Reynolds Building Systems Jefferson Safety guide

!"#$%&'()'*%#$%+,-./#0"1234%5(32/%1"2%+,-./#0"1%*'6$7%1"#$%&'()'*
&'. (,1 82 +,-#237 #( 6",*2 ,/ #( -'/17 6#1",)1 +,($2(1 9/,& :2.(,*3$
;)#*3#(0%<.$12&$7%=(+4 >%%?,-./#0"1%@A@A
Assembly Book
Manufactured by Reynolds Building Systems, Inc.
205 Arlington Drive Greenville, PA 16125
Sentry Buildings
BCDE@FD%;)#*3#(0
the Jefferson
:2G#$23%H'/+"%BF7 %@A@@

I,)%6#**%(223%1,%/2(1%JCK%$#E%$2+1#,($%,9%$+'99,*3#(0%1,%$'92*.%#($1'**%1"2%$2+,(3%9*,,/%&'12/#'*4
5$2%$'921.%"'/(2$$2$%6"2(%,(%1"2%$+'99,*3#(04%?,($#32/%"#/#(0%'%-/,92$$#,('*%/,,92/%1,%#($1'**
1"2%$"#(0*2$%,/%&21'*%/,,94%%!"2.%"'G2%1"2%L(,6*2302%'(3%2M)#-&2(1%1,%3,%1"2%N,8%-/,-2/*.4
IMPORTANT INFORMATION ABOUT YOUR KIT
*
Tools
Required:
!%O'(3%,/%?#/+)*'/%<'6 !P2G2* !Q"#**#-$%<+/263/#G2/
!?,/3*2$$%R/#** !H2'$)/#(0%!'-2 !S/'&#(0%<M)'/2
!?')*L#(0%T)( !FD%U%BAD%P'332/J$K !O'&&2/
!<'921.0*'$$2$V%W*6'.$%62'/%$'921.%0*'$$2$%6"2(%+)11#(0%,/%('#*#(0X
!*%<+'99,*3#(0
Building Permits: ?"2+L 6#1" .,)/ *,+'* OYW ,/ 8)#*3#(0 +,32 ,99#+2 9,/ '(. /2M)#/2&2(1$7
/2$1/#+1#,($%,/%-2/&#1$%(2+2$$'/.%9,/%+,($1/)+1#,(4
Foundation: ;.%,6(2/4%:292/%1,%(2E1%-'02%9,/%9,)(3'1#,(%$)002$1#,($%'(3%$#Z24
What's Included: Y)/ -'+L'02 #(+*)32$ -/2[+)1 &'12/#'*$ 9,/ 1"2 @(3 9*,,/ /,,9 0'8*2$7 /,,9
1/)$$2$ '(3 0'8*2 1/#&4 !6, $#(0*2 ")(0 #($)*'123 6#(3,6$ 6#1" 1/#& '(3 G#(.* $")112/$4 !"#$
&'12/#'* #$ 32*#G2/237 curb side in covered van7 ,( 16, \DE]D -'**21$4 <22 8'+L -'02 9,/ &'12/#'*
*#$14 !"2 ('#*$ '(3 "'/36'/2 (2+2$$'/. 1, +,($1/)+1 1"2 *,62/ 6'**$ '/2 -'+L23 #( 1"2 1,- ,9 DWD
-'**214 !"2 ,1"2/ &'12/#'*$ ,( 1"2 -'**21 6#** (,1 82 )$23 )(1#* 1"2 9#/$1 9*,,/ 6'**$ '(3 *,91 9*,,/
'/2%+,&-*21234
S/'&#(0 *)&82/ 9,/ 1"2 9#/$1 9*,,/ 6'**$ '(3 *,91 9*,,/7 2E12/#,/ $#3#(07 *,91 9*,,/#(0 '(3 /,,9
$"2'1"#(0 6#** 82 32*#G2/23 8. ' *,+'* $)--*#2/4 !"#$ 6#** 82 ' $2-'/'12 32*#G2/. '(3 .,) 6#** 82
(,1#9#23 829,/2 1"'1 32*#G2/. 1'L2$ -*'+24 H'12/#'* #$ *#$123 ,( 1"2 8'+L -'02$4 <,&2,(2 6#** (223
1,%$#0(%9,/%8,1"%32*#G2/#2$4
Owner Supplied: YG2/"2'3 FD E C^C 0'/'02 3,,/ 6#1" *,6 "2'3/,,& "'/36'/24 :,,9 $"#(0*2$7
&21'* /,,9 23027 92*1 '(3 G2(1#*'1#,( '++2$$,/#2$4 Q'#(1 9,/ $#3#(0 '(3 1/#&4 W33#1#,('* *)&82/ 9,/
9/'&#(0%'33#1#,('*%6#(3,6%'(3%3,,/%,-2(#(0$4
Assembly Help: H,(3'.%1"/)%S/#3'. FAA[@\_[B_]] FVAA%1,%_VAA%`!
a22L2(3%[%'912/%",)/$ ]@\[FCC[\b_]
2&'#*%1,V%%questionscbarnkits.com
Care of product prior to assembly: R, (, 2E-,$2 *)&82/ '(3 $"221 0,,3$ 1, #(+*2&2(1 62'1"2/4
W$$2&8*. $",)*3 820#( -/,&-1*. 1, -/2G2(1 1"2 16#$1#(0 ,9 *)&82/4 d,1#9. ,)/ +,&-'(. 6#1"#(
bA%3'.$%,9%'(.%3'&'02%,/%&#$$#(0%#12&$%9,/%9)**%/2-*'+2&2(14
Building Tips: S,**,6 1"2 '$$2&8*. <12-$ #( $2M)2(+24 <L#--#(0 $12-$ 6#** /2$)*1 #( +,&-,(2(1$
(,1 9#11#(0 -/,-2/*.4 !"2 ('#*$7 "'/36'/2 '(3 "2'32/ &'12/#'* (22323 1, '$$2&8*2 1"2 *,62/ 6'**$
'(3 *,91 9*,,/ '/2 -'+L'023 ,( 1"2 1,- ,9 -'**21 DWD4 !"2 ,1"2/ &'12/#'*$ ,( 1"2 -'**21 6#** (,1 82
)$23%)(1#*%1"2%9#/$1%9*,,/%6'**$%'(3%*,91%9*,,/%'/2%+,&-*21234

