Tattile ANPR MOBILE Series User manual

Tattile srl - Via Gaetano Donizetti, 1 - 25030 Mairano (BS) Italy - Tel. [phone] - Fax. [phone] - [email protected]


ANPRMOBILESeries
AutomaticNumberPlateRecognition

Ori
g
inalInstructionsforInstallation
Documentnumber:RMM_00029Rev.09


 TableofContents
RMM_00029_09 2 / 42 ANPR Mobile
Contact:

TattileS.r.l.
ViaDonizetti1
25030Mairano–Brescia,Italy
Ph.+3903097000
Fax+3903097001
http://www.tattile.com
[email protected]

http://www.tattile.com

Thispublicationiscopyrightprotected
Copyright©2020TattileS.r.l.Mairano(Brescia),Italy
Thisdocumentoranypartofitmustnotbereproducedinanyform,norinformationtherein
containeddisclosedtothirdparties,normethods,proceduresortestsdescribed,performedwithout
theauthorizationofTattileS.r.l..
Alltrademarksandlogosreferencedhereinbelongtotheirlegitimateowners;third‐partybrands,
productnames,tradenames,corporatenamesandcompanynamesmaybetrademarksoftheir
respectiveownersorregisteredtrademarksofothercompaniesandhavebeenusedforpurposesof
explanationandtotheowner'sbenefit,withoutimplyingaviolationofcopyrightlaw.

 TableofContents
RMM_00029_09 3 / 42 ANPR Mobile
TableofContents
1AboutthisDocument...........................................................................................................................6
1.1ScopeofthisDocument................................................................................................................6
1.2WhothisDocumentisfor..............................................................................................................6
1.3TypographicConventions..............................................................................................................6
2Precautions/SafetyInstructions.........................................................................................................8
2.1SafetyInstructions.........................................................................................................................8
2.2IntendedUseoftheProduct.......................................................................................................10
2.3KnownorForeseeableMisuseoftheProduct............................................................................10
3GeneralCharacteristics......................................................................................................................11
3.1Features.......................................................................................................................................11
3.2Dimensions..................................................................................................................................12
3.2.1ProductDimensions.....................................................................................................12
3.3PhysicalInterface........................................................................................................................13
3.3.1ProductOverview........................................................................................................13
3.3.2PowerSupply,EthernetandstrobeConnector...........................................................14
3.4TechnicalSheet/Specifications..................................................................................................16
3.5IdentificationoftheProduct.......................................................................................................18
3.6Conformity–Compliance............................................................................................................19
3.7Disposal.......................................................................................................................................20
4PreparationandInstallation..............................................................................................................21
4.1PackageContent..........................................................................................................................21
4.2BuildingtheConnectorCables....................................................................................................21
4.2.1CablingthePowerSupply............................................................................................22
4.3MountingtheProduct.................................................................................................................23
4.3.1Devicecheck................................................................................................................23
5Use....................................................................................................................................................24
5.1SearchingtheDevice...................................................................................................................24
5.2DownloadingtheFreewareSoftwareToolTattilePathfinder....................................................24
5.3ModifyingtheIPAddressoftheDevice......................................................................................25
5.4ConnectingtotheWebInterface................................................................................................25
5.5WhattoDoWhenStartingtheDevicefortheFirstTime...........................................................26
5.6UpdatingtheFirmware...............................................................................................................27
5.7TypesofuseforCameramodels.................................................................................................28
5.7.1F01710Shortdistancereading‐parallelparking........................................................28
5.7.2F01845Mediumdistancereading‐curbsideparking.................................................29

 TableofContents
RMM_00029_09 4 / 42 ANPR Mobile
5.7.3F01696Longdistancereading‐patrolling...................................................................30
6TroubleshootingandSupport............................................................................................................31
6.1Troubleshooting..........................................................................................................................31
6.2Support........................................................................................................................................31
7Maintenance.....................................................................................................................................32
7.1CableCheck.................................................................................................................................32
7.2CleaningtheProtectionGlass.....................................................................................................32
7.3FasteningSystemCheck..............................................................................................................32
7.4WaterandHumidityCheck.........................................................................................................32
8Accessories........................................................................................................................................34
8.1MatingPartsKit...........................................................................................................................34
8.2MagneticBase.............................................................................................................................34
8.2.1Importantsafetywarnings...........................................................................................34
8.2.2Priortopurchasingthemagneticplate,followingpointsneedtobecheckedand
verified.........................................................................................................................36
8.2.3Assembly......................................................................................................................37
8.2.4Disassembly..................................................................................................................39
8.2.5AdditionalDirections...................................................................................................39
8.2.6DrivingTips...................................................................................................................40
8.2.7MaintenanceDirections...............................................................................................41
9RevisionHistory.................................................................................................................................42
 


