Sony MHS-5200A User manual

STR-DE515
AEP Model
UK Model
SERVICE MANUAL
FM STEREO/FM-AM RECEIVER
MICROFILM
ManufacturedunderlicensefromDolbyLaboratories
Licensing Corporation.
“DOLBY”, “PRO LOGIC” and the double-D symbol
are trademarks of Dolby Laboratories Licensing
Corporation. SPECIFICATIONS
— Continued on next page —
Amplifier section
Power output
Stereo mode (DIN 1kHz, 4ohms)
110W + 110W
Surround (DIN 1kHz, 4ohms)
mode Front : 90W/ch
Center : 90W
Rear :
(DIN 1kHz, 8ohms)
30Wch
Frequency PHONO : RIAA
response equalization curve
± 0.5dB
TV/LD, CD, TAPE/MD,
VIDEO, 5.1/DVD :
10Hz - 50kHz ± 1dB
InputsSensitivity Impedance S/N
(weighting
network,
input level)
PHONO 2.5mV 50 74dB
(MM) Kilohms 72dB***
(A,2.5mV)
CD, 200mV
5.1/DVD 50 82dB
TAPE/MD, 150mV Kilohms 82dB***
TV/LD, (A, 150mV)
VIDEO ***78 IHF
Outputs TAPE/MD REC OUT :
Voltage : 150mV,
Impedance:10kilohms
VIDEO AUDIO OUT :
Voltage : 150mV,
Impedance:10kilohms
WOOFER
Voltage : 2V
Impedance:10kilohms
PHONES :Accepts low
and high impedance
headphones
Muting Full mute
BASS BOOST + 10dB at 70Hz
TONE ± 8dB at 100Hz and
10kHz
FM tuner section
Tuning range 87.5 - 108.0MHz
Aerial terminalss75ohms, unbalanced
Sensitivity Mono : 18.3 dBf, 2.2µV
/75ohms
Stereo : 38.3 dBf, 22.5µV
/75ohms
Usable 11.2 dBf, 1µV
sencitivity /75ohms (IHF)
S/N Mono : 76dB
Stereo : 70dB
Harmonic Mono : 0.3%
distortion at Stereo : 0.5%
1kHz
Separation 45dB at 1kHz
Frequency 30Hz - 15kHz
+ 0.5 dB
response – 2
Selectivity 60dB at 400kHz
AM tuner section
Tuning range 522 - 1611 kHz
Aerial Loop aerial
Usable 50dB/m (at 999kHz)
sensitivity
S/N 54dB (at 50mV/m)
Harmonic 0.5% (50mV/m,
distortion 400Hz)
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

— 2 —
TABLE OF CONTENTS
Specifications ··············································································· 1
1. GENERAL
Location and Function of controls················································ 3
2. EXPLANATION OF ICTERMINALS ···················5
3. DIAGRAMS
3-1. Circuit Boards Location ····················································· 7
3-2. Printed Wiring Boards (Main Section) ······························· 8
3-3. Schematic Diagram (Main Section) ································· 13
3-4. Schematic Diagram (Display Section) ····························· 18
3-5. Printed Wiring Boards (Display Section) ························· 21
4. EXPLODEDVIEWS
4-1. Front Panel Section ·························································· 25
4-2. Chassis Section ································································· 26
5. ELECTRICAL PARTS LIST································ 27
Selectivity 35dB
General
System Tuner section : PLL
quartz-locked digital
synthesizer system
Preamplifier section :
Low-noise NF type
equalizer
Power amplifier section :
Pure-complimentary
SEPP
Power 230V AC, 50/60Hz
requirements
Power 230W
consumption
AC outlets Switched 100W
Dimensions 430 ×145 ×295mm
Mass (Approx.) 7.2kg
Supplied FM wire aerial (1)
accessories AM loop aerial (1)
Remote controller
(remote) (1)
Size AA (R6) batteries (2)
Scart adaptor (1)
Design and specifications are subject to change without notice.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK !OR DOTTED LINEWITH
MARK !ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
I/O
O
O
O
O
O
O
O
—
I
I
I
O
O
I
O
I
I
I
I
—
O
O
O
O
I
I
I
I
—
—
—
—
—
I
O
O
O
O
O
O
Description
Fluorescent indicator tube drive.
Power supply (+5V).
System clock.
System data.
PLL data input from TU001.
Chip enable output.
Chip enablr output.
Input for model slect.
Standby relay ON/OFF control.
Protector detect input.
System reset terminal.
Auto stop detect input.
Stereo detect input.
Ground.
Speaker relay drive.
Surround Relay.
Power relay drive.
Not used.
A/D signal input terminal.
A/D3 key input terminal.
A/D2 key input terminal.
A/D1 key input terminal.
Power supply (+5V).
Reference voltage (+5V).
Ground.
Not used (Open).
Ground.
System clock (4.19MHz).
System clock (4.19MHz).
Mute drive output for µPD2581V (IC701).
Plologic LED drive.
CINEMA STUDIO LED drive.
Hall LED drive.
Tuner mute drive output.
