Swing Slide Climb Manor Multi MPS050 User manual

Manor Multi
Play Set
MPS050
WARNING: ONLY FOR DOMESTIC OUTDOOR USE.
THIS PLAYSET SATISFIES ALL THE REQUIREMENTS OF THE AUSTRALIAN STANDARD AS/NZS ISO 8124 AND
HAS BEEN CERTIFIED BY AN INDEPENDENT LABORATORY. TO GUARANTEE SAFETY, PLEASE GIVE SPECIAL
ATTENTION TO THE ASSEMBLY, SAFETY, AND CARE INSTRUCTIONS DETAILED IN THIS DOCUMENT.
Distributed By
South Earl Pty Ltd
Warning: Maximum fall height is 170 cm
3-12
Years
MAX
2 CHILDREN

A4 x 2
YB5 x 1
YB54 x 2
YB363 x 1
YB367 x 2 YB368 x 2
YB372 x 1
YB379 x 1
YB386 x 1 YB387 x 1
YB381 x 1 YB382 x 1 YB383 x 1
YB395 x 4 YC3 x 8 YC18 x 2
YB384 x 1 YB385 x 1
YB373 x 4 YB375 x 2 YB376 x 1
YB369 x 7 YB370 x 2 YB371 x 4
YB377 x 1
YB364 x 1 YB365 x 1 YB366 x 2
YB92 x 2 YB210 x 2 YB211 x 2 YB292 x 1
YB19 x 2 YB20 x 2 YB22 x 2
10 x 1

YB379
YB378
YB377
YB376
YH329
YH330
YH331
YD7
YJ10
YE9
YG13
YF10
YG5
YL5
YL4
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
1
1
1
1
2
2
1
4
4
8
8
16
16
16
8
Required Parts
YH332
YH333
YJ10
YB371
YE9
YG13
YL5
x
x
x
x
x
x
x
2
6
48
2
4
4
4
Required Parts
1
2

YB384
YB386
YD7
YE12
YL4
YF10
YL5
YB383
YH385
YH329
YE9
YG13
YG5
x
x
x
x
x
x
x
x
x
x
x
x
x
1
1
2
4
8
4
4
1
1
1
4
8
4
Required Parts
YH330
YH331
YB375
YB381
YJ10
YL4
YF10
YH329
YD7
YG5
YB382
YE9
YG13
YL5
x
x
x
x
x
x
x
x
x
x
x
x
x
x
2
1
2
1
4
4
12
1
2
12
1
4
4
12
Required Parts
3
4

YH332
YH333
YJ10
x
x
x
2
6
48
Required Parts
YB371
YI49
YE9
YG13
YL5
x
x
x
x
x
2
1
4
4
4
Required Parts
YB365
YB395
YD10
YD63
YD51
YE1
YE9
YG13
YI147
YJ8
YK2
YL4
x
x
x
x
x
x
x
x
x
x
x
x
1
2
6
1
4
6
6
12
1
6
8
12
Required Parts
56
7

YB364
YB395
YD10
YD51
YD63
YE1
YE9
YG13
YI48
YJ8
YK2
YL4
x
x
x
x
x
x
x
x
x
x
x
x
1
2
6
4
1
6
6
12
1
6
8
12
Required Parts
YB367
YD52
YL4
YB366
YE1
YG13
x
x
x
x
x
x
2
8
16
2
16
16
Required Parts
8
9

YB370
YB368
YB92
YD10
YC27
YE20
YE28
YE12
YG13
YG5
YG6
YJ1
YL4
YL5
x
x
x
x
x
x
x
x
x
x
x
x
x
x
2
2
2
4
2
2
8
4
2
8
4
4
12
2
Required Parts
YB369
YE15
YL5
YG13
x
x
x
x
7
14
14
14
Required Parts
10
11

YB292
YD64
YB211
YL5
YN1
YE1
YB363r
YD1
YB5
YG13
YE12
YB387r
YB210
YN2
YN3
YL4
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
1
1
2
12
2
2
1
1
1
16
2
1
2
4
6
4
Required Parts
12
r
r
r

YB373
YB374
YC30
YE19
YE20
YG13
YI50
YL4
x
x
x
x
x
x
x
x
4
3
4
6
4
4
1
10
Required Parts
14

YB372
YB54
YG4
YJ1
YE9
YL5
YC18
YN30
YL4
YD10
YG13
YJ3
YC24
x
x
x
x
x
x
x
x
x
x
x
x
x
1
2
2
4
2
2
2
2
2
4
2
2
1
Required Parts
15