 TableofFigures
RMM_00029_09 5 / 42 ANPR Mobile
TableofFigures
Figure1:HazardDistanceevaluation....................................................................................................10
Figure2:TattileANPRMobiledimensions............................................................................................12
Figure3:Productoverview...................................................................................................................13
Figure4:Powersupplypinoutconnector.............................................................................................14
Figure5:Matingpinoutconnector.......................................................................................................14
Figure6:Strobeschematicsection.......................................................................................................15
Figure7:Productlabel..........................................................................................................................18
Figure8:AssemblyConnectorinstructions...........................................................................................22
Figure9:ANPRMobileAdvancedmainwebpage................................................................................26
Figure10:Framegrabbersetting............................................................................................................27
Figure11:Shortdistanceparallelparking...............................................................................................28
Figure12:Mediumrangeapplication.....................................................................................................29
Figure13:Longrangeapplication...........................................................................................................30
Figure14:MagneticBasewithsafetybelt(includedinthepackage)....................................................34
Figure15:Metallicroof...........................................................................................................................36
Figure16:Slidingglasssunroofs.............................................................................................................36
Figure17:Correct/Uncorrectmountingontheroof..............................................................................36
Figure18:Verifymountingroof..............................................................................................................37
Figure19:CleanroofandMagneticPlate...............................................................................................37
Figure20:Papersheettest.....................................................................................................................38
Figure21:SafetyCableuse.....................................................................................................................38
Figure22:Prohibitionofopeningthesunroof........................................................................................38
Figure23:DismantlingoftheMagneticBase.........................................................................................39
Figure24:Warningmagneticdamage....................................................................................................39
Figure25:RemovebeforeCarwash.......................................................................................................40
Figure26:Checkthescrewtight.............................................................................................................41




1AboutthisDocument
RMM_00029_09 6 / 42 ANPR Mobile
1 About this Document
1.1 Scope of this Document
ThisdocumentshowstheuserhowtocorrectlyinstallandsetuptheAutomaticNumberPlateReader
MOBILESeries.

1.2 Who this Document is for
Table1summarizesthegroupsthisdocumentisaimedat,withabriefdescriptionofthetypeof
informationthemanualmustsupplytohelpthemunderstandtheproduct.

ReadershipgroupDescriptionAim
InstallerTechnicianresponsibleforproduct
installationinthetraffic
application.
Supplyallinformationon:
 Mechanicalinstallation
 Electricalinstallation
 Productmaintenance
SystemintegratorITadministratorresponsiblefor
productintegration,configuration
andsoftwaredevelopment.
Supplyallinformationon:
 Productcharacteristics
 Productusage
Table1:Whothisdocumentisfor

1.3 Typographic Conventions
Table2summarizestypographicconventionsand/orstylesusedinthisdocumentsoitcanbereadand
understoodmoreeasily.

ConventionMeaning
 PrerequisitePrecedingconditionrequiredbeforeanaction.
 ActionSingleaction.
1. StepOneofasequenceofactions.
– SubstepAdditionalstepsofanactionorastep.
IntermediateoutcomeResultofastep.
 OutcomeResultofanactionorasequenceofactions.
 ListListofelements.
– SublistAdditionalelementsofalist.
SaveButtons,windows,tabs;softwaremodules.
[CTRL]Keyboardstrikes
trueInsertedorselectedvalue.
“FinishedOK”Programmessages.
Table2:Typographicconventions

1AboutthisDocument
RMM_00029_09 7 / 42 ANPR Mobile

DANGER!Typeandsourceofdanger!(indicatesanhazardoussituation,thatifnotavoided,will
resultindeathorseriousinjury)!
Possibleconsequences(optional).
 Preventivemeasure.