Pin Name
DIG7
DIG6
DIG5
DIG4
DIG3
DIG2
DIG1
+5V
S. CLK
S. DATA
PLL. DATA
S. CE (LC7288)
S. CE (LV100)
REARRY
BRIDGE CABLE
PROTECT
RESET
AUTO-STOP
STEREO-IN
AVss
SP-RY
SURR-RY
POWER-RY
Not used
SIGNAL
A/D3
A/D2
A/D1
AVDD
AV. REF
GND
NC
Vss
X1
X2
IC. MUTE
PROLOGIC
CSTUDIO
HALL
T. MUTE
SECTION 2
EXPLANATION OF ICTERMINALS
Pin No.
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
I/O
O
O
O
I
I
I
I
—
I
I
O
—
O
O
O
I
I
I
I
I
O
O
O
O
O
O
O
O
O
O
—
O
O
O
O
O
O
O
O
O
Description
Volume up.
Volume down.
Standby LED drive.
System power ON/OFF.
RDS data input terminal.
RDS clock input terminal.
Stop signal input from NJM2103D (IC950).
Ground.
Sircs signal input.
Power switch input terminal.
5.1ch input LED.
Power supply (+5V).
Bass boost LED drive.
Line mute drive.
Surround Lch mute.
Input for model select.
Key in 4.
Key in 3.
Key in 2.
Key in 1.
Surround Rch mute.
Key out 15.
Key out 14.
Key out 13.
Key out 12.
Key out 11.
Key out 10.
Key out 9.
Key out 8.
Key out 7.
Connect to –24V.
Key out 6.
Key out 5.
Key out 4.
Key out 3.
Key out 2.
Key out 1.
Fluorescent indicator tube drive.
Pin Name
VOLUME UP
VOLUME DOWN
STANDBY
SYS. POWER
RDS. DATA. IN
RDS. CLK. IN
STOP
Vss
SIRCS
POWER SW
5.1ch LED
+5V
BASS BOOST
FUNC. MUTE
SL MUTE
VERSION
K14
K13
K12
K11
SR MUTE
S15
S14
S13
S12
S11
S10
S9
S8
S7
VLOAD
S6
S5
S4
S3
S2
S1
DIG10
DIG9
DIG8
SECTION 3
DIAGRAMS









Fluorescent indicator tube drive.
3-1. CIRCUIT BOARDS LOCATION
— 3 — — 4 — — 5 — — 6 — — 7 —
IC201 : µPD78044FGF-064-3B9
SP-SW board
PRIMARY board
SECONDARY board
STBY board
MAIN board
VIDEO board
SWITCH board
VOLUME board
VR TONE board
KEY board
DISPLAY board
SECTION 1
GENERAL
LOCATION AND FUNCTION OF CONTROLS







Fluorescent indicator tube drive.
123 54 6 7
8
9!º!¡
!™!£
!¢
!∞
!§
!¶
!•
!ª
@º
@¡
@™
@£
@¢@∞@§
123 4
5
6
7
89!º
!¡

!™!¢!∞
!£
1POWER switch
2CENTER LEVEL +, – buttons
3REAR LEVEL +, – buttons
4STANDBY indicator
5FUNCTION indicators
65.1 INPUT indicator
7MASTER VOLUME control
8BALANCE control
9TREBLE control
!º BASS control
!¡ BASS BOOST button/indicator
!™ SURROUND ON/OFF button
!£ MODE button
!¢ EFFECT/DELAY TIME, SET UP, 5.1/DVD INPUT buttons
!∞ TAPE/MD button
!§ PHONO button
!¶ TV/LD button
!• TUNER button
!ª VIDEO button
@º CD button
@¡ DIRECT button
@™ SHIFT button
@£ Numeric buttons
@¢ Tuner control buttons
@∞ PHONES jack
@§ SPEAKERS (A/B) buttons
15.1 INPUT (FRONT/REAR/CENTER/WOOFER)
2WOOFER
3WIRELESS REAR SPEAKER
4AC OUTLET
5AC power cord
6FRONT SPEAKERS (A/B)
7SURROUND SPEAKERS (CENTER)
8SURROUND SPEAKERS (REAR)
9VIDEO
!º TV/LD
!¡ TAPE/MD
!™ CD
!£ PHONO
!¢ ANTENNA (FM/AM)
!∞ SIGNAL GND
<FRONT>
<REAR>
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

4-1. FRONT PANEL SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
1 4-980-639-01 KNOB (R14)
2 X-4946-873-1 KNOB (R48) ASSY
3 4-989-844-11 PANEL, FRONT
4 4-980-109-01 BUTTON (P-M)
*5 4-921-941-01 CUSHION (FL)
*6 4-943-107-11 HOLDER (FL TUBE)
*7 4-980-658-01 CASE (413226)
8 3-704-366-01 SCREW (CASE) (M3X8)
*9 A-4392-952-A DISPLAY BOARD, COMPLETE
10 1-773-252-11 WIRE (FLAT TYPE) (27 CORE)
