6
SPECIAL SAFETY INSTRUCTIONS FOR LOG SPLITTER
1. The log splitter must always be used by
one operator only.
2. Nobody must be allowed to use the log
splitter unless they have read the
instruction manual and have been
instructed in the regulations to follow for
correct and safe use.
3. The machine must be used by adults only.
Use of the log splitter by apprentices of not
less than 16 years of age must be
supervised by an adult authorized to use
the machine.
4. Never wear loose, unbuttoned clothing
which may become trapped in moving
parts.
5. Position the machine on a support surface
of 60-75 cm height, free from any objects
that could prevent complete freedom of
movement for the operator while working.
The surface must be perfectly leveled to
prevent the machine from falling during
operation.
6. it is prohibited to work with the machine on
the ground. This is not only an
uncomfortable working position but it it can
also be dangerous because the operator
has to bring his face close to the machine,
and thus risks being struck by chips or
debris.
7. Check that the logs to be split are free
from nails or wire, which may fly up or
damage the machine, the ends of the logs
must be cut square, branches must be cut
off flush with the trunk.
8. Never try to split logs larger than those
indicated in the technical specifications.
This could be dangerous and may
damage the machine.
9. Break wood in the direction of the grain,
do not place wood across the log splitter
and leave it in that position for splitting; it
may be dangerous and may seriously
damage the machine.
10. Never attempt to cut two logs at once, one
may fly up and hit you.
11. If the log moves away from the blade,
retract the ram or the blade and turn the
log through 900.
12. Do not attempt to load the log in the log
splitter while the ram is in motion, you
could get trapped and injured.
13. Keep your hands well away from any splits
and cracks which open in the log; these
may close suddenly and crush or
amputate your fingers.
14. Never force the log splitter for more than 5
seconds keeping the cylinder under
pressure in the attempt to split excessively
hard wood. After this time interval, the oil
under pressure is overheated and the
machine could be damaged. It is thus
better to stop and rotate the log by 900to
see whether it can be split in a different
position. In any case, if you are not able to
split the log, this means that its hardness
exceeds the capacity of the machine and
thus that log should be discarded so as
not to damage the lop splitter.
15. Do not force the blade by pushing the log
on the upper part, as this can cause the
blade to break or damage the body of the
machine. Always set the log on the guides.
16. Never leave the machine unattended
while it is running. If you leave the
machine, even for a short time, remove
the power supply or any possible cause of
accidental start-up.
17. The log splitter must never be used by an
operator who is under the influence of
alcohol, drugs, medicines, or who is tired.
A clear mind is essential for safety.
18. Never request the assistance of another