N O T I C E ! Typeandsourceofdanger!(usedtoaddresspracticesnotrelatedtophysicalinjury)!
Possibleconsequences(optional).
 Preventivemeasure.



Usefulsuggestionoradditionalinformation.
 Preventivemeasure.



2Precautions/SafetyInstructions
RMM_00029_09 8 / 42 ANPR Mobile
2 Precautions / Safety Instructions
2.1 Safety Instructions
 Readandunderstandthismanualpriortousetheproduct.Misuseoftheproductmayresultin
damages.Tattileisnotresponsibleforanydamageduetonegligenceinreadingthismanual.
 Mountthedeviceonamechanicallystablestructure.
 Thecamerashallbereachableonlybymaintenanceoperator.
 Alwaysobservethepolaritiesofthepowersuppliesandthepowerrequirementsspecifiedinthis
manual.
 Turnoffallelectricalpowerbeforemakingorbreakinganyelectricalconnections.Makingor
breakingconnectionswhenpowerisoncanresultsindamagetothedevice.
 Donotplacethepowersupplyandsignalcablesparalleltocablescarryinghigh‐currentswitching
voltages.
 DANGER! 
Highlevelsofartificialopticalradiationcancausedamagetobotheyesandskin.Exposurelimit
valueshavebeendrawnupforsuchhazards.EverylightsystemisplacedwithinaRiskGroup,which
definesthelevelofriskwhenthelightisusednormally,higherlevel,higherriskgroupnumber,from
1to3.WhenthelightemitslessthantheexposurelimitvaluesitiscategorizedasExemptGroup.
Evaluationofriskgroupismadeat0.2mdistance,thatistheminimumhazarddistanceconsidered.
Thehazarddistance(HD)isthepointfurthestfromtheilluminatoratwhichtheExemptGroup
exposurelimitisexceeded.


2Precautions/SafetyInstructions
RMM_00029_09 9 / 42 ANPR Mobile
Illuminatorriskgroupandhazarddistanceevaluation
F01710,F01845
IRilluminatorlens36°(wavelength860nm,±15nmspectralbandwidth@50%ofmaxintensity)
Hazard
Ultraviolet
hazard


200‐400nm
(Es/Euva)
Retinalblue
lighthazard


300‐400nm
(Lb)
Retinalblue
lightorthermal
hazard

400‐780nm
(Lr)
Cornea/lens
infraredhazard


780‐3000nm
(Eir)
Retinalthermal
hazard,weak
visualstimulus

780‐1400nm
(Lir)
Risk
Group ExemptGroupExemptGroupExemptGroupExemptGroupExemptGroup
HD –––––
HD=Hazarddistance
TheproductisinExemptGroup,nolabellingrequired.


F01696
IRilluminatorlens17°(wavelength860nm,±15nmspectralbandwidth@50%ofmaxintensity)
Hazard

Ultraviolet
hazard

200‐400nm
(Es/Euva)
Retinalbluelight
hazard

300‐400nm
(Lb)
Retinalbluelight
orthermal
hazard
400‐780nm
(Lr)
Cornea/lens
infraredhazard

780‐3000nm
(Eir)
Retinalthermal
hazard,weak
visualstimulus
780‐1400nm
(Lir)
Risk
GroupExemptGroupExemptGroupExemptGroupRiskGroup1ExemptGroup
HD–––0.27m–
HD=Hazarddistance
TheproductinexcessofExemptGrouplimitsoitislabelled:

Table3:IRilluminatorRiskGroupandHazardDistance

ForilluminatorexceedingExemptGrouplimitcamerashallbeinstalledasdetailedinthefigure
below,atdistanceL>HD,thereisnorisktothepublic.
Operatorormaintenancestaffworkinginfrontofthecamera,facingtheilluminator,atdistanceless
HDmustuseappropriateshieldingoreyeprotection,aswritteninthelabelling.



2Precautions/SafetyInstructions
RMM_00029_09 10 / 42 ANPR Mobile

Figure1:HazardDistanceevaluation


2.2 Intended Use of the Product
 Theproductisdesignedforautomaticnumberplaterecognitionforthefollowingapplications:
‐ Policeenforcement
‐ Crimeprevention

2.3 Known or Foreseeable Misuse of the Product
 Allotherusesnotincludedintheintendeduseoftheproductareconsideredasanimproperuseof
theproduct.


