Samsung SP43R2HEX User manual

PROJECTION TV RECEIVER
Chassis : J59A(P)
Model: SP43R2HEX/XSG
PROJECTION TV RECEIVER CONTENTS
Specifications
Alignment and Adjustments
Exploded View and Parts List
Electric Parts List
PCB Diagram
Schematic Diagram
1.
2.
3.
4.
5.
6.
SERVICE Manual

Specifications
Samsung Electronics 1-1
1. Specifications
Broadcasting System CW: EURO Mult i ( PAL , SECAM - B/G, D/K, I , L/L‘ )
CS :PAL Multi(PAL,SECAM-B/G,D/K,I,NT4. 43,NT3. 58)
ScanningSystem 100Hz/Progressive
Tuning Range
VHF :CH2~CH12
UHF :CH21 ~CH69
Cable:CHS1 ~ CHS40
Antenna Impedence 75ohm Unbal anced
Intermediate Frequency
Sound Out put STD:15W MAX : 20W
Rated Voltage AC20V/Free-voltage(option)
White Balance
High Voltage 29KV
FUSE 250V 6. 3A
CODE NO : 3601-000300
Power Consumption 240W
SYSTEM VIDEO(MHz) SOUND(MHz)
B/G38.90 33.40
D/K 38.90 32.40
I38.90 32.90
L(L‘ ) 34.5(41.0) 41.0(34.5)
3
RF MODE
H/L
L/L
xy
290
290
295
290
Y
8.5
0.4
DTV Mode(1080i/50Hz)
H/L
L/L
xy
290
290
295
290
Y
9.5
0.4

MEMO
1-2 Samsung Electronics

Alignment and Adjustments
Samsung Electronics 2-1
2. Alignment and Adjustments
2-1 When entering the service mode;
1. Turn on the TV, and then select “STANDARD” on the picture adjustment mode.
2. Turn off the TV(STAND-BY).
3. Enter the service mode by pressing the remote control keys in the following sequence:
Info -> Menu -> Mute -> Power ON
Note : If necessary, re-do steps 1~3.
Initial display when the service mode is switched.
2-1-1 WHEN A RF SIGNAL IS RECEIVED
2-1-2 SERVICE MODE CONTROL KEYS
✍PRECAUTIONS
1. When EEPROM IC (IC902) is replaced, first connect the power cord and wait for about 4~5 seconds.
2. After replacing EEPROM IC (IC902), enter the Service mode. Next, enter the standard data or the
previous EEPROM IC data before replacement. And then check and adjust any items related to
Geometric, Picture, Option.
DEFLECTION
DEFL. 480P OFFSET
DEFL. 1080I OFFSET
DEFL. 576P OFFSET
VIDEO ADJUST 1
VIDEO ADJUST 2
VIDEO ADJUST 3
VIDEO ADJUST 4
YC DELAY
VIDEO ADJUST DNIe 1
VIDEO ADJUST DNIe 2
OPTION F5 21 80
CHECKSUM 0000
RESET
T-CHMPEU-XXXX yy.mm.dd
MAIN MENU
UP / DOWN
RIGHT / LEFT
MENU DISPLAY
Select item by moving cursor
Decrease or increase the adjustment values
[Navigation Key]

Alignment and Adjustments
2-2 Samsung Electronics
2-2 FACTORY MODE MENU(EUROPE)
2-2-1(A) DEFLECTION (CW_PAL)
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
UP BLK
LO BLK
31 31
31
31 31
31
7
0
0
7
25 31
31 31
31 31
31
31
31
31
0
0
50
25
0
5
0
4
Item Range Initial Data
4:3 Wide
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
Remark
Variable
FIX
Variable
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
2-2-1 CW MODEL

Alignment and Adjustments
Samsung Electronics 2-3
2-2-1(B) DEFLECTION(NTSC)
Item Range
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
Remark
Variable
FIX
Variable
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
UP BLK
LO BLK
31 31
31
31 31
31
7
0
0
7
25 31
31 31
31 31
31
31
31
31
0
0
50
25
0
5
0
4
Initial Data
4:3 Wide

Alignment and Adjustments
2-4 Samsung Electronics
2-2-1(C) 480p offset
0
0
0
Adjust Value
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
15
0
0
Item Range Initial Data
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 25
0 ~ 25
0 ~ 15
0 ~ 15
Remark
FIX
FIX
Adjust
FIX
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
UP BLK
LO BLK

Alignment and Adjustments
Samsung Electronics 2-5
2-2-1(D) 1080i/50Hz offset
Adjust Value
0
Adjust Value
Adjust Value
0
0
0
0
0
0
0
0
0
0
Adjust Value
0
0
50
25
0
5
0
0
Item Range Initial Data
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 25
0 ~ 25
0 ~ 15
0 ~ 15
Remark
Adjust
Adjust
Adjust
Adjust
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
UP BLK
LO BLK

