Volvo 2005 V70 Manual

2005
VOLVO V70/V70R/XC70/XC90
TP 3977202

© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC ?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VADIS.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VADIS.
• Do not install any accessories in the areas between the A and B-pillars, the B and C-pillars,
and the C and D-pillars.
Test terminal
Fuse in cargo compartment auxiliary fuse box
Changes introduced up to and including June 2004
Any changes made to the vehicle after this date are not included in the
manual. If necessary, refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These
adaptations depend on factors such as legal requirements, taxation, and
market demands.
This manual may therefore include illustrations and text that do not apply to
the vehicles in your country.
Order number TP 3977202
Replaces previous publication 3977201 Electronic Wiring Diagram (EWD) TP 3978001
Volvo retains the right to make amendments

TP3977202 V70/V70R/XC70/XC90 2005
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable curtain) ..................................................... 2
Abbreviations................................................................. 5
How to use the wiring diagrams 1:2............................... 6
Electrical distribution 1:2 V70 ........................................ 8
Electrical distribution 1:2 XC90.................................... 10
Fuses
Engine compartment 11A/1-8.......................................12
Engine compartment 11B/1-6.......................................13
Engine compartment 11B/8-23.....................................14
Passenger compartment 11C/1-4.................................15
Passenger compartment 11C/5-8.................................16
Passenger compartment 11C/9-14...............................17
Cargo compartment 11E/1-7 & 11F/1-2........................18
Central Electronic Module (CEM) F1-F16.....................19
Central Electronic Module (CEM) F17-F34...................20
Rear Electronic Module (REM) F1-F19 ........................21
Rear Electronic Module (REM) F20-F38 ......................22
Relays
Ignition and relays........................................................ 23
Engine compartment FMA2 - FST3............................. 24
Other relays................................................................. 25
Ground connections
Overview...................................................................... 26
31/1 - 31/46 ................................................................. 27
31/47 - 31/70 ............................................................... 28
31/72 - 31/83 ............................................................... 29
31/84 - 31/91 ............................................................... 30
31/93 - 31/94 ............................................................... 31
31/95 - 31/118 ............................................................. 32
31/120 ........................................................................ 33
Control modules
Overview positions V70............................................... 34
Overview designations V70......................................... 35
Overview positions XC90............................................. 36
Overview designations XC90....................................... 37
Central Electronic Module (CEM) 1:2.......................... 38
Rear Electronic Module (REM) 1:2.............................. 40
High speed CAN data communication......................... 42
Low speed CAN data communication V70.................. 43
Low speed CAN data communication XC90................ 44
LIN data communication 1:2........................................ 45
Data communication MOST, XC90.............................. 47
Group 23 Fuel system
Engine management system, 5-cyl 1:2........................ 48
Engine management system, 5-cyl Turbo 1:2............. 50
Engine management system, 6-cyl 1:2........................ 52
Engine management system, Bi-fuel 1:2..................... 54
Engine management system, Diesel 1:2..................... 56
Emission control, 5-cyl................................................. 58
Emission control, 5-cyl Turbo & 6-cyl Turbo................ 59
Group 26 Cooling system
Cooling fan................................................................... 60
Group 27 Engine control
Cruise control ...............................................................61
Group 32 Generator and voltage regulator
Power supply ............................................................... 62
Group 33 Starting system
Starting system............................................................ 63
Group 35 Lighting
High and low beams/Bi-Xenon & Daytime running
lights V70 .................................................................. 64
High and low beams/Bi-Xenon & Daytime running
lights XC90 ................................................................ 65
Fog lights ..................................................................... 66
Brake lights.................................................................. 67
Reversing lights ........................................................... 68
Home safe lighting....................................................... 69
Running/parking lights, tail lights & license plate
lighting V70 ............................................................... 70
Position/parking lights, tail lights & license plate
lighting XC90 ............................................................. 71
Interior lighting V70...................................................... 72
Interior lighting XC90 ................................................... 73
Beam length adjustment V70....................................... 74
Beam length adjustment XC90.................................... 75
Auxiliary light................................................................ 76
Group 36 Additional electrical equipment
Rain sensor.................................................................. 77
Direction indicators and flashing hazard lights V70 ... 78
Direction indicators and hazard warning flashers
XC90 ........................................................................ 79
Wipers/washers, windshield......................................... 80
Wiper/Washer Headlights V70..................................... 81
High pressure headlight washer .................................. 82
Wiper/washer, rear window.......................................... 83
Horn ........................................................................ 84
Electronic immobilizer.................................................. 85
Anti-theft alarm V70..................................................... 86
Anti-theft alarm XC90................................................... 87
Accessory Electronic Module (AEM) 1:2...................... 88
Parking assistance....................................................... 90
Group 37 Wiring and fuses
Diagnostics system...................................................... 91
12V outlet..................................................................... 92
Cable harness tow hitch, 4-pin..................................... 93
Tow hitch cable harness, 4/7-pin................................. 94
Tow hitch cable harness, 7-pin.................................... 95
Tow hitch cable harness, 13-pin ................................. 96
Group 38 Instruments
Seat belt reminder ....................................................... 97
Driver information module............................................ 98
Driver information module Bi-fuel................................. 99
Group 39 Other
Audio V70 ................................................................. 100
Audio XC90................................................................ 101
Audio with extra amplifier V70 1:2............................. 102
Table of Contents 1:2

