Weber GENESIS 320 User manual

Assembly - Pg. 9
#59753
PLACE STICKER HERE
59753 09/01/11 LP
EN - INTERNATIONAL ENGLISH
0845BQ-0033
0845
Register your grill online at www.weber.com®
GAS GRILL
LP Gas Grill Owner’s Guide
YOU MUST READ THIS OWNER’S GUIDE
BEFORE OPERATING YOUR GAS GRILL.
mDANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odour continues, keep away from the
appliance and immediately call your gas
supplier or your fire service.
Leaking gas may cause a fire or explosion,
which can cause serious bodily injury or
death, or damage to property.
mWARNING
1. Do not store or use petrol or other
flammable vapours and liquids in the
vicinity of this or any other appliance.
2. A gas supply cylinder not connected for
use should not be stored in the vicinity
of this or any other appliance.
mWARNING: Follow all leak-check
procedures carefully in this manual
before operating barbecue. Do this even
if barbecue was dealer-assembled.
mWARNING: Do not ignite this appliance
without first reading the BURNER
IGNITION sections of this manual.
INFORMATION FOR THE INSTALLER:
This manual must remain with the owner,
who should keep it for future use.
OUTDOOR USE ONLY.

2
WARNINGS
m DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or
death, or in a fire or an explosion causing damage to property.
m WARNINGS
m Follow regulator connection instructions for your type of
gas grill.
m Do not store a spare or disconnected gas supply cylinder
under or near this barbecue.
m Do not put a barbecue cover or anything flammable on or in
the storage area under the barbecue.
m Improper assembly may be dangerous. Please carefully
follow the assembly instructions in this manual.
m After a period of storage and/or non-use, the Weber Gas
Barbecue should be checked for gas leaks and burner
obstructions before use. See instructions in this manual for
correct procedures.
m Do not use a flame to check for gas leaks.
m Do not operate your Weber®gas barbecue if there are any
leaking gas connections.
m Flammable materials should not be present within
approximately 60 cm of the back or sides of the barbecue.
m Your Weber®gas barbecue should not be used by children.
Accessible parts of the barbecue may be very hot. Keep
young children away while it is in use.
m Exercise caution when using your Weber®gas barbecue. It
will be hot during cooking or cleaning, and should never be
left unattended, or moved while in operation.
m If the burners should go out during cooking, turn off all gas
valves. Open the lid and wait five minutes before attempting
to re-light the gas flame, while observing the ignition
instructions.
m Do not use charcoal, briquettes or lava rock in your Weber®
gas barbecue.
m While cooking, never lean over the open barbecue or place
hands or fingers on the front edge of the cookbox.
m Should an uncontrolled flare-up occur, move food away
from the flames until flaring subsides.
m Should a grease fire occur, turn off all burners and leave lid
closed until fire is out.
m The Weber®gas barbecue should be cleaned thoroughly at
regular intervals.
m When cleaning valves or burners do not enlarge orifices or
ports.
m Liquid propane gas is not natural gas. The conversion or
attempted use of natural gas in a LP gas unit is dangerous
and will void your warranty.
m A dented or rusty gas supply cylinder may be hazardous
and should be checked by your gas supplier. Do not use a
gas supply cylinder with a damaged valve.
m Even though your gas supply cylinder may appear to be
empty, it might still contain gas. The cylinder should be
transported and stored accordingly.
m Under no circumstances should you attempt to disconnect
the gas regulator or any gas fitting while your barbecue is in
operation.
m Use heat-resistant barbecue mittens or gloves when
operating barbecue.
m Do not use this barbecue unless all parts are in place.
The unit must be properly assembled according to the
instructions outlined in the assembly instructions.
m When changing gas container, stay away from ignition
sources.
m Do not build this model of grill in any built-in or slide in
construction. Ignoring this warning could cause a fire or
an explosion that can damage property and cause serious
bodily injury or death

WWW.WEbER.cOm®3
TAbLE OF cONTENTS
WARNINGS ..........................................2
TAbLE OF cONTENTS .................................3
EXPLODED VIEW - Q300 ...............................4
EXPLODED VIEW LIST - Q300 ..........................5
EXPLODED VIEW - Q320 ...............................6
EXPLODED VIEW LIST - Q320 ..........................7
PARTS LIST .........................................8
ASSEmbLY ..........................................9
WARRANTY ........................................22
GENERAL INSTRUcTIONS ............................23
OPERATING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
STORAGE AND/OR NON-USE ......................................23
GAS INSTRUcTIONS .................................24
IMPORTANT LP CYLINDER INFORMATION ...........................24
SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS .........24
CONNECTING THE LIQUID PROPANE CYLINDER......................25
CHECK FOR GAS LEAKS..........................................26
REFILLING THE LIQUID PROPANE CYLINDER.........................28
RECONNECT THE LIQUID PROPANE CYLINDER ......................28
bEFORE USING THE bARbEcUE .......................29
CATCH PAN AND DISPOSABLE DRIP PAN ............................29
HOSE INSPECTION ..............................................29
IGNITER INSPECTION FOR MODELS WITH ELECTRONIC IGNITION ......29
IGNITION & USAGE ..................................30
IGNITION .......................................................30
TO EXTINGUISH .................................................30
MANUAL IGNITION ...............................................31
TO EXTINGUISH .................................................31
GRILLING TIPS & HELPFUL HINTS .....................32
PREHEATING THE BARBECUE .....................................32
COOKING METHODS .............................................32
GRILLING BASICS ...............................................32
TROUbLESHOOTING ................................33
HANDLE LIGHT TROUbLESHOOTING - Q320 .............33
mAINTENANcE .....................................34
CLEANING......................................................34
WEBER®SPIDER/INSECT SCREENS ................................34
BURNER TUBE CLEANING OR REPLACEMENT .......................35
PUSH-BUTTON IGNITION SYSTEM OPERATIONS ......................36
ELECTRONIC IGNITION SYSTEM OPERATIONS .......................36
ELECTRONIC IGNITION SYSTEM REPLACEMENT .....................36
ANNUAL MAINTENANCE ..........................................37
mEmO .............................................38

