Reynolds Building Systems West Virginia 16'x20' Safety guide

!"#$%&'()'*%#$%+,-./#0"1234%5(32/%1"2%+,-./#0"1%*'6$7%1"#$%&'()'*
&'. (,1 82 +,-#237 #( 6",*2 ,/ #( -'/17 6#1",)1 +,($2(1 9/,& :2.(,*3$
;)#*3#(0%<.$12&$7%=(+4 >%%?,-./#0"1%@A@A
Assembly Book
West Virginia
Manufactured by Reynolds Building Systems, Inc.
205 Arlington Drive Greenville, PA 16125
Sentry Buildings
:2B#$23%C'/+"%D7%@A@@
EFGH@AG%;)#*3#(0

I,)%6#**%(223%1,%/2(1%JFK%$#H%$2+1#,($%,9%$+'99,*3#(0%1,%$'92*.%#($1'**%1"2%$2+,(3%9*,,/%&'12/#'*4
5$2%$'921.%"'/(2$$2$%6"2(%,(%1"2%$+'99,*3#(04%?,($#32/%"#/#(0%'%-/,92$$#,('*%/,,92/%1,%#($1'**
1"2%$"#(0*2$%,/%&21'*%/,,94%%!"2.%"'B2%1"2%L(,6*2302%'(3%2M)#-&2(1%1,%3,%1"2%N,8%-/,-2/*.4
IMPORTANT INFORMATION ABOUT YOUR KIT
*
Tools
Required:
!%O'(3%,/%?#/+)*'/%<'6 !P2B2* !Q"#**#-$%<+/263/#B2/
!?,/3*2$$%R/#** !C2'$)/#(0%!'-2 !S/'&#(0%<M)'/2
!?')*L#(0%T)( !UG%V%EAG%P'332/J$K !O'&&2/
!<'921.0*'$$2$W%X*6'.$%62'/%$'921.%0*'$$2$%6"2(%+)11#(0%,/%('#*#(0Y
!*%<+'99,*3#(0
Building Permits: ?"2+L 6#1" .,)/ *,+'* OZX ,/ 8)#*3#(0 +,32 ,99#+2 9,/ '(. /2M)#/2&2(1$7
/2$1/#+1#,($%,/%-2/&#1$%(2+2$$'/.%9,/%+,($1/)+1#,(4
Foundation: ;.%,6(2/4%:292/%1,%(2H1%-'02%9,/%9,)(3'1#,(%$)002$1#,($%'(3%$#[24
What's Included: Z)/ -'+L'02 #(+*)32$ -/2\+)1 &'12/#'*$ 9,/ 1"2 @(3 9*,,/ /,,9 0'8*2$7 /,,9
1/)$$2$ '(3 0'8*2 1/#&4 !6, $#(0*2 ")(0 #($)*'123 6#(3,6$ 6#1" 1/#& '(3 B#(.* $")112/$4 !"#$
&'12/#'* #$ 32*#B2/237 curb side in covered van7 ,( 16, ]GH^G -'**21$4 <22 8'+L -'02 9,/ &'12/#'*
*#$14 !"2 ('#*$ '(3 "'/36'/2 (2+2$$'/. 1, +,($1/)+1 1"2 *,62/ 6'**$ '/2 -'+L23 #( 1"2 1,- ,9 GXG
-'**214 !"2 ,1"2/ &'12/#'*$ ,( 1"2 -'**21 6#** (,1 82 )$23 )(1#* 1"2 9#/$1 9*,,/ 6'**$ '(3 *,91 9*,,/
'/2%+,&-*21234
S/'&#(0 *)&82/ 9,/ 1"2 9#/$1 9*,,/ 6'**$ '(3 *,91 9*,,/7 2H12/#,/ $#3#(07 *,91 9*,,/#(0 '(3 /,,9
$"2'1"#(0 6#** 82 32*#B2/23 8. ' *,+'* $)--*#2/4 !"#$ 6#** 82 ' $2-'/'12 32*#B2/. '(3 .,) 6#** 82
(,1#9#23 829,/2 1"'1 32*#B2/. 1'L2$ -*'+24 C'12/#'* #$ *#$123 ,( 1"2 8'+L -'02$4 <,&2,(2 6#** (223
1,%$#0(%9,/%8,1"%32*#B2/#2$4
Owner Supplied: ZB2/"2'3 UG H F_F 0'/'02 3,,/ 6#1" *,6 "2'3/,,& "'/36'/24 :,,9 $"#(0*2$7
&21'* /,,9 23027 92*1 '(3 B2(1#*'1#,( '++2$$,/#2$4 Q'#(1 9,/ $#3#(0 '(3 1/#&4 X33#1#,('* *)&82/ 9,/
9/'&#(0%'33#1#,('*%6#(3,6%'(3%3,,/%,-2(#(0$4
Assembly Help: C,(3'.%1"/)%S/#3'. UAA\@]`\E`^^ UWAA%1,%`WAA%a!
b22L2(3%\%'912/%",)/$ ^@]\UFF\]D`^
2&'#*%1,W%%questionscbarnkits.com
Care of product prior to assembly: R, (, 2H-,$2 *)&82/ '(3 $"221 0,,3$ 1, #(+*2&2(1 62'1"2/4
X$$2&8*. $",)*3 820#( -/,&-1*. 1, -/2B2(1 1"2 16#$1#(0 ,9 *)&82/4 d,1#9. ,)/ +,&-'(. 6#1"#(
DA%3'.$%,9%'(.%3'&'02%,/%&#$$#(0%#12&$%9,/%9)**%/2-*'+2&2(14
Building Tips: S,**,6 1"2 '$$2&8*. <12-$ #( $2M)2(+24 <L#--#(0 $12-$ 6#** /2$)*1 #( +,&-,(2(1$
(,1 9#11#(0 -/,-2/*.4 !"2 ('#*$7 "'/36'/2 '(3 "2'32/ &'12/#'* (22323 1, '$$2&8*2 1"2 *,62/ 6'**$
'(3 *,91 9*,,/ '/2 -'+L'023 ,( 1"2 1,- ,9 -'**21 GXG4 !"2 ,1"2/ &'12/#'*$ ,( 1"2 -'**21 6#** (,1 82
)$23%)(1#*%1"2%9#/$1%9*,,/%6'**$%'(3%*,91%9*,,/%'/2%+,&-*21234