TP3977202 V70/V70R/XC70/XC90 2005
Road Traffic Information (RTI) V70............................ 104
Road Traffic Information (RTI) XC90......................... 105
Handsfree V70........................................................... 106
Handsfree XC90........................................................ 107
CD-Changer V70....................................................... 108
CD/MD player XC90.................................................. 109
Cellular phone V70.................................................... 110
Subwoofer XC90........................................................ 111
Infotainment XC90..................................................... 112
Rear Seat Entertainment, XC90................................ 113
Rear Seat Entertainment, XC90 1:2.......................... 114
Group 43 Transmission
Automatic transmission AW55-50/51SN/AW50/51
AWD ...................................................................... 116
Automatic transmission, 4T65AWD........................... 117
Geartronic.................................................................. 118
Shift lock.................................................................... 119
Differential Electronic Module (DEM)......................... 120
Group 59 Brake system
Brake control system................................................. 121
Group 64 Steering
Electronic power steering .......................................... 122
Group 76 Shock absorbers
Four-C V70................................................................ 123
Group 83 Doors and openings
Central locking system V70....................................... 124
Central locking system XC90..................................... 125
Power windows.......................................................... 126
Power sunroof............................................................ 127
Group 84 Exterior decorative elements etc.
Power door mirrors.................................................... 128
Heated door mirrors................................................... 129
Heated rear window................................................... 130
Group 85 Interior equipment
Power driver’s seat.................................................... 131
Power passenger seat............................................... 132
Heated seats ............................................................. 133
Group 87 Climate controls
Climate control system 1:2......................................... 134
Parking heater, auxiliary heater ................................ 136
Relay, electric engine heater ..................................... 137
Parking heater, remote start ...................................... 138
Parking heater, Call start ........................................... 139
Short stop heater ....................................................... 140
Rear climate control system XC90............................. 141
Group 88 Internal equipment
Remote garage door opener...................................... 142
Supplemental Restraint System (SRS) V70 ............. 143
Supplemental Restraint System (SRS) XC90 ........... 144
Connectors............................................... 145
Junction points ........................................172
Cable harnesses’ routing in vehicle
Engine harness Gasoline............................................183
Engine harness Diesel................................................184
Engine compartment harness LHD, V70....................185
Engine compartment harness RHD, V70....................186
Engine compartment harness LHD, XC90..................187
Engine compartment harness RHD, XC90.................188
Passenger compartment harness LHD, V70 ..............189
Passenger compartment harness RHD, V70..............190
Passenger compartment harness LHD, XC90............191
Passenger compartment harness RHD, XC90...........192
Cargo compartment harness V70...............................193
Cargo compartment harness XC90............................194
Roof harness & Inflatable curtain harness V70...........195
Tailgate harness V70..................................................195
Roof harness XC90 ....................................................196
Tailgate harness XC90 ...............................................196
Harness, doors V70....................................................197
Harness, doors XC90..................................................198
Harnesses Bi-Fuel V70...............................................199
Rear Seat Entertainment XC90 ..................................200
Component illustrations..........................201
Index......................................................... 274
List of components 1:6............................276
Table of Contents 2:2

