Whirlpool 3RLGR5437KQ1 User manual

TOP AND CONSOLE PARTS
1
For Model: 3RLGR5437KQ1
(Designer White)
05−04 Litho in U.S.A. (djc) Part No. 8180025
27"GAS DRYER

TOP AND CONSOLE PARTS
2
For Model: 3RLGR5437KQ1
(Designer White)
8180025
Illus. Part
No. No. DESCRIPTION
1 Literature Parts
LIT8299808 Wiring Diagram
LIT8318343 Guide, Use & Care
LIT8528096 Instructions, Installation
LIT8315975 Guide, User &
Installation (UK)
Following May Be Purchased
DO−IT−YOURSELF
REPAIR MANUALS
LIT677818 Manual, Do−It−
Yourself Repair
(Dryer)
2 8317305 Panel, Rear Console
3 8299770 Timer
4 8317342 Cover,
Terminal Block
5 3395382 Switch,
Push−To−Start
7 693995 Screw, 8−18 x 3/8
8 8271363 Cap, End (R.H.)
9 8271316 Bracket, Control
10 3390646 Screw, 8−18 x 5/16
12 388326 Screw, Console
13 3399638 Switch, Temperature
14 3391018 Tie, Cable
15 8271339 Knob, Control
16 3397269 Connector, Timer
17 717252 Receptacle, 2−Way
18 3403499 Connector,
2−Position
(Gas Valve)
19 8529869 Harness, Wiring
20 8312687 Timer Knob
Assembly
21 8271341 Knob,
Push−To−Start
22 8318255 Strap, Console
23 357213 Nut, Push−In (2)
24 8271399 Top
26 8271369 Cap, End (L.H.)
27 3936144 Connector
28 3403498 Connector,
3−Position
(Gas Valve)
31 8318382 Panel, Control
32 8283293 Wire, Jumper Assembly
33 3398893 Wire, Ground
35 3390647 Screw, 8−18 x 1/2
36 98139 Screw, 8−32 x 5/16
37 357572 Clip, Grounding
40 8283170 Resistor, Assembly
41 3394427 Clip, Harness
44 94614 Terminal
50 3347243 Connector, 6−Circuit

CABINET PARTS
3
For Model: 3RLGR5437KQ1
(Designer White)
8180025

CABINET PARTS
4
OPTIONAL PARTS (NOT INCLUDED)
For Model: 3RLGR5437KQ1
(Designer White)
8180025
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
2 98139 Screw, 8−32 x 5/16
3 694091 Screw, 8−18 x 3/8
4 3394331 Plate, Cover
5 8318457 Switch, Broken
Belt
6 3400000 Screw, 10−24 x 3/8
7 8310656 Cabinet
8 3392100 Foot, Dryer
279810 Foot − Optional
(Extended Length
Package Of 2)
(Not Included)
9 660658 Clamp, Motor (2)
10 3387374 Spring, Idler
11 3389420 Retainer, Idler
12 697750 Plug, Multivent
13 3388672 Pulley Assembly
14 697776 Screw, 10−32 x 5/8
15 3977633 Transformer
16 340025 Wire, Ground
17 3395532 Exhaust Pipe
& Bracket
18 233520 Washer, Thrust
19 3389249 Nut, Inner
Door (4)
20 690997 Tri Ring
21 3389247 Hinge & Pin
Assembly (2)
22 342055 Screw, 8−18 x 1/2
23 8066120 Lever, Snap
Switch
24 3394081 Wire, Belt Switch
25 49026 4" − 90 Elbow
26 3393657 Restrainer, Belt
27 3404470 Motor, Assembly
50 HZ.
28 3395534 Exhaust Pipe
(Short)
29 3402548 Pulley 50 HZ.
30 3387610 Belt, Drive
32 3387118 Bracket, Motor
33 3395535 Exhaust Pipe
(Long)
34 3388600 Clip, Lint Duct
35 3400934 Screw,
6−20 x 1 1/16
36 693995 Screw, 8−18 x 3/8
37 8318396 Seal, Foam
38 3390902 Clip, Door
Hinge (2)
39 3388674 Idler Bracket
40 297092 Clip (2)
41 3406109 Door Switch
Assembly
42 3397659 Block, Terminal
43 279318 Terminal, Brass
& Tinned (3)
Includes Illus. 45
44 3387242 Seal, Front Panel
45 279393 Terminal Block
Screw Kit ( For
Terminal Block)
46 3388229 Retainer
47 3392563 Door, Rear
48 697773 Screw, 6−20 x 7/8
49 3387872 Door, Front
51 8317373 Upper Front Panel
52 696144 Strike, Door
53 3977712 Cord, Power
54 8316063 Adapter,
Gas Inlet
56 694415 Clip, Strain
Relief
57 3390735 Seal, Door
58 3392538 Catch, Door
Assembly
60 3389522 Handle, Door
61 697215 Toe, Panel
Optional Parts Not Included
Dryer Exhaust Kit
(For Side & Bottom Venting)
62 279818 White
Illus. Part
No. No. DESCRIPTION
ACCESSORY PARTS
3406911 Dry Rack
4392067 Kit,
Dryer Repair
8522199 Kit, Dryer
Vent Testing
PAINT, TOUCH−UP (1/2oz.)
72017 White
PAINT, PRESSURIZED SPRAY
(12 oz.)
350930 White
350938 Primer, Gray
PAINT, BULK (1 qt.)
799344 White (Uncut)

