THOR TRG Series User manual

COOK
LIKE
A
GOD
TRG MODELS TRG3001 | TRG3601

PROFESSIONA L
GAS RA NGETOPS
USE AND CARE MANUAL
TRG MODELS
TRG3001 |TRG3601

TABLE OF CONTENTS
Warnings ...................................................................................................................................................... 2
Welcome ....................................................................................................................................................... 2
Before you start ........................................................................................................................................... 2
Safety and Warnings .................................................................................................................................... 3
Safety Symbols ............................................................................................................................................. 3
Electrical Shock Hazard ............................................................................................................................... 3
Tipping Hazard .............................................................................................................................................. 3
Explosion Hazard .......................................................................................................................................... 3
Fire Hazard ................................................................................................................................................... 4
Poisoning Hazard .......................................................................................................................................... 4
Hot Surface Hazard ...................................................................................................................................... 4
Other Safety Tips .......................................................................................................................................... 4
SELF-CLEANING OVEN SAFETY INSTRUCTIONS ........................................................................................ 5
Gas Supply Requirements ........................................................................................................................... 6
Safety Tips for Gas Operation ....................................................................................................................... 6
Dimensions and Clearances ........................................................................................................................ 6
Top Hood and cabinet specifications ............................................................................................................ 7
ANTI-TIP DEVICE INSTALLATION ................................................................................................................ 7
Anti-tip device installation - wall mount ...................................................................................................... 7
Electric Power Supply Requirements ......................................................................................................... 8
Install oven Knobs ........................................................................................................................................ 9
Install oven handle ....................................................................................................................................... 9
Install rubber pad on back panel ................................................................................................................ 10
Electrical Grounding Instructions .............................................................................................................. 10
Connect Range to Gas Supply .................................................................................................................... 10
Connect Range to Gas Supply ..................................................................................................................... 10
After installation ......................................................................................................................................... 10
First Use ..................................................................................................................................................... 11
Conditioning the oven ................................................................................................................................. 11
Cook top Safety Guideline ......................................................................................................................... 11
Surface Burner Ignition .............................................................................................................................. 11
Simmer and Boil ......................................................................................................................................... 11
Flame Size .................................................................................................................................................. 12
Power Failure ............................................................................................................................................. 12
Cook top ...................................................................................................................................................... 12
oven cooking guidelines ............................................................................................................................. 12
OVEN COOKING GUIDELINES ..................................................................................................................... 12

TABLE OF CONTENTS
The oven control panel ............................................................................................................................... 12
Setting the clock ........................................................................................................................................ 13
Setting the kitchen timer ........................................................................................................................... 13
Control Lockout .......................................................................................................................................... 13
Time Cooking ............................................................................................................................................. 13
Delay Start .................................................................................................................................................. 13
Turning the light on and off ........................................................................................................................ 14
Minimum and maximum settings .............................................................................................................. 14
Using the oven racks .................................................................................................................................. 14
Baking ........................................................................................................................................................ 15
Convection baking ...................................................................................................................................... 15
Convection roasting .................................................................................................................................... 15
Broiling ....................................................................................................................................................... 16
Using Keep Warm ....................................................................................................................................... 16
Using Sabbath ............................................................................................................................................ 16
Temp Adjust ................................................................................................................................................ 17
Temp Unit (Fahrenheit or Celsius temperature selection) ........................................................................ 17
Time of Day (12hr/24hr) ............................................................................................................................. 17
Sound On/Off .............................................................................................................................................. 17
Control lockout ........................................................................................................................................... 17
Self-cleaning .............................................................................................................................................. 18
Care and cleaning of the oven .................................................................................................................... 19
Cleaning Burner caps and brass flame spreaders .................................................................................... 20
Cleaning oven shelves ................................................................................................................................ 20
Cleaning broil/roast pan and slotted grid .................................................................................................. 20
Cleaning bake and broil burners ................................................................................................................ 20
Cleaning porcelain surfaces ...................................................................................................................... 20
Cleaning the oven glass window ................................................................................................................ 20
Cleaning the oven door gasket ................................................................................................................... 20
Cleaning stainless steel surfaces .............................................................................................................. 20
Troubleshooting Guide .............................................................................................................................. 21
Cook top ..................................................................................................................................................... 21
Oven ............................................................................................................................................................ 21
Information Code ....................................................................................................................................... 23
Removing the oven door ............................................................................................................................. 23
Replacing the oven door ............................................................................................................................ 24
Removing and replacing the storage drawer ............................................................................................. 24
Replacing the oven light ............................................................................................................................. 25
Replacing the burner parts ........................................................................................................................ 25
Warranty .................................................................................................................................................... 25
Warranties and Duration ............................................................................................................................ 25
Thor Group will pay for ............................................................................................................................... 25
Thor Group will not pay for ........................................................................................................................ 25
Warranty and Product Registration ........................................................................................................... 26