Foundation Types & Measurements
ImportantW I,) 6#** (223 1, "'B2 ' -/,-2/ 9,)(3'1#,( #($1'**23 1, $)--,/1 1"2 8)#*3#(04
R2-2(3#(0%,(%1"2%#(12(323%)$2%3212/&#(2$%6"'1%1.-2%,9%9,)(3'1#,(%#$%82$14
Do Not &'L2 1"2 9,)(3'1#,( *'/02/ 1"'( 1"2 8)#*3#(0 $#[24 b"2( #($1'**#(0 1"2 8)#*3#(0
,( ' +,(+/212 $*'87 #($1'** 1"2 $#3#(0 9*)$" 6#1" 1"2 8,11,& -*'124 b"2( #($1'**#(0 ,( ' 6,,3
9*,,/7 2H12(3 1"2 $#3#(0 D_]e 82*,6 1"2 8,11,& -*'12 1, +,B2/ 1"2 2302 ,9 1"2 9*,,/#(04
b,,3%S*,,/%,(%:)((2/$W%%<)#1'8*2%9,/%$1,/'02
,/%6,/L$",-4%!/2'123%FHF%*)&82/%,B2/%'%823
,9%0/'B2*%S*,,/%N,#$1%$",)*3%82%1/2'123%@HF
$-'+23%EFe%,(%+2(12/%'(3%+,B2/23%6#1"%D_]e
1,(0)2%'(3%0/,,B2%6,,3%9*,,/#(04
Foundation TypesW b"'1 9,)(3'1#,( #$ 82$1 32-2(3$ ,( 6"'1 1.-2 ,9 #12&$ 6#** 82 $1,/234
!"2 8)#*3#(0 +,32 #( .,)/ '/2' 6#** '*$, 3212/&#(2 6"'1 1.-2 ,9 9,)(3'1#,( +'( 82 )$234
X 926 3#992/2(1 1.-2$ ,9 9,)(3'1#,($ '/2 $",6( 82*,64 ?"2+L 1"2 [,(#(0 '(3 8)#*3#(0 +,32
/2M)#/2&2(1$%#(%.,)/%'/2'4
LP siding "'$%'%`A%.2'/%6'//'(1.%'(3%#$%'*/2'3.%-/#&234
X--*. 16, +,'1$ ,9 *'12H '+/.*#+ -'#(1 9,/ 1"2 9#(#$" +,'14
Q'#(1 1"2 8,11,& 2302 ,9 1"2 $#3#(07 this is important4
C'#(1'#( Fe 1, Ue ,9 +*2'/'(+2 9/,& 1"2 8,11,& 2302 ,9
1"2 $#3#(0 '(3 1"2 0/,)(34 R,(G1 '**,6 0'/32( &)*+" 1,
8)#*3 )- '(3 L22- $"/)8$ ' &#(#&)& ,9 EG '6'. 9/,& 1"2
8)#*3#(04
Wood Floor on Wood Runners
Floating Cement Slab
Foundations Types
S*,'1#(0%<*'8%%X%+,(+/212%$*'8%#$%#32'*
9,/%$1,/'02%,9%+'/$%,/%,1"2/%1.-2$%,9
"2'B.%#12&$4
Exterior Siding Information
Tongue Edge
LAP Edge

W
WWWWWW
Pre-cut 2x4
Wall Studs
E4 <2*2+1%J@K%16,%@H]\UG%J,(2%6#**%82%1/2'123K%#9%(2+2$$'/.%1/#&%1,%'%*2(01"%,9%fFe4%Q,$#1#,(%1"2
8,'/3$%1,021"2/%'(3%#(3#+'12%6#1"%GgG%%&'/L$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234
Stud Spacing
XX
X X
X
X
X
X
96" Top Wall Plate
96" Treated Bottom Plate
16"
15-1/4" 16"
Step 2A Assemble (2) Two 8' Side Wall Frames
Step 1 Assemble (2) Two 92-1/2" Rear Wall Frames
D4 :2-2'1%1,%8)#*3%'(,1"2/%f@\E_@e%*,(0%6'**%9/'&24
]4 C'/L%8,1"%9/'&2$%GRear Wall Frames'%'(3%$21%9/'&2$%'$#324
Treated Bottom Plate
E4 ?)1 J@K 16, @H]\UG J,(2 6#** 82 1/2'123K 1, ' *2(01" ,9 f@\E_@e4 Q,$#1#,( 1"2 8,'/3$ 1,021"2/
'(3%#(3#+'12%6#1"%GgG%%&'/L$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234
@4 C'/L%'%G?G%'(.6"2/2%821622(%9#/$1%16,%$1)3%&'/L$4%!"#$%#$%/292/2(+23%#(%'%*'12/%$12-4
Note: When building the lower walls, use
treated 2x4s for the bottom wall plates.
@4 =($1'**%J^K%$2B2(%-/2\+)1%6'**%$1)3$%821622(%1"2%1,-%'(3%8,11,&%-*'12$4%%d'#*%1"2
1/2'123%8,11,&%-*'12%1,%2'+"%6'**%$1)3%6#1"%J@K%16,%EF3%0'*B'(#[23%32+L%('#*$4
5$2%J@K%16,%EA3%+,'123%$#(L2/%('#*$%-2/%$1)3%1,%$2+)/2%1"2%1,-%-*'124
The length of pre-cut wall studs will vary from 92-1/4" to
93" depending on your locality.
Stud Spacing
XX
X X
X
X
X
X
92-1/2 Top Wall Plate
92-1/2" Treated Bottom Plate
16"
11-3/4" 16"
C
C