Foundation Types & Measurements
ImportantV I,) 6#** (223 1, "'G2 ' -/,-2/ 9,)(3'1#,( #($1'**23 1, $)--,/1 1"2 8)#*3#(04
R2-2(3#(0%,(%1"2%#(12(323%)$2%3212/&#(2$%6"'1%1.-2%,9%9,)(3'1#,(%#$%82$14
Do Not &'L2 1"2 9,)(3'1#,( *'/02/ 1"'( 1"2 8)#*3#(0 $#Z24 a"2( #($1'**#(0 1"2 8)#*3#(0
,( ' +,(+/212 $*'87 #($1'** 1"2 $#3#(0 9*)$" 6#1" 1"2 8,11,& -*'124 a"2( #($1'**#(0 ,( ' 6,,3
9*,,/7 2E12(3 1"2 $#3#(0 b^\e 82*,6 1"2 8,11,& -*'12 1, +,G2/ 1"2 2302 ,9 1"2 9*,,/#(04
a,,3%S*,,/%,(%:)((2/$V%%<)#1'8*2%9,/%$1,/'02
,/%6,/L$",-4%!/2'123%CEC%*)&82/%,G2/%'%823
,9%0/'G2*%S*,,/%N,#$1%$",)*3%82%1/2'123%@EC
$-'+23%BCe%,(%+2(12/%'(3%+,G2/23%6#1"%b^\e
1,(0)2%'(3%0/,,G2%6,,3%9*,,/#(04
Foundation TypesV a"'1 9,)(3'1#,( #$ 82$1 32-2(3$ ,( 6"'1 1.-2 ,9 #12&$ 6#** 82 $1,/234
!"2 8)#*3#(0 +,32 #( .,)/ '/2' 6#** '*$, 3212/&#(2 6"'1 1.-2 ,9 9,)(3'1#,( +'( 82 )$234
W 926 3#992/2(1 1.-2$ ,9 9,)(3'1#,($ '/2 $",6( 82*,64 ?"2+L 1"2 Z,(#(0 '(3 8)#*3#(0 +,32
/2M)#/2&2(1$%#(%.,)/%'/2'4
LP siding "'$%'%_A%.2'/%6'//'(1.%'(3%#$%'*/2'3.%-/#&234
W--*. 16, +,'1$ ,9 *'12E '+/.*#+ -'#(1 9,/ 1"2 9#(#$" +,'14
Q'#(1 1"2 8,11,& 2302 ,9 1"2 $#3#(07 this is important4
H'#(1'#( Ce 1, Fe ,9 +*2'/'(+2 9/,& 1"2 8,11,& 2302 ,9
1"2 $#3#(0 '(3 1"2 0/,)(34 R,(D1 '**,6 0'/32( &)*+" 1,
8)#*3 )- '(3 L22- $"/)8$ ' &#(#&)& ,9 BD '6'. 9/,& 1"2
8)#*3#(04
Wood Floor on Wood Runners
Floating Cement Slab
Foundations Types
S*,'1#(0%<*'8%%W%+,(+/212%$*'8%#$%#32'*
9,/%$1,/'02%,9%+'/$%,/%,1"2/%1.-2$%,9
"2'G.%#12&$4
Exterior Siding Information
Tongue Edge
LAP Edge

Pre-cut Wall
Stdu
Frame Window Opening
Frame Door Opening
Refer to door manufactures
instructions for installation details
40" window
Cripplers
27" Header
36" Header
Supports
27" Sill
Rough Opening Details for Window and Door
a"2( '$$2&8*#(0 1"2 *,62/ 6'** 9/'&2$ .,) 6#** (223 1, 32+#32 6"2/2 .,) 6'(1
1, *,+'12 1"2 2(1/. 3,,/ '(3 1"2 @\e E bCe 6#(3,6 $)--*#23 #( ,)/ L#14 !"2 321'#*$
82*,6 $",6 ",6 1, 9/'&2[#( 1"2 /,)0" ,-2(#(0$4 If you add additional windows,
follow the manufacturer's instructions for the rough opening size.
B4 <2*2+1 ' 6'** $1)3 6"2/2 .,) 6'(1 1, $1'/1
%#($1'**#(0%1"2%6#(3,6%,-2(#(04%=($1'**
'(,1"2/%6'**%$1)3%$-'+23%@]e%'6'.4
@4 P,+'12 J\K 9,)/ \Ae *,(0 @E\$ 9/,& ,)/ L#14
?)1%,(2%1,%'%%*2(01"%,9%%@]e4
b4 =($1'**%1"2$2%@E\$%'$%$",6(%,(%/#0"14
\4 ?)1%J@K%\Ae%*,(0%@E\$%1,%bCe4%=($1'**%'$
"2'32/%$)--,/1$%'(3%'%-/2[8)#*1%"2'32/4
_4 ?)1%*291,G2/%@E\$%#(1,%8*,+L$%'(3%#($1'**
1"2%8*,+L$%'8,G2%1"2%"2'32/4
*H'#(1'#(%BCe%$1)3%$-'+#(0%$,%1"2
$#3#(0%6#**%&221%1"2%$1)34
*
Pre-cut Wall
Stud
80-1/2" Header
Supports
Pre-built 37-1/2"
Door Header
B4 <2*2+1 ' 6'** $1)3 6"2/2 .,) 6'(1 1, $1'/1
#($1'**#(0%1"2%3,,/%,-2(#(04%=($1'**%'
'(,1"2/%6'**%$1)3%$-'+23%b][B^@e%'6'.4
@4 ?)1 J@K 16, -/2[+)1 6'** $1)3$ 1, ' *2(01"
,9%FA[B^@4
b4 =($1'**%1"2$2%$1)3$%'$%"2'32/%$)--,/1$4
\4 =($1'** ' b][B^@e *,(0 -/2[8)#*1 3,,/ "2'32/
,G2/%1"2%$)--,/1$%$1)3$4
_4 ?)1%@E\%8*,+L$%'(3%#($1'**%8*,+L$%'8,G2
1"2%"2'32/4
*
Pre-cut Wall
Stdu
27" Between
Studs