If the information in these instructions is not followed exactly, a fire or explosion may
result causing property damage, personal injury or death.
- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of
this or any other appliance.
- WHAT TO DO IF YOU SMELL GAS
· Do not try to light any appliance.
· Do not touch any electrical switch.
· Do not use any phone in your building.
· Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's
instructions.
· If you cannot reach your gas supplier, call the fire department.
- Installation and service must be performed by a qualified installer, service agency or
the gas supplier.
What to do if you smell gas
· Do not light any appliance.
· Do not touch an electrical switch.
· Immediately call the gas supplier from a neighbor’s phone.
· Open a window and leave the area.
· Follow the gas supplier’s instructions.
· If you cannot reach the gas supplier, call the fire department.
WARNING
These are the most critical warnings summarized below
WARNINGS
2

Thank you for purchasing your indoor range. We appreciate your business and we recommend that you
read this entire User’s Manual before operating your new appliance for the first time.
This manual contains instructions on how to properly install and set up your new range, as well as
insights into the unique features that our product offers. Please keep this manual for future reference,
as it contains answers to questions that you might have as you begin to cook.
Thanks you
Never Operate the Top Surface Cooking Section of this Appliance Unattended
· Failure to follow this warning statement could result in fire, explosion, or burn hazard that could cause
property damage, personal injury, or death.
· If a fire should occur, keep away from the appliance and immediately call your fire department.
DO NOT ATTEMPT TO EXTINGUISH AN OIL/GREASE FIRE WITH WATER.
WARNING
Make sure that the anti-tip of the range has been properly installed.
√ Find the model and serial numbers on the CSA label in the bottom right-hand corner of the
backboard. Note these numbers down for future reference in the space provided in section ‘Warranty
and service’.
√ Read this guide, taking special note of the ‘Safety and warnings’ section. Remove all the packaging
from the oven(s) and cook top. Recycle items that you can. If any adhesive residue is left on surfaces,
remove this using dish washing liquid on a soft cloth. Do not use any harsh or abrasive cleaners.
√ Make sure you follow the instructions under ‘First use’ before using your range for cooking.
To reduce the risk of fire, electrical shock, injury to persons, or damage when using the appliance,
follow the important safety instructions listed below:
BEFORE YOU START
WELCOME
2

WARNING
CAUTION
CAUTION
IMPORTANT
SYMBOL DEFINITION
SAFETY AND WARNINGS
SAFETY SYMBOLS
ELECTRICAL SHOCK HAZARD
Before removing a faulty oven light bulb, make sure you turn OFF the
power to the range at the main fuse or circuit breaker panel. If you don’t
know how to do this, contact an electrician.
Do not remove the kick panel or the back panel. Due to electrical wires
behind it, both panels should only be removed by a qualified technician.
This appliance is equipped with a three-prong grounding plug for your
protection against shock hazard and should be plugged directly into a
properly grounded power outlet. Do not under any circumstances cut or
remove the grounding prong from this plug.
Failure to follow this advice may result in death or electrical shock.
2

