%<#3#(0%$",)*3%2F12(3
(,%&,/2%1"'(%dHBe@c%-'$1%6'**%1,%/2+2#W2%9/,(1
6'**%-'(2*4
G4 :2-2'1%1,%$#32%,--,$#12%$#32%6'**4
L4 N/2+1%9/,(1%6'**%-'(2*%'(3%$2+)/2%+,/(2/$%6#1"
BA3%$#(O2/$%'(3%('#*%$#32%6'**%$#3#(0%1,%@FG$4
;/'+2%6#1"%-/2H+)1%6'**%$1)3$4
X4 ?)1%'(3%/2&,W2%8,11,&%@FG%9/,&%3,,/%,-2(#(04
g4 \'#*%6'**$%1,%9*,,/%1"/,)0"%8,11,&%-*'124%<-'+2%BA3%$#(O2/$%@Gc%'-'/14
Back Wall
Siding Extends
3/4" Below Plate Cut 2x4 Plate
from Opening
Cut Edge

Step 6 Install 2x4 Tie Plates
B4 ?)1%'%@FGHB@E%8,'/3%#(%"'*94%=($1'**%'%@FGHXE%,(%'%$#32%6'**7%9*)$"%6#1"%1"2%@FG%,(%1"2%8'+O%6'**4
=($1'**%'%@FGHB@E%(2F14%=($1'**%1"2%@(3%XE%*,(0%@FG%9*)$"%6#1"%1"2%@FG%,(%1"2%9/,(1%6'**4%?)1%*2(01"
1,%9#14%5$2%BA3%$#(O2/$%1,%$2+)/2%1"2%1#2%-*'12$%1,%9/,(1%'(3%8'+O%6'**$%'(3%'*,(0%*2(01"4
@4 :2-2'1%1,%#($1'**%@FG$%,(%1"2%,--,$#12%$#32%6'**4
d4 ?)1%Y@Z%16,%B@E%*,(0%@FG$%1,%9#1%821622(%$#32%6'**%1#2%-*'12$%'(3%#($1'**%,(%9/,(1%'(3%8'+O%6'**$4
Cut 2x4-12' to Fit
2x4-6' Tie Plate
2x4-12' Tie Plate
Step 7 Install Metal 2x4 Joist Hangers
=($1'**%Y@@Z%162(1.%16,%@FG%b,#$1%"'(02/$%'*#0(23
6#1"%1"2%6'**%$1)3$%,(%8,1"%$#32%6'**$4%5$2%'%$",/1
@FG%8*,+O%'$%'%0')02%1,%2($)/2%1"2%@FG$7%#($1'**23
#(%(2F1%$12-7%6#**%82%9*)$"%6#1"%1"2%1,-%,9%1"2%@FG%1#2
-*'12%6"2(%#($1'**234%<2+)/2%1"2%"'(02/%6#1"%BHBe@c
"'(02/%('#*$4
2x4 Gauge Block
2x4-6' Tie Plate

Step 8 Install Loft Floor
Step 9A Install Loft Floor Sheathing
Before installing floor sheathing consider where to locate the 2' x 4' access
opening. The detail below shows one possibility. Regardless of desired
layout it is important to install sheathing staggered when possible.
Important: Before securing the 2x4 floor joists make sure the side walls are plumb. The
building width should be 12'-0" measuring from the outside of the 2x4 tie plates.
?)1%YBBZ%2*2W2(%@FGHB@E%8,'/3$%1,%'%*2(01"%,9%Bdgc%'(3%#($1'**
#(%1"2%&21'*%"'(02/$4%5$2%BHBe@c%"'(02/%('#*$4
4' x 8'
Suggested 2'x4 Opening Location
4' x 8'
4' x 8'
2' x 4'
4' x 8'
4' x 4'
Cut a 4' x 8'
in half
4' x 4'
4' x 4'
Cut a 4' x 8'
in half

