Volvo C30 - ANNEXE 798 Quick start guide

WIRING DIAGRAM 2010
VOLVO C30, S40 (04-), V50 & C70 (06-)
TP 39150201

© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B posts, the B and C posts, and the C
and D posts.
Test terminal
Data link connector in the passenger compartment.
Changes introduced up to and including December 2008
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWD) can be ordered from Technical Information Shop (TIS) at
w ww.volvocarstechinfo.ford.com/vss
We retain the right to make modifications.

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 3
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain) ......................................................... 2
Abbreviations................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Electrical distribution 1:2................................................ 9
Fuses
Engine compartment distribution box F1-F7................. 11
Distribution box in engine compartment F8-F16........... 12
Distribution box in engine compartment F17-F25......... 13
Distribution box in engine compartment F26-F32......... 14
Distribution box in engine compartment F33-F34......... 15
Engine compartment distribution box F35-FH1 ............ 16
Main fuse box battery ................................................... 17
Fuse holder midi ........................................................... 18
Central Electronic Module (CEM) F43-F48................... 19
Central Electronic Module (CEM) F49-F61................... 20
Central Electronic Module (CEM) F62-F69................... 21
Central Electronic Module (CEM) F73-F85................... 22
Central Electronic Module (CEM) F86 .......................... 23
Battery PF1-PF2........................................................... 24
Relays
Ignition switch and relays............................................. 25
Distribution box in engine compartment R1-R14 ......... 26
Engine compartment.................................................... 27
Central electronic module (CEM) R15-R18 ................. 28
Central electronic module (CEM) R1-R11B................. 29
Other relays ................................................................. 30
Ground connections
Overview...................................................................... 31
31/3 - 31/10 cont.......................................................... 32
31/10 - 31/11 ............................................................... 33
31/12 - 31/66 cont........................................................ 34
31/66 - 31/80 ............................................................... 35
31/83 - 31/102 ............................................................. 36
31/107 - 31/114 ........................................................... 37
31/115 - 31/160 ........................................................... 38
Ground connections in chassis.................................... 39
Control modules
Overview locations....................................................... 40
Overview designations................................................. 41
Central electronic module (CEM) 1:2........................... 42
Data communication, Low speed CAN 1:2.................. 44
Data communication, High speed CAN ....................... 46
Data communication MOST......................................... 47
Data communication LIN 1:2 ....................................... 48
Ignition switch (SCU) ................................................... 50
Accessory electronic module (AEM)............................ 51
Group 23 Fuel system
Engine management system, 4-Cyl. 1.6l 1:2 ............... 52
Engine management system, 4-Cyl. 1.8l & 2.0l 1:2..... 54
Engine management system, 5-Cyl. 1:2 ...................... 56
Engine management system, 5-Cyl. Turbo 1:2............ 58
Engine management system Diesel, 4-Cyl. 1.6l 1:2 .... 60
Engine management system Diesel, 4-Cyl. 2.0l 1:2 .... 62
Engine management system Diesel, 4-Cyl. 2.0l
MPS6 1:2 ..................................................................... 64
Engine management system Diesel, 5-Cyl. 2.4l 1:3 .... 66
Emission control 4-Cyl. 1.6l ......................................... 69
Emission control, 4-Cyl. 1.8l & 2.0l .............................. 70
Emission control 5-Cyl. ................................................ 71
Emission control 5-Cyl. Turbo...................................... 72
Group 26 Cooling system
Cooling fan................................................................... 73
Group 27 Engine controls
Cruise control 4-Cyl. .....................................................74
Cruise control 5-Cyl. .....................................................75
Start/stop function.........................................................76
Group 32 Alternator and voltage regulator
Power supply 4-Cyl. ..................................................... 77
Power supply 5-Cyl. ..................................................... 78
Group 33 Starting system
Starting system 4-Cyl................................................... 79
Starting system 5-Cyl................................................... 80
Group 35 Lighting
High and low beam ...................................................... 81
Active headlights, (Dual Xenon) S40/V50.................... 82
High and low beam, (Dual Xenon) C30/C70................ 83
Running/Parking lights, Tail lights S40/V50................. 84
Running/Parking lights, Tail lights (Dual Xenon)
S40/V50 ....................................................................... 85
Running/Parking lights, Tail lights C30/C70................. 86
Running/Parking lights, Tail lights (Dual Xenon)
C30/C70....................................................................... 87
Brake lights S40/V50 ................................................... 88
Brake lights C30/C70................................................... 89
Reversing lights S40/V50............................................. 90
Reversing lights C30/C70 ............................................ 91
Fog lights S40/V50 ...................................................... 92
Fog lights C30/C70 ...................................................... 93
Fog lights LHD Japan S40/V50.................................... 94
Fog lights LHD Japan C30/C70 ................................... 95
Follow-me-home lighting.............................................. 96
Interior lighting C30/S40/V50 1:2................................. 97
Interior lighting C70 1:2................................................ 99
Instrument and control illumination ............................ 101
Auxiliary lights............................................................ 102
Table of Contents 1:3

