Treo Fitness T101 User manual

T101 & T102 060509 © 2009 Treo Fitness Products  Made in China
FOR MODEL :
T101
T102
TREADMILL OWER’S GUIDE

3
INTRODUCTION
Important Safety Instructions
Before You Begin
T101 Operation
T102 Operation
4
6
10
TAB LE OF C ONT ENT S
CONGRATULATIONS and THANK YOU for your purchase of this Treo Fitness treadmill!
Whether your goal is to win races or simply enjoy a fuller, healthier lifestyle, an Treo Fitness treadmill
can help you attain it – adding club-quality performance to your at-home workouts, with the ergonomics
and innovative features you need to get stronger and healthier, faster. Because we're committed to
designing fitness equipment from the inside out, we use only the highest quality components. It's a
commitment we back with one of the strongest frame-to-motor warranty packages in the industry.
You want exercise equipment that offers the most comfort, the best reliability and the highest quality in
its class.
18
26
28
CONTACT INFORMATION Back Panel
Installation Guide
Conditioning Guidelines

4 5
This product is rated more than 10 amperes and is for use on a circuit having a suitable volts and is
factory-equipped with a specific electric cord and plug to permit connection to a proper electric circuit.
Make sure that the product is connected to an outlet having the same configuration as the plug.
No adapter should be used with this product. If the product must be reconnected for use on a different
type of electric circuit, the reconnection should be made by qualified service personnel.
IMPORTANT SAFETY INSTRUCTIONS
OPERATION
To reduce the risk of damaging important components on your treadmill, it is
strongly recommended that your treadmill is plugged into a dedicated 16 amp
circuit, without the use of an additional extension cord and/or power strip.
Failure to comply may void the warranty.
IMPORTANT:
It is essential that your treadmill is used only indoors, in a climate controlled room. If your treadmill
has been exposed to colder temperatures or high moisture climates, it is strongly recommended that the
treadmill is warmed up to room temperature before first time use. Failure to do so may cause premature
electronic failure.
SAVE THESE INSTRUCTIONS
Read all instructions before using this treadmill. When using an electrical product, basic precautions
should always be followed, including the following: Read all instructions before using this treadmill. It is the
responsibility of the owner to ensure that all users of this treadmill are adequately informed of all warnings
and precautions.
WARNING
Connect this exercise product to a properly grounded outlet only.
See grounding instructions.
GROUNDING INSTRUCTIONS
This product must be grounded. If a treadmill should malfunction or breakdown, grounding provides a path
of least resistance for electrical current to reduce the risk of electrical shock. This product is equipped with
a cord having an equipment-grounding conductor and a grounding plug. The plug must be plugged into an
appropriate outlet that is properly installed and grounded in accordance with local codes and ordinances.
WARNING
Improper connection of the equipment-grounding conductor can result in a risk of
electric shock. Check with a qualified electrician or serviceman if you are in doubt
as to whether the product is properly grounded. Do not modify the plug provided
with the product. If it will not fit the outlet, have a proper outlet installed by a
qualified electrician.
WARNING
Never use the treadmill before securing the
safety tether clip to your clothing.
•
If you experience any kind of pain, including
but not limited to chest pains, nausea,
dizziness, or shortness of breath, stop
exercising immediately and consult your
physician before continuing.
•
Do not wear clothes that might catch on any
part of the treadmill.
•
Always wear athletic shoes while using this
equipment.
•
Do not jump on the treadmill.•
Unplug treadmill before moving or cleaning
it. To clean, wipe surfaces down with soap
and slightly damp cloth only; never use
solvents. (See MAINTENANCE)
•
At no time should more than one person be
on treadmill while in operation.
•
Failure to comply will void the warranty.
The treadmill should not be used by persons
weighing more than 110 kg.
•
The treadmill is intended for in-home use only.
Do not use this treadmill in any commercial,
rental, school or institutional setting. Failure
to comply will void the warranty.
•
Do not use treadmill in any location that is
not temperature controlled, such as but not
limited to garages, porches, pool rooms,
bathrooms, car ports or outdoors. Failure to
comply may void the warranty.
•
When using an electrical appliance, basic precautions should always be followed, including the following.
Read all instructions before using this appliance:
SAVE THESE INSTRUCTIONS
At NO time should pets or children under the age of 12 be closer to the treadmill than 10 feet.
At NO time should children under the age of 12 use the treadmill.
Children over the age of 12 should not use the treadmill without adult supervision.
Always unplug this appliance (or treadmill) from the electrical outlet
immediately after using and before cleaning.
WARNING
Stand on the siderails before starting the treadmill. Read Instruction
Manual before using. Remove safety key when not in use and store out of
reach of chidren.
FOR HOUSEHOLD USE ONLY
TO REDUCE THE RISK OF INJURY TO PERSONS:
TO REDUCE THE RISK OF ELECTRIC SHOCK:
WARNING
WARNING
TO REDUCE THE RISK OF BURNS,FIRE,ELECTRICAL SHOCK
OR INJURY TOPERSONS:
Close supervision is necessary when this appliance (or treadmill)
is used by, on, or near children, invalids, or disabled persons.
•
An appliance should never be left unattended when plugged in.
Unplug from outlet when not in use, and before putting on or
taking off parts.
•
Use this appliance (or treadmill) only for its intended use
as described in this manual. Do not use attachments not
recommended by the manufacturer.
•
Never operate this appliance (or treadmill) if it has a damaged
cord or plug, if it is not working properly, if it has been dropped
or damaged, or dropped into water. Return the appliance (or
treadmill) to a service center for examination and repair.
•
Do not carry this appliance (or treadmill) by supply cord or use
cord as a handle.
•
Keep the cord away from heated surfaces.•
Never operate the appliance (or treadmill) with the air openings
blocked. Keep the air openings free of lint, hair, and the like.
•
Never drop or insert any object into any opening.•
Do not use outdoors.•
Do not operate where aerosol (spray) products are being used or
where oxygen is being administered.
•
To disconnect, turn all controls to the off position, then remove
plug from outlet.
•
Do not operate under blanket or pillow. Excessive heating can
occur and cause fire, electric shock, or injury to persons.
•
Do not operate under blanket or pillow. Excessive heating can
occur and cause fire, electric shock, or injury to persons.
•
This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have been
given supervision or instruction concerning use of the appliance
by a person responsible for their safety.
•
•If the supply cord is damaged, it must be
replaced by the manufacturer, its service
agent or similarly qualified persons in order
to avoid a hazard.