YE12
YE9
YE15
YL4
YG13
YD2
x
x
x
x
x
x
2
6
2
10
10
10
Required Parts
16

After Sales Service : [phone]
Manor Playset
SAFETY ADVICE
- As per legal requirements, a swing seat with flexible means of suspension must have a 40cm minimal distance between the ground and
the swing. This distance is important for safety.The distance between the swing seat and the ground and the trapeze and the ground can be
adjusted using the plastic height adjustment hooks.
- Warning: This product is only to be used by children between the ages of 3 and 12.
- Warning: Not to be used by anyone weighing over 50kgs, simultaneously not to exceed a combined weight of 150 kgs.
- Warning: Choking hazard - small parts can be dangerous for children.
- Warning: This play set must be used under adult supervision.
- This product is for private use at home only. Under no circumstances is it to be used in parks, schools, camp sites, hotels, public leisure
areas etc.
- The Play Set should be set up on a flat surface at least 2 metres away from any structures or obstacles (walls, fences, trees, washing
lines, cables etc).
- To avoid eye damage, we advise that the swing and slide should not be setup directly facing the sun.
- The Play Set should be installed over impact absorbing surfaces such as sand, wood-bark chips, rubber and foam and must NOT be set
up on a hard surface (concrete, tarmac etc). For detail on surfacing materials please refer to the provided consumer information sheet.
- We recommend to secure your swing set firmly into the ground using concrete.
- The anchorage must be checked regularly.
- Dispose of packaging thoughtfully.
- Do not allow children to play with packaging.
- Please see below diagram for maximum fall height of swing.
CAUTION ! This Product includes timber and/or fabric, Please Keep away from fire.
FIXING INTO THE GROUND
IMPORTANT ! For safety reasons, your Play Set must be embedded into the ground.
- Place your Play Set in the desired position and mark a square area 250mm x 250 mm around each of the feet. Dig holes 300 mm deep.
(The feet must be in the center of the square)
- Fill the holes with concrete. Do not exceed the ground level. Fit the embedding piece into the center of the concrete so that fixtures for
screwing the posts into place rise out of the concrete.
- When the concrete is dry, screw the posts to the embedding pieces.
- Anchors shall be placed level with or under ground in order to reduce tripping hazards.
IMPORTANT ! Wait until the concrete is set before using and check anchorages regularly.
MAINTENANCE
- All parts should be checked at least once a month.
- Check all nuts and bolts for tightness and tighten when required.
- Check for signs of wear to bolt coverings. If sharp edges are found, replace as required.
- In certain regions (seaside areas), certain coatings could be prone to damage. In this case, it is advisedto use a rust prevention treatment.
- Check swing seats, chains, ropes and other means of attachment for evidence of deterioration; replace when required in accordance with
the manufacturer's instructions.
- All parts that are under constant friction should be oiled regularly using a suitable lubricant.
- The ground on which the play centre is set up should be cleared regularly. All objects such as stones or anything else that could cause
injury in the case of a fall should be removed.
- It is recommended that during the winter period when the equipment is not in use, all apparatus are removed to prevent deterioration due
to bad weather.
- Sand rusted areas and tubular members and repaint using a non-lead based paint when required
- Modifications to the original activity toy should only be carried out under instructions from the manufacturer.
- Defective parts should only be replaced in accordance with the manufacturer's instructions.
- For aesthetic reasons, you may want to apply a timber treatment to the timber parts.
IMPORTANT NOTICE FOR TIMBER CARE & MAINTENANCE
This product contains timber components that are naturally subject to deterioration in the outdoor elements. All outdoor timber products
require routine inspection and regular maintenance.
To combat the eects of outdoor exposure and greatly increase the lifespan of your play set or cubby,we strongly recommend that you apply
a protective coat of exterior grade lacquer or oil to all timber parts upon first assembly. In order to best maintain the timber we recommend
reapplying protective coats every 3 months.
Failure to care for your timber parts by applying protective lacquer or oil will greatly reduce the lifespan of your product.
For information on the most suitable exterior lacquer or oil, please consult your hardware specialist. Please ensure the product does not
contain hazardous chemicals once dry that can pose a potential health risk to children.
To ensure continued safety of your product, Major timber maintenance should be performed at twelve month intervals from the date of
installation. All timber parts should be inspected for splintering and structural defects and treated as follows:
- For very minor splinters or chipping, a light sand and coat of exterior water repellent oil/varnish is suitable.
- If timber has cracked, rotted, or split significantly, replacement parts may be required. Please contact our customer service team on (03)
9786 0055 for all replacement part enquiries.
We hope you have a safe and enjoyable time using the Manor Play Set (MPS050).