11 1-769-912-11 WIRE (FLAT TYPE) (9 CORE)
12 1-773-001-11 WIRE (FLAT TYPE) (15 CORE) (9cm)
13 4-951-620-01 SCREW (2.6X8), +BVTP
*14 A-4392-954-A VR-TONE BOARD, COMPLETE
15 4-977-593-11 RING (DIA. 50), ORNAMENTAL
16 3-008-600-11 EMBLEM (5-AR), SONY
*17 A-4392-957-A KEY BOARD, COMPLETE
18 4-977-358-11 CUSHION (8X12.5)
FL201 1-517-141-11 INDICATOR TUBE, FLUORESCENT
4-2. CHASSIS SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
*51 1-665-289-11 SP-SW BOARD
52 4-951-801-01 BUTTON (S)
53 4-812-134-00 RIVET (DIA.3.5), NYLON
*54 1-665-286-11 PRIMARY BOARD
*55 1-665-287-11 SECONDARY BOARD
*56 1-665-285-11 STANDBY BOARD
*57 A-4392-959-A MAIN BOARD, COMPLETE
*58 3-703-244-21 BUSHING (2104), CORD
*59 4-989-899-61 PANEL, BACK
*60 1-665-261-11 VIDEO BOARD
61 1-769-942-11 WIRE (FLAT TYPE) (11 CORE)
— 27 —— 25 — — 26 — — 28 —
CNJ903
54 55
56
63
65
64
58
59
#4
69
61
57
52 51
62
#2
T901
not supplied
#2
#1
#1
not supplied
not supplied
#1 #3 #1
#1
#1
#1 #1 #1
#1#1 #1
#1
#1
#1
#1
#3
not supplied
#1
#1
#1
#1
#1
#1
#1
#1
53
#1
70
60
71
not supplied
#1
IC601, 651
Q553, 554, 703,
704, 753, 754
66
UK model
SONY
87
8
6
5
5
4
16
15
2
115
913 10
8
13 11 12
14
(Including p A)
13
FL201
#1
#1
#1
#1
not supplied
317
p A
a
a
8
18
18
62 X-4947-207-1 FOOT ASSY (F50150S)
63 4-924-098-01 HOLDER, PC BOARD
*64 A-4392-956-A SWITCH BOARD, COMPLETE
*65 4-924-098-21 HOLDER, PC BOARD
!66 1-770-019-11 ADAPTOR CONVERSION PLUG 3P (UK)
69 1-773-011-11 WIRE (FLAT TYPE) (15 CORE) (24cm)
70 3-905-609-01 SCREW (TRANSISTOR)
!71 1-769-744-11 CORD, POWER
!CNJ903 1-526-794-11 OUTLET, AC
!T901 1-431-269-11 TRANSFORMER, POWER
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
*A-4392-952-A DISPLAY BOARD, COMPLETE
************************
*4-921-941-01 CUSHION (FL)
*4-943-107-11 HOLDER (FL TUBE)
< CAPACITOR >
C201 1-104-905-11 CAPACITOR 0.22F 5.5V
C201 1-125-486-11 DOUBLE LAYERS 0.22F 5.5V
C202 1-164-159-21 CERAMIC 0.1uF 50V
C203 1-124-465-00 ELECT 0.47uF 20% 50V
C204 1-164-159-21 CERAMIC 0.1uF 50V
C205 1-162-294-31 CERAMIC 0.001uF 10% 50V
C206 1-164-159-21 CERAMIC 0.1uF 50V
C207 1-126-096-11 ELECT 10uF 20% 35V
< CONNECTOR >
CNP205 1-779-366-11 CONNECTOR, BOARD TO BOARD 4P
CNS201 1-569-327-11 SOCKET, CONNECTOR 27P
CNS202 1-770-403-11 HOUSING,CONNECTOR(PC BOARD)10P
< DIODE >
D201 8-719-815-85 DIODE 1S1585
D202 8-719-815-85 DIODE 1S1585
D203 8-719-815-85 DIODE 1S1585
D204 8-719-815-85 DIODE 1S1585
D211 8-719-815-85 DIODE 1S1585
D212 8-719-815-85 DIODE 1S1585
D213 8-719-815-85 DIODE 1S1585
D214 8-719-815-85 DIODE 1S1585
D223 8-719-815-85 DIODE 1S1585
D231 8-719-815-85 DIODE 1S1585
D233 8-719-313-48 DIODE SEL6210S-TH12 (STANDBY)
D234 8-719-057-97 DIODE SEL5923A-TP15 (5.1/DVD)
D235 8-719-313-50 DIODE SEL6810A-TH12 (HALL)
D236 8-719-313-50 DIODE SEL6810A-TH12 (C.STUDIO)
D237 8-719-313-50 DIODE SEL6810A-TH12 (PRO LOGIC)
D239 8-719-057-97 DIODE SEL5923A-TP15 (5.1/DVD)
D240 8-719-057-97 DIODE SEL5923A-TP15 (5.1/DVD)
< FILTER >
FL201 1-517-141-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC201 8-759-479-19 IC uPD78044FGF-064-3B9