W
WWWWWW
Pre-cut 2x4
Wall Studs
If you are adding additional windows or doors, frame-in rough opening(s)
per manufacturer's instructions.
@4 =($1'** J^K $2B2( -/2\+)1 6'** $1)3$ 821622( 1"2 1,- '(3 8,11,& -*'12$4 d'#* 1"2 1/2'123 8,11,&
-*'12%1,%2'+"%6'**%$1)3%6#1"%J@K%16,%EF3%0'*B'(#[23%32+L%('#*$4%5$2%J@K%16,%EA3%+,'123%$#(L2/
('#*$%-2/%$1)3%1,%$2+)/2%1"2%1,-%-*'124
D4 :2-2'1%1,%8)#*3%JEK%,(2%&,/2%UG%*,(0%6'**%9/'&24
]4 C'/L%8,1"%9/'&2$%GSide Wall Frames'%'(3%$21%9/'&2$%'$#324
Step 2B Assemble (2) Two 8' Side Wall Frames continued
Step 3 Assemble Door Header
Treated Bottom Plate
99" Long 2x8
48" OSB Filler
W
W
W
W
W
W
GLUE
E4 ?)1%J@K%16,%EAG%*,(0%@HU%8,'/3$%1,%'%*2(01"%,9%ffe4
@4 P,+'12%'%@]e%H%]Ue%%Z<;%J,/#2(123%$1/'(3%8,'/3K%-'(2*%-'+L23%#(%,)/%L#14%?)1%J@K%16,
^\E_@e%H%]Ue%9#**2/$%1,%9#1%821622(%1"2%@HU%8,'/3$4
D4 X--*. 6,,3 0*)2 1, 8,1" $#32$ ,9 2'+" Z<; 9#**2/ 6#1" ' 8/)$" '(3 #($1'** #( 1"2 +2(12/
,9 1"2 @HU 8,'/3$4 d'#* 1,021"2/ )$#(0 EA3 +,'123 $#(L2/$4 5$2 JE@K 162*B2 ('#*$ $-'+23
2B2(*.%,(%2'+"%$#324
99" Long 2x8
OSB 1-1/2"
from End

Stud Spacing
X
X
X
X
X
X
X
X
Pre-cut 2x4
Wall Studs
E4 !/#&7 if necessary7 J@K 16, @H]\E@G 8,'/3$ J,(2 6#** 82 1/2'123K 1, ' *2(01" ,9 E]]e4 Q,$#1#,( 1"2
8,'/3$%1,021"2/%'(3%#(3#+'12%6#1"%GgG%&'/L$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'1234
Step 4 Assemble (2) Two 12' Side Wall Frames
144" Top Wall Plate
144" Treated Bottom Plate
16"
15-1/4" 16"
@4 =($1'** JEAK 12( -/2\+)1 6'** $1)3$ 821622( 1"2 1,- '(3 8,11,& -*'12$4 d'#* 1"2 1/2'123
8,11,&%-*'12%1,%2'+"%6'**%$1)3%6#1"%J@K%16,%EF3%0'*B'(#[23%32+L%('#*$4%5$2%J@K%16,
EA3%+,'123%$#(L2/%('#*$%-2/%$1)3%1,%$2+)/2%1"2%1,-%-*'124
D4 :2-2'1%1,%8)#*3%'(,1"2/%E]]e%*,(0%6'**%9/'&24
]4 C'/L%8,1"%9/'&2$%GSide Wall Frames'%'(3%$21%9/'&2$%'$#324
Treated Bottom Plate

When setting the wall panels the door opening can be positioned on the right,
as shown below, or reverse framing to position on the left end of the wall.
X
X
XX
X
X
XX
SS
X
X
X
X
Step 5 Assemble 15'-5" Front wall Door Frame
2x8 Door Header
2x4-15'-5" Treated
Bottom Plate
2x4-15'-5"
Top Plate
@4 X$$2&8*2 1"2 9/,(1 6'** 9/'&2 )$#(0 1"2 6'** -*'12$ +)1 '8,B2 '(3 #($1'**#(0 JFK $#H -/2\+)1 6'**
$1)3$%,B2/%1"2%GgG%&'/L$4
D4 ?)1%J@K%16,%-/2\+)1%$1)3$%1,%'%*2(01"%,9%U@e%'(3%#($1'**%1"2&%'$%"2'32/%$)--,/1$%)$#(0%JEAK%12(
EA3 $#(L2/$4 =($1'** 1"2 @HU "2'32/ 8. 1,2\('#*#(0 1"2 2(3$ 1, 1"2 '3N'+2(1 $1)3$ 6#1" EA3 $#(L2/$4
]4 ?)1 J`K 9#B2 -#2+2$ 9/,& ' -/2\+)1 $1)3 1, 9#1 821622( "2'32/ '(3 1,- @H] -*'124 =($1'** 6#1" EA3
$#(L2/$%1"/,)0"%1,-%-*'12%'(3%1,2('#*%#(1,%"2'32/4%<'B2%+)1,99%9,/%(2H1%$12-4
`4 P,+'12%'%@^e%*,(0%-/2\8)#*1%@H]%6#(3,6%"2'32/%'(3%JFK%$#H%]Ae%*,(0%@H]$4%?)1%JEK%,(2%,9%1"2
]Ae *,(0 @H] 1, ' *2(01" ,9 @^e '(3 #($1'** '$ ' $#** -*'12 '$ $",6( 82*,64 5$2 JDK 1"/22 ]Ae *,(0
@H]$%'$%6#(3,6%N'+L$%)(32/%$#**%-*'12%J16, 6#** 82 $#32 8. $#32K4%?)1%J@K%16,%]Ae%*,(0%@H]$%1,
DFe '(3 #($1'** '$ "2'32/ $)--,/1$ '$ $",6(4 ?)1 9/,& @H] +)11,99 JDK 1"/22 -#2+2$ 1, 9#1 821622(
"2'32/%'(3%1,-%@H]%-*'124%J16,%6#**%82%$#32%8.%$#32K
E4 ?)1%J@K%16,%@H]\EFG%J,(2%6#**%82%1/2'123K%1,%'%*2(01"%,9%EU`e4%Q,$#1#,(%1"2%8,'/3$%1,021"2/%'(3
#(3#+'12%6#1"%GgG%%&'/L$%6"2/2%1"2%6'**%$1)3$%6#**%82%*,+'123%'(3%'(%G<G%6"2/2%1"2%3,,/%"2'32/
$)--,/1%$1)3$%6#**%82%*,+'12344
2x4 Header Blocking
2x4 Header
2x4 - 36"
Supports
2x4 - 27"
Sill Plate
2x4 - 40"
Window
Jacks
15' - 5" Wall Plates
28-1/2"
17-1/2" 17-1/2"
Treated
Regular
19-1/2" 96" Door Opening
99" Door Header
Cut 2x4
Blocks to Fit
2x4 Header
Support Studs