TP3977202 V70/V70R/XC70/XC90 2005 5
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Generator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements etc.
Group 85 = Interior equipment
Group 87 = Climate controls
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = The switch remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A=Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D=Germany
DK = Denmark
E=Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J=Japan
KOR = Korea
N=Norway
NL = Netherlands
S=Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Accessory
AMP = Amplifier
AUDIO = Audio system
AUTO = Automatic transmission
Bi-X = Bi-Xenon
CEM = Central Electronic Module
DRL = Daytime Running Lights
DSTC = Dynamic Stability Traction Control
ECC = Electronic climate control system
ECPS = Electronic power steering
EXC = Exclusive
EXT. D = Extended electrical distribution
HISPEED = High speed data bus
LH = Left-hand side
LHD = Left-hand drive
LOSPEED = Low speed data bus
MAN = Manual transmission
OPN = Option (factory-installed)
PCL = Power Child Lock
PETROL = Gasoline
REM = Rear Electronic Module
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SRS = Airbag
SUBWOOF = Bass speaker
SULEV = Super Ultra Low Emission Vehicle
SUM = Suspension Module (SUM)
T=Turboengine
ULEV = Ultra Low Emission Vehicle
W/O = Without
5CYL = 5-cylinder engine
6CYL = 6-cylinder engine
Colors
BL = Blue
BN = Brown
GN = Green
GR = Gray
LBL = Light Blue
LGN = Light Green
OR = Orange
P=Pink
R=Red
SB = Black
VO = Violet
W=White
Y = Yellow

TP3977202 V70/V70R/XC70/XC90 2005 6
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Combined these give a component designation, for
example 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3Switch
4 Control module
5 Driver Information Module
6 Electric motor
7 Sensor
8Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
26 Converter
27 Optics
31 Ground connection
53 Junction point
54 Connector
B. Junction points
The wiring diagrams contain numbered junction
points, e.g. 53/352.
This manual contains a section with a list of junction
points. This list shows all the components which are
connected to each junction point.
The location of the junction points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the "Connectors" sec-
tion.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars are equipped with CAN, LIN & MOST
networks that transmit information. Connections to
these networks are shown in their entirety on the
respective wiring diagram. Complete information on
Data communication can be found in the section
entitled "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.

TP3977202 V70/V70R/XC70/XC90 2005 7
How to use the wiring diagrams 2:2
AF EDCB
G
10/1-2
BN
20
53/503
7/149
BN
GN
3
2
1
5
3
UEM
D:49
13
8
GN
BN
54/16
1
2
3
VO-W
1
2
11C/7
30+
1
2
11C/6
D:34
D:35
D:50
CEM
4/56
1
54/13
53/534
SWM
3/254
LIN
RR
31/98
4/70
1
11 R
R
BN
4
4
VO-W
WW
53/505
VO-W
D:11
54/13
14
W
BL-W
32
1
4
H
SB
31/93
BN
53/331
L
6/1
RSM
20
BN
BN
31/83
53/400
BN
CAN
LIN
C:31
BN
53/397
CAN
LIN
LIN
7
GN-W
D:58
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution
box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component
LIN
CAN
1
1