4
EXPLODED VIEW - Q300
1
2
3
4
5
6
7
8
9
11
12
13
15
14
16
17
18
19
20
22
23
24
25
26
27
10
Q300_EURO_LP_082511
21
Q300

WWW.WEbER.cOm®5
EXPLODED VIEW LIST - Q300
1. Swing-Up Work Table
2. Thermometer Assembly
3. Handle Assembly
4. Cooking Grate
5. Wire Brace
6. Outside Burner Tube
7. Inside Burner Tube
8. Electrode Assembly
9. Front Cradle Frame
10. Igniter
11. Large Control Knob
12. Small Control Knob
13. Disposable Drip Pan
14. Catch Pan
15. Left Leg
16. Tank Skirt
1 7. Bottom Rack
18. Lid
19. Rear Cradle Frame
20. Cookbox
21. Valve & Manifold - Regulator Assembly
(Hose and Regulator may not be included)
22. Bridge Piece
23. Right Leg
24. Wheel Cover
25. Hubcap
26. Wheel
2 7. Axle

6
EXPLODED VIEW - Q320
Q320
1
2
5
6
7
8
9
10
12
11
13
14
15
16
18
19
20
21
22
23
24
25
26
27
28
29
Q320_EURO_LP_081711
17
4
3

WWW.WEbER.cOm®7
EXPLODED VIEW LIST - Q320
1. Swing-Up Work Table
2. Thermometer Assembly
3. Handle Light Assembly
4. Handle Assembly
5. Cooking Grate
6. Wire Brace
7. Outside Burner Tube
8. Inside Burner Tube
9. Electrode Assembly
10. Front Cradle Frame
11. Ignition Button/ Ignition Module
12. Large Control Knob
13. Small Control Knob
14. Disposable Drip Pan
15. Catch Pan
16. Left Leg
1 7. Tank Skirt
18. Bottom Rack
19. Lid
20. Warming Rack
21. Rear Cradle Frame
22. Cookbox
23. Valve & Manifold - Regulator Assembly
(Hose and Regulator
may not be included)
24. Bridge Piece
25. Right Leg
26. Wheel Cover
2 7. Hubcap
28. Wheel
29. Axle

8
PARTS LIST
2-
1-
Q320
TOOLS NEEDED:
2- ¼-20 x 2¼"
PAN HEAD
PHILLIPS SCREW
12- ¼-20 x 1"
TRUSS HEAD
PHILLIPS SCREW
(BLACK)
WOOD BLOCK

WWW.WEbER.cOm®9
ASSEmbLY
12-

10
ASSEmbLY
2mPlace wheel frame on the right.
Ignition instruction sticker faces forward.

WWW.WEbER.cOm®11
ASSEmbLY
38-

12
ASSEmbLY
4

WWW.WEbER.cOm®13
5
ASSEmbLY

14
ASSEmbLY
64-
7

WWW.WEbER.cOm®15
ASSEmbLY
9
82-
1-

16
ASSEmbLY
A) Uncoil the hose and regulator of the Weber®Q™ 300/320.
B) Remove leg screw and secure hose and retention clip (1) to cart leg.
mWARNING: The hose must be secured to the cart
leg by the hose retention clip. Failure to do so
could cause damage to hose resulting in a fire or
explosion, which can cause serious bodily injury
or death and damage to property.
10
11
1

WWW.WEbER.cOm®17
ASSEmbLY
12 1 2
3

18
ASSEmbLY
13
1 2
3 4

WWW.WEbER.cOm®19
2-
ASSEmbLY
14
Q300
2-
Q320
You may hear a rattle in lightpod. This is normal.

20
ASSEmbLY
1
15 3- Q320
The Weber Q Grill Out™Handle Light has a “Tilt Sensor”:
Lid up - ON / Lid Closed - OFF. The power button (1) activates or
deactivates the “Tilt Sensor.” For daytime use, deactivate the sensor by
pressing power button (1).
Requires 3 “AAA” alkaline batteries (not included).
Use alkaline batteries only. Do not mix old and new batteries or different
types of batteries (standard, alkaline or rechargeable). If you do not plan
to use the Weber Q Grill Out™Handle Light for a month or more, remove
the batteries.