Swing Slide Climb BAW BAW CUBBY User manual

BAW BAW CUBBY PLAY SET
ASSEMBLY INSTRUCTIONS
1. Slide 4. Cubby house
2. Climbing rocks 5. Cubby window
3. Support handles
1
4
5
2
3

Ensure to read all warnings and instructions in
this user guide prior to first use.
Failure to assemble and maintain this item as
per instruction may cause injury to the user.
Please keep the instructions in a safe place
for future reference.
•WARNING! Not suitable for children under
3 years. Contains small parts.
• This Baw Baw Cubby Play Set is suitable for
children aged 3-12 years.
• This Baw Baw Cubby Play Set is only suitable
for domestic use and not designed for
commercial use.
• The Baw Baw Cubby Play Set should only be
assembled by adults.
• Adult supervision is always required when
children are playing with the Baw Baw Cubby
Play Set.
• Ensure all screws are fully tightened and
secure. Failure to do so may result in injuries.
• Check all coverings for exposed screws and
sharp edges.
• If the Baw Baw Cubby Play Set is faulty,
stop use immediately.
• Ensure regular inspections and maintenance
on the Baw Baw Cubby Play Set’s components
are performed.
• Do not fully tighten the screws until assembly
is complete.
• Do not modify the Baw Baw Cubby Play Set
yourself.
The Baw Baw Cubby Play Set satisfies all the
requirements of the Australian Standard
AS/NZ ISO 8124 and has been certified by
an independent laboratory.
TIMBER CARE
As timber is a natural product, it will deteriorate
in the weather over time. For maximum
longevity, it is highly recommended to apply an
initial 3 coats of a timber protectant such as
paint, lacquer or an exterior grade oil before
first use of the play set.
Minor twisting, warping, cracking and any other
natural occuring property of wood will occur.
PLEASE NOTE these occurrences are cosmetic
and will not aect the strength or integrity of the
product. If you have any concerns or queries
please contact the after sales service for further
assistance.
All outdoor wooden products require routine
inspection and regular maintenance.
After installation, a follow-up inspection should
take place after one week and twice a month
thereafter for the remaining life of your play
products. Maintenance should be performed at
any time it is deemed necessary. As a general
rule, major maintenance (wood refinishing)
should be performed at 6 month intervals
from the date of installation. Inspect and
performance base on the following checklist:
Major wooden parts: Inspect for splintering
and structure defects at regular intervals.
For minor splinters or chipping, lightly sand and
refinish with an exterior water repellent stain
can assist. If the timber has cracked or split
significantly, replacement parts may be
required. Please contact our After Sales Service
for any replacement requirements.
• It is preferable to pre-drill timber before fixing
screws to avoid cracks in the timber.
• The dimensions given in the instructions are
indicative only, they may vary according to the
assembly method.
• CAUTION! This product includes timber and
or fabric. PLEASE KEEP AWAY FROM FIRE.
• IMPORTANT: If living in area prone to
termites, please ensure any timber is treated
with termite protection. Ensure the product
does not contain hazardous chemicals once
dry that can pose a potential health risk to
children.
After Sales Service: 1300 457 272
BAW BAW CUBBY PLAY SET - SAFETY & WARNINGS