15'-5" Front Wall Frame
12' Side Wall Frame
Step 6 Set Wall Frames
E4 =($1'** ,(2 ,9 1"2 f@\E_@e /2'/ 6'** 9/'&2$ '0'#($1 #($#32 ,9 ' UG $#32 6'** 9/'&24 IMPORTANT:
Z/#2(1 2(3 &'/L23 6#1" ' G?G 1, +,/(2/4 <2+)/2 9/'&2$ 1,021"2/ '1 1"2 +,/(2/ )$#(0 J]K 9,)/ EA3
$#(L2/$4%;/'+2%6'**$%6#1"%-/2\+)1%$1)3$4
@4 =($1'** 1"2 ,1"2/ f@\E_@e /2'/ 6'** 9/'&2 1, 1"2 /2'/ 6'** 9/'&24 d'#* 1"2 /2'/ 6'** 9/'&2$ 1,021"2/
6"2/2%1"2.%8)11%6#1"%JUK%2#0"1%EA3%$#(L2/%J$1'002/%('#*$%,(%2'+"%$#32%,9%1"2%$1)3$K%4
D4 =($1'**%,(2%,9%1"2%E@G %*,(0%9/'&2%(2H1%1,%1"2%UG%$#32%6'**%9/'&24%<2+)/2%6#1"%EA3%$#(L2/$4
92-1/2" End Wall Frames
8' Side Wall Frame
Brace wall frames with
pre-cut wall studs.
End Marked 'C'
End Marked 'C'
]4 =($1'**%,--,$#12%$#32%6'**%9/'&2$4
` =($1'** 1"2 9/,(1 6'** 9/'&2 821622(
1"2%$#32%6'**%9/'&2$4%<2+)/2%9/'&2$
1,021"2/ '1 1"2 +,/(2/ )$#(0 J]K 9,)/
EA3%$#(L2/$4
F4 d'#*%9/'&2$%1,%1"2%9*,,/%)$#(0%EF3
T'*B4 $-#/'* ('#*$ ,/7 #9 2/2+1#(0 ,( '
+2&2(1%$*'87%+,(+/212%'(+",/%8,*1$
Jnot includedK $-'+23 @]e ,( +2(12/4
R, (,1 ('#* 1"2 @H] -*'12 #( 1"2 3,,/
,-2(#(04
Front and back wall frames are positioned between long side walls.
12' Side Wall Frame

If a siding panel has a damaged edge, install this edge at a corner where it will be
covered with corner trim.
?,(+/212%<*'8%S,)(3'1#,(W =($1'**%$#3#(0%9*)$"%6#1"%1"2%8,11,&%-*'124
b,,3%S*,,/%S,)(3'1#,(W aH12(3 1"2 $#3#(0 D_]e 82*,6 1"2 8,11,& -*'124
Step 7 Install 2x4 Tie Plates
16' Long 2x4 Tie Plate
Back Wall Frames
E4 =($1'**%'%EFG%*,(0%@H]%,(%1"2%8'+L%6'**4%5$2%EA3%$#(L2/$%$-'+2%EFe%'-'/1%1,%$2+)/2%1#2%-*'12$4
@4 :2-2'1%1,%#($1'**%'%EFG%*,(0%@H]%1#2%-*'12%,(%1"2%,--,$#12%9/,(1%6'**4
Step 8A Install Siding on Wall Frames
8' Long 2x4 Tie Plate
LP siding "'$%'%`A%.2'/%6'//'(1.%'(3%#$%'*/2'3.%-/#&234
X--*. 16, +,'1$ ,9 *'12H '+/.*#+ -'#(1 9,/ 1"2 9#(#$" +,'14
Q'#(1 1"2 8,11,& 2302 ,9 1"2 $#3#(07 this is important4
C'#(1'#( Fe 1, Ue ,9 +*2'/'(+2 9/,& 1"2 8,11,& 2302 ,9
1"2 $#3#(0 '(3 1"2 0/,)(34 R,(G1 '**,6 0'/32( &)*+" 1,
8)#*3 )- '(3 L22- $"/)8$ ' &#(#&)& ,9 EG '6'. 9/,& 1"2
8)#*3#(04
Exterior Siding Information
D4 =($1'**%'%@H]\E@G%8,'/3%,(%1"2%$#32%6'**%9/'&24%!"2%@H]%$#32%6'**%1#2%-*'12%6#**%8)11%'0'#($1
1"2%EFG%*,(0%1#2%-*'12%'1%1"2%8'+L%6'**4%5$2%EA3%$#(L2/$4
]4 ?)1%1,%9#1%'(3%#($1'**%'%@H]\UG%8,'/3%,(%1"2%$'&2%$#32%6'**%9/'&24
`4 :2-2'1%1,%#($1'**%@H]%1#2%-*'12$%,(%1"2%,--,$#12%$#32%6'**%9/'&2$4
Tongue Edge
LAP Edge

E4 =($1'** ' 9)** 6#31" $#3#(0 -'(2* ,( 1"2 $#32 6'** 6#1" 1"2 GPXQG 2302 9*)$" 6#1" 1"2 @H]$ ,( 1"2
8'+L%6'**4%=($1'**%J]K%9,)/%&,/2%$#3#(0%-'(2*$4%=9%(2+2$$'/.%+)1%*'$1%-'(2*%9*)$"%6#1"%@H]$%,(
9/,(1%6'**4%5$2%U3%0'*B4%8,H%('#*$%$-'+23%Ue%'-'/14
@4 =($1'** ' $#3#(0 -'(2* ,( 1"2 8'+L 6'** 6#1" 1"2 GPXQG 2302 9*)$" 6#1" 1"2 $#3#(0 ,( 1"2 $#32
6'**4%=($1'**%D%&,/2%-'(2*$4
LAP
Edge
Side Wall
Back Wall
Install This Panel First
Step 8B Install Siding on Wall Frames continued
D4 =($1'** $#3#(0 ,( ,--,$#12
$#32%6'**4
Cut & remove
2x4 Plate
]4 C2'$)/#(0%9/,&%1"2%G1,(0)2G%23027%+)1%'%$#3#(0%-'(2*%1,%'%6#31"%,9%@Ue4%=($1'**%1"#$%$#3#(0
-'(2*%,(%1"2%9/,(1%6'**%6#1"%1"2%G+)1G%2302%9*)$"%6#1"%1"2%$#3#(0%,(%1"2%$#32%6'**4%?)1%'(3
/2&,B2%1"2%$#3#(0%1"'1%2H12(3$%,B2/%1"2%6#(3,6%,-2(#(04
`4 =($1'**%'%]HU%$#3#(0%-'(2*4%:2&,B2%$#3#(0
1"'1%2H12(3$%,B2/%1"2%6#(3,6%,-2(#(04
F4 P,+'12 J@K 16, E]\E_@e H ]Ue $#3#(0 -'(2*$4
?)1%1"2$2%1,%9#1%'8,B2%3,,/%,-2(#(07%9*)$"
6#1"%8,11,&%,9%3,,/%"2'32/4
^4 =($1'**%1"2%/2&'#(#(0%$#3#(0%-'(2*%,(%1"2
6'**%9/'&24
U4 ?)1 '(3 /2&,B2 @H] -*'12 1"'1 2H12(3$ '+/,$$
1"2%3,,/%,-2(#(04%<'B2%1"2%@H]7%#1%6#**%82
)$23%#(%'%*'12/%$12-4
Cut Edge

