Steel Core 39411 User manual

*Actual product may vary slightly
Please carefully read and save these instructions before attempting to assemble, maintain, install, or operate this product.
Observe all safety information to protect yourself and others. Failure to observe the instructions may result in property
damage and/or personal injury. Please keep instructions for future reference.
For warranty purchases, please keep your dated proof of purchase. File or attach to the manual for safe keeping.
For Customer Service, Call 1-800-348-5004
or e-mail [email protected] 39411 01/2017
RADIATOR PRESSURE TESTER KIT
39411

[email protected] 21-800-348-5004
IMPORTANT SAFETY INFORMATION
1. TO PREVENT STEAM BURNS, DO NOT OPEN CAP OF HOT OR WARM RADIATOR.
2. Pressurize only with hand pump. Do not use engine to pressurize system.
3. Loosen the radiator cap slowly.
4. Keep away from hot engine parts and fluids.
5. Use this product only according to these instructions. Improper use can create hazards.
6. Wear ANSI-approved safety goggles and heat resistant work gloves during product
assembly and use.
7. Refer to the vehicle’s service manual for specific radiator pressure testing instructions
before use.
8. Clean up coolant spills immediately. Dispose of fluids according to local, state, and
federal codes and regulations.
9. Keep work area clean and well lit.
10. Do not overreach. Keep proper footing and balance at all times. This enables better
control of the product in unexpected situations.
11. Keep bystanders out of the area during assembly and use.
12. Do not assemble or operate when tired or when under the influence of drugs or
medication.
13. This product is not a toy. Do not allow children to play with or near this product.
14. Use as intended only.
15. Inspect before every use. Do not use if parts missing or damaged.
16. WARNING: The brass components of this product contain lead, a chemical known to
the State of California to cause cancer and birth defects or other reproductive harm.
(California Health & Safety Code § 25249.5, et seq.)
17. WARNING: This product contains di (2-ethylhexyl) phthalate (DEHP), a chemical
known to the State of California to cause cancer and birth defects or other
reproductive harm. (California Health & Safety Code § 25249.5, et seq.)
18. Maintain product labels and nameplates. These carry important safety information.
If unreadable or missing, contact FOT for a replacement.
OPERATING INSTRUCTIONS
1. Refer to the vehicle’s service manual for specific radiator pressure testing instructions.
2. Loosen the vehicle’s radiator cap slowly to relieve any excess pressure before
removing the cap completely. Do not open the cap of a hot radiator.
3. Select the Proper Adapter and configuration of the Stationary Seat accessories.
Securely attach the adapter to the filler neck of the radiator or expansion tank.
4. Attach the Quick Connector of the Hand Pump onto the Adapter.
5. Rapidly pump the Hand Pump while watching the pressure gauge. Pressurize the
radiator up to the optimal pressure only - Do not over pressurize the radiator.
Readings normally range 12 ~15 PSI. If the pressure level is too low, there may
be a leak in the radiator or hose.
6. Once the test is complete, release the air pressure by pressing the Pressure
Release Valve on the Hand Pump. Then disconnect the Quick Coupler and
Adapter assembly.
7. Store the Kit in its Case in a clean, dry, safe location out of reach of children.

PARTS LIST AND DIAGRAM
Note: Kit may work for only some models under each indicated make.
Note: Some parts are listed and shown for
illustration purposes only, and are not
available individually as replacement parts.
[email protected] 31-800-348-5004
Part Description Function*
1 Pump
2Blue
Adapter
Skoda®, SAAB®, Ford®,
Daewoo®, Audi®A4, A5, A6
3Yellow
Adapter
Skoda, Seat®, Audi,
Opel®, VW®, Ford
4Red
Adapter
Seat, Alfa Romeo®,
Audi, BMW®
5Orange
Adapter Land Rover®, BMW
7 Adapter
Lancia®, Volvo®,
Land Rover, Renault®,
Peugeot®, Opel®, Honda®,
Fiat®, Citroen®, Audi, VW®
8Adjustable
Seat
Toyota®, Suzuki®, Nissan®,
Mitsubishi®, Mercedes®,
Chrysler®, Citroen
950 mm Seat
Use with item 8
for Japanese and
European cars
Part Description Function*
10 35 mm Seat
Use with item 8 for
Japanese and European
cars including:
Suzuki, Nissan, Mitsubishi,
Chrysler, Citroen, Mercedes
11 27 mm Seat
Use with item 8 for
Japanese and European
cars including:
Toyota, Suzuki, Nissan
13 Adapter Kia®
14 Clip
Use with adapters and seat
accessories for: Toyota,
Suzuki, Mitsubishi, Nissan
15 Adapter Honda, Toyota
16 Adapter
Opel, Hyundai®, Honda,
Mitsubishi, Ford, Nissan,
Mazda®, Toyota
21 Green
Adapter GM®
22 Adapter GM, Ford
19 Case
11 10 9
1
3
15
4
21
8
7
22
19
2
516
13 14

Limited Manufacturer Warranty
FOT makes every effort to ensure that this product meets high quality and durability
standards. FOT warrants to the original retail consumer a 1-year limited warranty
from the date the product was purchased at retail and each product is free from
defects in materials. Warranty does not apply to defects due directly or indirectly
to misuse, abuse, negligence or accidents, repairs or alterations, or a lack of
maintenance. FOT shall in no event be liable for death, injuries to persons or
property, or for incidental, special or consequential damages arising from the
use of our products. To receive service under warranty, the original manufacturer
part must be returned for examination by an authorized service center. Shipping
and handling charges may apply. If a defect is found, FOT will either repair or
replace the product at its discretion.
DO NOT RETURN TO STORE
For Customer Service:
Email: [email protected] or Call 1-800-348-5004
[email protected] 41-800-348-5004