IC202 8-759-962-08 IC BA6208
IC203 8-759-332-18 IC GP1U27XB (REMOTE SENSOR)
< COIL >
L401 1-410-509-11 INDUCTOR 10uH
< TRANSISTOR >
Q201 8-729-900-63 TRANSISTOR DTA124ES
Q202 8-729-900-36 TRANSISTOR DTC124ES
Q203 8-729-900-36 TRANSISTOR DTC124ES
Q231 8-729-900-36 TRANSISTOR DTC124ES
Q232 8-729-119-76 TRANSISTOR 2SA1175-HFE
< RESISTOR >
R200 1-247-863-91 CARBON 22K 5% 1/4W
R201 1-247-903-00 CARBON 1M 5% 1/4W
R202 1-249-429-11 CARBON 10K 5% 1/4W
R203 1-249-429-11 CARBON 10K 5% 1/4W
R204 1-249-425-11 CARBON 4.7K 5% 1/4W F
R205 1-249-441-11 CARBON 100K 5% 1/4W
R206 1-249-429-11 CARBON 10K 5% 1/4W
R207 1-249-429-11 CARBON 10K 5% 1/4W
R211 1-247-863-91 CARBON 22K 5% 1/4W
R212 1-247-863-91 CARBON 22K 5% 1/4W
R213 1-247-863-91 CARBON 22K 5% 1/4W
R214 1-247-863-91 CARBON 22K 5% 1/4W
R216 1-247-863-91 CARBON 22K 5% 1/4W
R221 1-247-807-31 CARBON 100 5% 1/4W
R222 1-247-807-31 CARBON 100 5% 1/4W
R223 1-247-807-31 CARBON 100 5% 1/4W
R224 1-247-807-31 CARBON 100 5% 1/4W
R225 1-247-807-31 CARBON 100 5% 1/4W
R226 1-249-441-11 CARBON 100K 5% 1/4W
R227 1-249-441-11 CARBON 100K 5% 1/4W
R228 1-249-412-11 CARBON 390 5% 1/4W F
R229 1-249-410-11 CARBON 270 5% 1/4W F
R230 1-249-410-11 CARBON 270 5% 1/4W F
R231 1-249-427-11 CARBON 6.8K 5% 1/4W F
R270 1-247-807-31 CARBON 100 5% 1/4W
R283 1-249-427-11 CARBON 6.8K 5% 1/4W F
R284 1-249-427-11 CARBON 6.8K 5% 1/4W F
R285 1-249-399-11 CARBON 33 5% 1/4W F
R286 1-249-437-11 CARBON 47K 5% 1/4W
< SWITCH >
S201 1-554-937-11 SWITCH, KEY BOARD (CENTER LEVEL–)
S202 1-554-937-11 SWITCH, KEY BOARD (CENTER LEVEL+)
S203 1-554-937-11 SWITCH, KEY BOARD (REAR LEVEL–)
S204 1-554-937-11 SWITCH, KEY BOARD (REAR LEVEL+)
S205 1-554-937-11 SWITCH, KEY BOARD (PTY)
S206 1-554-937-11 SWITCH, KEY BOARD (EON)
S207 1-554-937-11 SWITCH, KEY BOARD (DISPLAY)
S208 1-554-937-11 SWITCH, KEY BOARD (CHARACTER)
S209 1-554-937-11 SWITCH, KEY BOARD (TUNING LEVEL–)
S210 1-554-937-11 SWITCH, KEY BOARD (TUNING LEVEL+)
S211 1-554-937-11 SWITCH, KEY BOARD (PRESET TUNING–)
S212 1-554-937-11 SWITCH, KEY BOARD (PRESET TUNING+)
S213 1-554-937-11 SWITCH, KEY BOARD (FM MODE)
S214 1-554-937-11 SWITCH, KEY BOARD (FM)
S215 1-554-937-11 SWITCH, KEY BOARD (AM)
S216 1-554-937-11 SWITCH, KEY BOARD (MEMORY)
< SWITCH >
SW200 1-771-054-11 SWITCH, PUSH (1 KEY) (POWER)
< VIBRATOR >
X201 1-577-101-11 VIBRATOR, CERAMIC 4.19MHz
************************************************************
*A-4392-957-A KEY BOARD, COMPLETE
********************
< CONNECTOR >
CNS205 1-770-397-11 HOUSING, CONNECTOR(PC BOARD)4P
< RESISTOR >
R232 1-249-411-11 CARBON 330 5% 1/4W
R233 1-249-413-11 CARBON 470 5% 1/4W F
R234 1-249-415-11 CARBON 680 5% 1/4W F
R235 1-249-417-11 CARBON 1K 5% 1/4W F
R236 1-249-419-11 CARBON 1.5K 5% 1/4W F
R237 1-249-421-11 CARBON 2.2K 5% 1/4W F
R238 1-247-843-11 CARBON 3.3K 5% 1/4W
R239 1-249-411-11 CARBON 330 5% 1/4W
R240 1-249-413-11 CARBON 470 5% 1/4W F
R241 1-249-415-11 CARBON 680 5% 1/4W F
R242 1-249-417-11 CARBON 1K 5% 1/4W F
R243 1-249-419-11 CARBON 1.5K 5% 1/4W F
R244 1-249-421-11 CARBON 2.2K 5% 1/4W F
R245 1-247-843-11 CARBON 3.3K 5% 1/4W
