Volvo XC70 2012 Quick start guide

WIRING DIAGRAM 2012
VOLVO XC70 (08-) & S80 (07-)
TP 39217202

© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Fuse in cargo compartment auxiliary fuse box.
Changes introduced up to and including structure week 11w20
Any changes made to the vehicle after this date are not included in the manual. If necessary,
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagrams (EWD) can be ordered from the Technical Information Shop (TIS)
at www.volvocarstechinfo.ford.com
We retain the right to make modifications

TP 39217202 XC70(08-) & S80(07-) 2012 3
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable curtain) ..................................................... 2
Explanations .................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Electrical distribution
Overview without Start/stop function ............................ 9
Overview with Start/stop function ................................ 10
Overview, Distribution box in engine compartment ..... 11
Overview, Distribution box in passenger
compartment................................................................ 12
Overview, Distribution box in cargo compartment ....... 13
Fuses
Distribution box in engine compartment F1-F7............. 14
Distribution box in engine compartment F8-F21........... 15
Distribution box in engine compartment F22-F31......... 16
Distribution box in engine compartment F32-F37......... 17
Distribution box in engine compartment F38 ................ 18
Distribution box in engine compartment F38-F39......... 19
Distribution box in engine compartment F39-F44......... 20
Central electronic module (CEM) F1-F3....................... 21
Central electronic module (CEM) F4-F19..................... 22
Central electronic module (CEM) F20-F24................... 23
Passenger compartment............................................... 24
Distribution box in passenger compartment F1 - F17... 25
Distribution box in passenger compartment
F18 - F22 ...................................................................... 26
Distribution box in passenger compartment
F25 - F30 ...................................................................... 27
Distribution box in cargo compartment FA1-FA11........ 28
Distribution box in engine compartment, cold zone ...... 29
Battery PF1-PF2........................................................... 30
Relays
Relays in the engine compartment .............................. 31
Relays in passenger compartment .............................. 32
Relays in cargo compartment ...................................... 33
Central Electronic Module (CEM) ................................ 34
Ground connections
Overview...................................................................... 35
31/1 - 31/6 ................................................................... 36
31/7 - 31/10 ................................................................. 37
31/15 - 31/47 ............................................................... 38
31/48 - 31/68 ............................................................... 39
31/83 - 31/88 ............................................................... 40
31/89 - 31/107 ............................................................. 41
31/117 - 31/TRM.......................................................... 42
31/INFOT - 31/AL ........................................................ 43
Control modules
Overview locations....................................................... 44
Overview designations................................................. 45
Central Electronic Module (CEM) 1:3 .......................... 46
Data communication high speed CAN......................... 49
Data communication high speed CAN, 4-Cyl............... 50
Data communication intermediate speed CAN, LHD... 51
Data communication intermediate speed CAN, RHD .. 52
Data communication, LIN 1:2....................................... 53
Data communication MOST......................................... 55
Steering Wheel Module (SWM) ................................... 56
Group 26 Cooling system
Cooling fan 4-Cyl. Turbo.............................................. 57
Cooling fan, 5-Cyl. Turbo & 6-Cyl. ............................... 58
Cooling fan, 4-Cyl. Diesel ............................................ 59
Cooling fan, 5-Cyl. Diesel ............................................ 60
Group 27 Engine controls
Cruise control 4-Cyl. Turbo...........................................61
Cruise control 4-Cyl. Diesel ..........................................62
Cruise control 5-Cyl. & 6-Cyl.........................................63
Cruise control 5-Cyl. Diesel ..........................................64
Start-/Stop function 4-Cyl. 1.6l Turbo............................65
Start-/Stop function 4-Cyl. 1.6l Diesel DV6C ................66
Start-/Stop function 5-Cyl. 1.6l Diesel VED5.................67
Group 28 Ignition and control system
Engine management system B4164T 1:2.................... 68
Engine management system B4204T6, T7 1:2............ 70
Engine management system B5254T10 1:2................ 72
Engine management system D4162T 1:3.................... 74
Engine management system D5244T11, T15, T17 &
D5204T3 1:3 ................................................................ 77
Engine management system B6324S4 1:2.................. 80
Engine management system B6324S5 1:2.................. 82
Engine management system B6304T4 1:2.................. 84
Emission control, 4-Cyl. 1.6l & 2.0l .............................. 86
Emission control 5-Cyl. Turbo...................................... 87
Emission control 6-Cyl. ................................................ 88
Group 32 Alternator and voltage regulator
Power supply 4-Cyl. Turbo........................................... 89
Power supply 4-Cyl. with start/stop.............................. 90
Power supply 5-Cyl. & 6-Cyl. ....................................... 91
Table of Contents 1:3