Step 12 Install Stairs
Steps not needed with this size and model.
Step 9 thru 11
IMPORTANT: Go now to the instructions in the stair kit book to install
the stairs, floor joist and flooring.

Step 13A Assemble Rear Gable
2x4 Block
E4 ?)1 J@K 16, @H]\EAG 8,'/3$ 1, ' *2(01" ,9 f^\E_@e4 Q,$#1#,( 1"2$2 @H]$7 on edge '(3 8)11 1,021"2/4
@4 Q,$#1#,(%J@K%16,%UE\D_]e%*,(0%@HF$%'(3%J@K%16,%^E\D_Ue%*,(0%@HF%8,'/3$%,(%1"2%@H]%-*'12$%'$
$",6(%82*,64%!"2%1,-%@HF%8,'/3$%"'B2%8*)2%&'/L$%,(%1"2%2(3$4%Q,$#1#,(%1"2$2%2(3$%1,021"2/
'1%1"2%1,-4
Assemble the roof gables and trusses on the center of the loft floor. This
will make it easier to stand the gable upright over the lower wall.
2x4 Block
2x4 Block
71-3/8" Long
Truss Leg
2x4 On Edge
97-1/2" Long 2x4 On edge
188-1/2"
71-3/8" Long
Truss Leg
81-3/4" Long
Truss Top
Truss Knee
D4 <2+)/2 1"2 1/)$$ *20 1, 1"2 @H] -*'12 6#1"
J@K%16,%@\E_@e%*,(0%32+L%$+/26$4
]4 =($1'** `\E_@e H E@e -*.6,,3 9#**2/$ ,( 1"2
@HF 1/)$$ *20$ (2'/ @H] 6#1" F3 +,&&,(
('#*$4%aH'+1%$-'+#(0%#$(G1%#&-,/1'(14
`4 <M)'/2
1/)$$4 C2'$)/2 3#'0,('**. 9/,& 1"2
L(22 ,9 1"2 @HF 1/)$$ 1, 1"2 8,11,& +,/(2/
,9 1"2 @H] -*'124 !"2 &2'$)/2&2(1$ 6#** 82
1"2 $'&2 JEUU\E_@eK 6"2( 1"2 1/)$$ #$ $M)'/24
F4 ?)1 @H] /2&,B23 9/,& 3,,/ ,-2(#(0 #(1,
Ue *,(0 8*,+L$4 !'+L ('#* ,/ $+/26 1"2 8*,+L$
'/,)(3 1"2 -2/#&212/ ,9 1"2 0'8*2 9/'&2 1,
-/2B2(1%1"2%0'8*2%9/,&%&,B#(04

E4 <2+)/2%1"2%@HF%8,'/3$%1,021"2/%'1%1"2%L(22%'(3%/#302%6#1"%E_@e%Z<;%0)$$21$4
5$2%F3%+,&&,(%('#*$4%d'#*%`\E_]e%H%E@e%Z<;%9#**2/$%6"2/2%$",6(%82*,64
@4 Q*'+2 J@K 16, UE\D_]e '(3 J@K 16, ^E\D_Ue @HF$ ,B2/ 1"2 9#**2/$4 <2+)/2 )$#(0 JFK $#H EA3 $#(L2/$
6"2/2%9#**2/$%'/2%*,+'1234
D4 =($1'** ' @E\D_]e "#0" -/2\8)#*1 0'8*2 9/'&2 '1 1"2 -2'L ,9 1"2 3,)8*2 /,6 ,9 1/)$$2$4 <2+)/2 1"2
9/'&2%1,%1"2%@HF%1/)$$%8,'/3$%6#1"%JFK%$#H%@\E_@e%32+L%$+/26$4
]4 Q,$#1#,( ' Ef\E_]e -/2\8)#*1 9/'&2 3#/2+1*. 82*,6 1"2 1,- 9/'&24 5$2 J@K 16, UA\E_@e *,(0 $1)3$
1,%"2*-%'*#0(%1"2%)--2/%'(3%*,62/%9/'&2$4%5$2%'%9/'&#(0%$M)'/2%1,%2($)/2%1"2%$1)3$%'/2%-*)&84
<+/26 8,11,& 9/'&2 1, @H] -*'12 )$#(0 @\E_@e $+/26$4 <2+)/2 1"2 UA\E_@e $1)3$ 1, 1"2 -/2\8)#*1
9/'&2$%)$#(0%@\E_@e%$+/26$4
Step 13B Assemble Rear Gable continued
F4 =($1'**%'%^@\`_Ue%'(3%'%F]\E_@e%6'**%$1)3%,(%1"2%*291%$#32%,9%1"2%0'8*2%9/'&24%5$2%'%$M)'/2%1,
2($)/2 1"2 $1)3$ '/2 -*)&84 d'#* 1, @H] 8,11,& -*'12 6#1" EA3 $#(L2/$ '(3 $+/26 1, @HF$ 6#1"
@\E_@e%$+/26$4%:2-2'1%1,%#($1'**%$1)3$%,(%/#0"1%$#32%,9%0'8*2%9/'&24
1/2" Gusset
at Ridge
1/2" Gusset
at Knee
`4 P,+'12%JDK%1"/22%]^\D_]e
*,(0%@H]$%'(3%1/#&%1,%9#1
'(3 #($1'** 821622( 9/'&2$4
cut to fit
Studs
Framing
Square
Framing
Square
64-1/2"
Stud
72-5/8"
Stud
Framing
Square
80-1/2"
Stud
Optional: You may choose to
rough-in a window opening.
19-1/4" High Pre-built Frame
5-1/4" x 12"
OSB Filler
5/1/4" x 12"
OSB Gusset