R246 1-249-411-11 CARBON 330 5% 1/4W
R247 1-249-413-11 CARBON 470 5% 1/4W F
R248 1-249-415-11 CARBON 680 5% 1/4W F
R249 1-249-417-11 CARBON 1K 5% 1/4W F
R280 1-249-419-11 CARBON 1.5K 5% 1/4W F
R281 1-249-421-11 CARBON 2.2K 5% 1/4W F
R282 1-247-843-11 CARBON 3.3K 5% 1/4W
< SWITCH >
S217 1-554-937-11 SWITCH, KEY BOARD (SURROUND ON/OFF)
S218 1-554-937-11 SWITCH, KEY BOARD (SET UP)
S219 1-554-937-11 SWITCH, KEY BOARD (EFFECT/DELAY TIME)
S220 1-554-937-11 SWITCH, KEY BOARD (TV/DBS)
S221 1-554-937-11 SWITCH, KEY BOARD (TUNER)
S222 1-554-937-11 SWITCH, KEY BOARD (PHONE)
S223 1-554-937-11 SWITCH, KEY BOARD (VIDEO)
S224 1-554-937-11 SWITCH, KEY BOARD (6)
S225 1-554-937-11 SWITCH, KEY BOARD (7)
S226 1-554-937-11 SWITCH, KEY BOARD (8)
S227 1-554-937-11 SWITCH, KEY BOARD (9)
S228 1-554-937-11 SWITCH, KEY BOARD (0)
S229 1-554-937-11 SWITCH, KEY BOARD (SHIFT)
S230 1-554-937-11 SWITCH, KEY BOARD (5.1/DVD INPUT)
S231 1-554-937-11 SWITCH, KEY BOARD (TAPE/MD)
S232 1-554-937-11 SWITCH, KEY BOARD (1)
S233 1-554-937-11 SWITCH, KEY BOARD (2)
S234 1-554-937-11 SWITCH, KEY BOARD (3)
S235 1-554-937-11 SWITCH, KEY BOARD (4)
S236 1-554-937-11 SWITCH, KEY BOARD (5)
S237 1-554-937-11 SWITCH, KEY BOARD (DIRECT)
S238 1-554-937-11 SWITCH, KEY BOARD (MODE)
S239 1-554-937-11 SWITCH, KEY BOARD (CD)
************************************************************
*A-4392-959-A MAIN BOARD, COMPLETE
*********************
3-905-609-01 SCREW (TRANSISTOR)
4-812-134-00 RIVET (DIA. 3.5), NYLON
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
7-685-872-09 SCREW +BVTT 3X8 (S)
< CAPACITOR >
C3 1-162-286-21 CERAMIC 220PF 10% 50V
C4 1-126-961-11 ELECT 2.2uF 20% 50V
C5 1-162-306-11 CERAMIC 0.01uF 20% 16V
C6 1-162-291-31 CERAMIC 560PF 10% 50V
C7 1-102-527-11 CERAMIC 82PF 5% 50V
C8 1-102-852-91 CERAMIC 47PF 5% 50V
C302 1-126-934-11 ELECT 220uF 20% 16V
C303 1-130-494-11 MYLAR 0.082uF 5% 50V
C304 1-137-367-11 FILM 0.0033uF 5% 50V
C305 1-130-494-11 MYLAR 0.082uF 5% 50V
C306 1-126-959-11 ELECT 0.47uF 20% 50V
C307 1-126-964-11 ELECT 10uF 20% 50V
C308 1-126-964-11 ELECT 10uF 20% 50V
C309 1-162-291-31 CERAMIC 560PF 10% 50V
C310 1-126-962-11 ELECT 3.3uF 20% 50V
C311 1-126-961-11 ELECT 2.2uF 20% 50V
C312 1-126-934-11 ELECT 220uF 20% 16V
C313 1-126-934-11 ELECT 220uF 20% 16V
C314 1-136-165-00 FILM 0.1uF 5% 50V
C316 1-124-252-00 ELECT 0.33uF 20% 50V
C317 1-126-933-11 ELECT 100uF 20% 16V
C318 1-137-363-91 FILM 680PF 5% 50V
C322 1-126-962-11 ELECT 3.3uF 20% 50V
C323 1-136-173-00 FILM 0.47uF 5% 50V
C324 1-126-967-11 ELECT 47uF 20% 16V
C325 1-136-165-00 FILM 0.1uF 5% 50V
C326 1-136-165-00 FILM 0.1uF 5% 50V
C327 1-126-959-11 ELECT 0.47uF 20% 50V
C328 1-126-963-11 ELECT 4.7uF 20% 50V
C329 1-126-959-11 ELECT 0.47uF 20% 50V
C330 1-126-963-11 ELECT 4.7uF 20% 50V
C331 1-124-250-11 ELECT 0.15uF 20% 50V
C332 1-126-962-11 ELECT 3.3uF 20% 50V
C333 1-124-250-11 ELECT 0.15uF 20% 50V
C334 1-137-372-11 FILM 0.022uF 5% 50V
SECTION 4
EXPLODEDVIEWS
Note:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delayshould beanticipated whenordering these
items.
• Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑ ↑
Parts of Color Cabinet’s Color
• Themechanical partswith noreference number
in the exploded views are not supplied.
• Hardware (# mark) list and accessories and
packing materials are given in the last of this
parts list.
The components identified by mark !or
dotted line with mark !are critical for safety.
Replace only with part number specified.
The components identified by mark !or dotted
line with mark !are critical for safety.
Replace only with part number specified.
SECTION 5
ELECTRICAL PARTS LIST
Note: • Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX, -X mean standardized parts, so they may
have some difference from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delayshould beanticipated whenordering these
items.
• CAPACITORS:
uF: µF
The components identified by mark !or
dotted line with mark !are critical for safety.
Replace only with part number specified.
• RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
• COILS
uH: µH
• SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
When indicating parts by reference number,
please include the board name.
DISPLAY DISPLAY KEY MAIN
pA : VOLUME board
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 29 —
C335 1-136-161-00 FILM 0.047uF 5% 50V
C336 1-126-934-11 ELECT 220uF 20% 16V
C337 1-126-964-11 ELECT 10uF 20% 50V
C338 1-126-964-11 ELECT 10uF 20% 50V
C339 1-126-964-11 ELECT 10uF 20% 50V
C340 1-126-964-11 ELECT 10uF 20% 50V
C341 1-126-934-11 ELECT 220uF 20% 16V
C342 1-126-962-11 ELECT 3.3uF 20% 50V
C343 1-126-962-11 ELECT 3.3uF 20% 50V
C344 1-136-165-00 FILM 0.1uF 5% 50V
C345 1-136-165-00 FILM 0.1uF 5% 50V
C346 1-126-959-11 ELECT 0.47uF 20% 50V
C347 1-126-963-11 ELECT 4.7uF 20% 50V
C348 1-126-959-11 ELECT 0.47uF 20% 50V
C349 1-126-963-11 ELECT 4.7uF 20% 50V
C350 1-124-250-11 ELECT 0.15uF 20% 50V
C351 1-126-962-11 ELECT 3.3uF 20% 50V
C352 1-124-250-11 ELECT 0.15uF 20% 50V
C357 1-164-159-21 CERAMIC 0.1uF 50V
C359 1-126-963-11 ELECT 4.7uF 20% 50V
C360 1-126-963-11 ELECT 4.7uF 20% 50V
C365 1-126-966-11 ELECT 33uF 20% 16V
C366 1-164-159-21 CERAMIC 0.1uF 50V
C370 1-164-159-21 CERAMIC 0.1uF 50V
C401 1-162-286-21 CERAMIC 220PF 10% 50V
C402 1-126-962-11 ELECT 3.3uF 20% 50V
C403 1-126-966-11 ELECT 33uF 20% 16V
C404 1-162-286-21 CERAMIC 220PF 10% 50V
C405 1-137-459-11 FILM 0.0056uF 5% 100V
C406 1-164-159-21 CERAMIC 0.1uF 50V
C407 1-137-365-11 FILM 0.0015uF 5% 50V
C408 1-162-294-31 CERAMIC 0.001uF 10% 50V
C409 1-126-962-11 ELECT 3.3uF 20% 50V
C410 1-164-159-21 CERAMIC 0.1uF 50V
C412 1-162-291-31 CERAMIC 560PF 10% 50V
C413 1-164-159-21 CERAMIC 0.1uF 50V
C415 1-164-159-21 CERAMIC 0.1uF 50V
C416 1-164-159-21 CERAMIC 0.1uF 50V
C434 1-162-286-21 CERAMIC 220PF 10% 50V
C435 1-162-286-21 CERAMIC 220PF 10% 50V
C451 1-162-286-21 CERAMIC 220PF 10% 50V
C452 1-126-962-11 ELECT 3.3uF 20% 50V
C453 1-126-966-11 ELECT 33uF 20% 16V
C454 1-162-286-21 CERAMIC 220PF 10% 50V
C455 1-137-459-11 FILM 0.0056uF 5% 100V
C457 1-137-365-11 FILM 0.0015uF 5% 50V
C459 1-126-962-11 ELECT 3.3uF 20% 50V
C460 1-164-159-21 CERAMIC 0.1uF 50V
C513 1-126-963-11 ELECT 4.7uF 20% 50V
C514 1-126-960-11 ELECT 1uF 20% 50V
C515 1-164-159-21 CERAMIC 0.1uF 50V
C516 1-126-963-11 ELECT 4.7uF 20% 50V
C517 1-162-193-31 CERAMIC 3.3PF 10% 50V
C552 1-162-282-31 CERAMIC 100PF 10% 50V
C553 1-126-933-11 ELECT 100uF 20% 10V
