Shinn Fu Road Xpedition I-4001 User manual
Owner’s Manual
MODEL I-4001
Rechargeable Spotlight
Printed in China
Shinn Fu Co. of America, Inc. © 2003 Revision
10939 N. Pomona Avenue
Kansas City, MO 64153
Made in China
How to use
You should charge your new light with the provided AC
charger for no more than 12 hours before initial use.
Unplug the charger at both ends, then depress trigger
to turn spotlight “ON” (fig. 1) and release trigger to turn
spotlight “OFF” (fig. 2). To lock switch on momentarily,
press trigger on and move locking bar into position (fig.
3). To release lock on switch, press locking bar into
unlock position (fig. 4).
NEVER leave light energized for more than 1 minute
continuously. Let cool for 1 minute before turning back
on.
How to recharge
• The supplied 9V, AC charger (AC adapter) and 12V DC
charger cord with built-in resistor are made specifically to
charge the sealed lead-acid 6V, 4a battery in your light. DO
NOT use any charging means other than those provided.
• Spotlight must be recharged with the switch in the
“OFF”position. Charging is indicated by the red LED light.
• Recharging time is 9hrs.using the AC charger OR
12hrs.using the DC charger cord. DO NOT charge longer
than the published times above. Such overcharging may
result in battery overheating and leakage.
Read, understand and follow all printed materials
provided with/on this device. Lens surface becomes
very hot. Do not leave light energized and unattended.
Let cool completely before laying on any surface.
Never lay light face down. Do not shine into eyes.
Charging produces hydrogen gas, which may explode
when exposed to fire. Do not charge or use near open
flame or glowing embers. Do not use charging cords
other than those provided by manufacturer. DC
charging cord’s cigarette lighter plug becomes very
warm when in use. Use caution when unplugging from
receptacle. Do not place plug on combustible surface
or vehicle seat, dash or floor until cool to the touch.
Do not attempt to service battery. Let qualified
personnel replace and dispose of old battery. Do not
overcharge battery. Keep out of the reach of children.
Do not use this light for any purpose other than
momentary lighting. Do not alter or modify this
product. Failure to heed these markings may result in
personal injury and/or property damage.
fig. 1 fig. 2
fig. 3 fig. 4
Save these instructions.For your safety, read, understand, and follow the information provided with and
on this spotlight. The owner and operator of this spotlight shall have an understanding of safe operating
procedures before attempting to use. The owner and operator shall be aware that use and repair of this product
may require special skills and knowledge. Instructions and safety information shall be conveyed in the operator's
native language before use of this product is authorized. If any doubt exists as to the safe and proper use of this
spotlight, remove from service immediately. Inspect before each use. Do not use if broken, bent, cracked or
damaged parts are noted. Any spotlight that appears damaged in any way, or operates abnormally shall be
removed from service
immediately. If the spotlight has been or suspected to have been dropped, immediately discontinue use until the
device has been checked by qualified personnel. Labels and Owner’s Manuals are available from manufacturer (see
Replacement Parts, page 4).
CONTAINS SEALED LEAD ACID BAT-
TERY. BATTERY MUST BE RECYCLED.
KEEP OUT OF THE REACH OF CHIL-
DREN.
Product Description
The “X” Road Pedition Rechargeable Spotlight is designed and engineered for intermittent use only.
Although the housing is water resistant, it is not waterproof and prolonged use in the rain or snow should
be avoided.
The light is especially useful during power outages and night-time activities such as boating and fishing.
NOTE: Use of spotlights to observe wildlife is illegal in some States. Consult and obey State regulations
regarding use of this device to observe wildlife.
WARNING
2
Pb
3
Important
• Do not completely discharge battery before
recharging. Deep discharge will decrease battery life.
• To maximize battery life, maintain battery charge
before storage. DO NOT OVERCHARGE the battery!
• Do not attempt to disassemble battery or remove any
parts projecting from battery terminals.
Battery
Let qualified personnel replace and dispose of the
battery. The battery used in your light is a 6V, 4 amp
hour, sealed lead-acid battery. Normal life expectancy
is 2 years. State of charge, vibration, heat and cold are
factors that will decrease the useful life of any lead-
acid battery. When disposing of Spotlight, do so in
accordance with Federal, State and local regulations
pertaining to disposal of lead-acid batteries, ABS
plastics and glass. Regulations may vary. Contact
your local Solid Waste Authority for recycling
information.
Maintenance
Clean cooled lens with household window cleaner,
then wipe with soft, clean, dry cloth. Clean ABS
housing with a clean, dry cloth. Do not expose
Spotlight to direct sunlight. Do not use in wet
conditions. Dry thoroughly before use. Store Spotlight
in dry, clean area only. Avoid high humidity.
To Replace Bulb (H3.6V 55W halogen bulb
only) :
1. Disconnect light from power source. Let cool for at
least 30 minutes before handling bulb.
2. Loosen and remove the screws in the right housing.
3. Lift up and set aside the right housing.
4. Remove the ground (black) wire connection from
bulb housing, then remove spring clip retainer.
Unplug bulb electrical connection, then remove
bulb.
5. When handling a new bulb, do not touch the glass
portion. Natural oils can cause premature bulb
failure. Wipe with clean, dry cloth.
6. Installation is reverse of above.
90 DAYS LIMITED WARRANTY
For a period of 90 days from date of purchase, Shinn Fu Company of America,Inc. will repair or
replace, at its option, without charge, any of its products which fails due to a defect in material or workmanship, or
which fails to conform to any implied warranty not excluded hereby. Performance of any obligation under this
warranty may be obtained by returning the warranted product, freight prepaid, to Shinn Fu Company of
America,Inc. Warranty Service Department, 10939 N Pomona Ave. KCMO 64153. Except where such
limitations and exclusions are specifically prohibited by applicable law, (1) the CONSUMER'S SOLE AND
EXCLUSIVE REMEDY SHALL BE THE REPAIR OR REPLACEMENT OF DEFECTIVE PRODUCTS AS DE-
SCRIBED ABOVE, and (2) Shinn Fu Company of America, Inc. SHALL NOT BE LIABLE FOR ANY
CONSEQUENTIAL OR INCIDENTAL DAMAGE OR LOSS WHATSOEVER, and (3) THE DURATION OF ANY
AND ALL EXPRESSED AND IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION, ANY WARRANTIES
OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, IS LIMITED TO A PERIOD OF 90
DAYS FROM DATE OF PURCHASE.
Some states do not allow limitations on how long an implied warranty lasts, so the above limitation may not
apply to you. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the
above limitation or exclusion may not apply to you. This warranty gives you specific legal rights, and you may also
have other rights which vary from state to state.
REPLACEMENT PARTS
When ordering parts, give model number, and description below. Write or call for current pricing: Shinn Fu Company
of America, Inc. 10939 N Pomona Ave. KCMO 64153 ph. (816) 891-6390, fax (816) 891-6599.
Part Description Quantity
1 H55 6V bulb 1
2 bulb clip 1
3 lens 1
Table of contents
