Springfree 721001 Installation instructions

Trampoline & Enclosure
Disassembly Instructions
Version 721001
The information in this document is subject to change without notice.
© Copyright Springfree Trampoline Inc. 2005, 2013. All rights reserved.

WARNING: Read the warnings on this page and those contained in
the User Guide before you disassemble the trampoline and enclo-
sure.
Do not attempt or allow somer-
saults. Landing on the head or neck
can cause serious injury, paralysis
or death even when landing on the
middle of the bed.
Treat any loaded rod with caution
until you are sure it is properly
installed or uninstalled. Keep your
face well away from any loaded rod.
Do not hold onto, or place ngers
between the rods while someone is
jumping on the trampoline.
Do not allow more than one person
at the same time on the trampoline
or enclosure. Use by more than
one person can result in serious
injury.
Never attempt to remove a black
net rod from its net pocket or
disengage (unlock) the rod sleeve
while the black net rod is under
tension.
Your Springfree trampoline has
been designed for residential
backyard use by both children and
adults. The Safe User Weight for
this trampoline is located on the
front panel of this manual and on
the front of the trampoline packag-
ing. Jumpers above the Safe User
Weight run a higher risk of injury
and should not use the trampoline.
Jumpers at or near the Safe User
Weight should take extra precaution
in their manoeuvres to ensure they
do not initiate contact with the
ground while jumping as this can
cause serious injury.

Disassembly Precautions
Read the following steps before beginning the assembly process.
Icons used in this Manual
Keep small children at least 25 ft (7.62 m) away while disassembling the trampoline; they could be
injured by improperly disassembled rods releasing and ejecting from the frame.
Do not attempt to use the trampoline if it is not completely assembled.
Disassembly typically takes two hours to complete. Two people are recommended.
Be aware that when loaded, the rods can spring back and may cause injury.
Treat any loaded rod with caution until you are sure it is properly installed. In particular, keep your
face well clear of the rods during disassembly. An improperly uninstalled rod could release and
cause facial injury or blindness.
The sleeves on the rods are intended to provide protection from any breglass bers or splinters. Do
not remove the sleeve.
1.
2.
3.
4.
5.
6.
We’ve included several helpful icons throughout the installation process to help make the disassembly
of your trampoline as easy as possible. We strongly encourage you to follow these icons carefully.
Here is what each one means:
WARNING - This icon warns of
potential danger. Always pay close
attention to these icons.
NOTE - We use this icon to ag
important information that should not
be overlooked.
TIP - This icon highlights techniques
or tricks you can use to simplify the
installation process.
SCAN HERE - We use this icon to
steer you to our website were we
have helpful demonstration videos
that will guide you through a specic
installation step. For your conve-
nience, we’ll also include the web

1
Remove the white c-clips located on the net rod sockets. Lift the bottom end of the black net rods
out of the net rod sockets and lower the net.
Remove the black net rods from the net rod pockets and the horizontal net rods (if applicable) from
the top edge of the net.
Starting at a corner, carefully pull the top edge of the net down over the edge of the mat. Continue
around the trampoline until the net is sitting at the bottom of the mat rods.
TIP - If you’re having difculty removing the black net rod from the net rod pocket, twist
the ball end of the rod and pull to release it.
TIP - Your trampoline model may differ from the one shown however, the disassembly
steps remain the same.
WARNING - Never attempt to remove a black net rod from its net rod pocket or disengage
(unlock) the rod sleeve while the black net rod is under tension.
SCAN HERE or visit http://springfr.ee/disassem for a helpful installation demonstration
video.
TIP
-
I
f you’re havin
g
difculty removin
g
the black net rod from the net rod pocket, twist
the ball end o
f
the rod and pull to release it
.
TIP
-
Y
our trampoline model may differ from the one shown however, the disassembly
ste
p
s remain the same
.
WARNIN
G
G
-
Never attempt to remove a black net rod from its net rod pocket or disen
g
a
g
e
(
unlock
)
the rod sleeve while the black net rod is under tension.

2
NOTE - Two people are required for disassembly.
NOTE - Before you remove a white mat rod from a mat rod holder read the instructions in
the following two panels.
WARNING - Treat any loaded rod with caution until you are sure it is properly installed or
uninstalled. Keep your face well away from any loaded rod.
Have one person position themselves inside the frame of the trampoline while the other stands
outside as shown.
NOTE
-
Two people are required
f
or disassembl
y.
NOTE
-
Be
f
ore you remove a white mat rod
f
rom a mat rod holder read the instructions in
the
f
ollowin
g
two
pa
nels
.
WARNING
ARNIN
G
-
T
reat an
y
loaded rod with caution until
yo
u are sure it is
p
ro
pe
rl
y
installed o
r
uninstalled. Keep your face well away from any loaded rod
.
Have one person position themselves inside the
f
rame o
f
the trampoline while the other stands
outs
id
e as s
h
own
.