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 4
Group 36 Additional electrical equipment
Direction indicators and hazard warning flashers
S40/V50..................................................................... 103
Direction indicators and hazard warning flashers
(Dual Xenon) S40/V50............................................... 104
Direction indicators and hazard warning flashers
C30/C70..................................................................... 105
Direction indicators and hazard warning flashers
(Dual Xenon) C30/C70 .............................................. 106
Wiper/washer windshield........................................... 107
Washer headlights..................................................... 108
Wiper/washer rear window C30/V50 ......................... 109
Rain sensor................................................................ 110
Keyless vehicle C30/S40/V50 1:2.............................. 111
Keyless vehicle C70 1:2 ............................................ 113
Parking assistance..................................................... 115
Immobilizer/Steering column lock module (SCL)....... 116
Horn ...................................................................... 117
Anti-theft alarm C30................................................... 118
Anti-theft alarm S40/V50............................................ 119
Anti-theft alarm C70................................................... 120
Alcolock ..................................................................... 121
Accessory Electronic Module (AEM) C30.................. 122
Accessory Electronic Module (AEM),
S40/V50/C70 ............................................................ 123
Group 37 Wiring and fuses
12V outlet C30/S40/V50 ............................................ 124
12V outlet, C70.......................................................... 125
Diagnostics system.................................................... 126
Cable harness towbar/tow hitch 4-pin S40/V50......... 127
Cable harness towbar/tow hitch 4-pin C30/C70 ........ 128
Cable harness towbar/tow hitch 7-pin S40/V50......... 129
Cable harness towbar/tow hitch 7-pin C30/C70 ........ 130
Cable harness towbar/tow hitch 13-pin
S40/V50/C70 ............................................................. 131
Cable harness towbar/tow hitch 13-pin C30 .............. 132
USB unit (AUU).......................................................... 133
Group 38 Instruments
Driver information module.......................................... 134
Seat belt reminder C30/S40/V50 ............................... 135
Seat belt reminder C70.............................................. 136
Group 39 Other
Audio C30/S40/V50 ................................................... 137
Audio C70.................................................................. 138
Audio High Performance/Premium Sound
C30/S40/V50 1:2 ....................................................... 139
Audio High Performance/Premium Sound C70 1:2 ... 141
Cellular phone 1:2...................................................... 143
Multimedia & Traffic information ................................ 145
Satellite radio ............................................................. 146
Subwoofer.................................................................. 147
Portable navigation system........................................ 148
Bluetooth.................................................................... 149
Bluetooth Handsfree, internal amplifier...................... 150
Bluetooth Handsfree, external amplifier..................... 151
Bluetooth Handsfree & AUU, internal amplifier.......... 152
Bluetooth Handsfree & AUU, external amplifier......... 153
Bluetooth Handsfree with AEM, internal amplifier,
LHD ...................................................................... 154
Bluetooth Handsfree with AEM, internal amplifier,
RHD ...................................................................... 155
Bluetooth Handsfree with AEM, external amplifier,
LHD ...................................................................... 156
Bluetooth Handsfree with AEM, external amplifier,
RHD ...................................................................... 157
Group 43 Transmission
Automatic transmission AW55-51.............................. 158
Transmission M66...................................................... 159
Automatic transmission MPS6................................... 160
Differential Electronic Module (DEM) S40/V50 .......... 161
Group 59 Brake system
Brake control system & STC...................................... 162
Brake control system & DSTC ................................... 163
Group 64 Steering
Speed dependent power steering .............................. 164
Group 83 Doors and openings
Central locking front doors C30/S40/V50................... 165
Central locking rear doors S40/V50........................... 166
Central locking C70.................................................... 167
Central locking trunk lid/tailgate C30 ......................... 168
Central locking trunk lid/tailgate S40/V50 .................. 169
Central locking trunk lid/tailgate C70 ......................... 170
Central locking storage compartment C70................. 171
Child safety lock S40/V50.......................................... 172
Central locking fuel filler flap...................................... 173
Signal receiver central locking C30/S40/V50............. 174
Signal receiver central locking C70............................ 175
Power windows front doors C30/S40/V50 ................. 176
Power windows C70 .................................................. 177
Power windows rear doors S40/V50.......................... 178
Power sunroof C30/S40/V50 ..................................... 179
Power roof C70.......................................................... 180
Table of Contents 2:3