TP 39217202 XC70(08-) & S80(07-) 2012 4
Group 33 Starting system
Starting system 4-Cyl. Turbo ....................................... 92
Starting system 5- & 6-Cyl........................................... 93
Starting system 4-Cyl. Diesel....................................... 94
Starting system 5-Cyl. Diesel....................................... 95
Group 35 Lighting
High and low beam...................................................... 96
High and low beam (Dual Xenon)................................ 97
Beam length adjustment, manual ................................ 98
Running/Parking light, Tail lights V70.......................... 99
Running/Parking light, Tail lights S80........................ 100
Running/Parking light, Tail lights (Dual Xenon) V70.. 101
Running/Parking light, Tail lights (Dual Xenon) S80.. 102
Fog lights V70............................................................ 103
Fog lights S80............................................................ 104
Brake lights V70......................................................... 105
Brake lights S80......................................................... 106
Reversing lights V70.................................................. 107
Reversing lights S80.................................................. 108
Follow-me-home lighting LHD ................................... 109
Follow-me-home lighting RHD................................... 110
Interior lighting, LHD 1:2 ............................................ 111
Interior lighting, RHD 1:2 ........................................... 113
Active headlight ......................................................... 115
Lighting in door sill trims ............................................ 116
Auxiliary lights............................................................ 117
Lighting mug holder and floor .................................... 118
Group 36 Additional electrical equipment
Rain sensor................................................................ 119
Direction indicator and hazard warning flashers
LHD V70 .................................................................... 120
Direction indicator and hazard warning flashers
LHD S80 .................................................................... 121
Direction indicator and hazard warning flashers
RHD V70.................................................................... 122
Direction indicator and hazard warning flashers
RHD S80.................................................................... 123
Wiper/washer windshield........................................... 124
High pressure headlight washer ................................ 125
Wiper/Washer rear window........................................ 126
Keyless vehicle 1:2.................................................... 127
Horn............................................................................ 129
Anti-theft alarm .......................................................... 130
Parking assistance..................................................... 131
Collision warning with power brake booster .............. 132
Tire pressure monitoring system (TPMS) .................. 133
Alcohol lock................................................................ 134
Group 37 Wiring and fuses
Diagnostics system .................................................... 135
Outlet 12 V................................................................. 136
Cable harness towbar/tow hitch 4-pin V70 ................ 137
Cable harness towbar/tow hitch 4-pin S80 ............... 138
Cable harness towbar/tow hitch 7-pin V70 ................ 139
Cable harness towbar/tow hitch 7-pin S80 ................ 140
Cable harness towbar/tow hitch 13-pin V70 .............. 141
Cable harness towbar/tow hitch 13-pin S80 .............. 142
Accessory USB unit (AUU) ........................................ 143
Group 38 Instruments
Seat belt reminder ..................................................... 144
Driver information module.......................................... 145
Analog clock .............................................................. 146
Group 39 Other
Cellular phone 1:2...................................................... 147
Audio 1:2.................................................................... 149
Audio Premium 1:3 .................................................... 151
DAB Radio ................................................................. 154
Telephone system Bluetooth ..................................... 155
Bluetooth Handsfree .................................................. 156
Rear seat entertainment ............................................ 157
Satellite radio ............................................................. 158
Parking camera.......................................................... 159
Navigation system, portable....................................... 160
TV ...............................................................................161
Group 43 Transmission
Transmission M66 & MMT 6...................................... 162
Automatic transmission, TF-80SC AWD.................... 163
Automatic transmission MPS6................................... 164
Automatic transmission AWF21................................. 165
Differential Electronic Module (DEM)......................... 166
Group 55 Parking brake
Electric parking brake ................................................ 167
Group 59 Brake system
Brake control system & DSTC ................................... 168
Group 64 Steering
Speed dependent power steering .............................. 169
Table of Contents 2:3