TIPPING HAZARD
All ranges can tip and cause injuries to adults and children. To
prevent tipping, install the anti-tip device supplied with your range.
Follow all installation instructions.
Even after the safety device is installed, do not step, lean or sit on
the oven door or place any heavy objects on it. Doing so may
result in personal injury.
Re-engage the anti-tip device if the range is moved. Do not
operate the range without the anti-tip device in place and engaged.
Make sure anti-tip device is installed as follows:
1) Slide the range forward.
2) Install the anti-tip device as described in the instruction sheet
3) Safely tilt the front section of the range and slide the range slowly back against the wall.
4) The rear pins should slide under the bracket. Do not use the appliance until it has been secured.
Failure to follow this advice may result in serious injury.
EXPLOSION HAZARD
If you smell gas, do not use the appliance. Open a window or door
to let the gas escape, then follow the instructions on the inside
front cover of this manual.
Do not use water on grease fires. A violent steam explosion may
result.
Turn all burners off, then smother fire or flame with a dry chemical
or foam-type extinguisher. Do not try to smother with flammable
blankets.
Do not heat unopened food containers such as cans. Build-up of
pressure may cause container to burst and result in injury.
Failure to follow this advice may result in injury or death.
SAFETY AND WARNINGS
3

FIRE HAZARD
Never use your appliance as a space heater. Persons could be
injured or a fire could start.
Keep the area around the appliance free from combustible
materials (e.g. wall coverings, curtains, drapes), gasoline and
other flammable vapors and liquids.
Clean the stove and burners regularly.
Do not let cooking grease or other flammable materials
accumulate on the surfaces or near the appliance.
Do not hang any articles (e.g. dish towels) off the oven handle.
Some fabrics may ignite or melt from the heat.
Never leave the cook top burners unattended when in use. Boil over causes smoking and greasy spill-
overs that may ignite.
Never spray an aerosol cleaner on or around the appliance while burners are lit, Be sure all the controls
are turned off and the appliance is cool. The aerosol gas and chemicals in such cleaners could, in the
presence of heat, ignite or cause metal parts to corrode.
Do not store flammables near cook top.
Flammable materials should not be stored in an oven or near the cook top. An accident could cause a
serious fire.
POISONING HAZARD
Never cover any slots, holes or passages in the oven bottom or
cover an entire rack or the oven floor with materials such as
aluminum foil. Doing so blocks airflow through the oven and may
cause carbon monoxide poisoning. Aluminum foil linings may also
trap heat, causing a fire hazard.
Clean the appliance with caution. If a wet sponge or cloth is used
to wipe spills on a hot cooking area, be careful to avoid steam
burn. Some cleaners can produce noxious fumes if applied to a
hot surface. Follow the directions of the cleaner manufacturer.
Never use this appliance as a space heater to heat or warm the
room. Doing so may result in carbon monoxide poisoning and
overheating of the appliance.
Failure to follow this advice may result in poisoning or death.
SAFETY AND WARNINGS
4

OTHER SAFETY TIPS
Read instructions before use
Read all the instructions before using the appliance. Use the appliance only for its intended purpose as
described in these instructions.
Read instructions before use
Read all the instructions before using the appliance. Use the appliance only for its intended purpose as
described in these instructions.
Install the stove properly
Be sure your stove is properly installed and grounded by a qualified technician.
Do not install or operate stove if damaged.
Do not operate the appliance if it is damaged or not working properly. If you received a damaged product,
contact your dealer or installer immediately.
Know how to turn off power in emergency
Be sure to have the installer show you where and how to turn off the power supply to the range (i.e. loca-
tion of the main fuse or circuit breaker panel) and where and how to turn off the gas supply to the range
in an emergency.
Do not leave children alone near stove
Children should not be left alone or unattended in the area where the appliance is in use. They should
never be allowed to play with the appliance or to sit or stand on any part of the appliance.
Do not store toys or candy over the stove
Do not regard the oven as a storage space. Storing in the oven space may cause unexpected injuries.
For safety reasons, do not store items of interest to children in cabinets above a range or at the back of
the range – children climbing on the range to reach items could be seriously injured.
HOT SURFACE HAZARD
Accessible parts may become hot during use.
Do not touch burners, areas near burners, the grill, griddle, grease drip- pans,
heating elements or interior surfaces of oven.
These may be hot enough to cause burns even though they are
dark in color. During and after use, do not touch, or let clothing or
other flammable materials contact these parts and surfaces until
they have had sufficient time to cool. Other parts and surfaces of
the appliance may become hot enough to cause burns - among
these areas are the grates, back trim and oven vents at the back
of the cook top, front edge, surfaces adjacent to the cook top, and
the oven door.
Use only dry potholders. Moist or damp potholders on hot
surfaces may result in burns from steam. Do not let potholder
touch hot heating elements. Do not use a towel or other bulky cloth.
Let hot grease cool before attempting to handle it. Failure to follow this advice could
result in burns and scalds.
SAFETY AND WARNINGS
4