Alignment and Adjustments
2-6 Samsung Electronics
0
0
0
Adjust Value
0
0
0
0
0
0
0
0
0
0
0
0
0
50
25
0
5
0
0
Item Range Initial Data
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 25
0 ~ 25
0 ~ 15
0 ~ 15
Remark
FIX
FIX
Adjust
FIX
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
UP BLK
LO BLK
2-2-1(E) 576p offset

Alignment and Adjustments
Samsung Electronics 2-7
2-2-1(F) VIDEO ADJUST 1
R Cutoff
G Cutoff
B Cutoff
Sub Bright
Color On/Off
CB Offset
CR Offset
R Drive
G Drive
B Drive
Sub Contrast
Sub Color
Sut Tint
CTI Level
COL Axis
LTI Level
LIT Mode
System
32
32
32
1
32
32
32
32
32
15
8
10
31
1
1
0
1
2
Item Range EEP-ROM Copy Data
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 1
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 23
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 3
0 ~ 3
1 ~ 3
Remark
Adjust
FIX
Adjust
Adjust
Adjust
Adjust
Adjust
FIX
Adjust
Adjust
Adjust
Field Test Data
Field Test Data
1080i Another Data
32
32
32
1
32
32
32
32
32
15
8
12
31
1
3
0
1
1
32
32
32
1
32
32
32
32
32
15
8
12
31
1
3
0
1
1
4:3 480p/576p 1080i

Alignment and Adjustments
2-8 Samsung Electronics
2-2-1(G) VIDEO ADJUST2
ABL Level
Gamma
DPIC Level
DC Trans
ABL TH
VM Level
VM Corint
VM f0
VM Limit
VM Delay
SHP CD
SHP f0
SHP f1 & P/O
AKB Time
BandPass 9407
HighPass 9407
S ABL
P ABL
3
0
3
2
15
1
0
1
2
0
1
1
13
13
24
40
3
15
Item Range
0 ~ 3
0 ~ 3
0 ~ 3
0 ~ 3
0 ~ 15
0 ~ 3
0 ~ 3
0 ~ 3
0 ~ 3
0 ~ 3
0 ~ 3
0 ~ 1
0 ~ 15
0 ~ 31
0 ~ 7
0 ~ 7
0 ~ 3
0 ~ 15
Remark
Field Test Data
3
0
3
2
15
1
0
1
2
0
1
1
13
13
24
40
3
15
EEP-ROM Copy Data
3
0
3
2
15
1
0
1
2
0
1
1
13
13
24
40
3
15
4:3 480p/576p 1080i

Alignment and Adjustments
Samsung Electronics 2-9
2-2-1(H) VIDEO ADJUST3
H Comp
V Comp
Pin Comp
AFC Comp
H-Sync Phase
NR Off Value
CG HAO
CG VAO
NR High Ref
NR Low Ref
NR High Value
NR Low Value
NR Hight Ref(S)
NR Low Ref(s)
NR High Value(S)
NR Low Value(S)
NR Read M/S
8 8
13 8
0
0
0
0
35
3
17
51
20
0
17
51
1
60
-
Item Range EEP-ROM Copy Data
4:3 Wide
0 ~ 15
0 ~ 15
0 ~ 7
0 ~ 7
0 ~ 1
0 ~ 9
0 ~ 20
0 ~ 20
0 ~127
0 ~127
0 ~255
0 ~255
0 ~127
0 ~127
0 ~255
0 ~255
0
Remark

Alignment and Adjustments
2-10 Samsung Electronics
2-2-1(I) VIDEO ADJUST4
SECAM Color Main
SECAM Color Pip
Picture Limit
OSD Contrast
TTX Contrast
NR_Bandpass
NR_Highpass
Noise Thresh
MOB Strength
SRS Clarity
Melody vol.
Real Time(Hour)
CXA HC Para DC
Video Mute
28
28
3
5
10
0
0
35
37
64
7
72
31
8
Item Range
0 ~255
0 ~255
0 ~ 3
0 ~ 15
0 ~ 15
0 ~ 127
0 ~ 127
0 ~ 10
Remark
EEP-ROM Copy Data
RF,480p/576p,1080i

Alignment and Adjustments
Samsung Electronics 2-11
2-2-1(J) YC DELAY
P.YC(AV) Delay
S.YC(AV) Delay
N.YC(AV) Delay
P.BG.YC Dealy
P.DK.YC Delay
P.I.YC Delay
P.M.YC Delay
P.N.YC Delay
S.BG.YC Delay
S.DK.YC Delay
S.I.YC Delay
S.M.YC Delay
S.L.YC Delay
N.M.YC Delay
Item
3
-5
1
3
1
2
0
0
-5
-8
-8
-7
-3
3
EEP-ROM Copy Data
RF,480p/576p,1080i
Range
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
-16~15
Setting Value(SEF)
Remark