TP3977202 V70/V70R/XC70/XC90 2005 8
Electrical distribution 1:2 V70
Overview
5
2
13
45
2
13
45
2
13
2
3
1
25
3
1
E
R
11A 11 A 11A
3
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
11
2
1
22
1
17/17
C6:2
C3:2
A1:1
C5:14 C4:11 C4:6
A1:5
C6:1
C4:8 C4:5
C6:9 C6:8 C5:15 C2:2
FST1
2/91
FST3
2/90
C3:4
A1:10
A1:11
C4:9
C4:10
C4:2
C3:3
C3:1
A1:13
2/32
3
2/14
FMA2
5
2
1
FMA3
2
11A
7
2
2
11A
6
11A
8
11B/14 11B/15 11B/16 11B/17 11B/18 11B/19 11B/20 11B/21 11B/22 11B/23 11B/24
C5:2 C6:11
A1:6
C5:11
C4:16
A1:8
C4:12 C4:14
A1:3
C5:13
C6:3
A1:14 A1:2 A1:7
FMI2
2/33
FMI1
2/22
FMA4
2/35
C2:1 15/30 C6:7
5
2
11A
4
11A
3
22
22
2
1
11B/1
11B/2 11B/3 11B/4 11B/5 11B/6 11B/7 11B/8 11B/9
11B/10 11B/11 11B/12
11B/13
31/93
BN
53/397
SB
20/16
R
B
R-W
SB
F
15/31
1
2
FST2
2/182
3
5
C5:12
C6:4
C4:4 C4:3
C6:12 C6:13
C1:1
C1:2
C4:15
C6:10
C6:6
2
1
4
54
54
SB
53/329
R
R
C4:1
A1:12
A
BL
D
R
C
BL-R
CNG/LPG

TP3977202 V70/V70R/XC70/XC90 2005 9
Electrical distribution 2:2 V70
Overview
6/25
2
R
R
R
R
R-W
6/26A:1
BL-R
E
4/9B:27/55
11C/11
11C/1
11
11C/2
22
11C/4
11
11C/3
1
11C/5
2
22
53/408
11C/8
1
11C/6
11
11C/7
22
2
1
11C/9
11
11C/10
222
4
3/1
R-SB
X
30
5
S
37
50
6
15
8
1
15 15I
16/65:1
BL-R
53/443
BL-R
11C/13
11C/12
11
22
53/415
4/9B:28/56
3/157:2
1
11E
6
7
2
4
5
22
2
3
22
1
F1-38
D:16
B:2
B:24
B:3
B:16
D:15
D:60
4/56
CEM
D:8
CAN
1/1
12V
+
SB SB
-
31/53
VO
VO
BL-R
2
RR
F
C:13
C:14
REM
4/58
54/40D
2
VO VO
D:50
D:35
LIN
BL-R
Y
Y-W
C:14
3/157:1
R
R
53/403
1
E:A
E:B
R
R
R
R
Y-R
CNG/LPG
R
R
K:1
A:13
A:4
AB DC
BL
BL
R-W BL-R
R
R
A:29
1
54/40C 12
F16
F3,5-10,
17-23,
31-32 ,34
F1-2,11,
13-16,
26-30,33
CAN
LIN

TP3977202 V70/V70R/XC70/XC90 2005 10
Electrical distribution 1:2 XC90
Overview
5
2
13
45
2
13
45
2
13
25
3
1
E
R
11A 11 A 11A
3
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
11
2
1
22
1
17/17
C6:2
C3:2
A1:1
C5:14 C4:11 C4:6
A1:5
C6:1
C4:8 C4:5
C6:9 C6:8 C5:15 C2:2
FST1
2/91
FST3
2/90
C3:4
A1:10
A1:11
C4:9
C4:10
C4:2
C3:3
C3:1
A1:13
2/32
3
2/14
FMA2
5
2
1
FMA3
2
11A
7
2
2
11A
6
11A
8
11B/14 11B/15 11B/16 11B/17 11B/18 11B/19 11B/20 11B/21 11B/22 11B/23 11B/24
A1:6
C5:11
C4:16
A1:8
C4:12 C4:14
A1:3
C5:13
C6:3
A1:14 A1:2 A1:7
FMI1
2/22
FMA4
2/35
C2:1 15/30 C6:7
5
2
11A
4
11A
3
22
22
2
1
11B/1
11B/2 11B/3 11B/4 11B/5 11B/6 11B/7 11B/8 11B/9
11B/10 11B/11 11B/12
11B/13
B
R-W
SB
F
15/31
1
2
FST2
2/182
3
5
C5:12
C6:4
C4:4 C4:3
C6:12 C6:13
C1:1
C1:2
C4:15
C6:10
C6:6
4
54
R
R
C4:1
A1:12
A
BL
D
R
C
BL-R

