Ronix RH-4703 User manual

GASOLINE GENERATOR 1200W
RH-4703

USER MANUAL 1
SPECIFICATIONS
Generator
Type Single Phase
Voltage
50Hz
220V
Max Power 1200W
Rated Power 900-1000W
Engine
Model LB156F
Type 4stroke Air Cooled Engine
Displacement 98cc
Fuel Unleaded gasoline
Fuel Tank
Capacity 5L
Set Net weight 23Kg
PARTS LIST
1
7
8
93
4
2
5
10 1413
12
611

GASOLINE GENERATOR 1200W
2
1- Fuel tank
2- Frame
3- Pilot lamp
4- Control panel
5- Dc socket
6- Alternator
7- AC protector
8- DC protector
9- AC socket
10- Voltmeter
11- Engine
12- Engine switch
13- Tank
14- Muffler
GAS-GENERATOR SET OWNER’SMANUAL
This generator mainly supplies electricity energy for traveling and lodging
outdoors etc., using the 154 gasoline engine manufactured by our copany
as its power.
It has many types for your choice, such as 50Hz/220V.
Before operating this set, be sure to read this manual to understand how
to correctly operate it.
SAFE USE
- Avoid operating the set before correctly reading this manual!
- Do not run this set indoor or anywhere the ventilation is poor!
- Drain out the fuel from the tank and the carburetor if the set is not in
use for a long time or is transported on the road!
- Stop the set and no smoking while refueling. If the fuel spilt out, wipe
up immediately!
- Do not unreasonably adjust the engine speed!

USER MANUAL 3
- Avoid touching the set with wet hands while it is running!
- Never operate the set in the rain or snow!
- Keep away from the fire and heat when the set is running or storied!
- Don’t connect the set to commercial power outlet, and don’t connect
one set to another one!
- Before starting do not connect electric apparatus. After the set is running, turn
the engine speed control lever to the position “FAST” and do not insert
the plug into socket until the set is stable!
- The set must be stored in the dry and neat environment, and keep
away from the flammable substance and explosion!
COMPONENT NAMES
WARNING!
Before running, be sure to check the following, or the set and the apparatus
could be damaged!
- Engine inspection
- Inspect according to the “Pre-operation inspection” in “Owner’s manual
for” A152F gas-engine”
TANK INSPECTION
- Is there gasoline in the tank?
- If there is no, fill about 5L gasoline into the tank.
- Leave 2~3 cm of space to the top of tank.
.APPARATUS PLUG INSPECTION
- Has the plug been put into the AC socket?
- Be sure to pull off the plug before running.
.GENERATOR INSPECTION
- Have all bolts of the generator connected to the engine been tigh?
- If someof them have been loose, please fasten them.

GASOLINE GENERATOR 1200W
4
.APPARTUS POWER INSPECTION
- The power of the apparatus should not exceed the output of the set, or
the set could be damaged!
STARTING PROCEDURE
- Before starting, please inspect according to the chapters of “SAFE
USE” and “PRE-OPERATION INSPECTION”, then do as the following!
- Open the fuel cock
- Open the engine switch
ON
OFF
- Turn speed contror lever to “FAST” side slightly

USER MANUAL 5
- Close the choke lever
- Start the engine
- After starting
Return the choke lever gradually to the open position, while watching
how the set is running.
- Adjust the frequency Of the set
Turn the speed control lever to “FAST” until the engine speed is stable,
then the ftequency will be also stable immediately.
-Put the plug to the AC socket

GASOLINE GENERATOR 1200W
6
STARTING PROCEDURE
-Pull the plug off
- Turn speed control lever to “SLOW” keep the engine running for 1~2
minutes.
- Close the engine switch
ON
OFF
- Turn speed control lever to “STOP”

USER MANUAL 7
- Close the fuel cock
AC PROTECTOR
- The set has safety device.
OFF
VOLTMETER AC SOCKET
AC PROTECTORRESET
OFF
DC PROTECTOR
PILOTLAMP
DC
ON
- The protector switch can bounce up to cut off the output when the apparatus
power exceeds the rated power of the set
- If the set output has been cut off, please reduce the load within rated
output, then press the switch to the position “reset”, the set will continue
to work.

GASOLINE GENERATOR 1200W
8
APPLICATION RANGE
Apparatus
AC
Power Factor
Output
(W)
Volt
(V)
50Hz
50Hz
50Hz 220
220
220 850 1
0.7~0.8
0.7~0.95
630
740
TROUBLES AND MAINTENANCE
.THE SET WON’T START FAVORABLY
Please inspect according to the relevant chapter in “Owner’s manual for
A154F gas-engine”
.VOLTAGE IS UNUSUAL
If the fluctuation rate of the out voltage exceeds 10%, please take off the
control panel, then change the capacitor. (You may search for helping
from the distributor.)
.FREQUENCY IS MUCH HIGHER OR LOWER
Turn speed control lever to the position “FAST”, then take the “portable”
speed-meter near the high-pressure-line, and adjust the engine speed
control bolt with the hand-screwdriver at the same time, until the indicating
amount is within 3100~3180rpm for the 50Hz set