vaperiza V500 Operational manual

!
!
!
!
!
!
!
!
V500
V1000
V1500
V2000
!
!
!
PRODUCT USER
MANUAL
!
!
!
TECHNICAL
SECIFICATIONS!
!
!
V500!
V1000!
V1500!
V2000!
Smoke!!
Output!
8000cu.ft!per!
minute!
10000cu.ft!
per!minute!
18000cu.ft!
per!minute!
20000cu.ft!
per!minute!
Warm!Up!
Time!
4.5!!
Minutes!
4.5!!
Minutes!
8!
Minutes!
8!
Minutes!
Tank!!
Capacity!
0.25!
Liters!
0.25!
Liters!
1.2!
Liters!
1.2!
Liters!
Power!
Consumption!
500!
Watt!
1000!
Watt!
1500!
Watt!
2000!
Watt!
Power!!
Supply!
110V!
240V!
110V!
240V!
110V!
240V!
110V!
240V!
Unit!
Dimensions!
25x14x19cm!
2.25Kg!
25x14x19cm!
2.25Kg!
53x32x27cm!
5.6Kg!
53x32x27cm!
5.6Kg!
!
!

!
!
!
!
!
!
CAUTION!)
Keep$this$device$away$from$rain$and$moisture$
Unplug$Mains$lead$before$opening$the$housing$
Make$sure$of$the$voltage$on$your$end$in$suitable$for$the$unit$
For)your)own)safety,)please)read)this)user)manual)carefully)before)you)initially)start)
Any$person$involved$with$the$installation,$operation$and$maintenance$of$this$device$
has$to$ =$Be$qualified$
=$Follow$the$instructions$in$this$manual$
$
1. INTRODUCTION)
Thank$you$for$having$chosen$the$AVE$Vaperiza$range.$You$will$see$you$have$
acquired$a$powerful$and$versatile$device.$Unpack$your$item.$Before$you$initial$
start=up,$please$make$sure$that$there$is$no$damage$caused$by$transportation.$
Should$there$be$any,$please$consult$your$dealer$and$do$not$attempt$to$use$the$
device.$
$
2. SAFTEY)INSTRUCTIONS)
If$the$device$has$been$exposed$to$drastic$temperature$fluctuation$(e.g.$after$
transportation),$do$not$switch$it$on$immediately.$The$arising$condensation$
water$might$damage$your$device.$Leave$device$switched$off$until$it$has$
reached$room$temperature.$Always$plug$in$the$power$plug$last.$Make$sure$
that$the$power=switch$is$set$to$the$OFF$position$before$you$connect$the$
device$to$the$mains.$Never$let$the$power=cord$come$into$contact$with$other$
cables.$Handle$the$power=cord$and$all$connections$with$the$mains$with$
particular$caution.$Make$sure$that$the$available$voltage$is$not$higher$then$
stated$on$the$rear$panel.$Make$sure$that$the$power=cord$is$never$crimped$or$
damaged$by$sharp$edges.$Check$the$device$and$the$power=cord$from$time$to$
time.$CAUTION!$Before$filling$the$machine$disconnect$from$mains.$Never$drink$
fluid$or$use$it$on$the$inside$or$outside$of$a$human$body.$If$fluid$gets$in$contact$
with$skin$or$eyes,$rinse$thoroughly$with$water.$If$it$is$necessary$call$a$doctor$
immediately$DANGER$OF$EXPLOSION!$Never$add$flammable$liquids$of$any$
kind$to$the$fog$liquid.$Keep$minimum$distance$of$50cm$to$nozzle.$Always$
disconnect$from$mains,$when$the$device$is$not$in$use$or$before$cleaning$it.$
Only$handle$the$power=cord$by$the$plug.$Never$pull$out$the$plug$By$tugging$
the$power=cord.$Keep$away$children$and$amateurs.$Never$leave$this$device$
running$unattended$
$
!
!
!
!
!
!
!
3. STARTING)OPERATION)
Install$the$device$on$a$plane$surface.$The$fluid$tank$of$the$device$needs$to$be$
filled$with$standard$smoke$fluid$before$starting$up$operation$and$always$
disconnected$from$the$mains$as$fluid$could$be$spilled.$We$recommend$high=
quality$AVE$Magic$Mist$fluid.$You$must$not$use$substances$that$are$classified$
as$“dangerous$working$material”$or$“inflammable$fluids”.$If$fluid$should$get$
into$the$interior$of$the$device,$disconnect$from$mains$immediately$and$
consult$a$technician.$Switch$the$device$on$via$the$power$switch.$Connect$the$
remote$control$with$the$remote$control=socket$through$the$three=pin$socket$
at$the$back$of$the$unit.$After$a$certain$warm=up$time,$the$device$is$ready$to$
operate.$Upon$warming$up$the$fogger$is$ready$to$emit$and$by$switching$the$
control$box$the$fogger$starts$emission.$A$high$quality$thermostat$regulates$the$
temperature.$
CAUSTION:$The$escape$nozzle$will$heat$up$during$operation.$Therefore$do$not$
tough$the$nozzle$until$it$has$cooled$down$completely.$
$
CLEANING)THE)HEATING)ELEMENT)
The$heating$element$should$be$regularly$cleaned$every$30$operational$hours$in$order$
to$avoid$clogging.$Use$smoke$machine$cleaner$available$at$your$dealer.$
$
PROCEDURE:)
Fill$cleaner$into$empty$tank.$Run$machine$several$times$in$a$well=ventilated$room$only.$
The$number$of$repetitions$depends$on$the$pollution$level$of$the$vaporizing$elements.$
After$use$clean$all$remaining$cleaners$and$rinse$the$tank$thoroughly.$There$are$no$
serviceable$parts$inside$the$device$except$for$the$fuse.$Maintenance$and$service$
operations$are$only$to$be$carried$out$by$an$authorized$dealer.$
$
PLEASE)NOTE:$All$information$is$subject$to$change$without$prior$notice.$
!
PRODUCT USER
MANUAL
!
!