TP3977202 V70/V70R/XC70/XC90 2005 11
Electrical distribution 2:2
Overview XC90
6/25
2
R
R
R
R
R-W
6/26A:1
BL-R
E
11C/11
11C/1
11
11C/2
22
11C/4
11
11C/3
1
11C/5
2
22
53/408
11C/8
1
11C/6
11
11C/7
22
2
1
11C/9
11
11C/10
222
4
3/1
R-SB
X
30
5
S
37
50
6
15
8
1
15 15I
16/65:1
BL-R
53/443
BL-R
11C/13
11C/12
11
22
53/415
4/9B:28/56
3/157:2
1
11E
6
7
2
4
5
22
2
3
22
1
D:16
B:2
B:24
B:3
B:16
D:8
D:15
4/56
CEM
D:60
CAN
1/1
12V
+
SB
-
31/53
VO
VO
VO
VO
BL-R
2
RR
F
SB
C:13
C:14
REM
CAN
LIN
4/58
54/40D
2
C:14
D:50
D:35
LIN
BL-R
Y
Y-W
3/157:1
R
R
R
53/403
11C/14
1
2
1
E:B
E:A
R
R
R
R
K:1
1
AB DC
BL A:29
4/9B:27/55
F3,5-10,
17-23,
31-32 ,34
F1-2,11,
13-16,
26-30,33
R
R
R
54/40C 12
BL
R-W BL-R
R
R
F1-38

TP3977202V70/XC70/V70R/XC902005 12
11A Fuses in engine compartment
No. Fuse function via A
1 20/22-26 Glow plug 2/14 60
2 11B/20-21 Fuses in engine compartment fuse box - 40
3 11B/17-18 Fuses in engine compartment fuse box - 40
8 6/29 Motor, cooling fan 4/71 60
11A /7
11A /4
11A /2
11A /3
11A /8
11A /1
Fuses
Engine compartment 11A/1-8

TP3977202V70/XC70/V70R/XC902005 13
11B Fuses in engine compartment
No. Fuse function via A
1 6/35 Fuel pump, auxiliary heater
6/73 Coolant pump, auxiliary heater
9/30 Auxiliary heater
4/7
4/7
4/7
25
2 54/8 Connector cable harness extra lights, 30-feed - 20
3 4/46 Engine Control Module (ECM), 5-cyl normally aspirated
4/50 Electronic Throttle Module (ETM), Bi-Fuel
6/120 Engine throttle body, 5-cyl normally aspirated
-
-
4/46
10
4 4/46 Engine Control Module (ECM), Diesel, Bi-fuel
7/15 Heated oxygen sensor
7/82 Heated oxygen sensor, diagnosis 1
7/103 Heated oxygen sensor 3
8/111 Solenoid valve, high-pressure diesel
-
-
-
-
-
20
5 6/67 Pump, fuel leakage control
6/105 Fuel distributor, gas
8/17 EGR valve, Diesel
8/18 EVAP valve
8/19 Solenoid, variable valve time, inlet
8/28 Turbo control valve
8/64 Solenoid valve, engine mounting, Diesel
8/75 Valve, fuel cut-off DFCO
8/81 Solenoid, variable valve timing outlet
8/82 Solenoid, variable turbo geometry, Diesel
9/32 PTC resistor - air preheating
-
-
-
-
-
-
-
-
-
-
-
10
6 7/17 Mass airflow sensor (MAF), Diesel - 10
4/46 Engine Control Module (ECM), Gasoline
7/17 Mass airflow sensor (MAF), Gasoline
8/6-11 Injectors
-
-
-
15
continues
X
X
X
X
X
X
17
18
19
20
21
22
23
24
9
10
11
12
13
14
15
16
1
2
3
4
5
6
7
8
Fuses
Engine compartment 11B/1-6