Alignment and Adjustments
2-12 Samsung Electronics
2-2-1(K) VIDEO ADJUST DNIe 1
NR Scale Max
NR Scale Min
NR HPF TH
NR EDGE TH
NR Sel
CE Cutoff
CE Upper
CE Gain L
CE Gain U
CE HPF Gain
DCE CUTOFF
DCE UPPER
DCE GAIN L
DCE GAIN U
CTI GAIN
DEP OV GAIN H
DEP OV GAIN V
DE CORING
R NOISE TH1
R NOISE TH2
R NOISE TH3
R NR ON
DE NOISE GAIN
DE GAIN
DEP GAIN2 H
DEP GAIN2 V
48
16
0
4
2
0
0
45
45
128
32
196
45
45
8
127
127
1
8
72
128
1
8
20
42
0
Item Range
0 ~ 255
0 ~ 255
0 ~ 7
0 ~ 7
0 ~ 3
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 15
0 ~ 127
0 ~ 127
0 ~ 63
0 ~ 127
0 ~ 255
0 ~ 255
0 ~ 1
0 ~ 15
0 ~ 127
0 ~ 127
0 ~ 127
Remark
Field Test Data
Field Test Data
EEP-ROM Copy Data
RF 480p/576p 1080i

Alignment and Adjustments
Samsung Electronics 2-13
2-2-1(L) VIDEO ADJUST DNIe 2
DE H CONT
DE V CONT
WS ON
WS GAIN
CTE GAIN
RED OFFSET
GREEN OFFSET
BLUE OFFSET
48
16
0
4
2
Adjust Value
Adjust Value
Adjust Value
Item Range
0 ~ 255
0 ~ 255
0 ~ 1
0 ~ 63
0 ~ 255
0 ~ 255
0 ~ 255
0 ~ 255
Remark
Adjust
Adjust
Adjust
2-2-1(M) Option (67h 10h)
SYSTEM
BEE
ASPECT
X-RAY
AUTO FM
PIP
LNA
LETTER BOX
TTX LANG GRP
AGC
NATURAL ZOOM
DNIe
TELEWEB
SAMSUNG LOGO
Item
CW/CS
ON<->OFF
WIDE<->4:3
ON<->OFF
ON<->OFF
ON<->OFF
ON<->OFF
ON<->OFF
WEST/EAST/CIS/TURK-GRK
/ARABIC/HEBREW
ON<->OFF
ON<->OFF
ON/DEMO/OFF
ON<->OFF
ON<->OFF
CW
OFF
WIDE/4:3
ON
ON
ON
ON
ON
WEST
OFF
OFF
DEMO
OFF
OFF
Remark
CS:Russia Option
OPTION
OPTION
ON:Germany Only
Range Copy Data
EEP-ROM Copy Data
RF 480p/576p 1080i
Adjust Value
Adjust Value
Adjust Value
Adjust Value
Adjust Value
Adjust Value

Alignment and Adjustments
2-14 Samsung Electronics
2-2-2(A) DEFLECTION
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
39 31
31
44 31
31
7
0
0
7
25 31
37 31
33 31
31
31
31
31
0
0
50
25
0
5
Item Range Initial Data
4:3 Wide
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
Remark
Variable
FIX
Variable
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
2-2-2 CS MODEL

Alignment and Adjustments
Samsung Electronics 2-15
2-2-2(B) DEFLECTION(NTSC)
Item Range
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
Remark
Variable
FIX
Variable
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
FIX
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
39 31
31
44 31
31
7
0
0
7
25 31
37 31
33 31
31
31
31
31
0
0
50
25
0
15
Initial Data
4:3 Wide

Alignment and Adjustments
2-16 Samsung Electronics
2-2-2(C) 480p offset
Initial Value
Initial Value
Initial Value
Initial Value
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
50
25
0
5
Item Range Initial Data
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 25
0 ~ 25
0 ~ 15
0 ~ 15
Remark
Adjust
Adjust
Adjust
Adjust
Adjust
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
UP BLK
LO BLK

Alignment and Adjustments
Samsung Electronics 2-17
2-2-2(D) 1080i/50Hz offset
Item Range Initial Data
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 15
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 63
0 ~ 3
0 ~ 3
0 ~ 63
0 ~ 63
0 ~ 25
0 ~ 25
0 ~ 15
0 ~ 15
Remark
V Amp
V Shift
H EW
H Shift
V Linearity
Upper Linearity
Lower Linearity
V SC
H Parabolra
Upper Corner
Lower Corner
H Trapezium
Bow
Angle
V Position
Up UCG
Lo UCG
CXA Left Blk
CXA Right Blk
CG HAO
CG VAO
UP BLK
LO BLK
Initial Value
Initial Value
Initial Value
Initial Value
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
50
25
5
5
Adjust
Adjust
Adjust
Adjust