Don’t wear lose clothing that could catch fire
Loose-fitting or hanging garments should never be worn while using the appliance.
Do not repair or replace parts yourself (unless recommended)
Do not repair or replace any part of the appliance unless specifically recommended in the manual. All
other servicing should be referred to a qualified technician. Technicians must disconnect the appliance
from the power supply before any servicing.
Careful opening oven door
Use care when opening the oven door by allowing warm air or steam escape before removing or replac-
ing food. Keep oven vent ducts unobstructed.
Do not touch hot oven shelves
Protect your hands from burning by making sure the oven is cool before sliding oven shelves into oven. If
a shelf must be removed while the oven is hot, do not let oven mitts or potholder contact the base of the
oven or hot heating elements in the oven.
Protect glass oven doors
Do not use harsh/abrasive cleaners, scourers or sharp metal scrapers to clean the oven door glass since
they scratch the surface, which may result in the glass shattering. Never step on oven door or place a
heavy object (like a Turkey) on it.
Check for gas leaks
When the appliance installed, check for gas leaks according to the instruction before use.
Ventilation hood is mandatory
This appliance should not be operated without a properly sized and operational ventilation hood.
Use proper gas conversion kit
This stove only uses natural gas. For LP gas, please use conversion kit (not included with the stove).
Please have a certified technician install the unit and kit. If planning to resell unit, please indicate wheth-
er it is natural gas or has LP kit installed.
Do not reach for items over the stove when it is lit
Be careful when reaching for items stored in cabinets above the appliance.
Read all instructions before using the product to ensure proper and safe operation.
Install or locate the product only in accordance with the provided Installation Instructions.
Do not attempt to adjust, repair, service or replace any part of your appliance unless it is specifically
recommended in this guide. Do not use the range as a space heater.
Do not leave children unattended in the area where the range is in use. Never allow children to sit or
stand on any part of the range. Do not let children play with the range.
All servicing should be referred to a qualified technician.
Have the technician show you the location of the gas shut off valve and how to shut it off in an emergency.
SAFETY AND WARNINGS
4

Always disconnect power to appliance before any type of servicing.
Do not use abrasive or caustic cleaners or detergents on this appliance. They may cause permanent
damage to the surface.
When cooking, set the burner controls so that the flame heats only the bottom of the utensil and does
not overlap at the sides of the utensil.
Utensils (pots and pans) that conduct heat slowly, i.e. glass pots, should be used in conjunction with
burner flames at a low or medium setting.
Turn off all controls and wait for appliance parts to cool down before touching them. Do not touch the
burner grates or surrounding areas until cool.
Do not use water on grease fires.
Clean appliance with caution.
Always turn pot handles to the side or back of the range. Do not turn handles towards the area where
they are easily burned. Handles should not extend over the adjacent burners.
Use the range only for cooking tasks as outlined in this manual. When using the range, do not touch the
grates, burner caps, burner bases, or any other parts in proximity to the flame. These components may
be hot enough to cause burns.
Use dry pot holders. Moist or damp pot holders on hot surfaces may result in burns from
steam.
Do not use a towel or other bulky cloth.
Do not heat unopened food containers. Buildup of pressure may cause the container to explode and
result in injury.
During and after use, do not touch interior surfaces of the oven until cool.
Do not let pot holder touch hot surface areas.
SELF-CLEANING OVEN SAFETY INSTRUCTIONS
Do not touch oven surfaces during self-clean operation. Keep children away from the oven during
self-cleaning. Failure to follow these instructions may cause burns. Before operating the self-clean
cycle,wiping off all excessive spillage, remove pans,shiny metal oven racks and other utensils from the
oven. Only enameled (not shiny) oven racks may be left in the oven. Do not use self-clean to clean other
parts, such as drip pans or bowls. Before operating the self-clean cycle, wipe grease and food soils from
the oven.
Excessive amount of grease may ignite leading to smoke damage to your home. If the self-cleaning
mode malfunctions, turn the oven off and disconnect the power supply. Have it serviced by a qualified
technician. Do not clean the door gasket. The door gasket is essential for a good seal. Care should
be taken not to rub, damage or move the gasket. Do not use oven cleaners. No commercial oven cleaner
or oven liner protective coating of any kind should be used in or around any part of the oven. Never keep
pet birds in the kitchen. Birds are extremely sensitive to the fumes released during an oven self-clean
cycle. Fumes may be harmful or fatal to birds. Move birds to a well-ventilated room.
SAFETY AND WARNINGS
5