BEFORE YOU BEGIN
LOCATION OF THE TREADMILL
Place the treadmill on a level surface. There should be 6 feet of clearance
behind the treadmill, 3 feet on each side and one foot in front for folding
and the power cord. Do not place the treadmill in any area that will block
any vent or air openings. The treadmill should not be located in a garage,
covered patio, near water or outdoors.
SAFETY KEY
Your treadmill will not start unless the safety key is placed in position. Attach the clip end securely to your
clothing. This safety key is designed to cut the power to the treadmill if you should fall. Check the operation
of the safety key every 2 weeks.
NEVER USE THE TREADMILL WITHOUT SECURING THE SAFETY KEY CLIP TO YOUR
CLOTHING. PULL ON THE SAFETY KEY CLIP FIRST TO MAKE SURE IT WILL NOT
COME OFF YOUR CLOTHING.
WA RNING
PROPER USAGE
Your treadmill is capable of reaching high speeds. Always start off using a slower speed and adjust the speed in
small increments to reach a higher speed level. Never leave the treadmill unattended while it is running. When
not in use, remove the safety key, turn the on/off switch to off and unplug the power cord. Make sure to follow
the MAINTENANCE schedule in this manual. Keep your body and head facing forward. Do not attempt to turn
around or look backwards while the treadmill is running. Stop your workout immediately if you feel pain, faint,
dizzy or are short of breath.
Do not operate the treadmill if the power cord or plug is damaged.
If the treadmill appears to not be working properly, do not use the treadmill.
CONGRATULATIONS! on choosing your treadmill. You’ve taken an important step in develop-
ing and sustaining an exercise program! Your treadmill is a tremendously effective tool for achieving your
personal fitness goals. Regular use of your treadmill can improve the quality of your life in so many ways.
HERE ARE JUST A FEW OF THE HEALTH BENEFITS OF EXERCISE:
WARNING
WARNING
6 7
ss
o
L
t
hgi
eW
•
tra
e
Hr
ei
ht
l
a
e
HA
•
e
n
o
Tel
c
s
uM
d
ev
orpmI•
sle
ve
Ly
g
ren
Ey
li
a
D
des
ae
r
cn
I•
sse
r
t
S
d
e
cude
R•
n
o
is
s
erp
eD
dn
ay
tei
x
n
A
g
nir
e
t
n
u
o
CnI
p
l
e
H
•
e
g
a
m
I
f
leS
d
e
vo
r
p
m
I
n
A
•
s
sen
t
i
F
Treow
e
n
r
u
o
Y
.
t
i
ba
h
esicrexe
e
htpolevedotsist
if
e
n
eb
e
s
e
ht
g
n
i
p
a
e
r
ot
y
e
k
ehT
-
r
e
x
eruoy
n
ign
i
tt
eg
mo
rf
u
o
yt
n
eve
r
p
t
aht
s
e
l
catsb
oe
htetanimil
eu
oy
p
lehlliw
l
lim
d
a
e
r
T
es
uu
o
y
nehwtuok
r
ow
ru
oyh
t
i
w
e
r
efre
t
nit'no
w
ssenk
r
ad
dn
a
reht
a
ewtneme
l
cn
I
.em
i
t
es
i
c
ht
i
w
uo
y
s
e
div
o
rpl
au
namsihT.emohru
o
y
fotro
f
mo
c
e
htn
i
llimdaerTssentiFTreor
uo
y
eg
de
lw
o
n
kete
l
pmo
c
e
r
omA.enihc
am
w
e
n
ruoygniy
o
jnednagn
i
s
u
r
ofnoi
t
amr
of
nic
i
sa
b
yhtl
a
ehaf
o
laogr
uo
y
gnisi
l
a
ern
i
uoyts
iss
alliw
l
l
i
m
daerTss
e
nt
i
Fwen
ru
oyf
o
.elytsefi
l
DO NOT STAND ON THE BELT
While you are preparing to use the treadmill, do not stand on the
belt. Place your feet on the side rails before starting the treadmill.
Start walking on the belt only after the belt has begun to move. Never
start the treadmill at a fast running speed and attempt to jump on!
FOLDING
Firmly grasp the back end of the treadmill. Carefully lift the end of the treadmill deck into the upright position
until the foot lock latch engages and securely locks the deck into position. Make sure the deck is securely
latched before letting go. To unfold, firmly grasp the back end of the treadmill. Gently press down on the foot
lock latch with your foot until the lock latch disengages. Carefully lower the deck to the ground.
MOVING
Your Treo Finess treadmill has a pair of transport wheels built into the base frame.To move,make sure the
treadmill is folded and securely latched.Then firmly grasp the handebars,tilt treadmill back and roll.
Treo
6 feet
1 foot
3 feet 3 feet
H
C
TAL
-
KCOLTOOF