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 5
Group 84 Exterior decorative elements, etc.
Power door mirrors C30/S40/V50.............................. 181
Power door mirrors C70............................................. 182
Heated door mirrors................................................... 183
Rear window defroster............................................... 184
Blind spot information system.................................... 185
Group 85 Interior equipment
Power driver’s seat with memory function LHD
S40/V50..................................................................... 186
Power driver’s seat with memory function RHD
S40/V50..................................................................... 187
Power driver’s seat with memory function LHD
C30/C70..................................................................... 188
Power driver’s seat with memory function RHD
C30/C70..................................................................... 189
Power passenger seat with memory function LHD
C30/C70..................................................................... 190
Power passenger seat with memory function RHD
C30/C70..................................................................... 191
Power driver’s seat LHD S40/V50 ............................. 192
Power driver’s seat RHD S40/V50............................. 193
Power passenger seat LHD S40/V50 ........................ 194
Power passenger seat RHD S40/V50........................ 195
Heated seats.............................................................. 196
Group 87 Climate control system
Climate control system, 4-Cyl. Gasoline 1:2 .............. 197
Climate control system, Diesel 1.6l & 2.0l 1:2............ 199
Climate control system, 5-Cyl. 1:2 ............................. 201
Climate control system PTC-elements....................... 203
Parking heater, auxiliary heater ................................. 204
Relay, electric engine heater ..................................... 205
Electric engine heater Flexifuel.................................. 206
Group 88 Internal equipment
Supplemental restraint system C30/S40/V50 1:2 ...... 207
Supplemental restraint system C70 1:2..................... 209
Remote controlled garage door opening.................... 211
Rear-view mirror with automatic dimming.................. 212
Index 1:2 ....................................................213
List of components 1:6 ............................215
3:3Table of Contents

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 6
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 59 = Brake system
Group 64 = Steering
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Designations ignition switch
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E=Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N=Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Accessories
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
AWD = All wheel drive
CAN = CAN communication
D = Diesel
DPY = Display
ECC = Electronic climate control system
ETA = Throttle unit
EXT. X = Extended X-feed
GDL = Gas discharge lamp
HISPEED = High speed data bus
IR = Infrared sensor
LIN = LIN communication
LHD = Left-hand drive
LOSPEED = Low speed data bus
MAN = Manual transmission
MEMORY = Memory driver’s seat
MMS = Mass Movement Sensor
PETROL = Gasoline
RHD = Right-hand drive
SCR = Screened
SRS = Airbag
T = Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow
Explanations
Abbreviations