3GeneralCharacteristics
RMM_00029_09 11 / 42 ANPR Mobile
3 General Characteristics
3.1 Features
TattileANPRMobileisanembeddedcameraproducedbyTattileforautomaticlicenseplatereading.
ANPRMobileissuitableforPoliceenforcement,crimeprevention,patrolenforcementandeverywhere
aportablesolutionisrequired.
ItisequippedwithMegapixelsensor,abletoreadlicenseplateinalllightconditions.
Itcombinesmultiplecomponentsinacompactsolution,suchas:sensor,infraredilluminatorand
processorwithintegratedOCR(OpticalCharacterRecognition)toreadautomaticallylicensePlate.
Thesystemdoesnotrequiretheinstallationofprocessingunitsonboardofthecars,norofphysical
connectionbetweenthecamerasandtheonboardcomputer/tablet.Infact,thelicensePlateanalysisis
donedirectlyfromthecamerasinstalledontheroof,bonnetortrunkofthecarandthedata
transmissionoccursinWi‐Fimode.Thiswayitispossibletospeeduptheinstallation,makingANPR
Mobileeasilytransportablefromacartoanother,withaconsequentcostsreduction.
Tattilenewsolutionisequippedwithasophisticatedsoftwarethatenablestocaptureimagesinboth
grayscaleandcolor,withthebestautomaticselectionofacquisitionparameterswithmultipleauto
exposure.
TheANPRMobiledevicesareavailablein3version,dependingonexpectedreadingdistance:

‐Shortdistance:tosatisfythelicenseplatereadinginsmallparkinglots,parallelparkingand
everywheretheplatetobereadisatverycloseddistancefromthecamera(distance<2,5m)
‐Mediumdistance:tosatisfythelicenseplatereadingforcurbsideparking,diagonalparking,and
everywhereit'sneededtoreadlicenseplatesofvehiclesparkedatshort‐mediumdistancefromthe
camera(3m<distance<7m)
‐Longdistance:forreadingplatesatvariousdistanceswhilepatrollingontheroad(distanceupto25
meters)



3GeneralCharacteristics
RMM_00029_09 12 / 42 ANPR Mobile
3.2 Dimensions
3.2.1 Product Dimensions
Figure2showstheoverallviewoftheTattiledevice,dimensionsinmillimeters.


Figure2:TattileANPRMobiledimensions


3GeneralCharacteristics
RMM_00029_09 13 / 42 ANPR Mobile
3.3 Physical Interface
3.3.1 Product Overview


Figure3:Productoverview
RefDescription
1OCRcamera(ANPRimage)
2Illuminator
3Contextcamera(Overviewimage)
4Backcover
5Camerahousing
6Closingflange
7PowerSupplyandEthernetconnector
8Productlabel
9Safetyhazardlabel
10Mountingbracket

Table4:Productoverview


3GeneralCharacteristics
RMM_00029_09 14 / 42 ANPR Mobile
3.3.2 Power Supply, Ethernet and strobe Connector


Thetypeofthepowersupplyconnectoris:M168PoleMale.
 Matingpartincludedinthepackage.



Figure4:Powersupplypinoutconnector

PINSignalnameDescription
1+12Vdc Powersupply
2TxPEthernet
3RxPEthernet
4StrobeOutOutputStrobe
5TxNEthernet
6GNDGround(powersupply)
7RxNEthernet
8StrobeGNDGNDOutputStrobe

Table5:Powersupply,Ethernetandstrobeconnector

 MatingpartM168PoleFemaleincludedinthepackage.
  