3-1/2" x 24" OSB Filler
IMPORTANT: Do not
placeheavyweight onloft
at this point.
96" Between OSB Fillers
Back
Wall Side
Wall
1x3 Corner Trim
Step 10 Install Corner Trim
IMPORTANT: Lower Trim Must Be Installed Before Installing Roof Gables!
1x4 Trim Boards
d4 =($1'**%Y@Z%16,%gBHgeCc%*,(0%BFG%6"#12
-#(2%1/#&%8,'/3$%821622(%+,/(2/
8,'/3$4%!/#&%$",)*3%82%9*)$"%6#1"
S<;%$"2'1"#(04%?)1%@(3%8,'/3%1,%9#14
G4 :2-2'1%1,%#($1'**%1/#&%8,'/3$%1,%1"2
9/,(1%6'**%-'(2*4
Step 9B Install Loft Floor Sheathing continued
Siding Filler
OSB Filler
B4 V,+'12%YdZ%1"/22%@c%F%GCHdeGc%9#**2/%$1/#-$4%\'#*%1"2$2%,(%1,-%,9%1"2%$#3#(0%,(%1"2%8'+O%6'**4
5$2%X3%0'*W4%('#*$4
@4 =($1'**%Y@Z%16,%``c%*,(0%BFd%6"#12%-#(2%1/#&%8,'/3$%'$%+,/(2/%1/#&%1,%1"2%8'+O%6'**4%?)1
*2(01"%$,%1/#&%#$%9*)$"%6#1"%1,-%,9%S<;%9#**2/%'(3%8,11,&%,9%$#3#(04%=($1'**%1/#&%9*)$"%6#1"
1"2%$#3#(0%,(%1"2%$#32%6'**$4%5$2%X3%0'*W4%('#*$%$-'+23%B@c%'-'/1%1,%#($1'**%'**%1/#&4
B4 V,+'12%YGZ%9,)/%dHBe@c%F%@Gc%S<;%9#**2/$4%=($1'**%'1%9/,(1%'(3%8'+O%+,/(2/$%,(%1,-%,9%@FG%1#2
-*'12$4%5$2%YGZ%9,)/%X3%+,&&,(%('#*$%2'+"4%=($)/2%1"2%$-'+2%821622(%9#**2/$%#$%`Xc4
@4 =($1'**%*,91%9*,,/#(0%821622(%S<;%9#**2/$4%N302%,9%$"2'1"#(0%$",)*3%82%9*)$"%6#1"%9/,(1%'(3%8'+O
6'**%1#2%-*'12$4%:292/%1,%1"2%$)002$123%*'.,)1%,(%-/2W#,)$%-'024%=($1'**%9*,,/#(0%)$#(0%X3%+,&&,(
('#*$%$-'+23%B@c%'-'/14
Back
Wall Side
Wall

Step 11A Assemble Gables
32-1/2" Long 2x4s
49-1/2"
Long 2x4
Right Pre-built
Gable Frame
1x4 Block MUST
be Positioned Here
and Another on
Opposite Side
Gable Stud
Detail 'A'
Temporary
1x4 blocks
5-3/4"x14"
Gusset
B4 ['1"2/%-/2H8)#*1%0'8*2%2(3%9/'&2$7%YBZ%,(2%*291%'(3%YBZ%/#0"17%YBZ%,(2%G`HBe@c%*,(0%@FG%'(3%Y@Z
16,%d@HBe@c%*,(0%@FG$%6#1"%'(0*23%2(3$4
@4 M,$#1#,(%1"2$2%+,&-,(2(1$%1,021"2/%'$%$",6(%82*,64%^"2(%'*#0(23%+,//2+1*.%1"2%8,11,&%@FG$
6#**%82%$1/'#0"1%'(3%&2'$)/2%B@EHAc%9/,&%2(3%1,%2(34%Pre-built gable ends highlighted in gray.
d4 !2&-,/'/#*.%1'+O%BFG%8*,+O$%1,%*,91%9*,,/#(0%'/,)(3%1"2%9/'&2%&2&82/$4%!"2$2%8*,+O$%6#**%82
CcHB@c%*,(0%'(3%&'.%"'W2%'(0*23%2(3$4%I'O2%$)/2%Y@Z%16,%,9%1"2$2%8*,+O$%'/2%-,$#1#,(23%#($#32
2'+"%-/2H8)#*1%0'8*2%2(3%9/'&2%'$%$",6(4%M,$#1#,(%1"2%/2$1%,9%1"2%8*,+O$%'--/,-/#'12*.%$-'+23
1,%",*3%@FG$%#(%-*'+24%!"2$2%6#**%#($)/2%1"'1%'**%1/)$$2$%'(3%0'8*2$%'/2%8)#*1%2F'+1*.%1"2%$'&24
US%\S!%('#*%8*,+O$%1,%0'8*24
G4 <2+)/2%1"2%8,11,&%@FG%1,%1"2%0'8*2%$1)3%)$#(0%Y@Z%16,%@HBe@c%$+/26$4
L4 V,+'12%Y@Z%16,%LHdeGcFBGc%S<;%0)$$21$4%K11'+"%1"2$2%1,%1,-%,9%2'+"%0'8*2%$1)3%1,%$2+)/2%9/'&2
1,%d@HBe@c%@FG$4%5$2%X3%+,&&,(%('#*$4%<22%U21'#*%EKE4