C554 1-164-040-11 CERAMIC 4PF 0.25PF 50V
C555 1-102-989-00 CERAMIC 68PF 5% 500V
C556 1-102-989-00 CERAMIC 68PF 5% 500V
C560 1-126-967-11 ELECT 47uF 20% 16V
C561 1-137-372-11 FILM 0.022uF 5% 50V
C567 1-162-193-31 CERAMIC 3.3PF 10% 50V
C570 1-162-286-21 CERAMIC 220PF 10% 50V
C601 1-162-282-31 CERAMIC 100PF 10% 50V
C602 1-162-282-31 CERAMIC 100PF 10% 50V
C604 1-104-665-11 ELECT 100uF 20% 25V
C605 1-162-294-31 CERAMIC 0.001uF 10% 50V
C610 1-137-372-11 FILM 0.022uF 5% 50V
C641 1-162-282-31 CERAMIC 100PF 10% 50V
C642 1-162-282-31 CERAMIC 100PF 10% 50V
C643 1-162-282-31 CERAMIC 100PF 10% 50V
C651 1-162-282-31 CERAMIC 100PF 10% 50V
C652 1-162-282-31 CERAMIC 100PF 10% 50V
C654 1-104-665-11 ELECT 100uF 20% 25V
C660 1-137-372-11 FILM 0.022uF 5% 50V
C702 1-162-282-31 CERAMIC 100PF 10% 50V
C703 1-126-933-11 ELECT 100uF 20% 10V
C705 1-102-233-00 CERAMIC 33PF 10% 500V
C710 1-126-967-11 ELECT 47uF 20% 16V
C711 1-137-372-11 FILM 0.022uF 5% 50V
C720 1-162-286-21 CERAMIC 220PF 10% 50V
C721 1-126-923-11 ELECT 220uF 20% 10V
C722 1-126-964-11 ELECT 10uF 20% 50V
C740 1-128-562-11 ELECT 47uF 20% 100V
C741 1-128-562-11 ELECT 47uF 20% 100V
C742 1-126-925-11 ELECT 470uF 20% 10V
C752 1-162-282-31 CERAMIC 100PF 10% 50V
C753 1-126-933-11 ELECT 100uF 20% 10V
C755 1-102-233-00 CERAMIC 33PF 10% 500V
C760 1-126-967-11 ELECT 47uF 20% 16V
C761 1-137-372-11 FILM 0.022uF 5% 50V
C770 1-162-286-21 CERAMIC 220PF 10% 50V
C799 1-164-159-21 CERAMIC 0.1uF 50V
C801 1-104-664-11 ELECT 47uF 20% 25V
C802 1-104-664-11 ELECT 47uF 20% 25V
C803 1-125-556-11 ELECT(BLOCK) 8200uF 20% 56V
C804 1-125-556-11 ELECT(BLOCK) 8200uF 20% 56V
C805 1-130-781-00 FILM 0.22uF 10% 100V
C806 1-130-781-00 FILM 0.22uF 10% 100V
C807 1-104-664-11 ELECT 47uF 20% 25V
C808 1-104-664-11 ELECT 47uF 20% 25V
C809 1-126-960-11 ELECT 1uF 20% 50V
C810 1-126-960-11 ELECT 1uF 20% 50V
C811 1-126-974-11 ELECT 3300uF 20% 50V
C812 1-126-974-11 ELECT 3300uF 20% 50V
C813 1-101-001-00 CERAMIC 0.001uF 50V
C814 1-101-001-00 CERAMIC 0.001uF 50V
C820 1-161-494-00 CERAMIC 0.022uF 25V
C821 1-161-494-00 CERAMIC 0.022uF 25V
C822 1-104-664-11 ELECT 47uF 20% 25V
C823 1-104-664-11 ELECT 47uF 20% 25V
C950 1-126-767-11 ELECT 1000uF 20% 16V
C951 1-164-097-11 CERAMIC 0.022uF 50V
C952 1-126-960-11 ELECT 1uF 20% 50V
C953 1-124-464-11 ELECT 0.22uF 20% 50V
C954 1-126-795-11 ELECT 10uF 20% 50V
C955 1-164-159-21 CERAMIC 0.1uF 50V
CC01 1-162-282-31 CERAMIC 100PF 10% 50V
CC02 1-162-282-31 CERAMIC 100PF 10% 50V
CC03 1-162-282-31 CERAMIC 100PF 10% 50V
CC04 1-162-282-31 CERAMIC 100PF 10% 50V
MAIN
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 30 —
CC05 1-162-282-31 CERAMIC 100PF 10% 50V
CC06 1-162-282-31 CERAMIC 100PF 10% 50V
CC07 1-162-282-31 CERAMIC 100PF 10% 50V
CC51 1-162-282-31 CERAMIC 100PF 10% 50V
CC52 1-162-282-31 CERAMIC 100PF 10% 50V
CC53 1-162-282-31 CERAMIC 100PF 10% 50V
CC54 1-162-282-31 CERAMIC 100PF 10% 50V
CC55 1-162-282-31 CERAMIC 100PF 10% 50V
CC56 1-162-282-31 CERAMIC 100PF 10% 50V
CC57 1-162-282-31 CERAMIC 100PF 10% 50V
< CONNECTOR >
CNP503 1-695-087-11 PIN, CONNECTOR (PC BOARD) 7P
CNP504 1-695-087-11 PIN, CONNECTOR (PC BOARD) 7P
CNP702 1-764-474-11 PIN, CONNECTOR (PC BOARD) 5P
CNS204 1-569-327-11 SOCKET, CONNECTOR 27P
CNS251 1-569-060-11 SOCKET, CONNECTOR 11P
CNS701 1-568-442-11 SOCKET, CONNECTOR 9P
CNS802 1-770-480-11 SOCKET, CONNECTOR PIN 4P
< DIODE >