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 7
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
63 Branching point
64 Connector
B. Branching points
The wiring diagrams contain numbered junction
points, e.g. 63/352.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the
"Connectors" section.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN and MOST networks that
transfer information. Connections to these networks
are not shown in their entirety in the respective wir-
ing diagram. Complete information on CAN and
MOST communication is found in the section "Con-
trol modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 8
How to use the wiring diagrams 2:2
Explanation of symbols
= System voltage
= Ground connection via wiring
= Ground connection in compo-
nent/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN
H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution
box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in com-
ponent

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 9
Electrical distribution 1:2
Overview
F
D
ABC
1
F36
F34
F35
F33
F32
3
2
5
1
3
2
5
5
3
12
35
12
F10
F17
F14
BK-WH
GN-BU
2/32
R14
2/133
R3
R13
2/35
R10
2/82
F12
F13
F9
RD-OG
RD
RD-OG
RD-GN
RD-OG
RD-OG
15/31
6/25
50
31
M
ACM
30
B:1
6/26
B+
31
G
B:1
A:1
RD
RD
12V BK
31/3
1/1
BK
31/4
PF2 PF1
RD
RD-OG
40
14
39
64/90=15/31A
64/91
7/51:6
8/84:1
6/114:1
64/90=
15/31A
11
4
BK-RD
GY
64/90=15/31A
41
12
21
BK-BU
GN-BU
GN-BU
GN-YE GN-YE
GN-YE
GN-OG
GN-YE
GN-BU
GN-YE
BK-YE
WH-BU
BK-RD
I4
I5
BK-RD
2
11
2
35
63/13
GN-YE
GN-YE
5 cyl
I4 Diesel
64/90=
15/31A
31
GN-BU
64/113
6
GN-BU
6
LIN
R12
2/14
F6 2
1
5
3
1
2
16
G030184

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 10
Electrical distribution 2:2
Overview
RD-WH
RD-BK
RD-GN
RD-OG
RD-BU
RD-OG
RD-BU
2
1
3
5
3
1
5
2
3
1
5
2
2
5
3
1
CAN
CEM
4/56
LIN
BK-YE
G:11
C
G:18
E:29
E:9
E:30
3/1
30
15X
5
50 S
B:7
A:42 A:15 A:30 A:17
B:5 B:2
B:1
B:3
GY-BK RD-GN YE GN-WH
64/111
5
G:9
E:22
E:23
E:20
E:21
RD-YE
RD-BU
RD-WH
RD-OG
RD
RD
BK-BU
2/182
R9
2/34
R4
2/22
R11
R2
2/17
F20
F26
F3
F30
F31
F2
F16
F23
F4
F18
F27
F29
F11
F8
F7
F1
F5
F21
F28
F22
F15
A
RD-OG
BK-WH
F
GN-BU
15/31
WH-BK
R5
F24
BK-RD
13
64/90=15/31A
RD
WH-BK
BK BK BK
GN-WH
OG-BU
23
64/90=15/31A
64/90=15/31A
RD
RD-WH
RD-WH
S40/V50
C70
RD 13
17
64/90=15/31A
BK-YE
18
GN-YE
BK-RD
B
64/861
1
RD
D
16/10
63/121
63/231
63/120
16/11
GN-WH 10/5:1
10/6:1
GN-YE 6/104:1
35
12
2/142
64/113
7
31/114
I4
G030186

