Tanaka TPE-270PF Setup guide

IllustrIllustr
IllustrIllustr
Illustraa
aa
ated Pted P
ted Pted P
ted Parar
arar
arts Mants Man
ts Mants Man
ts Manualual
ualual
ual
Model Number:
TPE-270PF/PN
26cc Portable Edger
P/N 29249
Rev 001
Date 5-7-07
Nikko Tanaka Engineering U.S.A.,Ltd.• 1028 4th Street SW, Bldg B • Auburn, WA 98001 • Phone: [phone] • Fax: [phone]
www.tanakapowerequipment.com [email protected]

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 1
TPE-270PF/PN
ENGINE / CYLINDER, PISTON, CRANKSHAFT • FIGURE 1
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
1 157-01680-90 CAP,SPARK PLUG ASS'Y 1
2 018-11610-21 PLUG,SPARK 1
3 255-01680-20 COVER,SPARK PLUG,RUBBER 1
6 001-01680-90 SET,CYLINDER 1
7 994-61050-184 BOLT,HEX,5X18,S 4
9 017-01680-200 GASKET,CYLINDER 1
11 041-01601-200 RING,PISTON 2
12 030-01680-90 SET,PISTON 1
13 039-00000-201 CIRCLIP,PISTON PIN 2
14 037-01700-200 PIN,PISTON 1
16 046-01680-80 CRANKSHAFT 1
17 999-62091-325 BEARING,NEEDLE,F-910 1
18 068-10100-200 KEY,WOODRUFF,3X13X4.5 1
40 178-01680-80 CORD,STOP 1
41 274-01680-80 CORD,EARTH 1
46 994-16040-186 SCREW,WS,4X18 2
47 182-0186A-201 WASHER,SPECIAL 2
50 167-21743-90 COIL,IGNITION ASS'Y 1
55 250-01680-20 TUBE,INSULATOR 1

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 2
TPE-270PF/PN
CRANKCASE, FLYWHEEL • FIGURE 2
P/N046-01680-80
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
19 330-00200-210 SHIM,12.2X19X.10 1 *Shims are "as needed" to obtain
19 330-00200-220 SHIM,12.2X19X.15 1 correct side clearance
19 330-00200-230 SHIM,12.2X19X.20 1
19 330-00200-240 SHIM,12.2X19X.30 1
21 991-01080-011 NUT,8 1
22 798-01630-200 PULLEY,STARTER 1
26 359-10112-203 WASHER,CLUTCH B 1
31 072-01680-90 CRANKCASE,ASSY 1 *Crankcase assy includes, bearings,
32 999-66122-206 SEAL,OIL,#TC12227 2 seals and gaskets
33 999-61600-100 BEARING,BALL,#6001 2
34 090-01680-20 GASKET,CRANKCASE 1
36 994-14050-251 SCREW,5X25 2
37 990-11050-381 SCREW,5X38 2
38 992-10050-012 WASHER,S,5 2
51 155-21743-80 ROTOR,MAGNETO 1 * Magneto includes starter pawls
52 992-00080-011 WASHER,8 1
54 991-01080-011 NUT,8 1

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 3
TPE-270PF/PN
FUEL TANK, FUEL SYSTEM, AIR CLEANER • FIGURE 3
P/N455-01680-91

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 4
TPE-270PF/PN
FUEL TANK, FUEL SYSTEM, AIR CLEANER • FIGURE 3
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
41 403-0097A-21 GASKET,INLETMANIFOLD 1
42 404-0097A-90 SET,CARB INSULATOR 1
45 994-16050-241 SCREW 5x24WS 2
46 402-0602K-21 GASKET,CARBURETOR 1
50 455-01680-91 SET,CARBURETOR 1
53 436-0162V-20 BASE,CLEANER 1
54 528-01680-20 VALVE,CHOKE 1
55 999-67008-012 O-RING,S-8 1
56 470-0602N-200 COLLAR,CLEANER 1
57 423-0637C-800 BODY,CLEANER 1
58 992-00050-011 WASHER,SMALL,5 2
59 992-10050-012 WASHER,S,5 2
60 990-11050-602 SCREW,5X60 2
61 446-0637C-200 ELEMENT,CLEANER 1
62 452-01680-90 SET,CLEANER COVER 1
63 380-0637C-200 BOLT,CLEANER COVER 1
68 659-04300-20 COLLAR C 3
70 442-25143-800 PUMP,PRIMING 1
71 595-01680-90 CAP,TANK ASS'Y 1
75 649-01680-20 COLLAR,TANK FIXING 1
76 994-63050-204 BOLT, HEX5X20 2
77 940-04300-20 STAND,ENGINE 1
78 700-02504-080 PIPE,FUEL,2.5X4X80 2
79 534-32710-200 GROMMET,FUEL PIPE 1
80 992-01050-061 WASHER,5 1
81 994-61050-304 BOLT,HEX,5X30S 1
86 223-0162V-900 PIPE,FUEL,ASS'Y 1
87 680-00731-201 CLIP 6.3 1
89 675-04042-80 FILTER,FUEL 1
91 591-01685-20 TANK 1
121 564-00070-90 VENT,AIR ASSY 1
122 565-05032-20 PIPE, AIR VENT 1
123 646-3252L-90 AIR VENT VALVE ASSY 1
124 680-00731-201 CLIP 6.3 1
125 561-00070-20 COVER,AIR VENT 1