16' Rear Wall
Siding Extends 3/4" Below Bottom Plate
Siding Cutoff
Step 14 Install Siding on Rear Gable Frame
16' Rear Wall Side
Wall
1x4 Corner Trim
Step 15 Install Trim on End Walls
IMPORTANT: Trim Must Be Installed Before Installing Roof Gables!
E4 P,+'12 J]K 9,)/ E\E_@e H ]U\D_]e $#3#(0 9#**2/ $1/#-$4 =($1'** 1"2$2 ,( 1,- ,9 1"2 $#3#(0 ,( 1"2
8'+L%6'**4%5$2%'%926%U3%0'*B4%('#*$4%X33#1#,('*%('#*$%'/2%'--*#23%82*,64
@4 ?)1 '(3 #($1'** J@K 16, EH] \EAG 1/#& 8,'/3$ 9*)$" 6#1" 1,- ,9 9*,,/ '(3 8,11,& ,9 1"2 $#3#(04
=($1'** 1/#& 9*)$" 6#1" 1"2 $#3#(0 ,( 1"2 $#32 6'**$4 5$2 U3 0'*B4 ('#*$ $-'+23 E@e '-'/14 X**
1/#&%6#**%82%#($1'**23%6#1"%U3%0'*B4%('#*$%$-'+23%E@e%'-'/14
1x4 Trim
D4 =($1'**%J@K%16,%fFe%*,(0%EH]%1/#&
8,'/3$ 821622( +,/(2/ 8,'/3$4 !/#&
$",)*3%82%9*)$"%6#1"%1"2%*,91%9*,,/4
?)1%@(3%8,'/3%1,%9#14
]4 :2-2'1%1,%#($1'**%1/#&%1,%1"2%9/,(1
6'**%-'(2*4
Siding Filler
]4 =($1'**%UA\E_@e%*,(0%$#3#(0%-'(2*4
?)1 1"2 $#3#(0 1"'1 2H12(3$ 82.,(3
1"2%0'8*2%9'&24
E4 <1'(3%)-%1"2%0'8*2%9/'&2%'(3%$*#32%#1%1,%1"2%/2'/%,9%1"2%8)#*3#(04%Q,$#1#,(%1"2%9/'&2%6#1"%1"2
8,11,&%1,6'/3$%1"2%/2'/%6'**%$,%#1%+'(%82%2/2+123%'912/%1"2%$#3#(0%#$%'--*#234
@ =($1'** ' -/2\+)1 $#3#(0 -'(2* 6#1" 1"2 G+)1 2302G 9*)$" 6#1" 1"2 *291 $#32 ,9 1"2 0'8*2 9/'&24 !"2
$#3#(0 $",)*3 2H12(3 D_]e 82*,6 1"2 8,11,& @H] 0'8*2 -*'124 =($1'** $#3#(0 6#1" U3 0'*B4 ('#*$4
D =($1'** J@K 16, ]HU $#3#(0 -'(2*$4 ?)1 '(3
/2&,B2%$#3#(0%1"'1%2H12(3$%'8,B2%1"2%1,-
,9%1"2%0'8*2%9/'&24
Siding Flush with Frame

;29,/2 8/'+#(0 1"2 B2/1#+'* @H]$ #( -*'+2 '11'+"
J@K%16,%@H]%8*,+L$%1,%1"2%8'+L%,9%1"2%@H]$4
!"#$%6#**%+/2'12%1"2%-/,-2/%$-'+#(0%1,%$21%1"2
0'8*2%,B2/%1"2%*,62/%6'**4
2x4 Stake
2x4-12' Brace
2x4 Block
2x4-12' Vertical Boards
2x4 Block
2x4-12'
]4 d'#*%8,11,&%2302%,9%$#3#(0%1,%EH]%1/#&
6#1"%U3%0'*B'(#[23%8,H%('#*$4
Siding Extends Over
Trim. Paint edge
Step 16 Install Rear Roof Gable
@4 a/2+1 1"2 0'8*2 ,( 8'+L 6'**4 ;2 +')1#,)$ '(3 2($)/2 0'8*2 $#3#(0 2H12(3$ ,B2/ 1/#& ,( 8'+L
6'**4 ?2(12/ 0'8*2 6#1" 8,11,& @H] 2H12(3#(0 E\E_@e -'$1 *,62/ 6'** @H]$ ,( 8,1" $#32$4 d'#*
1,%9*,,/%)$#(0%EA3%$#(L2/$4%:2B#26%Step 18%9,/%'33#1#,('*%321'#*4
D4 :2&,B2 1"2 6'** 8/'+2$ 9/,& #(12/#,/ 6'**$ '(3 )$2 1"2& 1, 8/'+2 1"2 0'8*2 1, 1"2 *,91 9*,,/4
Brace Gable with
Pre-cut Studs
E4 =($1'**%J@K%16,%@H]\E@G%8,'/3$%,(%1"2%8'+L%6'**%1,%-/2B2(1
1"2%0'8*2%9/,&%9'**#(0%,99%3)/#(0%0'8*2%#($1'**'1#,(4%=($1'**
J@K 16, &,/2 @H]\E@ 8,'/3$ 1, 8/'+2 1"2 B2/1#+'* @H] #( -*'+24