Siding Extends 3/4" Below Plate
2x4s Under
Gable Frame
Tongue Edge on Right Side
Flush
Step 12A Install Front Gable Siding
Step 11B Assemble Gables Continued
B4 ?'/29)**.%1)/(%1"2%0'8*2%9/'&2%,W2/4%!2&-,/'/#*.%-*'+2%@FG$%)(32/%1"2%0'8*2%9/'&2%1,%O22-%1"2
9/'&2%*2W2*%6"#*2%#($1'**#(0%1"2%0'8*2%$#3#(04
@4 V,+'12%-/2H+)1%0'8*2%$#3#(04%^,/O#(0%*291%1,%/#0"1%#($1'**%'%$#3#(0%-'(2*%6#1"%'%E1,(0)2E%2302
'*,(0%/#0"1%$#324%=($1'**%9*)$"%6#1"%2(3%,9%9/'&2%'(3%2F12(3#(0%deGc%82*,6%1"2%8,11,&%@FG%-*'124
5$2%X3%0'*W4%('#*$%$-'+23%Cc%'-'/14
L4 V,+'12%Y@Z%16,%LAHdeGc%*,(0%@FG$4=($1'**%1"2$2%2P)'**.
$-'+23%9/,&%+2(12/%,9%1"2%0'8*24%<2+)/2%1"2%8,11,&%@FG
1,%1"2%0'8*2%$1)3$%)$#(0%Y@Z%16,%@HBe@c%$+/26$%2'+"4
X4 =($1'**%'%6,,3%0)$$21%'1%-2'O4
K--*.%0*)2%821622(%@FG$%'(3
0)$$21%'(3%('#*%)$#(0%YBGZ%9,)/122(
X3%+,&&,(%('#*$4
g4 V,+'12%Y@Z%16,%LHBe@cF@gHdeGc
0)$$21$4%K11'+"%1"2$2%1,%1,-%,9%2'+"
0'8*2%$1)3%1,%$2+)/2%1,%1"2%d@HBe@c
@FG$4%5$2%X3%+,&&,(%('#*$4
50-3/4" Gable Studs
5-1/2"x27-3/4"
Gusset

Step 12B Install Gable Siding continued
Step 13 Install Gable Overhang
G4 =($1'**%*'$1%$#3#(0%-'(2*4
d4 =($1'**%+2(12/%$#3#(04%=9%.,)%-)/+"'$23%'%$)(8)/$1%6#(3,6%.,)%&'.%+)1%1"2%,-2(#(0%#(%1"2
$#3#(0%'1%1"#$%1#&24%=($1/)+1#,($%'/2%-'+O23%#(%1"2%6#(3,6%8,F4%=1%#$%'3W#$'8*2%1,%#($1'**%1"2
6#(3,6%'912/%1"2%0'8*2%#$%$21
30-3/4" Long 2x4 77-3/8" Long 2x4
Do not remove the temporary 1x4 blocks until
the roof trusses and back gable are assembled.
B4 V,+'12%Y@Z%16,%ggHdeCc%*,(0%@FG%/'912/$%,(%0'8*24%=($1'**%@FG$%9*)$"%6#1"%1"2%1,-%,9%0'8*2
9/'&24%5$2%BA3%$#(O2/$4
@4 V,+'12%Y@Z%16,%dAHBeGc%*,(0%@FG%/'912/$%'(3%#($1'**%1,%9#(#$"4%@FG$%6#**%2F12(3%82.,(3%2(3%,9
0'8*24