TP3977202V70/XC70/V70R/XC902005 14
11B Fuses in the engine compartment
No. Fuse function via A
8 6/44 Cooling fan, electrics box, engine compartment
7/51 Accelerator pedal sensor
8/3 Electromagnetic clutch, climate control system
-
-
2/22
10
9 2/33 Relay fuel system, Bi-Fuel
8/79 Valve LPG, Bi-Fuel - 2/33 10
11 2/14 Relay, glow plug unit
2/22 Relay, climate control system
20/3-8 Spark plug and ignition coil
-
-
-
20
13 2/90 Relay, windshield wiper, low/high speed
2/91 Relay, intermittent windshield wiper
6/1 Windshield wiper motor
-
-
2/90, 2/91
25
14 4/16 Brake Control Module (BCM) - 30
15 2/182 Relay, high pressure headlight washer motor
6/104 High pressure headlight washer motor - 2/182 35
17 10/1 Left front lamp housing, daytime running lights
10/70 Left-hand low beam 4/56 4/56 20
18 10/11 Front left parking light
10/12 Front right parking light 4/56 4/56 15
19 4/16 Brake Control Module (BCM) - 30
20 10/2 Right front lamp housing, daytime running lights
10/66 Right-hand low beam 4/56 4/56 20
21 4/83 Fuel pump control module
6/31 Feed pump, ejectors
6/33 Fuel pump
4/56
4/56
4/56
15
22 6/25 Starter motor 2/35 35
23 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM), Gasoline - -10
X
X
X
X
X
X
17
18
19
20
21
22
23
24
9
10
11
12
13
14
15
16
1
2
3
4
5
6
7
8
Fuses
Engine compartment 11B/8-23

TP3977202V70/XC70/V70R/XC902005 15
11C Fuses in the passenger compartment
No. Fuse function via A
1 6/16 Driver seat motor, backrest angle, V70
6/17 Driver seat motor, up/down front edge, V70
6/18 Driver seat motor, up/down rear edge, V70
6/19 Driver seat motor, forward/backward, V70
4/52 Power Seat Module (PSM), V70
4/52
4/52
4/52
4/52
-
25
6/28 Motor, passenger compartment fan, XC90 4/31 30
2 6/20 Passenger seat motor, forward/backward, V70
6/64 Passenger seat motor, backrest angle, V70
6/65 Passenger seat motor, up/down front edge, V70
6/66 Passenger seat motor, up/down rear edge, V70
3/27
3/27
3/27
3/27
25
16/105 Audio control module (AUD), XC90 - 30
3 6/28 Motor, passenger compartment fan, V70 4/31 30
4/52 Power Seat Module (PSM), XC90
6/16 Driver seat motor, backrest angle, XC90
6/17 Driver seat motor, up/down front edge, XC90
6/18 Driver seat motor, up/down rear edge, XC90
6/19 Driver seat motor, forward/backward, XC90
4/52
4/52
4/52
4/52
4/52
25
4 3/75 Lock unit, right front door, V70
3/127 Passenger/Driver Door Module (PDM)/(DDM), V70
6/60 Front right power window motor, V70
6/63 Right-hand power door mirror, V70
9/34 Right-hand heated door mirror, V70
10/149 Right-hand door mirror lighting, V70
3/127
-
3/127
3/127
3/127
3/127
25
6/20 Passenger seat motor, forward/backward, XC90
6/64 Passenger seat motor, backrest angle, XC90
6/65 Passenger seat motor, up/down front edge, XC90
6/66 Passenger seat motor, up/down rear edge, XC90
3/27
3/27
3/27
3/27
continues
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
11C/19
11C /9 11C/29 11C/38
11C/10
11C/1 11C/3011C/20
Fuses
Passenger compartment 11C/1-4