Figure5:Matingpinoutconnector



3GeneralCharacteristics
RMM_00029_09 15 / 42 ANPR Mobile
Strobe Output

FeatureDescription
TypeOptoisolatedopencollector
Channels1
Maxvoltage24Vdc+10%
Minvoltage3.3Vdc‐10%
Maxcurrent50mA
Table6:StrobeInterface

Figure6:Strobeschematicsection


3GeneralCharacteristics
RMM_00029_09 16 / 42 ANPR Mobile
3.4 Technical Sheet / Specifications
General
ANPRMOBILERangeShort
Mono
Medium
Mono
Long
Mono 
PartNumberF01710F01845F01696  
StoragemicroSDcardupto32GB
StrobeOutput1
LANFastEthernet10/100
Wi‐Fi802.11b/g/n
OperatingSystemLinux
OtherSensor
IntegratedTilt‐rollsensor
IntegratedTemperatureandHumiditysensor
Powersupplyvoltageandcurrentmonitoringsensor
Realtimeclock
GPS Yes
OCRImageSensor(ANPR)
Type 2/3”NIRCMOSMono
Resolution1280x10241920x1080
Capturerate(fps)Upto100Upto60
LensC‐Mount
ContexImageSensor(Overview) 
Type 2/3”CMOSColor
Resolution 1280x10241920x1080
Capturerate(fps)Upto100Upto60
LensC‐Mount
Illuminator
NumberofLED’s6high
power10highpower
TypeIR@850nm
Illuminatorbeamangle(@half
radiantintensity)36°17°






3GeneralCharacteristics
RMM_00029_09 17 / 42 ANPR Mobile

ElectricalCharacteristics     
PowersupplyVoltageNominal12Vdc(Min.8,4÷Max.16,8)
*Minimumoperatingvoltageforintegratedilluminatoris10,5Vdc
Powerconsumption15W(@12Vdc)
Startingcurrent 5A(max)
Mechanical
Dimension 178x141x76mm(LxWxH)
Cameraweight 1,650kg
Housing ColorAnodizedAluminumandPlastic
VibrationISO16750‐3,testIV,Equipmentmountedonvehiclebody(atsteadytemp.T=23°C)
Environment
OperatingandStorage
Temperature ‐30°C÷+60°C
OperatingandStorage
HumidityUpto95%
ProtectionClass IP66‐IP67
SWfeaturesandperformance
Detection99%
Reading >95%
OCR OnboardANPRengine
AES256Yes
SHA2Yes
Compression JPG
Configuration
WebServer Installationandconfigurationbywebserveronboard
TCP/IPServerConfigurationandmonitoringthroughTCP/IPprotocol
DateandHour SynchronizationviaSNTPprotocolorGPS
SoftwareUpdate UpgradingviawebInterfaceandSDK
DataTransmission
FTP FTPClienttoFTPServermodeforremotedatatransmission,twodifferentFTP
destinationaddress
TCP/IP TattileTCP/IPopenprotocol;twodifferentFTPdestinationaddress
VideoStreaming 
H.264/MPEG4 ColorvideostreamingH.264orMPEG4
OperatingMode
FreeRun Continuousimagecaptureandprocessing
Table11:TechnicalSheet/Specifications


3GeneralCharacteristics
RMM_00029_09 18 / 42 ANPR Mobile

3.5 Identification of the Product

Figure7:Productlabel

PartDescription
1Companylogo
2Productpartnumber
3Productname
4Productserialnumber
5Serialnumberbarcode(code128)
6EthMacAddressnumber
7EthMacAddressnumberbarcode(code128)
8Revision
9CEmark
10WlanMacAddressnumber
11WlanMacAddressnumberbarcode(code128)
12RatedVoltageandCurrent
Table7:Productlabel

3GeneralCharacteristics
RMM_00029_09 19 / 42 ANPR Mobile
3.6 Conformity – Compliance
Tattiledeclaresundersoleresponsibilitythattheproductsdescribedinthismanualareinconformity
withtheessentialrequirementsofthefollowingEUdirectivesandstandards:
ComplianceDescription

 2014/53/EU, REDDirective(1)
 TheobjectivesandprotectionrequirementsoftheLowVoltageDirective
2014/35/EUandEMCDirective2014/30/EUareappliedunderDirective
2014/53/EU,Article3.1.