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 11
Fuses
Engine compartment distribution box F1-F7
15/31 Distribution box in engine compartment
No. Fuse function via A
F1 4/71 Cooling fan control module - 50
F2 6/71 Electrical power steering module (EPS) - 80
F3 2/193 Relay, comfort functions
4/56 Central electronic module (CEM)
F45 Fuse in the Central Electronic Module (CEM)
F48-F49 Fuses in the Central Electronic Module (CEM)
F60-F61 Fuses in the Central Electronic Module (CEM)
F62-F63 Fuses in the Central Electronic Module (CEM)
F68-F69 Fuses in the Central Electronic Module (CEM)
F80 Fuse in the Central Electronic Module (CEM)
F84-F85 Fuses in the Central Electronic Module (CEM)
-
2/193
2/193
2/193
2/193
-
2/193
2/193
-
60
F4 2/63 Relay, high beam
4/56 Central electronic module (CEM)
F55 Fuses in the Central Electronic Module (CEM)
F58-F59 Fuses in the Central Electronic Module (CEM)
F74 Fuses in the Central Electronic Module (CEM)
F77 Fuses in the Central Electronic Module (CEM)
-
-
-
2/63
-
-
60
F5 9/41 PTC-element - 80
F6 4/109 Glow plug control module (GCU), 5-Cyl. Diesel - 70
20/23-26 Glow plug, 4-Cyl. Diesel 2/14 60
F7 4/16 Brake Control Module (BCM), pump - 30
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 12
Fuses
Distribution box in engine compartment F8-F16
15/31 Distribution box in engine compartment
No. Fuse function via A
F8 4/16 Brake Control Module (BCM), valves - 20
F9 2/32 Main relay, engine management system
F32-F36 Fuses in the engine compartment distribution box
-
2/32
30
F10 4/31 Fan control module - 40
F11 2/182 Relay, headlight washer motor
4/59 Convertible Roof Module (CRM), C70
6/104 Pump, high pressure headlight washer
-
-
2/182
20
F12 2/82 Relay, heated rear window
9/2 Rear window defroster
-
2/82, 16/141
30
F13 6/25 Starter motor 2/35 30
F14 4/110 Trailer module (TRM) - 40
F15 4/59 Convertible Roof Module (CRM), C70 30
F16 2/159 Infotainment relay, S40/V50/C30
16/105 Audio module (AUD), S40/V50/C30
F22 Fuse, engine compartment distribution box, S40/V50/C30
F43 Fuse in the Central Electronic Module (CEM), S40/V50/C30
F64 Fuse in the Central Electronic Module (CEM), S40/V50/C30
F65-F67 Fuses in the Central Electronic Module (CEM), S40/V50/C30
-
-
-
-
-
2/159
30
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 13
Fuses
Distribution box in engine compartment F17-F25
15/31 Distribution box in engine compartment
No. Fuse function via A
F17 6/1 Wiper motor module (WMM) - 30
F18 2/80 Relay, reversing light
2/89 Relay, interior lighting
4/56 Central electronic module (CEM)
F46-F47 Fuses in the Central Electronic Module (CEM)
F56-F57 Fuses in the Central Electronic Module (CEM)
F79 Fuse in the Central Electronic Module (CEM)
F81-F83 Fuses in the Central Electronic Module (CEM)
F86 Fuse in the Central Electronic Module (CEM)
-
-
-
2/89
-
2/80
-
2/89
40
F20 2/17 Relay, horn
16/10 Horn 1
16/11 Horn 2
-
2/17
2/17
15
F21 4/7 Combustion preheater module (CPM) - 20
F22 16/79 Subwoofer module (SUB) - 25
F23 4/28 Transmission Control Module (TCM), MPS6 - 15
4/28 Transmission Control Module (TCM), 5-Cyl. - 10
4/46 Engine Control Module (ECM), 5-Cyl. -
F24 9/32 PTC resistor, crankcase ventilation, 5-Cyl. Diesel
9/38 Heated fuel filter, 5-Cyl. Diesel
2/142
2/142
20
F25 4/56 Central Electronic Module (CEM), 1.6l Diesel - 10
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 14
Fuses
Distribution box in engine compartment F26-F32
15/31 Distribution box in engine compartment