WARNING - Treat any loaded rod with caution until you are sure it is properly installed
or uninstalled. Keep your face well away from any loaded rod.
1 Outside Person:
Hold the white mat
rod with your palm
facing up. Stand
with one leg forward
and bend your
knees.
2 Outside Person:
Move the white mat
rod up and to the
right rmly as shown.
4 Inside Person:
Ensure the outside
person’s hands are
positioned as shown.
Pay careful attention
that their left hand is
tight against the
corner of the mat rod
holder. Then take
hold of the rod with
both hands.
3 Outside Person:
While still holding
the white mat rod,
bend your arm at a
right-angle and push
your elbow into your
hip.
1 Outside Person:
H
o
ld
t
h
e w
hi
te mat
r
od with your palm
facing up. Stand
with one leg forward
and bend your
knees.
2 Out
s
M
ove
t
rod
up
right

4 Ins
id
Ensu
re
p
ers
on
po
siti
o
Pay
ca
that t
h
ti
g
ht
a
corn
er
h
older
h
old o
f
b
oth h
3
O
ut
si
de
P
er
so
n:
Whil
e st
ill
h
o
ldi
n
g
the white mat rod
,
b
en
d
y
our arm at a
ri
gh
t-an
gl
e an
d
pu
s
h
y
our elbow into
y
our
hip
.

WARNING - Treat any loaded rod with caution until you are sure it is properly installed or
uninstalled. Keep your face well away from any loaded rod.
WARNING - Both people must maintain a steady grip on the rod until it is in its resting
position.
NOTE - When dislodging a white mat rod, be careful not to knock your hands against
adjacent rods.
5 Outside Person:
Push forward,
rocking from your
heels to the balls of
your feet, using the
weight of your body
to push the white
mat rod over the
back edge of the
mat rod holder.
Keep the mat edge
horizontal with your
other hand.
6 Inside Person:
Once the ball comes
to the back edge of
the mat rod holder,
pull the white mat rod
down and out.
Sometimes a forceful
pull is needed to
dislodge the ball from
the mat rod holder.
7 Inside and Outside
Person: Lower the
white mat rod and
carefully ease it to a
resting position.
5
Outside Person:
Push forward
,
r
ocking from your
h
ee
l
s
t
o
th
e
ba
ll
s
o
f
your feet, using the
weight of your body
to push the white
m
a
t r
od
o
v
e
r t
he
back edge of the
mat rod holder.
Keep the mat edge
horizontal with your
other hand
.
6
In
s
O
nce
to th
e
the
m
p
ull t
h
dow
n
S
om
e
p
ull i
s
dislo
d
the
m
7
Inside and Outside
P
erson:
L
ower t
h
e
w
hi
te mat ro
d
an
d
carefully ease it to a
rest
i
ng pos
i
t
i
on.

WARNING - Do not attempt to disassemble any frame components before the mat and
white mat rods have been removed.
WARNING - Treat any loaded rod with caution until you are sure it is properly installed
or uninstalled. Keep your face well away from any loaded rod.
3
Starting at a blue mat tag and moving in a counter clockwise direction, uninstall the white mat rods
at each colored tag. If your trampoline does not have green tags like the model shown, just
continue to the next blue tag.
Then continue working around the trampoline uninstalling one white mat rod to the right of each
uninstalled rod.
Remove the white mat rods from the frame and then pack the net, mat and rods.
Disassemble the frame in the reverse order to which it was assembled.
WARNIN
G
-
Do not attempt to disassemble any
f
rame components be
f
ore the mat an
d
whit
e
ma
t
ro
ds
h
av
e
be
en
r
em
ov
ed
.
WARNING
NING
-
T
reat any loaded rod with caution until you are sure it is properly installed
or uninstalled. Keep
y
our
f
ace well awa
y
f
rom an
y
loaded rod
.
ng
at a blue mat ta
g
and movin
g
in a counter clockwise direction, uninstall the white mat rods
n
Starti
n
c
h colored tag. I
f
your trampoline does not have green tags like the model shown, ju
st
at eac
at eac
continue to the next blue tag.
contin
Then contin e orking aro nd the trampoline ninstalling one hite mat rod to the right of eac
h