Snapper LT-100 Series User manual

Parts Manual fo
r
Revision C,
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
McDonough, GA, 30253 U.S.A.
TP 400-5330-C-TC-N
1/30/2008 Manual No. 7006261
LAWN TRACTOR
Copyright © 2008
Briggs & Startton Yard Power Products Group
Milwaukee, WI USA. All Rights Reserved
Briggs & Startton Corporation
MODEL
CLT23460 (7800344)
CLT24520 (7800345)
LT23460 (7800207)
LT24520 (7800212)
SLT23460 (7800342)
SLT24520 (7800343)

Table Of Content
s
TP 400-5330-C-TC-N
Manual No. 7006261HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 3
PAGE GROUP
4Hood / Seat Group
8Steering Group
10 Main Frame Group
14 Motion Drive Group
18 Fuel Tank Group
20 Engine Group
22 46" Mower Housing Assembly
26 46" Mower Deck Group
30 50" Mower Housing Assembly
32 50" Deck Blade Drive Assembly
34 50" Deck Housing Suspension Assembly
36 52" Mower Housing Assembly
38 52" Deck Blade Drive Assembly
40 52" Deck Housing Suspension Assembly
42 Decals
44 Electrical Group
46 Wiring Schematic

TP 400-5330-C-TC-N
Manual No. 7006261 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
4

Hood / Seat Group
Footnotes:
TP 400-5330-C-TC-N
Manual No. 7006261HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 5
Part No Descri
p
tionItem Qt
y
Note
1 7091016 4 HWST 1/4CX5/8
2 721487 1 BEARING, STEERING
3 7101355 1 CONSOLE TRACTOR
4 1960392 2 SCREW, PHILLIPS HD
5 1732031 1 HOOD GUIDE, RH
1732030 1 HOOD GUIDE, LH (not shown)
7 1933896 2 NUT, HEX LOCK 10C W/ NYL INSERT BZ
8 7090952 4 SCREW, 1/4-20 THREAD CUTTING
9 7101493 1 CUTTING HEIGHT INDICATOR
10 7101770 1 POD W/ DETENT
11 7101771 1 POD W/ COMPARTMENT
12 725181 1 CONTAINER, BATTERY
13 722858 16 CAPSCREW, 5/16-18
14 722411 2 SPRING, COMPRESSION 2.43LENGTH
15 7300677D 1 SEAT DECK
16 1727294D 1 PANEL HOOD RH SIDE
17 1727295D 1 PANEL HOOD LH SIDE
18 1722110D 1 HOOD, W/ LOUVERS
19 1731891 1 AIR DUCT, PLASTIC
20 1960295 12 SCREW, HEX WZ LOCK FLNG 1/4-20X0.625 BLK
21 1930641 12 HFLN, 1/4-20 LARGE BLK
22 7102076 1 CRUISE ROD LINK
23 7300820 1 LATCH, CRUISE (was 7400261, weldment)
24 7101894 1 ROD, PIVOT CRUISE
25 7300805 1 CHANNEL - CRUISE
26 7101891 1 CRUISE - ACTUATOR
27 7102074 1 PULL KNOB, 1/4-20 THREAD
28 7300696Z 1 DASH, SUPPORT BRKT RH
29 7300697Z 1 DASH, SUPPORT BRKT LH
30 7300810Z 1 BRACKET, SUPPORT CRUISE
31 7400252Z 1 WELDMENT, CLUTCH ROD SUPPORT
32 7101860 1 SEAT, HI BACK
33 721257 1 SUPPORT, SEAT
33 7300875D 1 SUPPORT, SEAT used on model SLT24520
34 720102 2 BOLT, SHOULDER 5/16-18
35 720360 2 CAP, PUSH ON
36 721259 1 ROD, PIVOT

Hood / Seat Group
TP 400-5330-C-TC-N
Manual No. 7006261 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
6

Hood / Seat Group
Footnotes:
TP 400-5330-C-TC-N
Manual No. 7006261HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 7
Part No Descri
p
tionItem Qt
y
Note
37 721214 1 SPRING, LEAF
38 722851 4 SCREW 1/4-14X.38”ST-
39 720163 2 FW, .34X.62X16GA
40 721425 2 BOLT, WING, 0.62L X 5/16-18 UNC 2A
41 720101 1 BOLT, SHOULDER 1/4-20 X 3.652 2A
42 721258 1 WASHER, CUP, 1.50 OD X 0.344 ID
43 727614 1 SPRING, COMPRESSION 4.57 FREE LENGTH
44 721531 1 PIVOT, BRACKET SEAT
44 7300794D 1 BRACKET SEAT PIVOT used on model SLT24520
45 7091298 2 HLN, 5/16-18-3B YZ ESNA
46 720146 1 NUT, 1/4-20 HF
47 721276 1 PLATE, INDEX
47 7300865Z 1 PLATE, INDEX used on model SLT24520
48 720182 12 FASTENER PANEL
49 7101772 1 MAT, LEFT
50 7101773 1 MAT, RIGHT
51 7300818Z 1 STIFFENER, STEERING
52 7300772Z 1 BULKHEAD
53 7300658Z 1 HOOD, PIVOT LH
54 7300657Z 1 HOOD, PIVOT RH
55 7101657 2 BOLT, SHOULDER
56 720142 2 NUT, HEX FLANGE, 3/8-16 NC
57 7101458 1 HARNESS, HEADLIGHT, TCT, 1/4 TERMINALS
58 1727296 1 HEADLIGHT ASSY (Includes #'s 59, 60, 61, & 62)
59 1728973 1 REFLECTOR, HEADLIGHT
60 1728974 1 LENS, HEADLIGHT
61 1723451 2 SOCKET, LIGHT
62 1677371 2 BULB, 12.8V (1141)
63 1728059D 1 GRILLE, SNAPPER
64 7101810 1 INSERT, LIGHT BAR

Steering Group
TP 400-5330-C-TC-N
Manual No. 7006261 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
8

Steering Group
Footnotes:
TP 400-5330-C-TC-N
Manual No. 7006261HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES 9
Part No Descri
p
tionItem Qt
y
Note
1 729275 1 COVER, INTEGRA
2 727628 1 STEERING WHEEL (SOFT RIM)
3 720973 1 BELLOWS - STEERING POST
4 7101525 1 STEERING POST - 24.56” LONG
5 722867 2 CAPSCREW 5/16-18
6 721242 1 BEARING - LOWER
7 725138 1 GEAR PINION
8 720119 1 SNAP RING, 0.543”ID
9 722620 2 FW, 1.862X .765 X 16GA
10 721318 2 HUB CAP
11 7101566 2 WHEEL & TIRE ASSY, 18X6.50-8

Main Frame Group
TP 400-5330-C-TC-N
Manual No. 7006261 HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
10