Snapper LT2044 (2690714) User manual

Parts Manual fo
r
Revision IR,
LAWN TRACTOR ELECTRIC CLUTCH
McDonough, GA, 30253 U.S.A.
TP 400-5278-IR-TC-N
6/6/2007 Manual No. 7006473
HYDRO DRIVE RMO GRAINGER
Copyright © 2007
Briggs & Startton Yard Power Products Group
Milwaukee, WI USA. All Rights Reserved
Briggs & Startton Corporation
MODEL
LT2044
(
2690714
)

Table Of Content
s
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
3
PAGE GROUP
4Wheels & Tires Group
6Hood, Grille & Dash Group
8Steering Group
10 Frame & Front Axle Group
12 Controls Group
14 Transmission Group
16 Seat Deck & Fuel Tank Group
18 Engine Group
20 Lift Group - Manual
22 44" Mower Deck - Housing, Arbors & Blades Group
26 44" Mower Deck - Belt, Idler Arm & Hitch Group
28 44" & 50" Mower Deck - Height Adjustment & Roller Bar Group
30 Decals Group
32 Electrical Group

Wheels & Tires Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
4

Wheels & Tires Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
5
Part No Descri
p
tionItem Qt
y
Note
1 1729708 2 WHEEL & TIRE ASSEMBLY, Front
2 1731951 1 TIRE, Turf 15 X 6.00 - 6 Saver TL
3 1664090 1 TUBE, Tire, Front
4 1726301 1 WHEEL & BUSHINGS ASSEMBLY, Front
5 1713167 4 BEARING
6 2812808 1 FITTING, Grease, 1/4-28 Thread
7 2172353 2 VALVE STEM & CAP
8 2860183 8 WASHER, 3/4
9 1722717 4 WASHER, Special Yellow
10 2827794 4 RING, Retaining
11 1722676 4 CAP, Hub
12 1713409 2 KEY, 3/16 x 3/16 x 3
13 2860202 2 WASHER
14 1730181 2 SPACER, 0.77 ID x 1-1/4 OD x 1.65 LG Powdered Metal Black
15 1732324 2 WHEEL & TIRE ASSEMBLY, Rear 22"
16 1732394 1 TIRE, Turf 22 X 10.00 - 8 Saver TL
17 2173477 1 TUBE, Tire, Rear, 22 X 10 - 8
18 1731954 1 WHEEL, Hub

Hood, Grille & Dash Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
6

Hood, Grille & Dash Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
7
Part No Descri
p
tionItem Qt
y
Note
1 1728031D 1 HOOD, W/Scoop
2 1960295 12 CAPSCREW, Whizlock, 1/4-20 x 5/8
3 1731891 1 DUCT, Air Inlet Plastic
4 1960392 1 SCREW, Pan Head #10-24 x 1/2
5 1960674 2 PUSH NUT
6 1728090 1 KNOB, Cruise Lock Green Plastic
7 1727999 1 COVER, Steering Shaft Plastic
8 1664847 2 CAPSCREW, Hex Head, Taptite, 5/16-18 x 3/4
9 1919381 2 WASHER, Plain, 5/16
10 1728089 1 KNOB, Brake Lock Plastic
11 1727293 1 DASHBOARD
12 1732031 1 GUIDE, Hood RH
13 1960096 2 WASHER
14 1928707 2 RIVET, Pop, Stem Black
15 1732030 1 GUIDE, Hood LH
16 1930641 12 NUT, Hex Flange Whiz, 1/4-20
17 1727295D 1 PANEL, Hood LH Side
18 1723123 1 ROD, Dash Support
19 1925003 1 SCREW, Taptite, 1/4-20 x 1/2
20 1933896 1 NUT, Hex, Nylon, Lock, #10-24
21 1727279A 1 HINGE, Hood LH
21 1727280A 1 HINGE, Hood RH
22 1728059D 1 GRILLE
23 1727294D 1 PANEL, Hood RH Side
24 1728975 1 INSERT, Lightbar
25 1727296 1 HEADLIGHT ASSEMBLY