V
VVVVVV
Pre-cut 2x4
Wall Studs
Treated Bottom Plate
Step 1 Assemble (2) Two 92-1/2" Rear Wall Frames
Note: When building the lower walls, use treated
2x4s for the bottom wall plates.
The length of pre-cut wall studs will vary from 92-1/4" to
93" depending on your locality.
\4 :2-2'1%1,%8)#*3%'(,1"2/%f@[B^@e%*,(0%6'**%9/'&24
_4 H'/L%8,1"%9/'&2$%DRear Wall Frames'%'(3%$21%9/'&2$%'$#324
b4 =($1'**%J]K%$2G2(%-/2[+)1%6'**%$1)3$%821622(%1"2%1,-%'(3%8,11,&%-*'12$4%%d'#*%1"2
1/2'123%8,11,&%-*'12%1,%2'+"%6'**%$1)3%6#1"%J@K%16,%BC3%0'*G'(#Z23%32+L%('#*$4
5$2%J@K%16,%BA3%+,'123%$#(L2/%('#*$%-2/%$1)3%1,%$2+)/2%1"2%1,-%-*'124
B4 ?)1 J@K 16, @E\[FD J,(2 6#** 82 1/2'123K 1, ' *2(01" ,9 f@[B^@e4 Q,$#1#,( 1"2 8,'/3$ 1,021"2/
'(3%#(3#+'12%6#1"%DgD%%&'/L$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234
@4 H'/L%'%D?D%'(.6"2/2%821622(%9#/$1%16,%$1)3%&'/L$4%!"#$%#$%/292/2(+23%#(%'%*'12/%$12-4
Stud Spacing
XX
X X
X
X
X
X
92-1/2 Top Wall Plate
92-1/2" Treated Bottom Plate
16"
11-3/4" 16"
C
C

Stud Spacing
X
X
X
X
X
X
X
X
144" Top Wall Plate
144" Treated Bottom Plate
16"
15-1/4" 16"
V
VVVVVV
Pre-cut 2x4
Wall Studs Treated Bottom Plate
B4 !/#&7 if necessary7 J@K 16, @E\[B@D 8,'/3$ J,(2 6#** 82 1/2'123K 1, ' *2(01" ,9 B\\e4 Q,$#1#,(
1"2%8,'/3$%1,021"2/%'(3%#(3#+'12%6#1"%DgD%&'/L$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234
Step 3A Assemble (2) Two 12' Side Wall Frames
@4 =($1'** J]K $2G2( -/2[+)1 6'** $1)3$ 821622( 1"2 1,- '(3 8,11,& -*'12$4 d'#* 1"2 1/2'123
8,11,& -*'12 1, 2'+" 6'** $1)3 6#1" J@K 16, BC3 0'*G'(#Z23 32+L ('#*$4 5$2 J@K 16, BA3
+,'123%$#(L2/%('#*$%-2/%$1)3%1,%$2+)/2%1"2%1,-%-*'124
b4 :2-2'1%1,%8)#*3%JbK%1"/22%&,/2%FD%*,(0%6'**%9/'&24
\4 H'/L%1"2%9/'&2$%DSide Wall Frames'%'(3%$21%9/'&2$%'$#324
Step 2 Assemble (4) Four 96" Long Side Wall Frames
Stud Spacing
XX
X X
X
X
X
X
96" Top Wall Plate
96" Treated Bottom Plate
16"
15-1/4" 16"
B4 <2*2+1%J@K%16,%@E\[FD%J,(2%6#**%82%1/2'123K%#9%(2+2$$'/.%1/#&%1,%'%*2(01"%,9%fCe4%Q,$#1#,(%1"2
8,'/3$%1,021"2/%'(3%#(3#+'12%6#1"%DgD%%&'/L$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234

Pre-cut 2x4
Wall Studs
Treated Bottom Plate
V
V
V
V
V
V
B4 =9%.,)%'/2%#($1'**#(0%'%FD%6#32%0'/'02%3,,/%+)1%J@K%16,%BAD%*,(0%@EF%8,'/3$%1,%'%*2(01"%,9%ffe4
S,/%'%fD%6#32%0'/'02%3,,/%+)1%@EF$%1,%'%*2(01"%,9%BBBe
@4 =($1'** JBAK 12( -/2[+)1 6'** $1)3$ 821622( 1"2 1,- '(3 8,11,& -*'12$4 d'#* 1"2 1/2'123
8,11,&%-*'12%1,%2'+"%6'**%$1)3%6#1"%J@K%16,%BC3%0'*G'(#Z23%32+L%('#*$4%5$2%J@K%16,
BA3%+,'123%$#(L2/%('#*$%-2/%$1)3%1,%$2+)/2%1"2%1,-%-*'124
b4 :2-2'1%1,%8)#*3%'(,1"2/%B\\e%*,(0%6'**%9/'&24
\4 H'/L%8,1"%9/'&2$%DSide Wall Frames'%'(3%$21%9/'&2$%'$#324
Step 4 Assemble Door Header
99" Long 2x8
48" OSB Filler
GLUE
99" Long 2x8
Step 3B Assemble (2) Two 12' Side Wall Frames continued
@4 P,+'12 ' @\e E \Fe Y<; J,/#2(123 $1/'(3 8,'/3K -'(2*$ -'+L23 #( ,)/ L#14 ?)1 J@K 16, ][B^\e
E%\Fe%9#**2/$%1,%9#1%821622(%1"2%@EF%8,'/3$
b4 W--*.%6,,3%0*)2%1,%8,1"%$#32$%,9%2'+"%Y<;%9#**2/%6#1"%'%8/)$"%'(3%#($1'**%#(%1"2%+2(12/%,9
1"2%@EF%8,'/3$4%d'#*%1,021"2/%)$#(0%BA3%+,'123%$#(L2/$4%5$2%JB@K%162*G2%('#*$%$-'+23%2G2(*.
,(%2'+"%$#324