TP 39217202 XC70(08-) & S80(07-) 2012 5
Group 76 Shock absorbers
Four-C ...................................................................... 170
Group 83 Doors and openings
Central locking front doors LHD................................. 171
Central locking front doors RHD................................ 172
Central locking rear doors.......................................... 173
Central locking trunk lid/tailgate V70 ......................... 174
Central locking trunk lid/tailgate S80 ......................... 175
Central locking fuel filler flap...................................... 176
Signal receiver central locking................................... 177
Power windows front doors LHD ............................... 178
Power windows front doors RHD............................... 179
Power windows rear doors ........................................ 180
Power sunroof............................................................ 181
Group 84 Exterior decorative elements, etc.
Power door mirrors LHD............................................ 182
Power door mirrors RHD ........................................... 183
Heated door mirrors LHD........................................... 184
Heated door mirrors RHD .......................................... 185
Blind spot information system LHD............................ 186
Blind spot information system RHD ........................... 187
Heated rear window................................................... 188
Group 85 Interior equipment
Power driver’s seat with memory function, LHD ........ 189
Power driver’s seat with memory function, RHD ....... 190
Power passenger seat, LHD...................................... 191
Power passenger seat, RHD ..................................... 192
Heated front seats with fans ...................................... 193
Heated front seats without fans ................................. 194
Heated rear seat........................................................ 195
Massage seats........................................................... 196
Group 87 Climate control system
Climate control system PTC-elements ...................... 197
Climate control system, 4-Cyl. Turbo 1:2................... 198
Climate control system 4-Cyl. Diesel 1:2................... 200
Climate control system 5- & 6-Cyl. 1:2 ...................... 202
Parking heater, auxiliary heater................................. 204
Parking heater, remote start ...................................... 205
Refrigeration box rear seat ........................................ 206
Group 88 Internal equipment
Rear-view mirror with automatic dimming.................. 207
Supplemental restraint system 1:2 ............................ 208
Power folding headrest.............................................. 210
Remote control garage opening ................................ 211
Group 89 Body other
Radiator masking blind .............................................. 212
Connectors............................................... 213
Branching points .....................................248
Cable harness routing in vehicle
Harness engine 4-Cyl. Turbo ......................................266
Engine harness, 5-Cyl.................................................266
Engine harness, 6-Cyl.................................................267
Harness engine, 6-Cyl. Turbo .....................................267
Harness engine, 2.0l Diesel ........................................268
Harness engine, 2.4l Diesel ........................................268
Engine compartment harness LHD.............................269
Engine compartment harness RHD ............................270
Harness dashboard, LHD ...........................................271
Harness Dashboard, RHD ..........................................272
Harness Floor, LHD S80.............................................273
Harness Floor, RHD S80 ............................................274
Harness Floor, LHD V70.............................................275
Harness Floor, RHD V70 ............................................276
Harness infotainment, LHD S80 .................................277
Harness infotainment, RHD S80.................................278
Harness infotainment, LHD V70 .................................279
Harness infotainment, RHD V70.................................280
Roof harness, S80 ......................................................281
Roof harness, V70 ......................................................281
Center console harness..............................................282
Tunnel harness ...........................................................282
Harness front door, left ...............................................283
Harness front door, right .............................................283
Harness rear door, left ................................................284
Harness rear door, right..............................................284
Trunk lid/tailgate harness, S80 ...................................285
Trunk lid/tailgate harness, V70 ...................................285
Harnesses rear axle....................................................286
Executive harnesses...................................................287
Component illustrations ..........................288
Index 1:2 ....................................................349
List of components 1:7 ............................351
Table of Contents 3:3

TP 39217202 XC70(08-) & S80(07-) 2012 6
Explanations
Abbreviations
Groups
Group 26 = Cooling system
Group 27 = Engine controls
Group 28 = Ignition and control system
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Group 89 = Body other
Ignition switch symbols
X = Accessories (audio position)
S= Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D= Germany
DK = Denmark
E= Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J= Japan
KOR = Korea
N= Norway
NL = Netherlands
S= Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
Du-X = Dual Xenon
ECC = Electronic climate control system
ETA = Throttle unit
EXC = Exclusive
GDL = Gas discharge lamp
HISPEED = High speed data bus
IR = Infrared sensor
KEYLESS = Keyless vehicle
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIDSPEED = Midspeed data bus
MMS = Mass Movement Sensor
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SCR = Screened
SRS = Airbag
T= Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow

TP 39217202 XC70(08-) & S80(07-) 2012 7
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
The systems are shown in non active
status, i.e. with “key removed” and when
doors, hatches and hood are closed.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4Control module
5 Driver information module
6 Electric motor
7Sensor
8 Actuator
9Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the "Connectors" sec-
tion.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these net-
works are not shown in their entirety in the respec-
tive wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the sec-
tion "Control modules".
F. A b b r ev i a t io n s
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Co mp on e n t l o c at io n
The end of the manual contains a section that
describes component appearance and location in
numerical order.

TP 39217202 XC70(08-) & S80(07-) 2012 8
How to use the wiring diagrams 2:2
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box
= Further connection to...
= Connector between cable har-
nesses
= Connector connected in compo-
nent

TP 39217202 XC70(08-) & S80(07-) 2012 9
15/36
R1
2/88
21
3
5
R4
2/193
2
1
3
5
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
21
3
5
2/82
15/32
RA2
21
3
5
A
RA1
RD-GN RD-GN
RD-GN
RD-VT
RD-VT
73/5075
2/16
74/504B
2
R7
2/31
2
1
35
11A/3
12
11A/2
12
11A/1
12
11A/4
12
11A/5
12
11B/17
RD
12
12
15/31
11B/27 CAN
CEM
4/56
C1:63
C1:13
C5:1
C5:2
LIN
C2:5
C2:17
C1:9
I05246
12 12 12 12 12
GY-BK
RD-BU RD-BK
GN-VT
RD-GN
RD-BN
RD-GY
RD-GN
74/504 14
VT-GN
VT-GN
BU
12V BK
31/3
1/1
RD 21
PF1
Electrical distribution Overview without Start/stop function

TP 39217202 XC70(08-) & S80(07-) 2012 10
15/36
R1
2/88
21
3
5
R4
2/193
2
1
3
5
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
21
3
5
2/82
15/32
RA2
21
3
5
A
RA1
RD-GN RD-GN
RD-GN
RD-VT
RD-VT
73/5075
2/16
74/504B
2
R7
2/31
11A/3
12
11A/2
12
11A/1
12
11A/4
1211A/5 12
11B/17
RD
12
12
15/31
11B/27
CAN
CEM
4/56
C1:63
C1:13
C5:1
C5:2
LIN
C2:5
C2:17
C1:9
I013546
12 12 12 12 12
GY-BK
RD-BU RD-BK GN-VT
RD-GN
RD-BN
RD-GY
RD-GN
74/504 14
VT-GN
VT-GN
BU
21 21 21 21 21 21
11A/8
21
2
1
35
15/37
R2
2/246
2
1
2
121
3
5
21
3
5
11A/7
2
1
2
1
11B/12
2
1
21
2
1
R1
2/166
11A/6
MF1
F10
11A/2
MF2
M11
11A/1
11A/4 11A/5 11A/3
11A/9
12V BK
31/131
1/2
RD
74/301
27
74/504
3
74/316 4
RD
RD
RD
RD
12V BK
31/3
1/1
RD 21
PF1
21
PF4
Electrical distribution Overview with Start/stop function