No. Fuse function via A
F26 2/35 Relay, starter motor
3/1 Start control module (SCU)
4/56 Central electronic module (CEM)
F44 Fuse in the Central Electronic Module (CEM)
F51-F54 Fuses in the Central Electronic Module (CEM)
F73 Fuse in the Central Electronic Module (CEM)
3/1
-
3/1
3/1
3/1
3/1
15
F27 8/3 Electromagnetic clutch, climate control system 2/22 10
F29 2/34 Relay, front fog lights
10/5 Fog light, front left
10/6 Fog light, front right
-
2/34
2/34
15
F30 4/46 Engine Control Module (ECM), 2.0l Diesel, 1.6l Gasoline - 3
6/73 Coolant pump, 1.6l Diesel 2/239 10
F31 6/26 Alternator, 4-Cyl. - 10
F32 2/14 Relay, glow plug system
6/143 Regulator motor, Turbo
7/15 Front heated oxygen sensor, 4-Cyl.
7/17 Mass air flow sensor (MAF), 5-Cyl. Diesel
7/82 Rear heated oxygen sensor, 4-Cyl.
8/6-8/10 Injection valves, 5-Cyl.
8/121 Coolant valve, 2.0l Diesel
8/122 Bypass valve, intercooler, 1.6l Diesel
-
-
-
-
-
-
-
-
10
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 15
Fuses
Distribution box in engine compartment F33-F34
15/31 Distribution box in engine compartment
No. Fuse function via A
F33 2/133 Relay vacuum pump
4/46 Engine control module (ECM), 5-Cyl. Diesel
6/114 Vacuum pump, 5-Cyl.
7/15 Front heated oxygen sensor, 5-Cyl.
7/82 Rear heated oxygen sensor, 5-Cyl. Turbo
7/186 Heated oxygen sensor, rear, 5-Cyl. without Turbo
7/187 Heated oxygen sensor, center, 5-Cyl. without Turbo
8/84 Switch, vacuum pump
9/32 PTC resistor, crankcase ventilation, 2.0l. Diesel
9/38 Heated fuel filter, 4-Cyl. Diesel
-
-
2/133
-
-
-
-
-
-
-
20
F34 2/35 Relay starter motor, 1.6l Diesel
2/242 Relay isolator battery, 1.6l Diesel
2/243 Relay isolator secondary battery, 1.6l Diesel
2/239 Relay coolant pump, 1.6l Diesel
4/46 Engine control module (ECM), 1.6l Diesel
4/109 Glow plug control module (GCU), 5-Cyl. Diesel
8/6-8/9 Injection valves, 1.6l.
8/77 Fuel volume control valve, 2.0l Diesel
8/111 Fuel flow control valve, 1.6l Diesel
8/119 Pressure monitor, climate control system, 5-Cyl.
8/120 EGR valve, 5-Cyl. Diesel
8/133 Control valve fuel pressure
20/3 -20/7 Spark plug and ignition coil
20/17 Transformer, ignition coils, 1.6l
-
-
-
-
-
-
-
-
-
-
-
-
-
-
10
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 16
Fuses
Engine compartment distribution box F35-FH1
15/31 Distribution box in engine compartment
No. Fuse function via A
F35 2/22 Relay, climate control system
4/46 Engine control module (ECM), 5-Cyl. Diesel
6/67 Fuel leakage control pump, 5-Cyl.
6/99 EGR motor, 1.6l Diesel, 1.8l Gasoline
7/17 Mass air flow sensor (MAF), 5-Cyl. Gasoline, 4-Cyl. Diesel
7/192 Water detection sensor, 4-Cyl. Diesel
8/6-8/9 Injection valves, 1.8l.
8/18 EVAP valve, Gasoline
8/19 Solenoid, variable valve timing, intake, 5-Cyl. Gasoline
8/28 Turbocharger control valve, 2.5l Turbo
8/45 Vacuum valve, variable intake manifold, 1.8l
8/65 Pressure switch, power steering, 1.6l
8/77 Fuel volume control valve, 2.0l Diesel
8/81 Solenoid, variable valve timing, exhaust, 2.5l Turbo
8/82 Solenoid, variable turbo geometry, 4-Cyl. Diesel
8/114 Valve, air/fuel mixing, 1.8l
8/132 Control valve, intake, 2.0l Diesel
9/32 PTC resistor, crankcase ventilation 5-Cyl. Gasoline
-
-
2/22
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
F36 4/46 Engine control module (ECM)
7/15 Front heated oxygen sensor, 5-Cyl. Diesel
7/51 Accelerator pedal sensor
-
-
-
10
FH1 10/65 Auxiliary lights, front right
10/69 Auxiliary lights, front left
2/64
2/64
20