15' - 5" Wall Plates
16"
11-3/4" 13-3/4" 16" 13-3/4" 11-3/4"
Treated X
XXX
Regular X
XXX
96" Door Opening
X
X
XX
X
X
XX
SS
99" Door Header
*
*Adjust opening height per garage
door manufacture's specifications
Step 5A Assemble 15'-5' Front wall - 8' Wide Door Opening
B4 ?)1%J@K%16,%@E\[BCD%J,(2%6#**%82%1/2'123K%1,%'%*2(01"%,9%BF_e4%Q,$#1#,(%1"2%8,'/3$%1,021"2/%'(3
#(3#+'12 6#1" DgD &'/L$ 6"2/2 1"2 6'** $1)3$ 6#** 82 *,+'123 '(3 '( D<D 6"2/2 1"2 $)--,/1 $1)3$
6#**%82%*,+'12344
2x4 Header Blocking
2x8 Door Header
Pre-cut 2x4
Studs
2x4-15'-5"' Treated Bottom Plate
96" Door Opening Width
=9 .,) '/2 #($1'**#(0 ' fD 6#32 0'/'02 3,,/ 0, 1, Step 5B4
2x4 Header
Support Studs
@4 W$$2&8*2 1"2 9/,(1 6'** 9/'&2 )$#(0 1"2 6'** -*'12$ +)1 '8,G2 '(3 JFK 2#0"1 -/2[+)1 6'** $1)3$4
5$2%BC3%0'*G'(#Z23%32+L%('#*$%9,/%1"2%8,11,&%-*'12%'(3%BA3%+,'123%$#(L2/$%9,/%1"2%1,-%-*'124
b4 :292/%1,%1"2%0'/'02%3,,/%$-2+#9#+'1#,($%1,%3212/&#(2%1"2%"2#0"1%,9%1"2%/,)0"%,-2(#(04%?)1%J@K
16,%-/2[+)1%$1)3$%1,%1"#$%"2#0"1%*2$$%B[B^@e%'(3%#($1'**%1"2&%'$%"2'32/%$)--,/1$%)$#(0%JBAK%12(
BA3 $#(L2/$4 =($1'** 1"2 @EF "2'32/ 8. 1,2[('#*#(0 1"2 2(3$ 1, 1"2 '3N'+2(1 $1)3$ 6#1" BA3 $#(L2/$4
\4 ?)1 J_K 9#G2 -#2+2$ 9/,& ' -/2[+)1 $1)3 1, 9#1 821622( "2'32/ '(3 1,- @E\ -*'124 =($1'** 6#1" BA3
$#(L2/$%1"/,)0"%1,-%-*'12%'(3%1,2('#*%#(1,%"2'32/4

*
*Adjust opening height per garage
door manufacture's specifications
Step 5B Assemble 15'-5' Front wall - 9' Wide Door Opening
B4 ?)1%J@K%16,%@E\[BCD%J,(2%6#**%82%1/2'123K%1,%'%*2(01"%,9%BF_e4%Q,$#1#,(%1"2%8,'/3$%1,021"2/%'(3
#(3#+'12 6#1" DgD &'/L$ 6"2/2 1"2 6'** $1)3$ 6#** 82 *,+'123 '(3 '( D<D 6"2/2 1"2 $)--,/1 $1)3$
6#**%82%*,+'12344
15' - 5" Wall Plates
16"
11-3/4" 7-3/4" 16" 7-3/4" 11-3/4"
Treated X
XXX
Regular X
XXX
108" Door Opening
2x4 Header Blocking
2x8 Door Header
Pre-cut 2x4
Studs
2x4-15'-5"' Treated Bottom Plate
108" Door Opening Width
X
X
XX
X
X
XX
SS
111" Door Header
2x4 Header
Support Studs
@4 W$$2&8*2 1"2 9/,(1 6'** 9/'&2 )$#(0 1"2 6'** -*'12$ +)1 '8,G2 '(3 JFK 2#0"1 -/2[+)1 6'** $1)3$4
5$2%BC3%0'*G'(#Z23%32+L%('#*$%9,/%1"2%8,11,&%-*'12%'(3%BA3%+,'123%$#(L2/$%9,/%1"2%1,-%-*'124
b4 :292/%1,%1"2%0'/'02%3,,/%$-2+#9#+'1#,($%1,%3212/&#(2%1"2%"2#0"1%,9%1"2%/,)0"%,-2(#(04%?)1%J@K
16,%-/2[+)1%$1)3$%1,%1"#$%"2#0"1%*2$$%B[B^@e%'(3%#($1'**%1"2&%'$%"2'32/%$)--,/1$%)$#(0%JBAK%12(
BA3 $#(L2/$4 =($1'** 1"2 @EF "2'32/ 8. 1,2[('#*#(0 1"2 2(3$ 1, 1"2 '3N'+2(1 $1)3$ 6#1" BA3 $#(L2/$4
\4 ?)1 J_K 9#G2 -#2+2$ 9/,& ' -/2[+)1 $1)3 1, 9#1 821622( "2'32/ '(3 1,- @E\ -*'124 =($1'** 6#1" BA3
$#(L2/$%1"/,)0"%1,-%-*'12%'(3%1,2('#*%#(1,%"2'32/4