ASSEMBLY ADVICE
• Follow the instructions exactly.
• This product must be assembled by adults.
• Once assembly has been completed, keep
the instructions in a safe place for future
reference. This can be particularly handy for
identification of parts if any after sales service
is required.
• Before commencing assembly, check tha
none of the parts are missing. If you find that
you are missing a part please contact our sales
service department.
• Retain extra parts to use as spares in the future
if necessary.
• Pre-drill timber before fixing with screws to
avoid cracks in the timber. The dimensions
given in the instructions are indicative only,
they may vary according to the assembly
method.
• As per legal requirements, a swing seat with
flexible means of suspension must have a
40cm minimal distance between the ground
and the swing. This distance is important for
safety. The distance between the swing seat
and the ground and the trapeze and the
ground can be adjusted using the plastic
height adjustment hooks.
• WARNING! This product is only to be used by
children between the ages of 3 and 12.
• WARNING! Choking hazard - small parts can
be dangerous for children.
• It must be used under adult supervision.
• This product is for private use at home only.
Under no circumstances is it to be used in
parks, schools, camp sites, hotels, public
leisure areas etc.
• The Play Set should be set up on a flat surface
and 2 metres away from any structures or
obstacles (walls, trees, washing lines, cables
etc).
• To avoid eye damage, we advise that the
swing and slide should not be setup directly
facing the sun.
• The Play set should be installed over impact
absorbing surfaces such as sand, wood-bark
chips, rubber and foam and must NOT be set
up on a hard surface (concrete, tarmac etc).
For detail surface materials please refer to the
attached consumer information sheet.
• We recommend to secure your swing set firmly
into the ground using concrete.
• The anchorage must be checked regularly.
• Dispose of packaging thoughtfully.
• Do not allow children to play with packaging.
• CAUTION: This product includes timber and/or
fabric. Please keep away from fire.
•IMPORTANT: For safety reasons, your Play Set
must be embedded into the ground.
• Place your Play Set in the desired position and
mark a square area 350mm x 350mm around
each of the feet. Dig holes 350mm deep.
(The feet must be in the centre of the square.
• Fill the holes with concrete. Do not exceed the
ground level. Fit the embedded piece into
the centre of the concrete so that fixtures for
screwing the posts to the embedding pieces.
• When the concrete is dry, screw the posts to
the embedding pieces.
• Anchors shall be placed level with or under
ground in order to reduce tripping hazards.
• IMPORTANT Wait until the concrete is set
before using and check anchorages regularly.
• All parts should be checked at least once
a month.
• Check all nuts and bolts for tightness and
tighten when required.
• Check for signs of wear to bolt coverings.
If sharp edges are found, replace as required.
• In certain regions (seaside areas), certain
coating could be prone to damage. In this
case, it is advised to use a rust prevention
treatment.
• Check all playset accessories and other means
of attachment for evidence of deterioration;
replace when required in accordance with the
manufacturer’s instruction.
• All parts that are under constant friction should
be oiled regularly using a suitable lubricant.
SAFETY ADVICE
MAINTENANCE

• The ground on which the play centre is set up
should be cleared regularly. All objects such
as stones or anything else that could cause
injury in the case of a fall should be removed.
• It is recommended that during the winter
period when the equipment is not in use,
all apparatus are removed to prevent
deterioration due to bad weather.
• Sand rested areas and tubular members and
repaint using a non-lead based paint when
required.
• Modifications to the original activity toy should
only be carried out under instructions from the
manufacturer.
• Defective parts should only be replaced
in accordance with the manufacturer’s
instructions.
• For aesthetic reasons, you may want to apply
a timber treatment to the timber parts.
Ensure the product does not contain
hazardous chemicals once dry that can pose
a potential health risk to children.
MAINTENANCE C0NT.

BAW BAW CUBBY PLAY SET - TIMBER
TOOLS REQUIRED
TIMBERS
PHILLIPS
SCREWDRIVER
27
28
29
30
31
32
1PC
3PCS
2PCS
2PCS
4PCS
6PCS
R
1PC
NO:14-4
3PCS
TOOLS REQUIRED
Phillips
Screwdriver Cordless Drill
and Phillips Head
Drill Bit
CORDLESS DRILL &
PHILLIPS HEAD DRILL BIT
1610001 X4
1100x76x76mm
1480x127x16mm
1418.64x86x50mm
461.4x76x16mm
1026.27x86x50mm
1425x127x16mm
610003 X2
610005 X2 610006 X1
610004 X2
610002 X1
2
34
56
27
28
29
30
31
32
1PC
3PCS
2PCS
2PCS
4PCS
6PCS
R
1PC
NO:14-4
3PCS
TOOLS REQUIRED
Phillips
Screwdriver Cordless Drill
and Phillips Head
Drill Bit
TAPE MEASURE
* Drill bit drivers supplied

78
910
11 12
13 14
BAW BAW CUBBY PLAY SET - TIMBER
610007 X2
610009 X1
610011 X2
610013 X2 610014 X1
610012 X14
610010 X2
610008 X2
1716.93x86x50mm
1026.27x86x50mm
1620x76x35mm
1273x76x22mm
1425x86x22mm
1425x120x22mm
1425x127x22mm
2226.47x127x22mm

BAW BAW CUBBY PLAY SET - TIMBER
15 16
17 18
19 20
21 22
610015 X1
610017 X1
610019 X2
610021 X5 610022 X2
610020 X1
610016 X5
610018 X2
1607x76x22mm
1425x127x22mm
1525x86x16mm
1525x127x16mm 808.89x76x22mm
1470x127x16mm
1480x76x16mm
1525x127x22mm

23 24
25 26
27 28
29 30
BAW BAW CUBBY PLAY SET - TIMBER
610023 X8
610025 X2
610027 X14
610029 X2
610028 X2
610030 X2
610026 X1
610024 X5
480x127x16mm
1612.72x76x22mm
276x127x16mm
560x127x16mm
431.7x86x16mm
465.7x127x16mm
1525x127x22mm
546.78x76x16mm