GAS SUPPLY REQUIREMENTS
Installation of this range must conform with local codes, or in the absence of local
codes, with national Fuel Gas Code ANSIZ223.1 / NFPA 54.
In Canada, installation must conform to the current natural Gas Installation /code, CAN
1-1.1-M81 and with local codes where applicable.
Safety tips for gas operation
Keep appliance area clear and free from combustible materials, gasoline, and other
flammable vapors.
Do not obstruct the flow of combustion air into the range and ventilation air away from
the range.
Ventilation: it is recommended that the unit be set under a powered, vented exhaust
hood of sufficient size and capacity.
Before installing the range, you must locate and secure the included anti-tip bracket to
the wall for your range.
CAUTION
The use of cabinets for storage above the appliance may result in a potential burn hazard. Combustible
items may ignite; metallic items may become hot and cause burns. If a cabinet storage is to be provided,
the risk can be reduced by installing a range hood that projects horizontally a minimum of 5" (12.7cm)
beyond the bottom of the cabinets.
The appliance shall not be used for space heating. This information is based on safety considerations.
NEVER use this appliance as a space heater to heat or warm the room. Doing so may result in carbon
monoxide poisoning and overheating of the oven.
All openings in the wall behind the appliance and in the floor under the appliance shall be sealed.
WARNING
WARNING
6

DIMENSIONS AND CLEARANCE
The range may be installed flush to the rear wall.
You may install a non-combustible material, such as tile, on the rear wall above the
range and up the vent hood.
It is not necessary to install non-combustible materials behind the range below the
counter top height.
The minimum distance from the side of the range above the counter top to combustible
sidewalls must be at least 10 inches.
The maximum depth of cabinets installed above cooking tops be 13 in (330mm).
36'' Gas Range Clearance
6

DIMENSIONS AND CLEARANCE
Top hood and cabinet specifications
7

Anti-tip device installation - wall mount
ANTITIP DEVICE INSTALLATION
7

ELECTRIC POWER SUPPLY REQUIREMENTS
Your range must be electrically grounded in accordance with local codes or, in the absence of local
codes, in accordance with the National Electrical Code (ANSI/NFPA 70, latest edition).
In Canada, electrical grounding must be in accordance with the current CSA C22.1
Canadian Electrical Code Part 1 and/or local codes. A copy of this standard may be
obtained from: National Fire Protection Association, 1 Battery march Park, Quincy,
Massachusetts 02269-9101.
The power supply must be the correct polarity. Reverse polarity will result in continuous
sparking of the electrodes, even after flame ignition. If there is any doubt as to whether
the power supply has the correct polarity or grounded, have it checked by a qualified
electrician.
Use 120V, 60Hz, and properly grounded branch circuit protected by a 15-amp or 20-
amp circuit breaker or time delay fuse.
8

ELECTRIC POWER SUPPLY REQUIREMENTS
8

ELECTRIC POWER SUPPLY REQUIREMENTS
This indoor gas cooking appliance is equipped with a three-prong (grounding) plug for
your protection against shock hazard and should be plugged directly into a properly
grounded threepronged receptacle.
Where a standard two-prong wall receptacle is encountered, it is the responsibility and
obligationof the customer to have it replaced with a properly grounded three-prong wall
receptacle.
Do not cut or remove the grounding prong from the power cord.
Before connecting plug to the cord, disconnect the electrical supply.
Label all wires prior to disconnection when servicing controls. Wiring errors can cause
improper and dangerous operation. Verify proper operation after servicing.
WARNING
CAUTION
1. Check the knobs.
INSTALL OVEN KNOBS
9

ELECTRIC POWER SUPPLY REQUIREMENTS
1. Your Thor range might have a KD handle that needs to be installed. Please Follow up the following
procedures for the oven door handle installation
INSTALL OVEN HANDLE
2. Check if the oven door handle is level and stable.
9