Whirlpool TK Pure 7B Di User manual

SERVICE Whirlpool EMEA
Customer Services TK Pure 7B Di
BAUKNECHT ServiceInformation
Condensation Dryer
TK Pure 7B Di
8560 798 03071
Last Modification: 03/20/08
Creation Date: 03/20/08
SparePartList 2
ExplodedView 4
TechnicalData 6
WiringDiagram 9
CircuitDiagram 11
Testprogram 13
ErrorCodes 14
ServiceBulletin481271340331 15
ServiceBulletin481271340300 16
ServiceBulletin481271340313 17
ServiceBulletin481271240301 19
ServiceBulletin481271340317 20
ServiceBulletin481271340336 21
ServiceBulletin481271340324 22
This document is only intended for qualified technicans who are aware of the
respective safety regulations.
Subject to modifications
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 2 of 23
SparePartList
Pos 12NC Description
004 0 481244011701 Bottom CD
011 0 481250018054 Foot adjustable
012 0 481252878033 Roll
012 1 481252898003 Shaft Front + Roll
012 2 481252028188 Shaft rear
021 0 481244010819 Front VBL GW
022 0 481244010821 Panel side GW
024 0 481244011569 Panel rear
030 0 481244011504 Table top short BK EBL
053 0 481244011155 Flap EBL WH
053 2 481241728103 Lock transmit. plinth EBL
053 4 481244011171 Plinth EBL WH
053 5 481241728102 Axle f.flap EBL
100 0 481244011705 Door transparent CD WH/BK
131 1 481227138354 Door lock system
133 2 481241728056 Lock Bag filter
191 0 481246668607 Gasket door
204 0 481246638014 Protector
220 0 481241818177 Drum cpl. SS
223 0 481241889017 Drum lifter GW
261 0 481241879821 Case f.water cont.
271 0 481235818164 BELT PV 1936 H6
273 0 481235818055 Pulley jokey
275 0 481249268129 Spring
291 0 481246668561 Gasket front
291 2 481246668837 Gasket drum rear
301 0 481245310691 Control panel + handle drawer
303 0 481249878682 Handle drawer galv.
331 0 481241458338 Knob timer
331 3 481241458307 Spring Knob timer
331 4 481241458345 Knob timer ring, silver
332 0 481251318197 Push button options
333 0 481251318196 Push button start
401 0 481236118532 Motor + fan wheel + clamp
401 1 481240118421 Clamp Motor
420 0 481212118144 Capacitor 10 mF
421 0 481212118284 Interf.filter
430 0 481236058212 Pump,draining cpl. IMS 12318002104
443 0 481236118537 Blower wheel
443 1 481236118518 Fan wheel with Clamp
443 2 481229088096 Clamp blower wheel, stainless
456 0 481225928895 Heat.elem. 1300W+1300W - 230V 1HAV0A4450
490 0 481232118042 Connect.cable 3m
490 0 481232118044 CABLE,MAINS 5M 4X1
490 1 481232128433 Strain relief + protect.
521 0 481221470748 Control unit TINY/DOMINO TB, Basic
521 0 481221470843 Control unit TINY/DOMINO BQ, progr.
620 0 481223958061 Module E1/7 Opt.
620 1 481223958063 Module humidity
631 0 481227138497 Microswitch f.pump/belt
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 3 of 23
Pos 12NC Description
631 1 481236018476 Floater
631 2 481236058093 O-Ring
633 0 481227618523 Switch door
633 1 481227618422 Pin Start reset GW
651 0 481213428056 Lamp drum light cpl.
651 1 481213418052 Lamp drum light
691 0 481225928863 Sensor temper.NTC
691 1 481228298014 Gasket NTC
692 0 481221058055 Bracket Sensor
692 1 481227858001 Sensor
692 2 481221058075 Cover Sensor, Kit
707 9 481253048165 Tube inflow
740 0 481251148417 Heat exchanger H2
741 0 481244008035 Blower cold air
741 1 481253048244 Cover blower house
743 0 481253048683 Air guide w/o Light/old Sensor ho.