Steering Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
8

Steering Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
9
Part No Descri
p
tionItem Qt
y
Note
1 1725024 1 CAP, Steering Wheel, Plain
2 1960576 1 NUT, Hex Lock, ESNA Light, 5/8-18, Thin
3 1924366 1 WASHER, 5/8
4 1728069 1 STEERING WHEEL, w/Aluminum Insert
5 1611710 1 RING, Klipring Extension
6 1960114 2 WASHER
7 1729665 2 BUSHING, Steering
8 1931277 4 NUT, Hex, Flange Whizlock, 5/16-18
9 1727940A 1 BRACKET, Sector Support
10 1930591 4 CAPSCREW, Hex Head, Flange Whiz Lock, 5/16-18 x 3/4
11 1931211 2 NUT, Whizlock, 3/8-16
12 1728027 1 GEAR, Steering, 26 teeth
13 1728122 2 SPACER, Sector Gear Powdered Metal Yellow
14 1934654 2 CAPSCREW, Hex, Flange, Whizlock, 3/8-16 x 1
15 1727813 1 SHAFT, Steering Gear & Spline Yellow

Frame & Front Axle Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
10

Frame & Front Axle Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
11
Part No Descri
p
tionItem Qt
y
Note
1 1728086 2 PIVOT, Hood Powdered Metal
2 1931277 16 NUT, Hex, Flange Whizlock, 5/16-18
3 1727982A 1 SUPPORT, Muffler, Hood 14GA
4 1931335 2 CARRIAGE BOLT, 5/16-18 x 1
5 1930601 14 SCREW, Taptite, 5/16-18 x 5/8
6 2860744 1 CAPSCREW, Hex Head, 5/8-11 x 3-1/4 G5
7 1960035 1 WASHER, Flat, 5/8
8 1727904A 1 SUPPORT, Front Footrest RH
9 1727260A 1 TOWER, 12GA
10 1731310A 1 SUPPORT, Seat Deck 12GA
11 1731309A 1 SUPPORT, Rear Frame 12GA
12 1930591 14 CAPSCREW, Hex Head, Flange Whiz Lock, 5/16-18 x 3/4
13 1727905A 1 SUPPORT, Front Footrest LH
14 1727901A 1 FRAME, 12GA
15 2860646 1 NUT, Hex Flange Two-Way Lock, 5/8-11
16 1727902A 1 PLATE, Axle Support
17 1930650 2 LOCKNUT, Hex, Flange, 7/16-14
18 2176440 4 BUSHING, Nylon, 3/4 Diameter
19 1704214 3 FITTING, Zerk
20 1727868 1 LINK, Drag
21 1727873A 1 SPINDLE & ARM ASSEMBLY, LH
22 1960747 2 NUT, Hex Nylock 3/8-24
23 1960160 4 WASHER, 3/4
24 1728080A 1 ROD, Tie
25 1930645 2 NUT, Hex, Flange, Locking, 3/8-16
26 1727872A 1 SPINDLE & CUP ASSEMBLY, RH
27 1731912 2 BUSHING, Powdered Metal
28 1960032 2 CAPSCREW, Hex Head, 3/8-16 x 1-1/4, .141 Thread G5
29 1927531 2 CAPSCREW, 7/16-14 x 2
30 1721918A 1 HOOK, “J”
31 1730186 2 BUSHING, Axle Pivot Powdered Metal
32 1728018 1 AXLE, Front Iron Casting Machined
33 1611710 2 RING, Klipring Extension
34 1726504 2 CAP, Hub

