Victory Cross Roads 8-Ball Installation and maintenance manual

Rider’s Manual
2010

For your nearest Victory dealer, call 1-800-POLARIS
or visit www.polarisindustries.com
Polaris Sales Inc.,
2100 Hwy. 55, Medina, MN 55340
Phone [phone]
Part No. 9922441 Rev 01
Printed in USA

California Proposition 65 Warning
This product contains or emits
chemicals known to the state of
California to cause cancer and birth
defects or other reproductive harm.
inside cover.fm Page 202 Monday, May 11, 2009 1:31 PM

The text is printed on 100% recycled
with 40% post-consumer waste (PCW).
inside back cover Vision.fm Page 202 Monday, May 11, 2009 1:31 PM

1
2010 RIDER’S MANUAL
Victory Vision®
Victory Vision 8-Ball™
P/N 9922441
E2009 Polaris Sales Inc. All Rights Reserved.
Printed in U.S.A.
9922441.book Page 1 Monday, May 11, 2009 1:16 PM

2
Introduction
General Information
All information contained within this publication is based on the latest product information
available at the time of publication. Product improvements or other changes may result in
differences between this manual and the motorcycle. Depictions and/or procedures in this
publication are intended for reference use only.
No liability can be accepted for omissions or inaccuracies. Polaris Industries reserves the
right to make changes at any time, without notice and without incurring obligation to make
the same or similar changes to motorcycles previously built. Any reprinting or reuse of the
depictions and/or procedures contained within, whether whole or in part, is expressly prohib-
ited.
All reference to RIGHT, LEFT, FRONT, REAR are from the operator’s perspective seated in
a normal riding position.
Features of VICTORY Motorcycles are covered by U.S. Patent Nos: 6,976,691; 6,407,663;
D489670; D482311; D482304; D481980; D481973; D474142.
9922441.book Page 2 Monday, May 11, 2009 1:16 PM

3
Introduction
Trademarks
The following are registered trademarks of Polaris Industries Inc.
POLARIS®
THE WAY OUT®
VICTORY MOTORCYCLES®
VICTORY VISION®
FREEDOM®
8-BALL™ is a trademark of Polaris Industries Inc.
DUNLOP® is a registered trademark of Dunlop Tire Corporation.
LOCTITE® is a registered trademark of Henkel Corporation.
XM Ready® is a registered trademark of XM® Satellite Radio Inc. All rights reserved.
iPod® is a registered trademark of Apple Inc.
Garmin® and zumo® are trademarks of Garmin Ltd. or its subsidiaries.
9922441.book Page 3 Monday, May 11, 2009 1:16 PM

4
Introduction
Failure to follow recommended precautions and procedures could result in severe injury or death.
Always heed all safety precautions and follow all operation, inspection and maintenance procedures
outlined in this manual.
Before You Ride
Read your Rider’s Manual
This rider’s manual contains information that is essential to safe riding and proper mainte-
nance of your VICTORY VISION motorcycle. Anyone who uses the motorcycle (operators
and passengers) must read the rider’s manual before riding. Carefully read and understand
the information found in the Safety section. Understand and follow the procedures outlined
in the Maintenance section to keep your VICTORY motorcycle in top condition on the road
or in storage. Bring the manual with you when you ride. Following the precautions and pro-
cedures in the manual will add to your enjoyment and help keep you riding safely. If you lose
or damage this manual, you can purchase a new one through any authorized VICTORY
dealer. The rider’s manual should be considered part of the motorcycle and remain with it if
sold.
WARNING
9922441.book Page 4 Monday, May 11, 2009 1:16 PM

5
Table of Contents
Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Reporting Safety Defects . . . . . . . . . . . . . . . . . . . . . . . 38
Component Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Instruments, Features & Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Pre-Ride Inspections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Cleaning and Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 245
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
9922441.book Page 5 Monday, May 11, 2009 1:16 PM

6
Table of Contents
Audio System. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 263
System Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . 263
System Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
CB Radio / Intercom (ICOM) . . . . . . . . . . . . . . . . . . . 288
AUX / iPod . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 300
XM Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 307
NAV MP3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 315
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 318
9922441.book Page 6 Monday, May 11, 2009 1:16 PM