Repositioned
1x4 Blocks
12'-0" Span
Step 14 Set Front Gable
B4 =($1'**%0'8*2%,(%1"2%9/,(1%6'**4%<2+)/2%8,11,&%,9
0'8*2%1,%*,91%9*,,/%'(3%S<;%9#**2/$%)$#(0%BA3%$#(O2/$4
@4 \'#*%1"2%8,11,&%2302%,9%1"2%$#3#(0%#(1,%1"2%BFG%1/#&4
5$2%X3%0'*W4%('#*$4 Bottom edge of gable siding
extends over 1x4 trim
Step 16 Assemble Roof Trusses
Important: Temporarily brace the gables with 2x4s
to secure gables until the roof sheathing is installed!
B4 =($2/1%*291%'(3%/#0"1%-/2H8)#*1%1/)$$%2(3$%#(1,%1"2%8*,+O$%1"'1%"2*3%1"2%0'8*2%9/'&2$%#(%-*'+24%=($)/2
$-'(%#$%B@EHAc%821622(%1/)$$%2(3$%'$%#(3#+'123%#(%3/'6#(0%82*,64
@4 ;)11%Y@Z%16,%ggHdeCc%*,(0%@FG$%'0'#($1%1"2%1/)$$%2(3$4%:2&,W2%1"2%BFG%8*,+O$%1"'1%$2+)/23%1"2
8,11,&%0'8*2%-*'12%'(3%/2-,$#1#,(%1,%O22-%/'912/$%'*#0(234%V,+'12%'%BCHBe@c%*,(0%@FG%/#302%8*,+O
6#1"%'(0*23%2(3$%'(3%#($1'**%'1%-2'O4%<2+)/2%/'912/$%'(3%/#302%8*,+O%'1%-2'O%6#1"%'%6,,3%0)$$214
=($1'**%6#1"%YBGZ%9,)/122(%X3%+,&&,(%('#*$%'(3%0*)24
d4 =($1'**%0)$$21$%,(%1/)$$%2(3$4%<22%U21'#*%K4%=($1'**%6#1"%Y@AZ%162(1.%X3%+,&&,(%('#*$%'(3%0*)24
G4 ?'/29)**.%9*#-%1/)$$%,W2/%'(3%#($1'**%'(,1"2/%0)$$21%'1%1"2%-2'O4
L4 <21%1/)$$%'$#324%:2-2'1%$12-$%1,%8)#*3%YBAZ%12(%&,/2%1/)$$2$4
X4 :2&,W2%12&-,/'/.%BFG%8*,+O$4
Front
Wall
Step 15 Assemble Rear Gable
:2-2'1%<12-$%BB%1"/,)0"%Bd%1,%'$$2&8*2%'(3%$21%/2'/%0'8*24
Detail 'A'
Tip: Place a gusset under
rafters to help level.
Repositioned
1x4 Blocks
Pre-built Truss
Assembly
77-3/8" long 2x4
Truss Rafter
Wood Gusset
GLUE
18-1/2" Ridge Block
12'-0" Span Measure Span
from Here