Controls Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
12

Controls Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
13
Part No Descri
p
tionItem Qt
y
Note
1 1727259 1 PAD, Foot Pedal Reverse
2 1960223 2 CARRIAGE BOLT, 5/16-18 x 1-1/4
3 1727935 2 SPACER, Pivot Powdered Metal
4 1727246A 1 PEDAL, Reverse
5 1728024 1 SPACER, Foot Pedal Powdered Metal
6 1931277 6 NUT, Hex, Flange Whizlock, 5/16-18
7 1728025 1 ACTUATOR, RMO Switch 20GA
8 1727898 1 ROD, Cruise Latch, 16.97LG
9 1728111 2 CLIP, Linkage, Black
10 1727267 1 ROD, Parking Brake, 16.38 LG Yellow
11 1960268 2 CARRIAGE BOLT, 3/8-16 x 1-1/4
12 1727894A 1 BRACKET, Idler 7GA
13 1729620 1 SPRING, Extension 07.52 LG Black
14 1728001 1 PULLEY, 3 OD Plastic
15 1960687 2 NUT, Hex Flange, 3/8-16 ESNA
16 1931335 1 CARRIAGE BOLT, 5/16-18 x 1
17 1728000 1 PULLEY, Idler
18 1721995 1 SPRING, Extension
19 1918447 1 PIN, Cotter 3/32 x 3/4
20 1727253 1 ROD, Brake, 15.1 LG
21 1731262 1 SPRING, Extension 05.37 LG Black
22 1727261 1 PEDAL, Brake Rubber
23 1722460 1 PIN, Quick
24 1727254 1 ROD, Brake Return, 12.60 LG
25 1727252A 1 PEDAL ASSEMBLY, Brake
26 1727899 1 ROD, Cruise Latch, 2.83 LG
27 2159181 1 SPRING, Tension, Clutch
28 1727897 1 LATCH, Cruise Powdered Metal
29 1728976 1 BOLT, Shoulder 5/16-18 G5
30 1727269A 1 LATCH, Brake Lock 10GA
31 1729576 1 BOLT, Shoulder 5/16-18 G5
32 1930601 3 SCREW, Taptite, 5/16-18 x 5/8
33 1727911A 1 PLATE, Bearing
34 1727909A 1 BRACKET, Pedal Pivot 10GA
35 1930591 1 CAPSCREW, Hex Head, Flange Whiz Lock, 5/16-18 x 3/4
36 1727250A 1 PEDAL ASSEMBLY, Forward
37 1721675 1 PAD, Foot Pedal Forward

Transmission Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
14

Transmission Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
15
Part No Descri
p
tionItem Qt
y
Note
1 1664847 1 CAPSCREW, Hex Head, Taptite, 5/16-18 x 3/4
2 1931277 8 NUT, Hex, Flange Whizlock, 5/16-18
3 1728120 1 ROD, Bypass, 11.44 LG Yellow
4 1722460 2 PIN, Quick
5 1960686 1 NUT, Hex Flange, 5/16-18 ESNA
6 1727903A 2 SUPPORT, Transmission
7 1930591 4 CAPSCREW, Hex Head, Flange Whiz Lock, 5/16-18 x 3/4
8 1729589 1 TRANSMISSION ASSEMBLY, K46HD
9 1960586 4 SCREW, Hex Head Flange Lock, 5/16-18 x 2-1/2
10 1960686 1 NUT, Hex Flange, 5/16-18 ESNA
11 1666697 1 SPACER
12 1728008 1 V-BELT, Drive Belt, HA 89.25 LG Aramid/Kevlar
13 1727258A 1 ARM, Control 7GA
14 1919326 1 WASHER, Flat, 5/16
15 1921333 1 CAPSCREW, Hex Head, 5/16-18 x 1
16 1728043A 1 STRAP, Torque 7 GA
17 1919381 1 WASHER, Plain, 5/16
18 1922127 1 CAPSCREW, Hex Head, 5/16-18 x 1-3/4

