2 82225
Table of Contents
Warnings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Service Helps
42. Washer Does Not Display Price . . . . . . . 46
Serial Plate Location. . . . . . . . . . . . . . . . . . . . 3 43. Washer Does Not Count Coins. . . . . . . . 46
44. Washer Will Not Start After Coins
Service Procedures Counted. . . . . . . . . . . . . . . . . . . . . . . . . 47
1. Cabinet Top. . . . . . . . . . . . . . . . . . . . . . . . . . 4 45. Washer Does Not Start. . . . . . . . . . . . . . 47
2. Service Door. . . . . . . . . . . . . . . . . . . . . . . . . 5 46. Drive Motor Does Not Run. . . . . . . . . . . 48
3. Graphic Panel Overlay. . . . . . . . . . . . . . . . . . 6 47. Washer Starts But Will Not Advance
4. Loading Door. . . . . . . . . . . . . . . . . . . . . . . . . 6 Through Cycle. . . . . . . . . . . . . . . . . . . . . 48
5. Loading Door Gasket. . . . . . . . . . . . . . . . . . . 8 48. Hot Water Does Not Enter Cylinder. . . . 49
6. Loading Door Shaft and Cam Assembly. . . . 8 49. Cold Water Does Not Enter Cylinder. . . 49
7. Door Lock Assembly. . . . . . . . . . . . . . . . . . . 9 50. Warm Water Does Not Enter Cylinder. . 49
8. Front Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . 12 51.NoHotWaterinDetergentDispenser. . . 50
9. Rear Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . 12 52. Cylinder Does Not Fill. . . . . . . . . . . . . . . 50
10. Belt(s). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 53.WaterDoesNotShutOff(WaterLevel
11. Motor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 TooHigh). . . . . . . . . . . . . . . . . . . . . . . . 50
12. Drain Valve. . . . . . . . . . . . . . . . . . . . . . . . . . 15 54. Water Does Not Drain or Drains Slow
13. Side Panel (Right or Left). . . . . . . . . . . . . . . 15 FromCylinder. . . . . . . . . . . . . . . . . . . . . 51
14. Selector Switch. . . . . . . . . . . . . . . . . . . . . . 17 55.WasherDoesNotTumble. . . . . . . . . . . . 51
15. Coin Accepter. . . . . . . . . . . . . . . . . . . . . . . . 18 56.WasherTumblesOnlyinOneDirection. 51
16. Coin Accumulator. . . . . . . . . . . . . . . . . . . . . 18 57. Washer Does Not Spin. . . . . . . . . . . . . . 51
17. Cycle Control Light. . . . . . . . . . . . . . . . . . . . 19 58.WasherDoesNotStopatEndofCycle. 52
18. Bleach Light. . . . . . . . . . . . . . . . . . . . . . . . . 19 59. Loading Door Will Not Open. . . . . . . . . . 52
19. Program Timer. . . . . . . . . . . . . . . . . . . . . . . 20 60.DoorLeaks. . . . . . . . . . . . . . . . . . . . . . . 52
20. Reversing Timer. . . . . . . . . . . . . . . . . . . . . . 21 61.ExcessiveVibration. . . . . . . . . . . . . . . . . 52
21. Circuit Breaker. . . . . . . . . . . . . . . . . . . . . . . 22
22. Pressure Switch. . . . . . . . . . . . . . . . . . . . . . 22 Wiring Schematics and Diagrams
23. Relay (Spin). . . . . . . . . . . . . . . . . . . . . . . . . 23 Wiring Schematic – 220/240 Volt, 60 Hertz,
24. Accumulator Transformer. . . . . . . . . . . . . . . 23 1Phase;208/240Volt,60Hertz,3
25. Capacitor (Spin or Wash). . . . . . . . . . . . . . . 24 Phase. . . . . . . . . . . . . . . . . . . . . . . . . . . 53
26. Dispenser. . . . . . . . . . . . . . . . . . . . . . . . . . . 24 WiringSchematic–208/240Volt,60Hz,3
27. Door Lock Solenoid and Thermoactuator Ph. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . 25 WiringDiagram–220/240Volt,60Hertz,
28. Water Inlet Valve (Hot or Cold). . . . . . . . . . 26 1Phase. . . . . . . . . . . . . . . . . . . . . . . . . 55
29. Siphon Break. . . . . . . . . . . . . . . . . . . . . . . . 27
30. Cylinder Assembly. . . . . . . . . . . . . . . . . . . . 28
31. Cylinder Pulley Removal. . . . . . . . . . . . . . . 32
32. Bearing Housing and Tub Back Removal. . 34
33. Bearing Removal. . . . . . . . . . . . . . . . . . . . . 35
34. Bearing Installation. . . . . . . . . . . . . . . . . . . . 36
35. Reassembly of Bearing Housing, Supports
and Tub Back. . . . . . . . . . . . . . . . . . . . . . . .
37
36. Reassembly of Bearing Housing and Tub
Back onto Cylinder Shaft. . . . . . . . . . . . . . .
38
37. Reassembly of Bearing Housing, Tub Back
and Cylinder Assembly to Outer Tub. . . . . .
41
Adjustments
38. Pressure Switch. . . . . . . . . . . . . . . . . . . . . . 42
39. Loading Door. . . . . . . . . . . . . . . . . . . . . . . . 43
40. Door Latch Switch. . . . . . . . . . . . . . . . . . . . 43
41. Door Lock Switches, Solenoid and
Mounting Bracket Assembly. . . . . . . . . . . .
44