floor
2x4 Tie Plate
2x6 Truss Plate
2x4 Top Plate
2x4 Wall Stud
1-1/2"
19-3/8"
24"
2x6 Truss Plate
:2'/%T'8*2
@HF%Q*'12%,(%<#32%b'**
24"
19-3/8" 24" 24" 24" 24"
@4 <*#32 0'8*2 1, 1"2 9/,(1 ,9 1"2 8)#*3#(04
Q,$#1#,( 1"2 9/'&2 6#1" 1"2 8,11,& 1,6'/3$
1"2 9/,(1 6'** $, #1 +'( 82 2/2+123 '912/ 1"2
$#3#(0 #$ '--*#234
D4 :2-2'1 Step 14 1, '--*. 0'8*2 $#3#(04 ?)1 '(3
/2&,B2 $#3#(0 9/,& 1"2 6#(3,6 ,-2(#(04
]4 :2&,B2 1"2 @H]\E@G 8,'/3$ )$23 9,/ 8/'+#(0
,( 8'+L 0'8*2 '(3 /2-2'1 Step 16 1, #($1'**
1"2 9/,(1 0'8*24
E4 :2-2'1%Step 13 1,%'$$2&8*2%9/,(1%0'8*24%X*12/%$1)3%9/'&#(0%9,/%6#(3,6%,-2(#(04%P,+'12%JDK
1"/22%]^\D_]e%*,(0%@H]$4%?)1%JEK%,(2%1,%DFe4%Q,$#1#,(%1"2$2%8,'/3$%'$%$",6(%82*,64%C2'$)/2
3#$1'(+2 1, 8,11,& 0'8*2 9/'&2 '(3 +)1 JDK 1"/22 @H]$ 1, 1"#$ *2(01" '(3 #($1'** )(32/ DFe 8,'/34
=($1'**%@H]$%6#1"%EA3%$#(L2/$4
36"
Step 17 Assemble & Install Front Gable
E4 =($1'**%JDK%1"/22%@HF\^G%'$%1/)$$%-*'12$%821622(%1"2%9/,(1%'(3%/2'/%0'8*2%6'**%-'(2*$
,(%2'+"%$#32%6'**4%?)1%1"2%*'$1%@HF%1,%9#14%!"2%@HF%-*'12$%$",)*3%-/,N2+1%E\E_@e%-'$1
1"2%@H]%1#2%-*'12%J$22%R21'#*%GXGK4%d'#*%@HF$%1,%1"2%9*,,/%6#1"%EA3%+,'123%$#(L2/%('#*$
3,)8*2%/,6%$-'+23%]e%'-'/14
@4 <1'/1#(0%'1%1"2%/2'/%0'8*2%#(3#+'12%6#1"%GgG%&'/L$%6"2/2%1"2%1/)$$2$%6#**%82%*,+'1234
!"2%*'$1%$-'+2%6#**%82%6#32/%1"'(%1"2%9#/$1%JEf\D_UeK%$-'+24
Step 18 Install 2x6 Truss Plates
Detail 'A'
:2'/%T'8*2
S/,(1%T'8*2
47-3/4"
Long 2x4
36" Long
2x4
Cut to Fit
Do not remove 2x4 blocks from floor.
They will be used to assemble trusses.

Step 19 Install 2x6 Soffit Blocks
E4 =($1'** JDK 1"/22 EHD\UG $1/#--#(0 ,( 2'+" $#32 6'**4 <1'/1#(0 9/,&
8'+L 6'** 8)11 ' @HF $,99#1 8*,+L '0'#($1 1"2 8,11,& ,9 1"2 @HF 1/)$$
-*'124 Q,$#1#,( 1"2 9#/$1 EHD 8,'/3 E\E_@e 9/,& 8'+L 6'** 1/#& '(3
#(1, (,1+"4 Tip: use a 2x4 block as a gauge to set the 1x3 correctly4
?,(1#()2 )$#(0 1"2 @HF $,99#1 8*,+L '$ ' 0')02 6"2( #($1'**#(0 (2H1
16, EHD 8,'/3$4 ?)1 *'$1 8,'/3 1, 9#1 E\E_@e 9/,& 9/,(1 0'8*2 1/#&4
5$2%^3%$#(L2/$%('#*#(0%6"2/2%$1)3$%'/2%*,+'1234
D4 =($1'**%'%3,)8*2%@HF%$,99#1%8*,+L
)(32/ 1"2 0'8*2 -'(2* '1 2'+" +,/(2/4
=($1'**%1"2$2%8*,+L$%9*)$"%6#1"%1"2
9'+2%,9%1"2%0'8*2%$#3#(04
1x3 Stripping
2x6 Soffit Block
2x6 Truss Plate
@4 =($1'**%$,99#1%8*,+L$%)(32/%2'+"%GgG%,(%1"2%1/)$$%-*'124<2+)/2%1"2%1,-%,9%1"2%$,99#1%8*,+L$%#(
-*'+2%8.%$+/26#(0%1"/,)0"%1"2%@HF%#(1,%1"2%$,99#1%8*,+L%6#1"%@\E_@e%32+L%$+/26$4%R/#**%'
E_Ue%3#'&212/%",*2%1,%-/2B2(1%1"2%6,,3%9/,&%$-*#11#(04
]4 <2+)/2%1"2%$,99#1%8*,+L$%#(%-*'+2
6#1" @\E_@e 32+L $+/26$4 R/#** ' ",*2
1,%-/2B2(1%1"2%6,,3%9/,&%$-*#11#(04
!"2 8,11,& ,9 8*,+L$ 6#** 82 $2+)/23
#(%'%*'12/%$12-4
2x4 Gauge Block 1x4 Corner
Trim
Install 2x4 Double Block
Flush with Gable Siding
'X' Marks

Step 20 Assemble Roof Trusses
E4 P'. 1/)$$ -'/1$ #($#32 1"2 @H] 8*,+L$ )$23 '/,)(3 0'8*2 9/'&2$4 Z(2 2(3 ,9 1"2 UE\D_]e *,(0
@HF 8,'/3$ "'B2 ' 8*)2 &'/L4 Q*'+2 1"2$2 2(3$ 1,021"2/ '1 1"2 /#3024 X33 ' @H] 8*,+L '1 1"2
8,11,&%,9%1"2%1/)$$%*20$%1,%L22-%1"#$%@HF%9/,&%&,B#(04
@4 <2+)/2 1"2 @HF 8,'/3$ 1,021"2/ )$#(0 -/2\+)1 -*.6,,3 0)$$21$4 h(22 0)$$21$ '/2 @]e 6#324
:#302 0)$$21 #$ DE\D_]e 6#324 X--*. 6,,3 0*)2 821622( 1"2 0)$$21$ '(3 1"2 @HF 8,'/3$4 <2+)/2
0)$$21$ 6#1" JDK 1"/22 /,6$ ,9 F3 +,&&,( ('#*$ $-'+23 Fe '-'/14 ImportantW 6"2( #($1'**#(0
1"2 0)$$21 '1 1"2 L(227 #($1'** 0)$$21 6#1" 1"2 $",/12$1 '(0*23 $#32 1,6'/3$ 1"2 /#3024 See detail
at bottom of page4
D4 !)/(%1/)$$%,B2/%'(3%'--*.%0)$$21$%1,%1"2%,1"2/%$#324%<21%1/)$$%'$#324
]4 X$$2&8*2%JUK%2#0"1%&,/2%1/)$$2$4%:2&,B2%@H]%8*,+L$
9/,&%9*,,/4
71-3/8" Truss
Member
Add 2x4 Block
GLUE
Short Side of Gusset Towards Ridge
81-3/4" Truss
Member
31-3/4" Wide Gusset
30" Wide Gusset