 2011/65/EU (Rohs Directive)

andthatthestandardsand/ortechnicalspecificationsreferencebelowhave
beenapplied:
Art 3.1a Safety
specifications
 EN 60950-1:2006 +A11:2009 +A1:2010 +A12:2011 +AC:2011 Safety
ITequipment
Art 3.1b EMC
specifications
 EN 301 489-1 v1.9.2 ERM,EMCCommonrequirement
 EN 301 489-3 v1.6.1 ERM,EMC,SpecificforSRD,1,5GHzGPSreceiver
 EN 301 489-17 v2.2.1 ERM,EMC specificforWideband2.4GhzSystem
‐ EN55022,emissionclassB
‐ EN61000‐4‐3,RFradiated3V/m
‐ EN61000‐4‐6,RFconducted3V
‐ ISO7637‐2(pulse1,2a,2b,3a,3b,4)
 EN 50498:2010 (Aftermarketelectronicequipmentinvehicles)
‐ EmissionEASslimitNarrowbandandBroadBand(UN‐ECEReg.10)
‐ ImmunityISO7637‐2(pulse1,2a,2b,3a,3b,4)
Art 3.2 Spectrum
(Radio spec.)
 EN 300 328 v1.8.1 ERM,SpectrumforWideband2.4GHzSystem
 EN 303 413 v1.4.1 ERM,spectrumforSRD,1.5GHzGPSreceiver
Art. 4.1
Prevention  EN 50581:2012 Technicaldocumentationfortheassessmentof
electricalandelectronicproductswithrespecttotherestrictionof
hazardoussubstances
Otherstandards EN 62471:2008 Photobiologicalsafetyoflampsandlampssystems
‐ F01589,F01590,F01622,F01710:ExemptGroup
‐ F01696,F01845:Riskgroup1(Infraredeye)HD=270mm
 EN 62311:2008 LimittoEMFieldforhumanexposure
 EN 60068-2-1 Environmentaltesting.Coldtest(‐30°C,16h)
 EN 60068-2-2 Environmentaltesting.DryHeattest(+60°C,16h)
 EN 60529 Degreesofprotectionprovidedbyenclosures(IP66)

3GeneralCharacteristics
RMM_00029_09 20 / 42 ANPR Mobile
ComplianceDescription
FCC

TattileherewithdeclaresthatthisproductisincompliancewiththefollowingUS
FederalRegulation:
FCC 47CFR part 15 USFederalRegulations,emissionlimitClassB
 Changesormodificationsnotexpresslyapprovedbytheparty
responsibleforcompliancecouldvoidtheuser'sauthoritytooperatethe
equipment.
 ThisdevicecontainsFCCID:2AULGT17950
 ThisdevicecomplieswithPart15oftheFCCRules.Operationissubjectto
thefollowingtwoconditions:(1)thisdevicemaynotcauseharmful
interference,and(2)thisdevicemustacceptanyinterferencereceived,
includinginterferencethatmaycauseundesiredoperation.
 Thisequipmenthasbeentestedandfoundtocomplywiththelimitsfora
ClassBdigitaldevice,pursuanttopart15oftheFCCRules.Theselimits
aredesignedtoprovidereasonableprotectionagainstharmful
interferenceinaresidentialinstallation.Thisequipmentgenerates,uses
andcanradiateradiofrequencyenergyand,ifnotinstalledandusedin
accordancewiththeinstructions,maycauseharmfulinterferenceto
radiocommunications.However,thereisnoguaranteethatinterference
willnotoccurinaparticularinstallation.Ifthisequipmentdoescause
harmfulinterferencetoradioortelevisionreception,whichcanbe
determinedbyturningtheequipmentoffandon,theuserisencouraged
totrytocorrecttheinterferencebyoneormoreofthefollowing
measures:
‐ Reorientorrelocatethereceivingantenna.
‐ Increasetheseparationbetweentheequipmentandreceiver.
‐ Connecttheequipmentintoanoutletonacircuitdifferentfrom
thattowhichthereceiverisconnected.
‐ Consultthedealeroranexperiencedradio/TVtechnicianfor
help.
 ThisproductcomplieswithFCCradiationexposurelimitssetforthforan
uncontrolledenvironment.Thedeviceshouldbeinstalledandoperated
withminimumdistanceof20cmbetweentheradiatorandyourbody.

Table8:Conformitystandards

3.7 Disposal


Packagingmaterialsarerecyclable.Donotdisposepackagingintounsortedwastebut
recycleit.



AttheendoftheirlifecyclealltheelectronicproductsmustbesenttoaWaste
ElectricalandElectronicEquipmentrecyclingcenter!