BULKHEAD PARTS
5
For Model: 3RLGR5437KQ1
(Designer White)
8180025

BULKHEAD PARTS
6
For Model: 3RLGR5437KQ1
(Designer White)
8180025
Illus. Part
No. No. DESCRIPTION
1 3399508 Shaft, R.H. Thread
2 3390647 Screw, 8−18 x 1/2
3 90767 Screw, 8−18 x 3/8
4 3394986 Spring, Lint
Screen Door
5 3394346 Air Duct Assembly
6 697813 Seal, Outlet
Housing
7 697814 Seal, Drum Front
8 3359452 Nut,3/8 x 16(R.H.)
9 8066086 Drum Hole
Plug
10 3390646 Screw, 8−18 x 5/16
11 8318409 Exhaust Duct
(Corrugated)
12 696302 Shield, Exhaust
13 3387230 Screw, 10−16 x 3/4
14 3394984 Door, Lint
Screen
15 8318486 Exhaust Pipe
16 3387709 Nut, 3/8−16 (L.H.)
17 3387809 Bulkhead, Rear
18 3387459 Washer, Support
19 3399509 Shaft, L.H. Thread
20 690997 Ring, Tri
21 8536973 Roller, Support
22 487909 Screw, 8−15 x 1/2
23 3394985 Outlet Housing
Assembly
25 8528998 Complete Drum
Assembly
26 97787 Screw, 11−16 x 3/4
27 697694 Seal, Drum
30 3388229 Clip, Exhaust
37 697772 Wheel, Blower
42 3387137 Thermostat,
Internal Bias
43 3403140 Thermostat,
High−Limit 205 F
(96 C)
44 8541568 Housing, Blower
45 8530036 Lint Duct Assembly
46 8066047 Funnel, Burner
48 338906 Sensor, Radiant
51 3357011 Screw, 10−16 x 1/2
52 697771 Cover, Blower
(Includes Illus.
No. 62)
53 8528122 Baffle, Drum
54 697557 Bulkhead, Front
58 8299979 Grill, Outlet
59 3392519 Thermal Fuse
60 697770 Seal, Cover Plate
62 697769 Seal, Lint Duct
64 3390721 Lint, Screen

3402853 BURNER ASSEMBLY
7
For Model: 3RLGR5437KQ1
(Designer White)
8180025

Illus. Part
No. No. DESCRIPTION
3402853 BURNER ASSEMBLY
1 3402853 Burner Assembly
50 Hz.
(White Rodgers)
2 688617 Tube, Burner
3 694298 Bracket, Ignitor
4 686590 Ignitor
5 3393909 Screw & Washer
(8−32 x 5/8)
6 3351614 Screw, 10−24 x 3/8
7 3389871 Base, Burner
8 3387057 Screw, 8−18 x 3/8
9 Orifice, Burner
234660 Type 1
299372 (Butane)
10 8281918 Valve, Gas
50 Hz. (Complete)
11 694421 Screw,
8−32 x 1/2 (2)
12 694538 Bracket, Coil
13 695297 Coil, 50 Hz.
(2 Terminal)
(Main)
14 695298 Coil, 50 Hz.
(Split)
(3 Terminal)
(Pilot Position)
15 694424 Leak, Limiter
16 694423 Screw, Regulator
Adjustment
17 694422 Spring, Regulator
20 239822 Plug, Pipe
21 3387224 Pipe, Gas Supply
22 3406051 Elbow Union
Assembly
23 3393767 Pipe, Tail
24 233076 Nut, Compression
25 3387561 Clamp, Pipe
26 3389889 Bracket, Support
Following Parts Not Illustrated
279918 Conversion Kit
8
For Model: 3RLGR5437KQ1
(Designer White)
8180025