Step 17 Set Trusses
@4 ?,(1#()2%$1'(3#(0%1/)$$2$%1,%9/,(1%,9%8)#*3#(04
I'O2%$)/2%1/)$$2$%'(3%0'8*2$%'/2%-*)&84%=9
(2+2$$'/.%$-'(%'%@FG%'+/,$$%1,-$%'(3%1'+O%1,
O22-%-*)&8%)(1#*%/,,9%$"2'1"#(0%#$%#($1'**234
B4 <1'/1#(0%'1%8'+O%0'8*2%$21%'%1/)$$%8.%$*#3#(0%2(3$%,W2/%@FG%9*,,/%b,#$14%!/)$$%2(3$%$",)*3%$21%9*'1
'1,-%9*,,/%b,#$14%<2+)/2%6#1"%YBAZ%12(%X3%+,&&,(%('#*$%,(%8,1"%$#32$4
Step 18 Install Sidewall Trim
@4 :2-2'1%1,%#($1'**%+,/(2/%1/#&%'1%1"2%,1"2/
1"/22%+,/(2/$4
d4 =($1'**%'%GE%*,(0%BFd%1/#&%'*,(0%1"2%1,-
,9%1"2%$#326'**4%5$2%1"2%0')02%8*,+O
1,%$21%6"2/2%1"2%1/#&%6#**%82%#($1'**234
G4 =($1'**%YdZ%1"/22%g@E%*,(0%BFd%1/#&%'*,(0
1"2%1,-%,9%1"2%$#326'**4%?)1%'%GE%*,(0%BFd
1/#&%8,'/3%1,%9#(#$"4
L4 :2-2'1%,(%,--,$#12%$#32%6'**4
It's easier to install the soffit if the corner and sidewall trim are installed first. This
enables the soffit to rest on the trim where it meets the building. See lower detail.
B4 V,+'12%'%deCc%F%dc%F%Cc%$#3#(0%0')02%8*,+O%-'+O23
#(%1"2%"'/36'/2%8'04%M*'+2%1"#$%0')02%8*,+O%)(32/
1"2%@FG%,W2/"'(0%'(3%8)11%'%``c%*,(0%BFG%1/#&
8,'/3%'0'#($1%#14%?)1%1/#&%8,'/3%1,%*2(01"%'(3
#($1'**%1"2%1/#&%9*)$"%6#1"%1"2%+,/(2/%1/#&%,(%1"2
8'+O%,9%1"2%8)#*3#(04%5$2%X3%0'*W4%('#*$4
99" Corner Trim
3/8" Gauge Block
1x3 Trim
3/8" Gauge Block

B4 V,+'12%YGZ%9,)/%%`HdeGc%F%GCc%$,99#1%-'(2*$4%S(%1"2%9/,(1%0'8*2%('#*%9#/$1%$,99#1%6#1"%1"2%EVKME
2302%-,$#1#,(23%`HdeGc%9/,&%1"2%8,11,&%2(3%,9%1"2%@FG%1,%'**,6%9,/%1"2%6#31"%,9%1"2%$,99#1%-'(2*$
,(%1"2%$#32%6'**$4%5$2%X3%0'*W4%('#*$4
Step 19 Install Soffit
@4 ?)1%1,%9#1%(2F1%$,99#1%1,%+,W2/%@FG%'1
1"2%-2'O4%=($1'**%Y@Z%16,%$,99#1%-'(2*$
,(%,1"2/%$#324
d4 V,+'12%YgZ%$2W2(%`HdeGc%F%GCc%$,99#1
-'(2*$4%I2'$)/2%9/,&%+2(12/%,9%9#/$1
1/)$$%1,%2302%,9%$,99#1%,(%0'8*24%?)1
'%$,99#1%-'(2*%1,%1"#$%*2(01"4%I'O2
$)/2%EVKME%2302%#$%1"2%$#32%+)1%,994
G4 \'#*%1"2%$,99#1%-'(2*%1,%1"2%2(3%,9
1"2%@FG$4%<22%Detail 'C'%82*,64
L4 =($1'**%&,/2%$,99#1%-'(2*$%'*,(0%1"2
$#32%,9%1"2%8)#*3#(0%+)11#(0%1"2%*'$1
$,99#1%-'(2*%9*)$"%6#1"%1"2%@FG%,(
1"2%/2'/%0'8*24
X4 :2-2'1%$12-$%dHL%1,%#($1'**%$,99#1
-'(2*$%,(%1"2%9/,(1%0'8*2%'(3%1"2
,--,$#12%$#32%6'**4
1x4 Trim Board
Detail 'C'
Nail Soffit to End of 2x4
Soffit
9-3/4"Soffit
9-3/4" Wide Soffit
Tongue Edge at
Center of Truss Cut Edge

