Snapper GT23540 User manual

Parts Manual fo
r
Revision IR,
GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
COPYRIGHT
©
2005
McDonough, GA, 30253 U.S.A.
TP 400-5063-IR-TC-N
5/26/2005 Manual No. 06456
SNAPPER PRODUCTS, INC.
ALL RIGHTS RESERVED.
HYDRO DRIVE RMO
MODEL
GT23540
(
2690258
)

Table Of Content
s
TP 400-5063-IR-TC-N
Manual No. 06456GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0 3
PAGE GROUP
4WHEELS & TIRES GROUP
6HOOD, GRILL & DASH GROUP
8STEERING GROUP - Power Steering with Tilt
10 FRAME GROUP
14 CONTROLS GROUP
18 CRUISE GROUP
20 TRANSMISSION GROUP
24 TRANSMISSION SERVICE PARTS - Tuff Torq K-71E
32 SEAT, DECK, TANK GROUP
34 ENGINE GROUP-23HP KOHLER
36 LIFT & POWER STEERING GROUP - HYDRAULIC
40 54" DECK - BELT & IDLER ARM GROUP
42 54" DECK - HEIGHT ADJ & ROLLER BAR GROUP
46 54" DECK - HOUSING & ARBOR GROUP
50 DECALS GROUP
52 ELECTRICAL GROUP - GT-RMO

WHEELS & TIRES GROUP
TP 400-5063-IR-TC-N
Manual No. 06456 GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
4

WHEELS & TIRES GROUP
Footnotes:
TP 400-5063-IR-TC-N
Manual No. 06456GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0 5
Part No Descri
p
tionItem Qt
y
Note
1 1722305 2 WHEEL & TIRE ASSEMBLY, Front (Includes Ref. 2, 3, 4, 5 & 6)
2 1722833 1 TIRE, 16 x 6-1/2, 8 Super Turf, Front
3 164247 1 TUBE, Tire 16 x 6 1/2 - 8, Front
4 1717056 2 BEARING, Ball
5 1722834 1 WHEEL, 5-3/8 x 7-15/16, Front
6 172353 2 VALVE STEM & CAP ASSEMBLY, Air
7 1919394 4 WASHER, 1
8 1722726 8 WASHER, Special, 1 x 2-1/2
9 932577 6 RING, Shaft
10 1722676 4 CAP, Hub Grey
11 105337 2 KEY, HI PRO, 1/4 x 2
12 1719172 2 WASHER, Axle Seal “L”, 2-1/2 x 2-17/32
13 960200 4 WASHER, 1
14 1721400 2 PLATE & HUB ASSEMBLY, Rear Wheel
15 1726489 2 WHEEL & TIRE ASSEMBLY, Rear 24” (Includes Ref. 6, 16, 17 &
1
16 1727146 1 TIRE, 24 x 12 - 12 Super Turf, Rear
17 157638 1 TUBE, Tire 24 x 12 - 12, Rear
18 1726490 1 WHEEL, 8-1/2 x 12, Rear
19 177725 10 NUT, Hex, 7/16-20, For Wheel Bolt

HOOD, GRILL & DASH GROUP
TP 400-5063-IR-TC-N
Manual No. 06456 GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
6

HOOD, GRILL & DASH GROUP
Footnotes:
TP 400-5063-IR-TC-N
Manual No. 06456GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0 7
Part No Descri
p
tionItem Qt
y
Note
1 1721804 1 PANEL, RH Side
1 41721804 1 PANEL, RH Side, Red
2 1721801 1 HOOD, no Louvers
2 41721801 1 HOOD, no Louvers, Red
3 1722110 1 HOOD, with Louvers
3 41722110 1 HOOD, with Louvers, Red
4 1960295 12 CAPSCREW, Hex Head Flange Lock,1/4-20 x 5/8
5 1960392 1 SCREW, Phillips Head, #10-24 x 1/2
6 1687054 1 DASHBOARD, RMO, Black
6 1687055 1 DASHBOARD, RMO with Hydra Lift Slot, Black
7 1933896 1 NUT, Hex Nylock,#10-24
8 1723123 1 ROD, Dash Support
9 1930641 12 NUT, Hex Flange Lock, 1/4-20
10 1721803 1 PANEL, LH Side
10 41721803 1 PANEL, LH Side, Red
11 1721808 1 HINGE, LH
12 1722391 1 DUCT, Air Inlet
13 1721802 1 GRILLE
13 41721802 1 GRILLE, Red
14 1721810 1 HEADLIGHT ASSEMBLY, (Includes Ref. Nos. 15 & 16)
15 1677371 4 BULB, Headligh
16 1723451 4 SOCKET, Headlight
17 1721809 1 HINGE, RH

STEERING GROUP - Power Steering with Tilt
TP 400-5063-IR-TC-N
Manual No. 06456 GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
8

STEERING GROUP - Power Steering with Tilt
Footnotes:
TP 400-5063-IR-TC-N
Manual No. 06456GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0 9
Part No Descri
p
tionItem Qt
y
Note
1 1724368 1 BOOT, Tilt Steering Unit
2 1722318 1 STEERING WHEEL, Straight Shaft
3 1960540 1 ROLL PIN
4 1723898 2 SPACER
5 1725024 1 CAP, Steering Wheel, Plain
6 1721736 1 MOUNTING PLATE
7 1724161 1 TILT STEERING UNIT Applies to Serial Number Units
1999 & Below.
8 1726026 1 TILT STEERING UNIT Applies to Serial Number Units
2000 & Above.
8 928372 4 NUT, Hex KEPS, 1/4-20
9 1722923 1 ADAPTER, 2-13/16 Long
10 1721677 2 COUPLER, 2-3/8 Long
11 1919438 2 NUT, Hex Lock, ESNA Light, 5/16-18
12 1922127 2 CAPSCREW, Hex Head 5/16-18 x 1-3/4
13 1960518 4 NUT, Push
14 1931320 4 CARRIAGE BOLT, 1/4-20 x 1-1/4
15 176440 1 BUSHING, Nylon
16 1960114 5 WASHER, 3/4
17 1722385 1 GEAR &, Shaft ASSEMBLY, Steering
18 1960032 1 CAPSCREW, Hex Head, 3/8-16 x 1-1/4
19 1930645 1 NUT, Hex Flange Two-Way Lock, 3/8-16
20 1664847 2 CAPSCREW, Hex Washer Head Taptite, 5/16-18 x 3/4
21 1721628 1 SHAFT & PINION ASSEMBLY, Steering Power wtih Tilt
22 1611710 1 RING, Clipring Extension
23 1722459 1 BEARING, 3/4 x 1-11/16
24 1722461 1 SPACER, 3/8” Long
25 1931211 2 NUT, Hex Flange Whiz Lock, 3/8-16, Small
26 1931348 2 CARRIAGE BOLT, 3/8-16 x 3/4
27 1718832 1 GENERATOR, Torque, Power Steering Unit
28 1917356 3 LOCKWASHER, Spring, 5/16
29 1921332 3 CAPSCREW, Hex Head, 5/16-18 x 3/4

FRAME GROUP
TP 400-5063-IR-TC-N
Manual No. 06456 GARDEN TRACTOR ELECTRIC CLUTCH
SERIES 0
10