Ronix RH-4760 User manual

6000W GASOLINE GENERATOR
RH-4760

USER MANUAL 1
TECHNICAL SPECIFICATION
Model RH-4760
Power 6000W
Voltage 220V
Frequency 50Htz
DC Output 12V-8A
Fuel Capacity 25Liter
Cylinder Capacity 389cc
Noise <75 DB
Weight 85kg
Full Load Continuous Working 8.5 Hours
1/2 Load Continuous Working 12.7 Hours
PARTS LIST
Handles
Exhaust
Outlets
Vibration Isolator
Battery
Easily
Assembled
Wheels
Recaptable
Control Panel
Combinetion
Switch
Reset Button Engine Switch
Voltage Meter

6000W GASOLINE GENERATOR
2
INTENDED USE / NOT INTENDED USE
The machines are portable generators with a four -stroke gasoline
engine, with AC 50Hz / 60Hz and 12V DC output for domestic use.
The gasoline generator set is suitable for temporary power supply.
It may only be operated in a well-ventilated area. The product is
intended for household use in accordance with the instructions, all
other applications, such as commercial exploitation, are specically
excluded. For damage or injury resulting from an abuse, the user
/ operator liable and not the manufacturer. Part of the intended use
is also the consideration of the safety and operating instructions
in the manual. Persons who should operate this machine will be
familiar with the instructions and the possible dangers. In addition,
the existing safety rules are strictly observed. Other general rules of
safety and security areas are respected. Changes to the machines,
including the liability of the manufacturer and any damage from
this set, the warranty expire. The machine must only be operated
outdoors or in a ventilated room.
RESIDUAL RISKS
Even when properly used the machine is always some residual risk that
cannot be ruled out. Because of e.g. Use, construction of the machine
can be derived during the use if the following potential hazards.
Inhalation of fumes (poisoning danger)
- Avoid contact with hot surfaces / exhaust system (burns)
- Impairment of hearing for non-adherence to the prescribed
hearing protection
- Contact with petrol/oil and the skin
- Inhalation of gasoline fumes
- Contact with the coming-promoting medium

USER MANUAL 3
SAFETY TIPS
- Never operate the generator in door or in a poor-ventilated area.
- Do not operate the generator under wet climate (rain, snow).
- Never connect to house power circuit if commercial power supply is not cut.
- Keep at least 1 m (3ft) away from inammables.
- Do not smoking when fueling.
- Do not spilling out when fueling.
- Remember to stop generator before fueling.
OTHER SAFETY TIPS
- Do not touch the mufer or mufer cover while the engine is
running or still hot.
- Do not touch the generator when either it or your hand are wet,
avoid short circuit or electric shock.
- Never permit anyone to operate the generator without proper
instruction.
- Always wear safety shoes and proper cloths.
- Keep children and pets away from the generator when the
generator is in operating.
INSPECTION BEFORE OPERATION
.LUBE OIL
Always check the oil level before start the stooping generator on a level place.
- Turn out the oil lter gauge (dipstick) and clean it with a clean cloth.
- Insert the dipstick back without screw in. and check the oil level.
- In the case that the oil level is below the lower mark of the dipstick,
rell the oil to the upper mark.
- Reinstall the dipstick.

6000W GASOLINE GENERATOR
4
.GENERATOR SET ADDING OIL GUIDE
- Access hatch closed
- Unclip the access hatch
- Open the door

USER MANUAL 5
- Remove the hatch
- Release the drain plug
- Add oil through funnel
- Tighten the drain plug
- Close the door

6000W GASOLINE GENERATOR
6
.FUEL
- Open the fuel tank cap.
- Check the fuel level and refuel if necessary.
- Refuel up to the shoulder of the fuel lter

USER MANUAL 7
- Reinstall the fuel tank cap.
.AIR CLEANER
- Loosen the clip and remove the air cleaner housing.
- Separate the primary and secondary element.
- Wash
.STARTING THE GENERATOR
- Remove all the loads from AC socket and switch off the BREAKER.

6000W GASOLINE GENERATOR
8
- Set the fuel cock to “ON” position.
ON
- Push the choke lever to “CLOSE’ position.
- Turn the engine switch to “ON” position.
- Pull the starter handle until resistance is felt, then pull it out swiftly
from original position.
- Once the generator dads, 4-6 gradually turn the chock lever to
“ON” position.