TP 39217202 XC70(08-) & S80(07-) 2012 11
Electrical distribution
Overview, Distribution box in engine compartment
15/31
11B/36
21
11B/37
21
11B/38
21
11B/41 11B/18 12
11B/16 12
11B/17
73/3068
73/3085 12
11B/19 12
11B/20 12
11B/21 12
11B/22 12
11B/23 12
11B/28 12
11B/29 12
YE-GN
RD
RD
RD
RD
GY-BK
RD
RD
GN-VT
RD-BK
RD-BU
RD-GN
RD-GY
RD-BN 15/36
15/36
15/32
4/56C5:2
4/56C5:1
RD
RD
RD
4/46B:16
6 CYL
RD
RD
RD
RD
RD
RD
RD
RD
GY-VT
GY-VT
GY-VT
GY-VT
RD
RD-BK
RD
11B/27 12
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
12
11A/7
12
12
12
12
12
12
21
11B/40
21
11B/39
21
11A/43
21
11A/42
21
11A/44
21
11B/33
21
11B/32
21
11B/31
21
11B/30
21
11B/35
21
11B/34
21
21
3
52/22
R13
R10
2
1
35
2/31
R7
21
3
52/32
21
3
52/35
R12
11B/13
11B/11
11B/9
11B/12
11B/10
12
11B/14 12
12
12
12
12
11B/8 12
9/42
4/56C1:13
4/56C1:63
RD
RD-VT
RD
2/142 R11
Diesel
2/133 R11
4 Cyl. T
4 Cyl. T &
4 Cyl. T
4 Cyl. T
5 Cyl. D
5 Cyl. D
BU-OG
GN-OG
GN-OG
BU-OG
YE-GN
74/301
16
I012211
2
1
35
2/17
R8
2
1
35
2/182
R9
RD-VT
RD
RD RD
73/3160
A
74/316
2
STOSTA
STOSTA
STOSTA
STOSTA
RD-BU
RD-BU
RD-BU
RD-BU
30+

TP 39217202 XC70(08-) & S80(07-) 2012 12
Electrical distribution
Overview, Distribution box in passenger compartment
2
1
35
4
R2
R1
2/88
2
1
35
4
R3
2
1
3
5
R4
2/193
21
3
5
11C/3 12
11C/2 12
11C/1 12
11C/4 12
11C/7 12
11C/6 12
11C/5 12
11C/8 12
11C/10 12
11C/9 12
11C/11 12
11C/14 12
11C/13 12
11C/12 12
11C/15 12
11C/18 12
11C/17 12
11C/19 12
11C/25 12
11C/24 12
11C/23 12
11C/22 12
11C/21 12
11C/16 12
11C/20 12
11C/27
12
11C/26
12
12
11C/28
12
11C/29
12
11C/30
RD
RD
RD
RD
RD
73/5117
15/36
RD-BN
RD-GY
I012227
15/31
11A/5
12
11A/4
12
30+
15/37
11A/3
12
11A/4
12RD-GY
RD-BN
STOSTA STOSTA

TP 39217202 XC70(08-) & S80(07-) 2012 13
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
21
3
5
2/82
15/32
RA2
21
3
5
A
RA1
RD-GN
RD-GN
RD-GN
RD-GN
RD-VT
RD-VT
73/5075
2/16
3
74/504B
RD-GN
30+
2
I012220
Electrical distribution
Overview, Distribution box in cargo compartment

TP 39217202 XC70(08-) & S80(07-) 2012 14
Fuses
Distribution box in engine compartment F1-F7
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F1 11A/1 4/56 Central Electronic Module (CEM)
10/2 Lamp housing, front right
F7 Fuse in the Central Electronic Module (CEM)
F9-F11 Fuses in the Central Electronic Module (CEM)
F21 Fuse in the Central Electronic Module (CEM)
F23 Fuse in the Central Electronic Module (CEM)
-
relay in CEM
relay in CEM
relay in CEM
relay in CEM
relay in CEM
50
F2 11A/2 4/56 Central Electronic Module (CEM)
10/1 Lamp housing, front left
F3-F6 Fuses in the Central Electronic Module (CEM)
F8 Fuse in the Central Electronic Module (CEM)
F13-F16 Fuses in the Central Electronic Module (CEM)
F22 Fuse in the Central Electronic Module (CEM)
F24 Fuse in the Central Electronic Module (CEM)
-
relay in CEM
relay in CEM
relay in CEM
-
-
-
50
F3 11A/3 11D/A1-11D/A11 Fuses in distribution box cargo compartment - 60
F4 11A/4 2/193 Relay, comfort functions
11C/1 Fuse in distribution box passenger compartment
11C/7-11C/15 Fuses in distribution box passenger compartment
11C/21-11C/22 Fuses in distribution box passenger compartment
11D/A5 Fuses in distribution box cargo compartment
-
-
-
2/193
-
60
F5 11A/5 2/88 Relay, 15-feed
11C/23-11C/24 Fuses in distribution box passenger compartment
11C/26-11C/30 Fuses in distribution box passenger compartment
-
2/88
2/88
60
F7 11A/7 9/42 PTC-element - 100
continues