Step 6A Set Wall Frames
B4 =($1'**%,(2%,9%1"2%f@[B^@e%8'+L%6'**%9/'&2$%'0'#($1%#($#32%,9%'%FD%$#32%6'**%9/'&24%;/'+2%6'**$
6#1"%-/2[+)1%$1)3$4%IMPORTANT:%Y/#2(1%2(3%&'/L23%6#1"%'%D?D%1,%+,/(2/4%<2+)/2%9/'&2$
1,021"2/%'1%1"2%+,/(2/%)$#(0%J\K%9,)/%BA3%$#(L2/$
@4 =($1'**%'%f@[B^@e%8'+L%6'**%9/'&2%'0'#($1%1"2%,1"2/%8'+L%6'**%9/'&24%d'#*%1"2%8'+L%6'**%9/'&2$
1,021"2/%6"2/2%1"2.%8)11%6#1"%JFK%2#0"1%BA3%$#(L2/%J$1'002/%('#*$%,(%2'+"%$#32%,9%1"2%$1)3$K%4
b4 =($1'**%'%B@D %*,(0%9/'&2%(2E1%1,%1"2%FD%$#32%6'**%9/'&24%<2+)/2%6#1"%BA3%$#(L2/$4
92-1/2" Back Wall Frames
8' Side Wall Frame
Brace wall frames with
pre-cut wall studs.
End Marked 'C'
End Marked 'C'
Front and back wall frames are positioned between long side walls.
12' Side Wall Frame

\4 =($1'**%'(,1"2/%FD%*,(0%$#32%6'**%9/'&24
15'-5" Front
WAll Frame
_4 =($1'**%,--,$#12%$#32%6'**%9/'&2$4
C4 =($1'**%1"2%9/,(1%6'**%9/'&2%821622(%1"2%$#32%6'**%9/'&2$4%<2+)/2%9/'&2$%1,021"2/%'1%1"2
+,/(2/%)$#(0%J\K%9,)/%BA3%$#(L2/$4
]4 d'#*%9/'&2$%1,%1"2%9*,,/%)$#(0%BC3%T'*G4%$-#/'*%('#*$%,/7%#9%2/2+1#(0%,(%'%+2&2(1%$*'87
+,(+/212%'(+",/%8,*1$%Jnot includedK%$-'+23%@\e%,(%+2(12/4%R,%(,1%('#*%1"2%@E\%-*'12%#(
1"2%3,,/%,-2(#(04
Step 6B Set Wall Frames continued
8' long center frame

If a siding panel has a damaged edge, install this edge at a corner where it will be
covered with corner trim.
?,(+/212%<*'8%S,)(3'1#,(V =($1'**%$#3#(0%9*)$"%6#1"%1"2%8,11,&%-*'124
a,,3%S*,,/%S,)(3'1#,(V `E12(3 1"2 $#3#(0 b^\e 82*,6 1"2 8,11,& -*'124
Step 7 Install 2x4 Tie Plates
16' Long 2x4 Tie Plate
b4 ?)1%'%@E\[FD%#(%"'*9%'(3%#($1'**%'%\D%*,(0%@E\%,(%1"2%$#32%6'**4%!"2%@E\%6#**%8)11%'0'#($1%1"2
BCD%*,(0%1#2%-*'12%,(%1"2%8'+L%6'**4%5$2%BA3%$#(L2/$4
\4 =($1'**%J@K%16,%%@E\[B@D%8,'/3$%,(%1"2%$'&2%$#32%6'**%9/'&24%?)1%1"2%*'$1%8,'/3%1,%9#14
_4 :2-2'1%1,%#($1'**%@E\%1#2%-*'12$%,(%1"2%,--,$#12%$#32%6'**%9/'&2$4
Back Wall
Frames
B4 =($1'**%'%BCD%*,(0%@E\%,(%1"2%8'+L%6'**4%5$2%BA3%$#(L2/$%$-'+2%BCe%'-'/1%1,%$2+)/2%1#2%-*'12$4
@4 :2-2'1%1,%#($1'**%'%BCD%*,(0%@E\%1#2%-*'12%,(%1"2%,--,$#12%9/,(1%6'**4
Step 8A Install Siding on Wall Frames
12' Long 2x4 Tie Plate
LP siding "'$%'%_A%.2'/%6'//'(1.%'(3%#$%'*/2'3.%-/#&234
W--*. 16, +,'1$ ,9 *'12E '+/.*#+ -'#(1 9,/ 1"2 9#(#$" +,'14
Q'#(1 1"2 8,11,& 2302 ,9 1"2 $#3#(07 this is important4
H'#(1'#( Ce 1, Fe ,9 +*2'/'(+2 9/,& 1"2 8,11,& 2302 ,9
1"2 $#3#(0 '(3 1"2 0/,)(34 R,(D1 '**,6 0'/32( &)*+" 1,
8)#*3 )- '(3 L22- $"/)8$ ' &#(#&)& ,9 BD '6'. 9/,& 1"2
8)#*3#(04
Exterior Siding Information
Tongue Edge
LAP Edge

Step 8B Install Siding on Wall Frames continued
B4 =($1'** ' 9)** 6#31" $#3#(0 -'(2* ,( 1"2 $#32 6'** 6#1" 1"2 DPWQD 2302 9*)$" 6#1" 1"2 @E\$ ,( 1"2
8'+L 6'**4 =($1'** JCK $#E &,/2 $#3#(0 -'(2*$4 =9 (2+2$$'/. +)1 *'$1 -'(2* 9*)$" 6#1" @E\$ ,( 9/,(1
6'**4%5$2%F3%0'*G4%8,E%('#*$%$-'+23%Fe%'-'/14
@4 =($1'**%'%$#3#(0%-'(2*%,(%1"2%8'+L%6'**%6#1"%1"2%DPWQD%2302%9*)$"%6#1"%1"2%$#3#(0%,(%1"2%$#32
6'**4%=($1'**%b%&,/2%-'(2*$4
LAP
Edge
Side Wall
Back Wall
Install This Panel First
b4 =($1'** $#3#(0 ,( ,--,$#12
$#32%6'**4
\4 =($1'**%'%9)**%6#31"%$#3#(0%-'(2*%,(%1"2%9/,(1%6'**%6#1"%1"2%DPWQD%2302%9*)$"%6#1"%1"2%$#3#(0
,(%1"2%$#32%6'**4%?)1%'(3%/2&,G2%'(.%$#3#(0%1"'1%2E12(3$%-'$1%1"2%3,,/%,-2(#(04
_4 P,+'12 J@K 16, B\[B^@e E \Fe $#3#(0 -'(2*$4 ?)1 1"2$2 1, 9#1 '8,G2 3,,/ ,-2(#(04 H'L2 $)/2
1"2$2%'/2%9*)$"%6#1"%8,11,&%,9%3,,/%"2'32/%'(3%2G2(%6#1"%1,-%,9%,1"2/%$#3#(04
Cut to Fit
C4 =($1'**%'(,1"2/%9)**%6#31"%$#3#(0%,(%1"2%/#0"1%$#32%,9%1"2%3,,/%,-2(#(04
]4 ?)1 '(3 /2&,G2 @E\ -*'12 1"'1 2E12(3$ '+/,$$ 1"2 3,,/ ,-2(#(04 <'G2 1"2 @E\7
#1%6#**%82%)$23%#(%'%*'12/%$12-4
LAP Edge Cut & remove
2x4 Plate