2x4-12' Board
Step 22 Install Soffit
E4 T'1"2/ J^K $2B2( `\E_]e H ]U\D_]e -/#&23
$,99#1 -'(2*$4 C2'$)/2 9/,& 1"2 9'+2 ,9 1"2
3,)8*2 8*,+L 1, 1"2 +2(12/ ,9 1"2 9#/$1 $,99#1
8*,+L4 ?)1 ,(2 $,99#1 -'(2* 1, 1"#$ *2(01"
/2&,B#(0 1"2 GPXQG 23024 =($1'** 6#1" +)1
2302 9*)$" 6#1" 1"2 3,)8*2 $,99#1 8*,+L '(3
1"2 G1,(0)2G 2302 +2(12/ ,9 $,99#1 8*,+L4
<2+)/2 1, 8*,+L$ '(3 EHD )$#(0 E\E_]e
$1'#(*2$$%1/#&%$+/26$4
@4 =($1'** 9)** *2(01" $,99#1 -'(2*$ '*,(0 1"2
$#32 6'**4 ?)1 1"2 *'$1 $,99#1 -'(2* 9*)$" 6#1"
1"2%2(3%,9%1"2%3,)8*2%$,99#1%8*,+L4
D4 =($1'** $,99#1 -'(2*$ ,( 1"2 ,--,$#12 6'**4
E4 =($1'** @HF "'(02/$ ,B2/ 1"2 GgG &'/L$ ,( 1"2 1/)$$ -*'12 '(3 9*)$" 6#1" ,)1$#32 2302 ,9 @HF4
5$2%E\E_@e%N,#$1%"'(02/%('#*$4%<21%1/)$$%*20$%#(1,%"'(02/4%5$2%EA3%+,'123%$#(L2/%('#*$%1,%$2+)/2
1"2%1/)$$%1,%1"2%&21'*%"'(02/%J)$2%"'(02/%2.2*21$%1,%0)#32%1"2%('#*$%'1%1"2%+,//2+1%'(0*2K4
@4 :2&,B2%1"2%@H]\E@G%8,'/3$%)$23%1,%8/'+2
1"2%9/,(1%0'8*24%X$%.,)%-/,0/2$$%$211#(0
1/)$$2$%1'+L%1"2$2%8,'/3$%1,%L22-%1/)$$2$
-*)&84 R,(G1 /2&,B2 1"2 @H]$ )(1#* 1"2 /,,9
$"2'1"#(0%#$%'--*#234
Cut Edge
]4 =($1'** EH] +,/(2/ 1/#& )(32/ $,99#1 ,( $#32 6'**$ 9*)$" 6#1" 9/,(1 '(3 8'+L 6'**
1/#&4%?)1%EH]\UG%1/#&%8,'/3$%9*)$"%6#1"%1"2%8,11,&%,9%1"2%$#3#(04
Step 21 Install Roof Trusses
2x6 Metal
Hanger
'Tongue' Edge

E4 :292/%1,%(2H1%-'02%9,/%1"2%-/,-2/%*'.,)1%,9%1"2%^_EFe%Z<;%$"2'1"#(04%C'L2%+2/1'#(%1"2
1/)$$2$%'(3%1"2%0'8*2$%'/2%-*)&84%=($1'**%'%-*.+*#-%821622(%2'+"%1/)$$%,(%1"2%1,-%/,6%,9
$"2'1"#(04%=9%.,)%'/2%#($1'**#(0%'%/#302%B2(17%+)1%1"2%1,-%/,6%,9%/,,9%$"2'1"#(0%Ee%82*,6%1"2
-2'L%,9%1"2%1/)$$%1,%'**,6%'#/%+#/+)*'1#,(%1"/,)0"%1"2%/#302%B2(14%See detail above. =($1'**
$"2'1"#(0%)$#(0%^3%+,'123%$#(L2/%('#*$%$-'+23%fe%'-'/14
Step 23 Install Front Gable Soffit
2x4x81-3/4"
2x4x
82-5/8"
E4 =($1'**%UE\D_]e%*,(0%@H]$%,(%1"2%1,-%,9%1"2%9/,(1
0'8*27 9*)$" 6#1" 1"2 1,- ,9 1"2 0'8*2 9/'&24 =($1'**
1"2%2(3$%6#1"%1"2%8*)2%&'/L%1,021"2/%'1%1"2%-2'L
,9%1"2%0'8*24%5$2%EA3%$#(L2/$%$-'+23%E@e%'-'/14
@4 =($1'** U@\`_Ue *,(0 @H]$ ,( 1"2 $#32 ,9 1"2 9/,(1
0'8*27%9*)$"%6#1"%1"2%$#32%,9%1"2%0'8*2%9/'&24
Step 24A Install Roof Sheathing
]4 ?)1 ' $,99#1 -'(2* 1, 9#1 82\
1622(%1"2%1,-%$,99#1%-'(2*
'(3%1"2%-2'L4
`4 ?)1 ' $,99#1 -'(2* 1, 9#1 9*)$"
6#1"%1"2%8,11,&%@H]4
8" Soffit
Panels
8" Soffit
Panel
D4 =($1'**%J@K%16,%Ue%6#32%H%]U\D_]e%-/#&23%$,99#1
-'(2*$ )(32/ 1"2 @H]$ 6#1" -/#&23 $#32 3,6( '(3
1"2 GPXQG 2302$ 1,021"2/ '1 1"2 L(22 ,9 1"2 0'8*24
5$2 E\E_]e $1'#(*2$$ 1/#& $+/26$ $-'+23 E@e '-'/14
:#302%i2(1
LAP Edges
!/)$$
<"#(0*2$
X#/
<-'+2