TP 39217202 XC70(08-) & S80(07-) 2012 15
Fuses
Distribution box in engine compartment F8-F21
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F8 11B/8 2/182 Relay, headlight washer motor
6/104 Washer motor headlights
-
2/182
20
F9 11B/9 6/1 Wiper Motor Module (WMM) - 30
F10 11B/10 4/7 Combustion Preheater Module (CPM)
4/106 Control module, remote parking heater start
-
-
25
F11 11B/11 4/31 Passenger compartment fan control module
6/28 Motor, passenger compartment fan
-
-
40
F13 11B/13 4/16 Brake Control Module (BCM), pump - 40
F14 11B/14 4/16 Brake Control Module (BCM), valves - 20
F16 11B/16 10/1 Lamp housing, front left
10/2 Lamp housing, front right
-
-
10
F17 11B/17 4/56 Central Electronic Module (CEM)
F18-F19 Fuses in the Central Electronic Module (CEM)
-20
F18 11B/18 4/16 Brake Control Module (BCM) - 5
F19 11B/19 4/99 Speed dependent power steering control module - 5
F20 11B/20 4/28 Transmission Control Module (TCM)
4/28B Transmission Control Module (TCM) MPS6
4/46 Engine Control Module (ECM)
4/9 Supplemental restraint system module (SRS)
-
-
-
-
10
F21 11B/21 9/43 Heated windshield washer nozzle, left
9/44 Heated windshield washer nozzle, right
-
-
10
continues

TP 39217202 XC70(08-) & S80(07-) 2012 16
Fuses
Distribution box in engine compartment F22-F31
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F22 11B/22 2/14 Relay, glow plug system
6/114 Vacuum pump, 5-Cyl. Turbo
-
2/133
5
F23 11B/23 3/111 Light Switch Module (LSM) - 5
F27 11B/27 2/31 Relay, 15-feed - 5
F28 11B/28 2/64 Relay, auxiliary lights
10/65 Auxiliary light, front right
10/69 Auxiliary light, front left
-
2/64
2/64
20
F29 11B/29 2/17 Relay, horn
16/10 Horn 1
16/11 Horn 2
-
2/17
2/17
15
F30 11B/30 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM)
-
-
10
F31 11B/31 4/28 Transmission Control Module (TCM) - 15
continues

TP 39217202 XC70(08-) & S80(07-) 2012 17
Fuses
Distribution box in engine compartment F32-F37
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F32 11B/32 8/3 Electromagnetic clutch, climate control system 2/22 15
F33 11B/33 2/22 Relay, climate control system
2/239 Relay coolant pump.
-
-
5
F34 11B/34 6/25 Starter motor
4/46 Engine Control Module (ECM)
2/35
2/35
30
F35 11B/35 4/109 Glow plug control module
8/82 Injector
8/111 Control valve fuel flow
20/3-8 Spark plug with ignition coil, 5- & 6-Cyl.
20/16 Capacitor 6-Cyl.
-
-
-
-
-
20
4/109 Control module glow plug, 5-Cyl. Diesel
20/3-6 Spark plug with ignition coil, 4-Cyl.
-
-
10
F36 11B/36 4/46 Engine Control Module (ECM), 4-, 5-, 6-Cyl.
6/120 Throttle unit
-
4/46
10
4/46 Engine Control Module (ECM), 5-Cyl. Diesel
6/120 Throttle unit, 5-Cyl. Diesel
-
4/46
15
F37 11B/37 4/46 Engine Control Module (ECM), 6-Cyl.
8/6-11 Injection valves
8/98 Control valve fuel pressure, Diesel
8/111 Control valve fuel flow, 5-Cyl. Diesel
8/115 Injector
8/116 Injector
7/17 Mass airflow sensor (MAF)
-
-
-
-
-
-
-
15
continues