D560 8-719-815-85 DIODE 1S1585
D610 8-719-815-85 DIODE 1S1585
D710 8-719-815-85 DIODE 1S1585
D721 8-719-815-85 DIODE 1S1585
D722 8-719-815-85 DIODE 1S1585
D723 8-719-815-85 DIODE 1S1585
D724 8-719-815-85 DIODE 1S1585
D725 8-719-815-85 DIODE 1S1585
D726 8-719-815-85 DIODE 1S1585
D727 8-719-815-85 DIODE 1S1585
D728 8-719-815-85 DIODE 1S1585
D801 8-719-002-33 DIODE UZL-24L
D802 8-719-302-38 DIODE RBV-602-01
D803 8-719-028-23 DIODE D3SBA20-4101
D804 8-719-010-38 DIODE UZ-5.1BSB
D810 8-719-200-82 DIODE 11ES2
D811 8-719-200-82 DIODE 11ES2
D812 8-719-200-82 DIODE 11ES2
D813 8-719-200-82 DIODE 11ES2
D814 8-719-815-85 DIODE 1S1585
D815 8-719-815-85 DIODE 1S1585
D817 8-719-001-31 DIODE UZL-9H3-TA
D818 8-719-815-85 DIODE 1S1585
D901 8-719-815-85 DIODE 1S1585
< TERMINAL >
*G200 1-537-738-21 TERMINAL, EARTH
*G201 1-537-738-21 TERMINAL, EARTH
*G202 1-537-738-21 TERMINAL, EARTH
< IC >
IC1 8-759-450-86 IC BU1922
IC300 8-759-442-97 IC LV1016
IC301 8-759-442-96 IC LA2786
IC302 8-759-636-74 IC M5218AP-22
IC401 8-759-805-14 IC LC7822
IC402 8-759-636-74 IC M5218AP-22
IC551 8-749-011-16 IC STK350-230
IC601 8-759-085-89 IC LM3875-S
IC651 8-759-085-89 IC LM3875-S
IC701 8-759-326-52 IC uPC2581V
IC801 8-759-604-40 IC M5F78M15
IC802 8-759-604-46 IC M5F79M15
IC950 8-759-333-83 IC NJM2103D
< JACK >
J401 1-770-614-11 JACK, PIN 4P (PHONO/CD)
J402 1-580-825-11 JACK, PIN 6P (TAPE/MD,TV/DBS AUDIO IN)
J403 1-770-614-11 JACK, PIN 4P (VIDEO)
< COIL >
L1 1-410-521-11 INDUCTOR 100uH
L301 1-410-509-11 INDUCTOR 10uH
L302 1-410-509-11 INDUCTOR 10uH
L551 1-420-872-00 COIL, AIR-CORE
L601 1-420-872-00 COIL, AIR-CORE
L651 1-420-872-00 COIL, AIR-CORE
L701 1-420-872-00 COIL, AIR-CORE
L751 1-420-872-00 COIL, AIR-CORE
< TRANSISTOR >
Q551 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q552 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q553 8-749-010-25 IC MN2488-OPY-M
Q554 8-749-010-26 IC MP1620-OPY-M
Q560 8-729-119-78 TRANSISTOR 2SC403SP-51
Q570 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q610 8-729-119-78 TRANSISTOR 2SC403SP-51
Q701 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q702 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q703 8-749-010-25 IC MN2488-OPY-M
Q704 8-749-010-26 IC MP1620-OPY-M
Q710 8-729-119-78 TRANSISTOR 2SC403SP-51
Q720 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q721 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q722 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
Q723 8-729-119-78 TRANSISTOR 2SC403SP-51
Q751 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q752 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q753 8-749-010-25 IC MN2488-OPY-M
Q754 8-749-010-26 IC MP1620-OPY-M
Q770 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q801 8-729-140-97 TRANSISTOR 2SB734-34
Q802 8-729-119-78 TRANSISTOR 2SC403SP-51
Q808 8-729-030-18 TRANSISTOR 2SD2525
Q809 8-729-119-78 TRANSISTOR 2SC403SP-51
Q951 8-729-030-18 TRANSISTOR 2SD2525
< RESISTOR >
R5 1-249-421-11 CARBON 2.2K 5% 1/4W F
R6 1-247-807-31 CARBON 100 5% 1/4W
R7 1-247-807-31 CARBON 100 5% 1/4W
R298 1-249-381-11 CARBON 1 5% 1/4W F
R299 1-249-381-11 CARBON 1 5% 1/4W F
MAIN
w w w . x i a o y u 1 6 3 . c o m
Q Q
3
7
6 3
1 5 1 5
0 9 9
2
8 9
4 2
9 8
T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3
Q Q
TEL [phone] QQ 376315150 892498299 TEL [phone] QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com