TENSIONING THE RUNNING BELT
The running belt has been properly adjusted at the
factory before it was shipped. At times the belt can
move off-center during shipment.
89
CAUTION:Running belt should NOT be moving
during tensioning. Over-tightening the running
belt can cause excessive wear on the treadmill as
well as its components. Never over-tighten the belt.
If you can feel a slipping sensation when running on the
treadmill, the running belt must be tightened. In most
cases, the belt has stretched from use, causing the
belt to slip. This is a normal and common adjustment.
To eliminate this slipping, TURN THE TREADMILL
OFF and tension BOTH THE REAR ROLLER BOLTS
using the supplied Allen wrench, turning them 1/4
TURN to the right as shown. Turn the treadmill on
and check for slipping. Repeat if necessary, but
NEVER TURN the roller bolts more than 1/4 turn at a
time. Belt is properly tensioned when the slipping
sensation is gone.
Belt is too far to the right side
Belt is too far to the left side
CENTERING THE RUNNING BELT
The running belt has been properly adjusted at the factory
before it was shipped. At times the belt can move off-
center during shipment. Before operating the treadmill,
make sure the belt is centered and remains centered to
maintain smooth operation.
CAUTION: Do not run belt faster than 1 mph while
centering. Keep fingers, hair and clothing away from belt
at all times.
If the running belt is too far to the right side:With
the treadmill running at 1 mph, turn the right adjust-
ment bolt clockwise 1/4 TURN at a time (using the
supplied Allen wrench). Check the belt alignment.
Allow belt to run a full cycle to gauge if more adjustment
is needed. Repeat if necessary, until the belt remains
centered during use.
If the running belt is too far to the left
side:With the treadmill running at 1 mph, turn the
right adjustment bolt counter-clockwise 1/4 TURN at
a time (using the supplied Allen wrench). Check
the belt alignment. Allow belt to run a full cycle to
gauge if more adjustment is needed. Repeat if
necessary, until the belt remains centered during
use.
e
rehw ll
im
d
ae
r
t
eh
t
d
e
c
a
l
p
ev
a
h
uo
y
e
c
n
O .
es
u
mumit
p
o
r
of
levele
b
d
luohs
l
lim
d
aertehT
e
sabl
l
imdae
r
t
e
ht n
o d
etaco
l
sre
l
levele
l
batsu
j
daeh
t rewo
lr
o
esiar,
t
iesu
o
t dne
tn
iuoy
e
h
t
gn
in
e
th
g
it
yb
e
ca
l
p
nisrellevelehtkco
l
,llimd
a
ert
e
ht
d
el
l
evelevahuoye
c
nO.emarf
.dednemmocersilev
e
ls'retnepraca ,
l
evelsillimd
a
ert
e
hte
r
ussaoT.emarfe
h
t tsniag
a
sihct
i
ws
f
fo/
n
oehT.
t
el
t
uor
e
wopa
ot
det
c
ennocy
lr
eporpsi
l
li
mda
e
rtru
oyta
h
t
er
us
ekaM
.
t
il s
i hc
t
i
w
s e
ht
ta
ht os,n
o
itis
op'
n
o
'
eht
o
t
h
c
t
i
wssihtp
i
l
F .dr
oc re
w
op e
h
t
ot
t
x
end
e
t
a
c
o
l
.p
u thg
i
l
l
liw
e
l
os
n
o
c
e
h
td
na
p
e
eb
a
ra
e
hll
i
wu
o
Y
LEVELLING
TURN POWERON
pad