Step 12 Install Stairs
Steps not needed with this size and model.
Step 9 thru 11
IMPORTANT: Go now to the instructions in the stair kit book to install
the stairs, floor joist and flooring.

Step 13A Assemble Rear Gable
2x4 Block
B4 ?)1 J@K 16, @E\[BAD 8,'/3$ 1, ' *2(01" ,9 f][B^@e4 Q,$#1#,( 1"2$2 @E\$7 on edge '(3 8)11 1,021"2/4
@4 Q,$#1#,(%J@K%16,%FB[b^\e%*,(0%@EC$%'(3%J@K%16,%]B[b^Fe%*,(0%@EC%8,'/3$%,(%1"2%@E\%-*'12$%'$
$",6(%82*,64%!"2%1,-%@EC%8,'/3$%"'G2%8*)2%&'/L$%,(%1"2%2(3$4%Q,$#1#,(%1"2$2%2(3$%1,021"2/
'1%1"2%1,-4
Assemble the roof gables and trusses on the center of the loft floor. This
will make it easier to stand the gable upright over the lower wall.
2x4 Block
2x4 Block
71-3/8" Long
Truss Leg
2x4 On Edge
97-1/2" Long 2x4 On edge
188-1/2"
71-3/8" Long
Truss Leg
81-3/4" Long
Truss Top
Truss Knee
b4 <2+)/2 1"2 1/)$$ *20 1, 1"2 @E\ -*'12 6#1"
J@K%16,%@[B^@e%*,(0%32+L%$+/26$4
\4 =($1'** _[B^@e E B@e Y<; 9#**2/$ ,( 1"2 @EC
1/)$$ *20$ (2'/ @E\ 6#1" C3 +,&&,( ('#*$4
`E'+1%$-'+#(0%#$(D1%#&-,/1'(14
_4 <M)'/2
1/)$$4 H2'$)/2 3#'0,('**. 9/,& 1"2
L(22 ,9 1"2 @EC 1/)$$ 1, 1"2 8,11,& +,/(2/
,9 1"2 @E\ -*'124 !"2 &2'$)/2&2(1$ 6#** 82
1"2 $'&2 JBFF[B^@eK 6"2( 1"2 1/)$$ #$ $M)'/24
C4 ?)1 @E\ /2&,G23 9/,& 3,,/ ,-2(#(0 #(1,
Fe *,(0 8*,+L$4 !'+L ('#* ,/ $+/26 1"2 8*,+L$
'/,)(3 1"2 -2/#&212/ ,9 1"2 0'8*2 9/'&2 1,
-/2G2(1%1"2%0'8*2%9/,&%&,G#(04

B4 <2+)/2%1"2%@EC%8,'/3$%1,021"2/%'1%1"2%L(22%'(3%/#302%6#1"%B^@e%Y<;%0)$$21$4
5$2%C3%+,&&,(%('#*$4%d'#*%_[B^\e%E%B@e%Y<;%9#**2/$%6"2/2%$",6(%82*,64
@4 Q*'+2 J@K 16, FB[b^\e '(3 J@K 16, ]B[b^Fe @EC$ ,G2/ 1"2 9#**2/$4 <2+)/2 )$#(0 JCK $#E BA3 $#(L2/$
6"2/2%9#**2/$%'(3%0)$$21$%'/2%*,+'1234
b4 =($1'** ' @B[b^\e "#0" -/2[8)#*1 0'8*2 9/'&2 '1 1"2 -2'L ,9 1"2 3,)8*2 /,6 ,9 1/)$$2$4 <2+)/2 1"2
9/'&2%1,%1"2%@EC%1/)$$%8,'/3$%6#1"%JCK%$#E%@[B^@e%32+L%$+/26$4
\4 Q,$#1#,( ' Bf[B^\e -/2[8)#*1 9/'&2 3#/2+1*. 82*,6 1"2 1,- 9/'&24 5$2 J@K 16, FA[B^@e *,(0 $1)3$
1,%"2*-%'*#0(%1"2%)--2/%'(3%*,62/%9/'&2$4%5$2%'%9/'&#(0%$M)'/2%1,%2($)/2%1"2%$1)3$%'/2%-*)&84
<+/26 8,11,& 9/'&2 1, @E\ -*'12 )$#(0 @[B^@e $+/26$4 <2+)/2 1"2 FA[B^@e $1)3$ 1, 1"2 -/2[8)#*1
9/'&2$%)$#(0%@[B^@e%$+/26$4
Step 13B Assemble Rear Gable continued
C4 =($1'**%'%]@[_^Fe%'(3%'%C\[B^@e%6'**%$1)3%,(%1"2%*291%$#32%,9%1"2%0'8*2%9/'&24%5$2%'%$M)'/2%1,
2($)/2 1"2 $1)3$ '/2 -*)&84 d'#* 1, @E\ 8,11,& -*'12 6#1" BA3 $#(L2/$ '(3 $+/26 1, @EC$ 6#1"
@[B^@e%$+/26$4%:2-2'1%1,%#($1'**%$1)3$%,(%/#0"1%$#32%,9%0'8*2%9/'&24
1/2" Gusset
at Ridge
1/2" Gusset
at Knee
_4 P,+'12%JbK%1"/22%\][b^\e
*,(0%@E\$%'(3%1/#&%1,%9#1
'(3 #($1'** 821622( 9/'&2$4
cut to fit
Studs
Framing
Square
Framing
Square
64-1/2"
Stud
72-5/8"
Stud
Framing
Square
80-1/2"
Stud
19-1/4" High Pre-built Frame
5-1/4" x 12"
OSB Filler
5/1/4" x 12"
OSB Gusset
Two Ridge Gussets have equal angles cuts. Four Knee Gussets have offset angles cuts.
21-3/4" High Pre-built Frame