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 17
Fuses
Main fuse box battery
15/34 Main fuse box battery
No. Fuse function via A
11M/1 6/26 Alternator
15/31 Distribution box in engine compartment
2/242
-
125
11M/2 7/240 Sensor battery monitoring - 15

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 18
Fuses
Fuse holder midi
15/37 Fuse holder midi
No. Fuse function via A
Cable fuse by secondary battery - 70
Cable fuse in distribution box in engine compartment - 70

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 19
Fuses
Central Electronic Module (CEM) F43-F48
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F43 4/124 Accessory USB unit (AUU)
16/1 Integrated Audio Module (IAM)
16/46 RTI Display
16/60 Phone module (PHM)
16/108 Multimedia module (MMM)
16/147 Bluetooth phone module (BPM)
17/42 USB-port
-
-
-
-
-
-
15
F44 4/46 Engine Control Module (ECM), 5-Cyl.
4/9 Supplemental restraint system module (SRS)
-
-
10
F45 9/1 Front 12V outlet
9/25 Rear 12V outlet
-
-
15
F46 3/111 Switch unit, lights
5/1 Driver Information Module (DIM)
10/1 Lamp housing, front left
10/2 Lamp housing, front right
10/29 Glove compartment lighting
10/97 Courtesy lighting, left
10/102 Courtesy lighting, right
Alcolock
-
-
-
-
-
-
-
-
5
F47 4/76 Remote control unit for garage door opener
10/22 Ceiling light
10/150 Rear reading light
10/114 Vanity mirror lighting, left, not C70
10/115 Vanity mirror lighting, right
-
-
-
-
-
5
F48 2/16 Relay, rear window wiper
2/92 Relay, windshield washer motor
2/93 Relay, rear window washer motor
6/2 Washer pump
6/32 Rear window wiper motor
-
-
-
2/92
2/16
15
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 20
Fuses
Central Electronic Module (CEM) F49-F61
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F49 4/9 Supplemental restraint system module (SRS)
7/93 Occupant Weight Sensor (OWS), USA/CDN
-
-
10
F51 2/142 Fuel filter preheater relay
4/82 Differential electronic module (DEM)
9/41 PTC-element
-
-
-
10
F52 4/16 Brake control module (BCM)
4/28 Transmission control module (TCM)
-
-
5
F53 6/71 Electrical power steering module (EPS) - 10
F54 4/46 Engine Control Module (ECM), 5-Cyl.
4/86 Parking assistance module (PAM)
4/112 Gas Discharge Lamp Module (GDL), master, left
4/113 Gas Discharge Lamp Module (GDL), slave, right
4/114 Headlamp Control Module (HCM)
10/1 Lamp housing, front left
10/2 Lamp housing, front right
-
-
-
-
-
-
-
10
F55 4/93 Keyless vehicle module (KVM) - 20
F56 4/119 Remote Keyless Entry (RKE)/Remote Receiver Module (RRX)
16/35 Siren control module (SCM)
-
-
10
F57 3/9 Contact brake light
17/13 Data link connector
-
-
15
F58 2/64 Relay auxiliary lights
4/113 Gas Discharge Lamp Module (GDL), slave, right
10/2 Lamp housing, front right
3/60
-
-
7.5
F59 4/112 Gas Discharge Lamp Module (GDL), master, left
10/1 Lamp housing, front left
-
-
7.5
F60 9/12 Seat Heating Module (SHM), driver’s side - 15
F61 9/13 Seat Heating Module (SHM), passenger side - 15
continues