BAW BAW CUBBY PLAY SET - TIMBER
31
33
35
35
32
34
36
36
610031 X2
610033 X2
610035 X1
610037 X2
610036 X2
610038 X2
610034 X2
610032 X2
371.4x127x16mm
643.1x86x16mm
1525x127x16mm
906x86x35mm
485x86x22mm
700x76x22mm
250.4x128.4x22mm
534.9x86x22mm

12
34
56
78
BAW BAW CUBBY PLAY SET - TIMBER
610037 X2
610039 X2
610041 X2
610043 X1
610042 X2
610044 X1
610040 X1
610038 X2
906*86*35mm
887.3*76*22mm
1525*127*16mm
1469.1*76*22mm
465*76*16mm
580*35*22mm
829.3*76*22mm
906*86*35mm

910
12
34
BAW BAW CUBBY PLAY SET - TIMBER
BAW BAW PLAY SET CUBBY - FIXINGS
610045 X1
B159 X2
B189 X4
B160 X8
B161 X8
610046 X1
640*35*22mm 508*35*16mm

56
78
910
11 12
BAW BAW CUBBY PLAY SET - FIXINGS
B165 X4
S91 X124
S96 X6
S65 X12
S79 X4
S119 X16
S92 X235
B169 X4

13 14
15 16
17 18
BAW BAW CUBBY PLAY SET - FIXINGS
N01 X12
W07 X14
MSC02 X2 MSC01 X2
N02 X30
W14 X12

12
BAW BAW CUBBY PLAY SET - ACCESSORIES
PCSL02 X1 PCAC17 X2
34
56
PCAC15 X6
PCHD23 X4 PCAC55 X1
PCHD27 X2

BAW BAW CUBBY PLAY SET - ASSEMBLY INSTRUCTIONS
1610001 = 2 PIECES
610003 = 1 PIECE
610008 = 1 PIECE
610011 = 1 PIECE
610018 = 1 PIECE
B165 = 2 PIECES
B161 = 2 PIECES
S119 = 4 PIECES
N02 = 4 PIECES
2610003 = 1 PIECE
610018 = 1 PIECE
610042 = 2 PIECES
S91 = 8 PIECES
610001
B165
2pcs
B161
2pcs
N02
2pcs
610011
610003 610001
610018
610008
S119
2pcs
S119
2pcs
N02
2pcs
610003
610018
610042
2pcs
S91
600mm
283mm
440mm 440mm
410mm
8 pieces

3
4
BAW BAW CUBBY PLAY SET - ASSEMBLY INSTRUCTIONS
610001 = 2 PIECES
610011 = 1 PIECE
610018 = 1 PIECE
B165 = 2 PIECES
B161 = 2 PIECES
S119 = 4 PIECES
N02 = 4 PIECES
610010 = 2 PIECES
610013 = 2 PIECES
B161 = 4 PIECES
S92 = 4 PIECES
N02 = 4 PIECES
B165
2pcs
B161
2pcs
N02
2pcs
S119
2pcs
S119
2pcs
STEP 2
610001
610011
610001
610008
N02
2pcs
S92
610010
610013
610013 610010
2pcs
N02
2pcs
S92
2pcs
B161
2pcs
B161
2pcs
N02
2pcs

BAW BAW CUBBY PLAY SET - ASSEMBLY INSTRUCTIONS
5S119 = 4 PIECES
6610012 = 14 PIECES
610017 = 1 PIECE
610014 = 1 PIECES
S92 = 64 PIECES
S119
2pcs
S119
2pcs
610017
610012
S92
14pcs
14pcs
610014

7
8
610015 = 1 PIECE
S92 = 18 PIECES
610006 = 1 PIECE
610007 = 2 PIECES
61009 = 1 PIECE
B160 = 4 PIECES
N02 = 4 PIECES
610015
S92
18pcs
610007
2pcs
610009
610006
B160
N02
BAW BAW CUBBY PLAY SET - ASSEMBLY INSTRUCTIONS

9
10
610005 = 2 PIECES
B169 = 4 PIECES
B189 = 2 PIECES
N02 = 6 PIECES
610020 = 1 PIECE
S119 = 2 PIECES
S96 = 2 PIECES
STEP 8
STEP 8
B169
2pcs
B189
2pcs
N02
N02
2pcs
610005
S119
2pcs
S96
2pcs
610020
BAW BAW CUBBY PLAY SET - ASSEMBLY INSTRUCTIONS

11
12
610036 = 2 PIECES
S119 = 2 PIECES
620021 = 1 PIECE
S91 = 11 PIECES
S119
2pcs
610036
2pcs
610034
S92
2pcs
BAW BAW CUBBY PLAY SET - ASSEMBLY INSTRUCTIONS