743 1 481253049096 Heating chamber SS
743 3 481253048239 Cover blow.house
743 8 481246688519 Gasket f.blow.house
750 0 481241879823 Tank condensw.4.3l
750 1 481253028856 Water guide
751 1 481241888044 Water collector
751 2 481240118472 Clamp sump cover
751 3 481227118014 Cover water switch
761 0 481248058322 Filter; bag GW
781 0 481253028243 EVACUATION PIPE 1,5 m F I D UK ND SP
783 0 481253008003 Hose inflow bottom
783 1 481253008009 Hose reflow long
783 2 481253008001 Hose Pump bottom
794 0 481246688863 Gasket AC, Bottom
794 1 481246628108 Gasket heater channel
794 4 481246688521 Gasket filter
900 1 481229088053 Clip
900 2 481229088099 Clip for Heater
900 3 481240418529 Crossbar Control panel
903 0 481253228028 Clip fix
910 1 481250248347 Screw,selftap 3,5x14
910 8 481250248348 Screw ST 4,2x11
912 4 481250248015 Screw 4,0x16-TORX
922 0 481253258005 Ring circlip Triring
922 1 481253258007 Ring circlip
930 0 481249298039 Spring f.flap
950 0 481246648101 Felt,strip bottom group
950 1 481246688517 Gasket inlet bottom
952 3 481246688522 Gasket sensor wiring
962 0 481246638012 Protector Motor
962 2 481246638056 Foil Aluminium Display board
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 4 of 23
ExplodedView
©
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 5 of 23
ExplodedView
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 6 of 23
TechnicalData
Dimensions+Weight
Product dimensions
Height ................................................................................................85 cm
Width ...............................................................................................59.5 cm
Depth .................................................................................................60 cm
Weight
net ....................................................................................................40 kg
Electricalbasedata
Voltage ...........................................................................................230 V ±10%
Frequency ...............................................................................................50 Hz
Fuse ......................................................................................................16 A
Total connected load ...................................................................................2.49 kW
Surroundingstemperature
Room temperature .........................................max. .........................................35 °C
Room temperature ..........................................min. ..........................................5 °C
Capacityoflaundry
Cotton .....................................................................................................7 kg
Easy care ................................................................................................2.5 kg
Directdrainingoption
Max. allowable length ....................................................................................2.5 m
Max. height for drain outlet ...............................................................................1.0 m
Heatingelement
Nominal voltage ..........................................................................230 V + 10 % / - 15 %
Total power ..................................................................................2 x 1300 W ±5 %
Resistor NTC ..........................................1300 W ..........................................36 Ω
Resistor NTC ..........................................2600 W ..........................................18 Ω
Thermostatscondenser
Caracteristics of the NTC
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 7 of 23
0 °C 34.6 kΩ
25 °C 11.5 kΩ
60 °C 3.3 kΩ
70 °C 2.4 kΩ
95 °C 1.2 kΩ
100 °C 1.0 kΩ
110 °C 0.8 kΩ
130 °C 0.5 kΩ
180 °C 0.2 kΩ
Safety thermostat ............................................................................................TL
Switch off temperature .........................................................................190 °C ±5 K
Main-andblowermotor
Type ....................................................................................1-phase asynchronous
Nominal voltage ..........................................................................230 V + 10 % / - 15 %
Frequency ...........................................................................................50 ±3 Hz
Power Consumption .....................................................................................285 W
Resistor (coil)
Main coil ............................................(2 - 3) ............................................19 Ω
Auxiliary coil ..........................................(3 - 4) ..........................................18 Ω
Condensationpump
Type ......................................................................................1-phase synchronous
Nominal voltage ....................................................................220 - 240 V + 10 % / - 15 %
Frequency ...............................................................................................50 Hz
Resistance ...........................................(25 °C) ...........................................450 Ω