USER MANUAL 9
ELECTRIC CONNECTING
To keep the generator in the best running and electric condition, please
obey the follows:
1. Ground the generator to prevent electric shock:
2. Refer some appliance for electric consumption:
Type Waltage Appliance Sample
Rated Starting Appliance Starting Rated
Electric
bulb or
heater
X1 X1 Electric bulb
TV
Electric bulb
100W100VA(W) 100VA(W)
Day light
lamp X2 X1.5 Day light lamp
40W Day
light lamp 80VA(W) 60VA(W)
Motor
drive X3.5 X2 Refrigerator Electric fan
Refrigerator
150W
450-750
VA 300VA(W)
3.If the generator is supply more than 2 appliances, be sure to start
them 5.3 one by one with the highest current rst.
CAUTION:
Do not connect the generator to home power circuit. When this
connection is necessary, be sure that a skilled electrician does the
job. Improper connecting between the generator and home power
circuit may cause damage of the generator and even re accident.

6000W GASOLINE GENERATOR
10
.AC ELECTRIC CONNECTING
- Starting the generator.
- Connecting the appliances.
- Turn on the BREAKER or push down the Ac protector.

USER MANUAL 11
.DC APPLICATION
The DC terminal may be used for charging 12V automotive-type batteries only.
- When using automotive-type batteries with battery cables, be sure to
disconnect the minus pole battery cable from the battery before charging.
- Connect the charging cable to the battery terminals and the DC
terminal of generator.
- Connect the positive battery terminal to the positive generator terminal
- Do not reverse the charging cables, or serious damage to the
generator and/or Battery may occur.
- Do not allow the free ends of the cable to touch each other, if this
occur, it will be short circuit the battery.
- When a large capacity battery is charged, excessive current ows
(the value varies depending on the discharged condition) and the fuse
for DC current will burn out.
- Batteries produce explosive gases. Keep sparks, ames and
cigarettes well away.
- To prevent the possibility of creating a spark near the battery,
always connect charging cables to battery rst and only then to
the generator. When disconnecting, you should disconnect the
cables at the generator rst.
- Charge the battery in a well-ventilated place.
- Before charging, remove the cap from each cell of the battery.
Discontinue charging if the electrolyte temperature exceeds 45°C.

6000W GASOLINE GENERATOR
12
OPPING THE GENERATOR
1. Turn off the Breaker.
2. Turn off the engine switch.
3. Turn off the fuel cock.
OFF
NOTE:
In emergency, turn the engine switch to -OFF to stop the generator.
WARNING!
Never stopping the generator at high speed under heavy load,
otherwise, the damage will result.

USER MANUAL 13
REGULAR INSPECTION AND MAINTENANCE
Daily and regular inspection is important to assure safe, proper
and long-term operation of the generator. Refer to the regular inspection
table when conducting inspection and maintenance.
Inspection Replace Cleaning Adjustment
Daily
check
20hrs or
rst month
50hrs or
every 3
month
100hrs or
every 6
month
300hrs
or every
1year
Lube oil
check
Replace
engine oil
Air cleaner
check
Air cleaner
wash
Fuel lter
cup
Fuel lter
Spark plug
Value
clearance
Culinder
clearance
Fuel tank
wash
Every 2years or when necessary

6000W GASOLINE GENERATOR
14
ENGINE OIL REPLACEMENT
1. Loosen the of drain plug crankshaft.
2. Drain off the engine oil in the dipstick.
3. Screw in and tighten the drain with seal washer.
4. Filing the engine of to the upper plug level.
5. Reinstall the dipstick
NOTE:
Recommended Engine oil
4-stroke gasoline engine oil SF, SF from API Service Classication
or SAE 10W-30 equivalent to SG Class. In Frigid Ambience
Temperature (below -15°C) SE.SF from API Service Classication
or SAE5W-30 equivalent to SG Class.
SPARK PLUG CLEANING
1. Dismantle the spark plug cap.
2. Dismantle the spark plug.

USER MANUAL 15
3. Clean away carbon sediment.
4. Measure the electrodes clearance.
0.7-0.8mm
5. Reinstall the spark plug and cap.
FUEL COCK CLEANING
1. Set the fuel cock to “OFF” position, and dismantle the lter cup.
Dismantle the fuel lter.
2. Clean the fuel lter with air blow from inside.
3. Clean the fuel lter cup thoroughly.
4. Mount a new rubber ring and the lter cup securely.
STORAGE OF GENERATOR
If the generator should be stored for a long time (more than 30
days), the following preparation should be made.
1. Loosen the carburetor’s drain plug and drain off the fuel in the fuel tank.
2. Loosen the oil drain plug and dipstick, dipstick, drain off the engine oil.
3. Reinstall the drain plug and dipstick.
8-4. Pull the starter handle gently until resistance is felt.

6000W GASOLINE GENERATOR
16
TROUBLESHOOTING
1. Starting failure
- Is the engine switch at “ON” position?
- Is the oil level too low?
- Is there enough the fuel?
- Check the spark plug.
2. Appliance do not work
- Check the appliance device.
- Is the BREAKER at “ON” position?