16' Rear Wall
Siding Extends 3/4" Below Bottom Plate
Siding Cutoff
Step 14 Install Siding on Rear Gable Frame
16' Rear Wall Side
Wall
1x4 Corner Trim
Step 15 Install Trim on Front and Back Walls
IMPORTANT: Trim Must Be Installed Before Installing Roof Gables!
B4 P,+'12%J\K%9,)/%B[B^@e%E%\F[b^\e%$#3#(0%9#**2/%$1/#-$4%=($1'**%1"2$2%,(%8'+L%6'**%9*)$"%6#1"%1,-%,9
9*,,/#(04 !"2/2 &'. 82 ' 0'- 821622( 1,- ,9 $#3#(0 '(3 $1/#-$4 5$2 ' 926 F3 0'*G4 ('#*$4 W33#1#,('*
('#*$%'/2%'--*#23%82*,64
@4 ?)1%'(3%#($1'**%J@K%16,%BE\%[BAD%1/#&%8,'/3$%9*)$"%6#1"%1,-%,9%9*,,/%'(3%8,11,&%,9%1"2%$#3#(04
=($1'**%1/#&%9*)$"%6#1"%1"2%$#3#(0%,(%1"2%$#32%6'**$4%5$2%F3%0'*G4%('#*$%$-'+23%B@e%'-'/14
1x4 Trim
b4 =($1'**%J@K%16,%fCe%*,(0%BE\%1/#&
8,'/3$ 821622( +,/(2/ 8,'/3$4 !/#&
$",)*3%82%9*)$"%6#1"%1"2%*,91%9*,,/4
?)1%@(3%8,'/3%1,%9#14
\4 :2-2'1%1,%#($1'**%1/#&%1,%1"2%9/,(1
6'**%-'(2*4
Siding Filler
\4 =($1'**%FA[B^@e%*,(0%$#3#(0%-'(2*4
?)1 1"2 $#3#(0 1"'1 2E12(3$ 82.,(3
1"2%0'8*2%9'&24
B4 <1'(3%)-%1"2%0'8*2%9/'&2%'(3%$*#32%#1%1,%1"2%/2'/%,9%1"2%8)#*3#(04%Q,$#1#,(%1"2%9/'&2%6#1"%1"2
8,11,&%1,6'/3$%1"2%/2'/%6'**%$,%#1%+'(%82%2/2+123%'912/%1"2%$#3#(0%#$%'--*#234
@ =($1'** ' -/2[+)1 $#3#(0 -'(2* 6#1" 1"2 D+)1 2302D 9*)$" 6#1" 1"2 *291 $#32 ,9 1"2 0'8*2 9/'&24 !"2
$#3#(0 $",)*3 2E12(3 b^\e 82*,6 1"2 8,11,& @E\ 0'8*2 -*'124 =($1'** $#3#(0 6#1" F3 0'*G4 ('#*$4
b =($1'** J@K 16, \EF $#3#(0 -'(2*$4 ?)1 '(3
/2&,G2%$#3#(0%1"'1%2E12(3$%'8,G2%1"2%1,-
,9%1"2%0'8*2%9/'&24
Siding Flush with Frame
All trim is installed using 8d galvanized box nails spaced 12" apart.

;29,/2 8/'+#(0 1"2 G2/1#+'* @E\$ #( -*'+2 '11'+"
J@K%16,%@E\%8*,+L$%1,%1"2%8'+L%,9%1"2%@E\$4
!"#$%6#**%+/2'12%1"2%-/,-2/%$-'+#(0%1,%$21%1"2
0'8*2%,G2/%1"2%*,62/%6'**4
2x4 Stake
2x4-12' Brace
2x4 Block
2x4-12' Vertical Boards
2x4 Block
2x4-12'
\4 d'#*%8,11,&%2302%,9%$#3#(0%1,%BE\%1/#&
6#1"%F3%0'*G'(#Z23%8,E%('#*$4
Siding Extends Over
Trim. Paint edge
Step 16 Install Rear Roof Gable
@4 `/2+1 1"2 0'8*2 ,( 8'+L 6'**4 ;2 +')1#,)$ '(3 2($)/2 0'8*2 $#3#(0 2E12(3$ ,G2/ 1/#& ,( 8'+L
6'**4 ?2(12/ 0'8*2 6#1" 8,11,& @E\ 2E12(3#(0 B[B^@e -'$1 *,62/ 6'** @E\$ ,( 8,1" $#32$4 d'#*
1,%9*,,/%)$#(0%BA3%$#(L2/$4
b4 :2&,G2 1"2 6'** 8/'+2$ 9/,& #(12/#,/ 6'**$ '(3 )$2 1"2& 1, 8/'+2 1"2 0'8*2 1, 1"2 *,91 9*,,/4
Brace Gable with
Pre-cut Studs
B4 =($1'**%J@K%16,%@E\[B@D%8,'/3$%,(%1"2%8'+L%6'**%1,%-/2G2(1
1"2%0'8*2%9/,&%9'**#(0%,99%3)/#(0%0'8*2%#($1'**'1#,(4%=($1'**
J@K 16, &,/2 @E\[B@ 8,'/3$ 1, 8/'+2 1"2 G2/1#+'* @E\ #( -*'+24