Power Consumption ..................................................................................14 ±2 W
Capacity (height 1.1m) .................................................................................2.6 l/min
Microswitch
Nominal voltage ..........................................................................230 V + 10 % / - 15 %
Frequency ............................................................................................50/60 Hz
Current ....................................................................................................16 A
Doorswitch
Nominal voltage ...........................................................................................12 V
Max. current .............................................................................................50 mA
Controlmodule
Type ............................................................................................TINY/DOMINO
Nominal voltage ..........................................................................230 V + 10 % / - 15 %
Frequency ............................................................................................50/60 Hz
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 8 of 23
Humiditymodule
Nominal voltage ...........................................................................................24 V
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 9 of 23
WiringDiagram
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 10 of 23
Legend
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 11 of 23
CircuitDiagram
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 12 of 23
Legend
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 13 of 23
Testprogram
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 14 of 23
ErrorCodes
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 15 of 23
ServiceBulletin481271340331
AUTHOR: Kay Augustin
LastUpdate: 03/01/11
VERSION: 1.0
TITLE: Opening of transparent door for Scirocco
SUBJECT:Customer complains about the opening of the transparent door during the cycle
REMEDIALACTION
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 16 of 23
ServiceBulletin481271340300
AUTHOR: Jürgen Reinhardt
LastUpdate: 06/02/08
VERSION: 1.2
TITLE: Insufficient Drying Performance Condensation Drier with dual coil heater 2x1300W, Tiny Domino Controls.
SUBJECT:
REMEDIALACTION
Upgrade of controls in production since week 12/2008. This modification is improving the performance in automatic drying
programs.Please re-program controls with SAM by using the latest data base version 62.
All Tinycontrols built before week 40 /2007 are not programmable bySAM, these controls must be replaced bynew
ones.
All concerned spare parts in the warehouse havebeen replaced bythe latest version of controls.Furthermore all the
service 12NC of Tiny controls built before week 40 / 2007 have been substituted as well.
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 17 of 23
ServiceBulletin481271340313
AUTHOR: Juergen Reinhardt
LastUpdate: 07/01/09
VERSION: 1.0
TITLE: Randomly does not start or does stop in programs "SYNTHETIC"or "TIMESTEERED 30min".
SUBJECT:Loose contact in program selector.
Condenser driers and air vented driers produced in week 43, 44, 45, 46 and 48 could be affected by this issue.
REMEDIALACTION
In case of an issue checkthe production date of the timer according to the pictures below.Only the supplier INVENSIS is
involved in this.The supplier AKO do not have an issue.
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 18 of 23
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 19 of 23
ServiceBulletin481271240301
AUTHOR: Ronny Schurricht
LastUpdate: 10/13/10
VERSION: 1.0
TITLE: Start Delay Indication
SUBJECT:Some customers are claiming that the StartDelayfunction is not working well. The machine seems to startone
hour earlier than expected. For example,at StartDelaytime 3hours the indication is switching from h:03 to h:02 after 1
minute.
REMEDIALACTION
The Start Delay function is working correct.
Reason for this behaviour is following:
If the start time is after 3h 00min it’s indicating h:03
If the start time is after 2h 59min it’s indicating h:02
If the start time is after 2h 00min it’s indicating h:02
If the start time is after 1h 59min it’s indicating h:01
If the start time is after 0h 59min it’s indicating :59
If the start time is after 0h 30min it’s indicating :30
www.mosogepszerviz.info

SERVICE Whirlpool EMEA
Customer Services
8560 798 03071, 03/20/08
page 20 of 23
ServiceBulletin481271340317
AUTHOR: Juergen Reinhardt
LastUpdate: 05/11/10
VERSION: 1.0
TITLE: Reset Procedure for F14 / FE failure
REMEDIALACTION
In case of shortage of the heating element or adisturbance due to welding of the heating relaythe following RESET proce-
dure must be always carried out:
Please follow the sequence below which must be performed within 10 seconds:
1) Turn the program selector in 6 o´clock position
2) Push "START"button three times
3) Turn program selector one position in clockwise direction (airing program)
4) Push "START"button three times
www.mosogepszerviz.info