Seat Deck & Fuel Tank Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
16

Seat Deck & Fuel Tank Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
17
Part No Descri
p
tionItem Qt
y
Note
1 1730159 1 SEAT, Hi Back, Steel Pan
2 1919381 4 WASHER, Plain, 5/16
3 1727268 1 LATCH, Seat 20GA E-Coat
4 1960667 4 CAPSCREW, Hex Head Flange Dog Point, 5/16-18 x 1
5 1731300 4 SPACER, 0.32 ID x 1-1/2 OD x 3/10 THK Powdered Metal Yellow
6 1727265A 1 SUPPORT, Seat 12GA
7 1960282 2 CARRIAGE BOLT, 5/16-18 x 3/4
8 1727266A 1 PIVOT, Seat 10GA
9 1931333 4 BOLT, Carriage, 5/16-18 x 3/4
10 1960686 4 NUT, Hex Flange, 5/16-18 ESNA
11 1729576 2 BOLT, Shoulder 5/16-18 G5
12 1704728 2 SPRING, Compression
13 1709256 4 WASHER, Spring Black
14 1704724 2 COVER, Spring
15 1729001 1 POD, LH Cup Holder
16 1674231 1 ELBOW FITTING
17 1654930 1 BUSHING
18 1727305 1 TANK, Fuel
19 1715917 1 CAP, Gas
20 1728006 1 PAD, Footrest LH
21 1931277 4 NUT, Hex, Flange Whizlock, 5/16-18
22 1728007 1 PAD, Footrest RH
23 1727264D 1 DECK, Seat w/Footrests (Red)
24 1960536 6 SCREW, Hex, Washer Head, Plastite, 1/4-20 x 1/2
25 1930601 2 SCREW, Taptite, 5/16-18 x 5/8
26 1729000 1 POD, RH Lift Quadrant

Engine Group
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
18

Engine Group
Footnotes:
TP 400-5278-IR-TC-N
Manual No. 7006473LAWN TRACTOR ELECTRIC CLUTCH
19
Part No Descri
p
tionItem Qt
y
Note
1 -- * ENGINE, 20HP Briggs & Stratton (Mod. 40G777-0400-E1)
2 1717473 1 VALVE, Shut Off Oil Drain
3 1731970 1 SEAL, Short
4 1728058A 1 SHIELD, Heat
5 1930601 4 SCREW, Hex Washer Head Taptite 5/16-18 x 5/8
6 1727997A 1 SHIELD, Heat
7 1727994 1 MUFFLER
8 1727976A 1 BRACKET, Muffler Mount
9 1727979 1 PIPE, Exhaust R.H.
10 1727980 1 PIPE, Exhaust L.H.
14 1925003 4 SCREW, Hex Washer Head Taptite 1/4-20 x 1/2
15 2834683 1 CLIP, Speed Wire
16 1731411 1 CONTROL, Throttle Double
17 2860112 2 CLAMP, Hose
18 1732001 1 HOSE, Fuel
19 1730268 2 CLIP, Hose
21 2820427 1 LOCKWASHER, External Tooth 3/8
22 1924940 1 WASHER, 3/8
24 1732576 1 PULLEY & HUB ASSEMBLY, Engine
25 1701011 1 TIE, Self Locking
26 1732875 1 RETAINER, Clutch
28 1731275 1 CLUTCH, Electric OGURA
29 1708264 1 WASHER, Hex
30 1918199 1 LOCKWASHER, Spring
31 1960649 1 CAPSCREW, Hex Head 7/16-20 x 3-1/2 G5
32 1731214 1 GASKET, Exhaust
33 2828635 4 SCREW, Hex Washer Head Taptite 3/8-16 x 1-1/4
34 1936228 2 CAPSCREW, Hex Socket Head 5/16-18 x 3/4 G8
35 1917356 2 LOCKWASHER, Spring 5/16
Note* See your local Briggs & Stratton dealer for service parts.

Lift Group - Manual
TP 400-5278-IR-TC-N
Manual No. 7006473 LAWN TRACTOR ELECTRIC CLUTCH
20