TP3977202V70/XC70/V70R/XC902005 16
Fuses
Passenger compartment 11C/5-8
11C Fuses in the passenger compartment
No. Fuse function via A
5 3/74 Lock unit, left front door, V70
3/126 Driver/Passenger Door Module (DDM)/(PDM), V70
6/58 Front left power window motor, V70
6/62 Left-hand power door mirror, V70
9/33 Left-hand heated door mirror, V70
10/148 Left-hand door mirror lighting, V70
3/126
-
3/126
3/126
3/126
3/126
25
3/74 Front left door lock unit, XC90
3/126 Driver/Passenger Door Module (DDM)/(PDM), XC90
6/58 Front left power window motor, XC90
6/62 Left-hand power door mirror, XC90
9/33 Left-hand heated door mirror, XC90
10/148 Left-hand door mirror lighting, XC90
3/126
-
3/126
3/126
3/126
3/126
6 3/117 Ceiling light switch unit, V70
4/70 Upper Electronic Module (UEM), V70
4/76 Remote controlled garage door opener, V70
10/25 Ceiling light, cargo compartment, V70
10/114 Left-hand vanity mirror lighting, V70
10/115 Right-hand vanity mirror lighting, V70
10/150 Rear reading light, V70
4/70
-
4/70
4/70
4/70
4/70
4/70
10
3/75 Lock unit, front right door, XC90
3/127 Passenger/Driver Door Module (PDM)/(DDM), XC90
6/60 Front right power window motor, XC90
6/63 Right-hand power door mirror, XC90
9/34 Right-hand heated door mirror, XC90
10/149 Right-hand door mirror lighting, XC90
3/127
-
3/127
3/127
3/127
3/127
25
7 6/15 Sunroof motor, V70 4/33 15
8 3/157 Switch airbag passenger side, V70
4/9 Control module, Supplemental Restraint System (SRS), V70
4/46 Engine Control Module (ECM), V70
4/56 Central Electronic Module (CEM), V70
4/58 Rear Electronic Module (REM), V70
16/65 Antenna ring/ignition switch lighting, V70
3/1
3/1
3/1, 4/56
3/1
3/1
3/1
7.5
continues
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
11C/19
11C /9 11C/29 11C/38
11C/10
11C/1 11C/3011C/20

TP3977202V70/XC70/V70R/XC902005 17
11C Fuses in the passenger compartment
No. Fuse function via A
9 3/111 Light Switch Module (LSM), V70
3/254 Steering Wheel Module (SWM), V70
4/68 Steering Angle Sensor module (SAS), V70
17/13 Data link connector, V70
-
-
3/254
-
5
16/46 Multimedia display, XC90
16/106 Control module, CD player (MP2), XC90
16/107 Control module, MD player (MP1), XC90
54/112 Connector cable harness Infotainment, 30-feed, XC90
-
-
-
-
10
10 16/1 Audio Module (AUM), V70
16/93 Control module, cellular telephone handsfree, V70 - -20
3/111 Light Switch Module (LSM), XC90
3/254 Steering Wheel Module (SWM), XC90
4/68 Steering Angle Sensor module (SAS), XC90
17/13 Data link connector, XC90
-
-
3/254
-
5
11 16/2 Amplifier, V70 - 30
3/157 Switch airbag passenger side, XC90
4/9 Control module, Supplemental Restraint System (SRS), XC90
4/46 Engine Control Module (ECM), XC90
4/56 Central Electronic Module (CEM), XC90
4/58 Rear Electronic Module (REM), XC90
16/65 Antenna ring/ignition switch lighting, XC90
3/1
3/1
3/1, 4/56
3/1
3/1
3/1
7.5
12 16/46 RTI display, V70 - 10
3/117 Ceiling light switch unit, XC90
4/70 Upper Electronic Module (UEM), XC90
4/76 Remote controlled garage door opener, XC90
10/114 Left-hand vanity mirror lighting, XC90
10/115 Right-hand vanity mirror lighting, XC90
10/150 Rear reading light, XC90
10/172 Reading light, third row of seats, XC90
4/70
-
4/70
4/70
4/70
4/70
4/70
13 16/60 Phone Module (PHM), V70 - 5
6/15 Sunroof motor, XC90 4/33 15
14 16/60 Phone Module (PHM), XC90 - 5
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
11C/19
11C /9 11C/29 11C/38
11C/10
11C/1 11C/3011C/20
Fuses
Passenger compartment 11C/9-14

TP3977202V70/XC70/V70R/XC902005 18
11E Fuses by battery
11F/1-2 Fuses in extra fuse box cargo compartment, XC90
No. Fuse function via A
1 4/58 Rear Electronic Module (REM)
Main fuse for: F1-F38 - -60
2 11 F/1 Fuse in cargo compartment auxiliary fuse box - 40
4 4/56 Central Electronic Module (CEM)
Main fuse for: F1-F2, F11, F13-F16, F26-F30, F33 - -50
5 4/56 Central Electronic Module (CEM)
Main fuse for: F3, F5-F10, F17-F23, F31-F32, F34 - -50
6 11C/1-5 Fuses in the passenger compartment fuse box, V70 - 50
11C/1, 3-6 Fuses in the passenger compartment fuse box, XC90 -
7 11C/6-13 Fuses in the passenger compartment fuse box, V70 - 50
11C/2, 9-14 Fuses in the passenger compartment fuse box, XC90 -
No. Fuse function via A
1 16/122 Rear Audio Separation module (RAS), XC90
16/124 Rear Seat Entertainment module (RSE), 30 feed - -10
2 16/124 Rear Seat Entertainment module (RSE), X feed - 5
11E/2
11E/7
11E/3
11E/5
11E/1
P2S04_11F
11F/1
11F/2
Fuses
Cargo compartment 11E/1-7 & 11F/1-2