Soffit
Straight Edge
2x4 Rafter
1x6
48" x 51"
48" x 96"
48" x 75"
51"
48" x 96"
48"
48" x 59-1/4"
48" x
35-1/4"
59-1/4"
Step 20 Install 1x6 Fascia on Side Walls
1x6 Fascia Board
@4 =($1'**%YBZ%,(2%GCc*,(0%BFX%1/#&%8,'/3%(2F14
?,(1#()2%6#1"%YdZ%1"/22%BFXHXE%1/#&%8,'/3$4
?)1%'%GCc%*,(0%BFX%1/#&%8,'/3%9*)$"%6#1"%1"2
9/,(1%$,99#1%,W2/"'(0%1,%9#(#$"4
d4 :2-2'1%,(%,--,$#12%$#326'**4
B4 <1'/1#(0%'1%1"2%8'+O%0'8*27%#($1'**%'%gLc%*,(0%BFX%1/#&%8,'/3%9*)$"%6#1"%1"2%9'+2%,9%1"2%@FG4
=($1'**%1"2%BFX%8,'/3%$,%1"2%1,-%,9%1"2%8,'/3%#$%'*#0(23%6#1"%1"2%1,-%,9%1"2%1/)$$2$4%!"2%/,,9
$"2'1"#(07%installed later7%$",)*3%/2$1%,(%1"2%9'$+#'4%5$2%'%$1/'#0"1%2302%'$%$",6(%82*,64%5$2
C3%0'*W4%('#*$4
Step 21A Install Roof Sheathing
Plyclip
Cut From
48"x96"
<)--*#23%#(%,)/%+,&-,(2(1%O#14
Front Gable
Back
Gable
48" x 96"
48" x 96"
48" 48" 48"
B4 V,+'12%Y@Z%GCcF`Xc%$"221$%,9%S<;4%?)1%9/,&%1"2$2
Y@Z%16,%GCcFL`HBeGc%$"221$4%J/,&%3/,-$%+)1%Y@Z%16,
GCcFdLHBeGc%$"221$4
@4 J,**,6#(0%*'.,)1%82*,6%#($1'**%/,,9%$"2'1"#(0
'++,/3#(0%1,%#($1/)+1#,($%,(%(2F1%-'024

@4 =($1'**%'%dAHBe@c%*,(0%@FG%821622(
1"2%/,,9%$"2'1"#(0%'(3%1"2%$,99#1%-'(2*
d4 :2-2'1%,(%,--,$#12%$#324
B4 I'O2%$)/2%1"2%1/)$$2$%'(3%0'8*2$%'/2%-*)&84
@4 :292/%1,%1"2%/,,9%$"2'1"#(0%*'.,)14%=($1'**
'%GCcFL`HBeGc%$"221%'1%*,62/%9/,(1%+,/(2/4
<"2'1"#(0%$",)*3%82%9*)$"%6#1"%$,99#1%'(3
/2$1%,(%BFX%9'$+#'4%<2+)/2%$"2'1"#(0%6#1"
X3%+,&&,(%('#*$4%<-'+2%('#*$%B@c%'-'/14
?,(1#()2%1,%8'+O%0'8*24
d4 !"2%1,-%/,6%,9%$"2'1"#(0%6#**%'**,6%'%0'-
'1%1"2%1,-%1,%'**,6%W2(1#*'1#,(%#9%/#302%W2(1
#$%'--*#234%=($2/1%Y@Z%16,%-*.H+*#-$%#(1,%1"2
/,,9%$"2'1"#(0%821622(%2'+"%1/)$$%'1%1"2
1,-%/,67%$22%3/'6#(0%,(%-/2W#,)$%-'024
9*)$"
Step 21B Install Roof Sheathing continued
Step 22 Install 2x4s in Front overhang
B4 <1'/1#(0%'1%1"2%-2'O%#($1'**%'%ggHdeCc%*,(0%@FG%821622(%1"2%/,,9%$"2'1"#(0%'(3%1"2%$,99#1
-'(2*$4%<21%1"#$%8,'/3%9*)$"%6#1"%2302%,9%$,99#1%-'(2*$%'(3%/,,9%$"2'1"#(04%5$2%X3%0'*W4%('#*$
,(%$,99#1%'(3%X3%+,&&,(%1"/,)0"%1"2%/,,9%$"2'1"#(04
Nail with 6d Common
Nail with 6d Galv.
K#/
<-'+2
48"x59-1/4"
OSB
48"x35-1/4"
OSB