floor
2x4 Tie Plate
2x6 Truss Plate
2x4 Top Plate
2x4 Wall Stud
1-1/2"
19-3/8"
24"
2x6 Truss Plate
:2'/%T'8*2
@EC%Q*'12%,(%<#32%a'**
24"
19-3/8" 24" 24" 24" 24"
@4 <*#32 0'8*2 1, 1"2 9/,(1 ,9 1"2 8)#*3#(04
Q,$#1#,( 1"2 9/'&2 6#1" 1"2 8,11,& 1,6'/3$
1"2 9/,(1 6'** $, #1 +'( 82 2/2+123 '912/ 1"2
$#3#(0 #$ '--*#234
b4 :2-2'1 Step 14 1, '--*. 0'8*2 $#3#(04 ?)1 '(3
/2&,G2 $#3#(0 9/,& 1"2 6#(3,6 ,-2(#(04
\4 :2&,G2 1"2 @E\[B@D 8,'/3$ )$23 9,/ 8/'+#(0
,( 8'+L 0'8*2 '(3 /2-2'1 Step 16 1, #($1'**
1"2 9/,(1 0'8*24
B4 :2-2'1%Step 13 1,%'$$2&8*2%9/,(1%0'8*24%W*12/%$1)3%9/'&#(0%9,/%6#(3,6%,-2(#(04%P,+'12%JbK
1"/22%\][b^\e%*,(0%@E\$4%?)1%JBK%,(2%1,%bCe4%Q,$#1#,(%1"2$2%8,'/3$%'$%$",6(%82*,64%H2'$)/2
3#$1'(+2 1, 8,11,& 0'8*2 9/'&2 '(3 +)1 JbK 1"/22 @E\$ 1, 1"#$ *2(01" '(3 #($1'** )(32/ bCe 8,'/34
=($1'**%@E\$%6#1"%BA3%$#(L2/$4
36"
Step 17 Assemble & Install Front Gable
B4 =($1'**%JbK%1"/22%@EC[]D%'(3%JBK%,(2%@EC[FD%'$%1/)$$%-*'12$%821622(%1"2%9/,(1%'(3%/2'/%0'8*2
6'**%-'(2*$%,(%2'+"%$#32%6'**4%?)1%1"2%*'$1%@EC%1,%9#14%!"2%@EC%-*'12$%$",)*3%-/,N2+1%B[B^@e
-'$1%1"2%@E\%1#2%-*'12%J$22%R21'#*%DWDK4%d'#*%@EC$%1,%1"2%9*,,/%6#1"%BA3%+,'123%$#(L2/%('#*$h
3,)8*2%/,6%$-'+23%BCe%'-'/14
@4 <1'/1#(0 '1 1"2 /2'/ 0'8*2 #(3#+'12 6#1" DgD &'/L$ 6"2/2 1"2 1/)$$2$ 6#** 82 *,+'1234 !"2 *'$1
$-'+2%6#**%82%6#32/%1"'(%1"2%9#/$1%JBf[b^FeK%$-'+24
Step 18 Install 2x6 Truss Plates
Detail 'A'
:2'/%T'8*2
S/,(1%T'8*2
47-3/4"
Long 2x4
36" Long
2x4
Cut to Fit
Do not remove 2x4 blocks from floor.
They will be used to assemble trusses.

Step 19 Install 2x6 Soffit Blocks
B4 =($1'** J\K 9,)/ BEb[FD $1/#--#(0 ,( 2'+" $#32 6'**4 <1'/1#(0 9/,&
8'+L 6'** 8)11 ' @EC $,99#1 8*,+L '0'#($1 1"2 8,11,& ,9 1"2 @EC 1/)$$
-*'124 Q,$#1#,( 1"2 9#/$1 BEb 8,'/3 B[B^@e 9/,& 8'+L 6'** 1/#& '(3
#(1, (,1+"4 Tip; use a 2x4 block as a gauge to set the 1x3 correctly4
?,(1#()2 )$#(0 1"2 @EC $,99#1 8*,+L '$ ' 0')02 6"2( #($1'**#(0 (2E1
BEb 8,'/3$4 ?)1 1"2 *'$1 8,'/3 1, 9#1 B[B^@e 9/,& 9/,(1 0'8*2 1/#&4
5$2%]3%$#(L2/$%('#*#(0%6"2/2%$1)3$%'/2%*,+'1234
b4 =($1'**%'%3,)8*2%@EC%$,99#1%8*,+L
)(32/ 1"2 0'8*2 -'(2* '1 2'+" +,/(2/4
=($1'**%1"2$2%8*,+L$%9*)$"%6#1"%1"2
9'+2%,9%1"2%0'8*2%$#3#(04
1x3 Stripping
2x6 Soffit Block
2x6 Truss Plate
@4 =($1'**%$,99#1%8*,+L$%)(32/%2'+"%DgD%,(%1"2%1/)$$%-*'124<2+)/2%1"2%1,-%,9%1"2%$,99#1%8*,+L$%#(
-*'+2%8.%$+/26#(0%1"/,)0"%1"2%@EC%#(1,%1"2%$,99#1%8*,+L%6#1"%@[B^@e%32+L%$+/26$4%R/#**%'
B^Fe%3#'&212/%",*2%1,%-/2G2(1%1"2%6,,3%9/,&%$-*#11#(04
\4 <2+)/2%1"2%$,99#1%8*,+L$%#(%-*'+2
6#1" @[B^@e 32+L $+/26$4 R/#** ' ",*2
1,%-/2G2(1%1"2%6,,3%9/,&%$-*#11#(04
!"2 8,11,& ,9 8*,+L$ 6#** 82 $2+)/23
#(%'%*'12/%$12-4
2x4 Gauge Block 1x4 Corner
Trim
Install 2x4 Double Block
Flush with Gable Siding
'X' Marks