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 5
TPE-270PF/PN
MUFFLER, CLUTCH, COVER • FIGURE 4
TPE-270PF
TPE-270PN

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 6
TPE-270PF/PN
MUFFLER, CLUTCH, COVER • FIGURE 4
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
4-1 7380168120 PROTECTOR,MUFFLER 1
4-3 7370168020 GASKET,MUFFLER 1 TPE-270PF
4-3 7370165A201 GASKET,MUFFLER 1 TPE-270PN
4-4 99415040182 SCREW,PS,4X18 2
4-5 99053060653 SCREW,HEX,6X65 2
4-6 99201060011 WASHER,6 2
4-7 7040168090 SET,MUFFLER 1 TPE-270PF
4-7 7040168790 SET,MUFFLER 1 TPE-270PN
4-10 7210440020 PIPE,TAIL 1
4-11 99434040081 SCREW,4X8/S 1
4-13 7320440020 ARRESTER,SPARK 1
4-15 7360168022 COVER 1 TPE-270PF
4-16 1330168020 SHIELD,HEAT 1 TPE-270PF
4-16 1330168720 SHIELD,HEAT 1 TPE-270PN
4-17 7350168080 COVER,MUFFLER A 1
4-20 99413050081 SCREW,5X8 P 2 TPE-270PF
4-20 99415050101 SCREW,5X10/PS 2 TPE-270PF
4-24 99415040142 SCREW,4X14/PS 2
4-30 2570168120 COVER,SPARK PLUG 1
4-31 35902103200 WASHER,CLUTCH,B 2
4-32 29001620800 SHOE,CLUTCH 2
4-33 3420630B200 SPRING,CLUTCH 1
4-34 3480602R200 WASHER,CLUTCH A 2
4-35 3570075T200 BOLT,STEP 2
4-36 99416050162 SCREW,5X16/WS 4
4-38 99205080030 WASHER,8 2
4-39 99072045164 SCREW,TAPPING,4.5X16 1

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 7
TPE-270PF/PN
RECOIL STARTER • FIGURE 5
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
5-0 7620094090 STARTER,RECOIL ASS'Y 1
5-2 78500940200 HANDLE,STARTER 2
5-3 77200940801 BODY,STARTER 1
5-4 78000940200 SPRING,RECOIL 1
5-5 78300940200 ROPE,STARTER 1
5-6 77400940200 REEL,STARTER ROPE 1 Prior to S/N V218191
5-6 7740163021 REEL,STARTER ROPE 1 S/N V218191 and after
5-7 7880163021 PAWL,STARTER 1
5-8 80105015200 WASHER,STARTER PULLEY 1
5-10 8370501521 PLATE,FRICTION 1
5-11 82205015200 SHIM,STARTER PULLEY 1 Prior to S/N V218191
5-11 8220423020 SHIM,STARTER PULLEY 1 S/N V218191 and after
5-12 8390423020 BOLT,SET 1

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 8
TPE-270PF/PN
CARBURETOR • FIGURE 6
0

www.tanakapowerequipment.com
PARTSINFORMATION
[email protected]
Page 9
TPE-270PF/PN
CARBURETOR • FIGURE 6
ITEM PART NUMBER DESCRIPTION QTY COMMENTS
0 4550168091 CARBURETOR SET 1 Includes gasket
1 51425100200 SCREW,THROTTLE SET 2
4 54425164200 STAY,ADJUST,CABLE 1
5 53925120200 SWIVEL 1 ~ Contained in Carburetor Repair Kit
7 48925100200 RING,STOP 1 P/N 650-25124-900
10 55025100200 O-RING 1 (Not available individually)
11 5992001W38 JET,MAIN LONG #38 1
12 ~ ~ ~ *GASKET,PUMP 1
13 ~ ~ ~ *DIAPHRAGM,PUMP 1
16 ~ ~ ~ *SCREEN,INLET 1
17 5752514780 BODY,PUMP ASS'Y 1
18 ~ ~ ~ *GASKET,DIAPHRAGM 1
19 ~ ~ ~ *DIAPHRAGM,METERING 1
20 47625004200 COVER,DIAPHRAGM 1
21 54825101200 SCREW,SET 4
22 61425137200 ADJUSTER,CABLE 1
23 99101060013 NUT,6 1
24 4310634C200 GASKET,CLEANER 1
41 5492516520 WASHER,THRUST 1