TP 39217202 XC70(08-) & S80(07-) 2012 18
Fuses
Distribution box in engine compartment F38
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 8/18 EVAP valve, 4-Cyl.
8/45 Vacuum valve variable intake manifold, 4-Cyl.
8/114 Valve mixing air/fuel, 4-Cyl.
-
-
-
10
7/17 Mass air flow sensor MAF, 4-Cyl. Turbo
8/18 EVAP valve, 4-Cyl. Turbo
8/19 Solenoid, variable valve timing, intake, 4-Cyl. Turbo
8/81 Solenoid, variable valve timing, exhaust, 4-Cyl. Turbo
-
-
-
-
8/77 Control valve, fuel volume, 4-Cyl. 2.0l Diesel -
8/3 Electromagnetic clutch climate control system, 5-Cyl. Turbo.
8/28 Turbocharger control valve, 5 & 6-Cyl. Turbo.
8/68 Relief valve, 6-Cyl. Turbo
8/81 Solenoid, variable valve timing, exhaust, 5-Cyl. Turbo.
8/117 Solenoid, variable valve timing, intake, 5-Cyl. Turbo.
-
-
-
-
-
7/35 Oil level sensor, 5-Cyl. Diesel
8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel
8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel
8/120 EGR valve, 5-Cyl. Diesel
8/122 Bypass valve, intercooler, Diesel
8/157 Turbocharger control valve, Diesel, 2T
-
-
-
-
-
-
continues

TP 39217202 XC70(08-) & S80(07-) 2012 19
Fuses
Distribution box in engine compartment F38-F39
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 4/46 Engine Control Module (ECM), 6-Cyl.
6/139 Upper actuator motor, intake manifold, 6-Cyl. W/O T
6/140 Lower actuator motor, intake manifold, 6-Cyl. W/O T
8/3 Electromagnetic clutch climate control system, 6-Cyl.
8/117 Solenoid, variable valve timing, intake, 6-Cyl.
8/125 Solenoid cam profile front, 6-Cyl. W/O T
8/126 Solenoid cam profile rear, 6-Cyl. W/O T
-
-
-
-
-
-
-
10
4/46 Engine Control Module (ECM)
8/3 Electromagnetic clutch, climate control system
8/19 Solenoid, variable valve timing intake bank 2
8/81 Solenoid, variable valve timing exhaust bank 2
8/117 Solenoid, variable valve timing intake bank 1
8/118 Solenoid, variable valve timing exhaust bank 1
-
-
-
-
-
-
F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl.
7/82 Rear heated oxygen sensor, 4-Cyl. Turbo
-
-
10
7/15 Front heated oxygen sensor, 5-Cyl. Diesel -
7/15 Front heated oxygen sensor, 5-Cyl. Turbo.
7/103 Rear heated oxygen sensor, 5-Cyl. Turbo.
8/18 EVAP valve, 5-Cyl. Turbo.
-
-
-
15
continues

TP 39217202 XC70(08-) & S80(07-) 2012 20
Fuses
Distribution box in engine compartment F39-F44
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F39 11B/39 7/15 Front oxygen sensor, bank 1, 6-Cyl.
7/82 Rear oxygen sensor, bank 1, 6-Cyl.
7/103 Front heated oxygen sensor bank 2, 6-Cyl. W/O T
7/104 Rear heated oxygen sensor bank 2, 6-Cyl. W/O T
8/18 EVAP valve, 6-Cyl.
-
-
-
-
-
15
7/15 Front heated oxygen sensor bank 2
7/82 Front heated oxygen sensor bank 1
7/103 Rear oxygen sensor bank 2
7/104 Rear oxygen sensor bank1
8/18 EVAP valve.
8/107 Variable intake valve
-
-
-
-
-
-
F40 11B/40 2/133 Relay vacuum pump
2/142 Relay pre-heater fuel filter, 5-Cyl. Diesel
2/239 Relay coolant pump
6/114 Vacuum pump, 4-Cyl. Turbo & 5-Cyl. Turbo
9/32 PTC resistor crankcase ventilation, 5-Cyl. Turbo
9/38 Heated fuel filter, 5-Cyl. Diesel
-
-
-
2/142
20
6/73 Coolant pump 2/239 10
F41 11B/41 6/67 Pump fuel leakage control 6-Cyl.
6/179 Electric transmission oil pump
7/200 Sensor, coolant temperature
9/32 PTC-resistor, crankcase ventilation 5 Cyl. Diesel
-5
F42 11A/42 20/22-26 Glow plug, 5-Cyl. 4/109 70
F43 11A/43 4/71 Cooling fan control module, 5-Cyl. Diesel, 6-Cyl.
4/71 Control module, cooling fan, 4-Cyl., 5-Cyl.
-
-
80
60
F44 11A/44 - --