Step 23 Install Front Gable Trim and Door Trim
1x6 Gable Trim
Tack 76-3/4" Long 1x4 Door Trim
d4 =($1'**%'(%C@c%*,(0%BFG%1/#&%8,'/3%+2(12/23
'8,W2%3,,/%,-2(#(04%=($)/2%8,'/3%#$%'8,W2
,-2(#(0%8.%deGc4%5$2%X3%0'*W4%('#*$4
G4 =($1'**%gXHdeGc%*,(0%BFG%1/#&%8,'/3$%,(%2'+"
$#32%,9%1"2%3,,/%,-2(#(0%9*)$"%6#1"%$#3#(04%!'+O
('#*%1"2$2%1/#&%8,'/3$%9,/%(,67%.,)%&'.%(223
1,%'3b)$1%1"2%1/#&%6"2(%.,)%#($1'**%1"2%3,,/$4
82" Long 1x4 Door Trim
3/4" Above Door Opening
Siding is 3/4"
Below Trim
B4 S(%9/,(1%0'8*2%#($1'**%Y@Z%16,%BFX%1/#&%8,'/3$%,W2/%1"2%@FG%8,'/3$7%9*)$"%6#1"%1"2%1,-%,9
1"2%S<;%/,,9%$"2'1"#(04%5$2%X3%0'*W4%('#*$4
@4 =($1'**%0'8*2%1/#&%,(%1"2%/2'/%0'8*24

If your door opening is out of square, the space around the doors will not
be even. You can remove and re-position the side trim to make allowances
for this. The side trim does not have to be flush with the frame of the door
opening. You can move the trim in or out to make the door spacing equal.
Left Door
X4 =($1'**%'%8'//2*%8,*1%,(%1"2%#($#32%*,62/%8'+O%,9
1"2%*291%3,,/%1,%$2+)/2%1"#$%3,,/%#(%-*'+2%6"2(
+*,$234%_,)%6#**%(223%1,%3/#**%'%",*2%9,/%1"2%/,)(3
$"'91%1,%3/,-%#(1,4
g4 =($1'**%'(,1"2/%8'//2*%8,*1%'1%1"2%1,-%,9%1"2%3,,/4
Barrel Bolt on the
back of left door
Step 24 Install Doors
@FG%J/'&2
BFG%!/#& <#3(0
=($#32%U,,/%V'1+"
U,,/%<1,-
B4 =($1'**%YdZ%1"/22%Xc%"#(02$%1,%$#32$%,9%1"2%3,,/$4
!,%-,$#1#,(%1"2%"#(02%-/,-2/*.7%",*3%1"2%/2+1'(0)*'/
-*'12%'0'#($1%1"2%9/'&24%5$2%@c%8*'+O%$+/26$4
@4 ;29,/2%9'$12(#(0%1"2%"#(02$%1,%1"2%1/#&7%12&-,/'/#*.
-/,-%1"2%3,,/$%#(%1"2%,-2(#(04%V2'W2%'%$-'+2%'1
1"2%1,-%'(3%'(3%821622(%1"2%3,,/$%'(3%1"2%$#32
1/#&%1,%'**,6%/,,&%9,/%1"2%3,,/$%1,%2F-'(3%3)2
1,%")&#3#1.4
d U212/&#(2%-,$#1#,(%,9%"#(02$%'(3%#($1'**%1,%$#32
1/#&%6#1"%@c%$+/26$4
G4 =($1'**%1"2%6#(3,6%)$#(0%1"2%$",/1%6"#12%$+/26$4
L4 =($1'**%3,,/%"'(3*2%#(1,%1"2%-/2H3/#**23%",*2%,(
/#0"1%$#32%3,,/4%^"2(%1"2%"'(3*2%#$%1)/(23%1"2
#($#32%*'1+"%6#**%",*3%3,,/$%+*,$234%!#0"12(%$21
$+/26%1,%9#(#$"4