TP3977202V70/XC70/V70R/XC902005 19
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 9/13 Seat Heater Module (SHM), right-hand - 15
F2 9/12 Seat Heater Module (SHM), left-hand - 15
F3 16/10 Horn 1
16/11 Horn 2, V70 - -15
F5 16/46 Multimedia display, XC90
16/94 Infotainment Control Module (ICM), XC90
16/106 Control module, CD player (MP2), XC90
16/107 Control module, MD player (MP1), XC90
16/108 Multimedia module (MMM), XC90
54/112 Connector cable harness Infotainment, increased D-feed, XC90
-
-
-
-
-
-
10
F8 16/35 Siren Control Module (SCM) - 5
F9 3/9 Brake light contact - 5
F10 3/112 Climate Control Module (CCM)
4/7 Combustion Preheater Module (CPM)
4/52 Power Seat Module (PSM)
5/1 Driver Information Module (DIM)
6/48 Damper Motor Module (DMM), recirculation
6/69 Damper Motor Module (DMM), ventilation/floor/defroster
6/95 Damper Motor Module (DMM), temperature, left-hand side
6/96 Damper Motor Module (DMM), temperature, right-hand side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/93 Occupant Weight Sensor (OWS)
7/159 Air Quality Sensor (AQS)
-
-
-
-
-
-
-
-
-
-
-
-
10
F11 9/1 Outlet 12V front
9/25 Outlet 12V rear
11 F/2 Fuse in cargo compartment auxiliary fuse box
-
-
-
15
F14 6/3 Right-hand headlight wiper motor, V70
6/4 Left-hand headlight wiper motor, V70 - -15
F15 4/16 Brake Control Module (BCM) - 5
F16 4/99 Electronic power steering control module
6/38 Left-hand headlight level adjustment motor
6/39 Right-hand headlight adjustment motor
8/76 Gas tank valve, Bi-Fuel
8/88 Solenoid, fuel tank CNG rear, Bi-Fuel
8/89 Solenoid, fuel tank CNG front left, Bi-Fuel
8/90 Solenoid, fuel tank CNG front right, Bi-Fuel
10/1 Left front lamp housing, Bi-Xenon
10/2 Right front lamp housing, Bi-Xenon
-
-
-
4/58
4/58
4/58
4/58
-
-
10
12
31 32 33
363534
4
35678910 11 12 13 14 15 16
17 18 19 20 21 22 23 24 25 26 27 28 29 30
Fuses
Central Electronic Module (CEM) F1-F16

TP3977202V70/XC70/V70R/XC902005 20
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F17 10/5 Front left fog light - 7.5
F18 10/6 Front right fog light - 7.5
F21 3/156 Gear Selector Module (GSM)
4/28 Transmission Control Module (TCM)
8/36 Shift lock solenoid
8/134 Solenoid, reverse interlock, manual
-
-
3/156
-
10
F22 10/68 Left-hand high beam - 10
F23 10/64 Right-hand high beam - 10
F28 3/27 Power passenger seat module - 5
16/1 Audio Module (AUM), V70
16/46 RTI display, accessory, V70
16/93 Control module, cellular telephone handsfree, V70
-
-
-
F33 6/114 Vacuum pump 8/84 20
F34 6/3 Right-hand headlight wiper motor, V70
6/4 Left-hand headlight wiper motor, V70
6/127 Washer motor
-
-
-
15
12
31 32 33
363534
4
35678910 11 12 13 14 15 16
17 18 19 20 21 22 23 24 25 26 27 28 29 30
Fuses
Central Electronic Module (CEM) F17-F34