Whirlpool AVM 510 User manual

SERVICE Whirlpool Europe
Customer Services AVM 510
This documentation is only intended for qualified technicians who are aware of the respec-
tive safety regulations.
Date: 07.04.1997 Subject to modification
Document-No.: 4812 714 11506
Model AVM 510
Version 8538 510 53221 Page
Introduction safety 2
Technical data 3 - 6
Spare part list 7
Exploded view 8
Wiring diagram 9 - 10
Service Manual
Microwave oven
AVM 510

SERVICE
07.04.1997 / Page 2 Whirlpool Europe
Doc. No: 4812 714 11506 Customer Service
Introduction safety
INTRODUCTION
Before leaving the factory each oven is carefully checked.
It must, however, be installed and used correctly.
Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact
the user understands how to use and maintain the oven.
The information in this section should be used as a reminder that the oven is safe and that anyone who uses it must
first read the instructions for use in order to be able to use the oven correctly and obtain best results.
SAFETY
To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.
Always disconnect the plug from the mains before starting work.
If there is no plug switch off the electric supply at the control box.
When you have finished servicing an oven before you reconnect it to the mains, make sure that:
- all the internal connections are correct
- the wires are insulated and not touching the door or the cabinet or anything sharp
- all the earth connections are electrically and mechanically sound
- do not modify or anyway interfere with the safety devices built-in to the oven
- make sure that each replacement part you use conforms to the manufacturer´s specifications
Do not start a repair if you have any doubt as to your ability to complete it.
CAUTION - MICROWAVE RADIATION
PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE MAGNETRON,
WAVEGUIDE OR ANTENNA IF THEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUT
AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE
AROUND MAGNETRON AND VISIBLE MICROWAVE CONNECTIONS (WELDING JOINTS).
Do not operate the oven if the following conditions exist:
- the door does not close firmly against the door support because of the door being warped or the hinges damaged.
- The door trims or seals are damaged.
- If there is any visible damage to the oven.
- if the door does not close properly.
Avoid operating the oven if known components in the interlock system, oven door or microwave
generating assembly are known defective. They must be replaced.
WARNING - HIGH VOLTAGE
IT IS POSSIBLE TO COME IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH
HV TRANSFORMER, HV CAPACITOR AND MAGNETRON. THEREFORE NEVER TRY TO MEASURE
THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING ELECTRIC
MEASUREMENTS INSIDE THE OVEN.

SERVICE Whirlpool Europe 07.04.1997 / Page 3
Customer Service Doc. No: 4812 714 11506
Technical data
Dimensions of cabinet
Height 298 mm
Width 492 mm
Depth 359 mm
Dimensions of cavity
Height 190 mm
Width 300 mm
Depth 300 mm
Cavity volume 22 l
Weight
Net 16,3 Kg
Packed 18,6 Kg
Electrical
Voltage 230 V
Power consumption 1330 W
Current consumption 6 A
Fuse 8 A
Power
Output power 850 W
Timer
Mechanical 60 min
Accessories
Glass tray, turntable ring

SERVICE
07.04.1997 / Page 4 Whirlpool Europe
Doc. No: 4812 714 11506 Customer Service

SERVICE Whirlpool Europe 07.04.1997 / Page 5
Customer Service Doc. No: 4812 714 11506

SERVICE
07.04.1997 / Page 6 Whirlpool Europe
Doc. No: 4812 714 11506 Customer Service

SERVICE Whirlpool Europe 07.04.1997 / Page 7
Customer Service Doc. No: 4812 714 11506

SERVICE
07.04.1997 / Page 8 Whirlpool Europe
Doc. No: 4812 714 11506 Customer Service

SERVICE Whirlpool Europe 07.04.1997 / Page 7
Customer Service Doc. No: 4812 714 11506
Spare part list
Model AVM 510
Service No. 853851053221
Version 853851053221
Pos. No. 12NC Code Description
001 1 4819 902 00031 Spacer
001 2 4819 902 00016 Lever
001 3 4819 902 00025 Spring,tension
002 0 4819 902 00172 Cabinet
002 2 4819 902 00082 Plate
002 3 4819 902 00049 Pin plastic
002 4 4819 902 00051 Bushing
013 0 4819 902 00115 Foot
013 1 4819 902 00055 Pin foot
013 2 4819 902 00056 Cap foot
041 0 4819 902 00007 Hinge,upper
042 0 4819 902 00008 Hinge,lower
042 1 4819 902 00317 Spacer
121 0 4819 902 00326 Door,inner
121 1 4819 902 00329 Door frame inner
130 0 4819 902 00228 Switchmechanism
131 2 4819 902 00014 Spring
131 3 4819 902 00328 Hook connector
131 4 4819 902 00037 Pivot
133 0 4819 902 00035 Lockingmechn.
133 1 4819 902 00036 Lockingmechn.
141 0 4819 902 00187 Oven glass outer
142 0 4819 902 00034 Foil door inner
143 0 4819 902 00198 Door frame outer
255 0 4819 902 00218 Turntable
264 0 4819 902 00192 Ring
264 1 4819 902 00042 Wheel
264 2 4819 902 00114 Shaft
320 0 4819 902 00277 Cover
332 0 4819 902 00279 Button,push
332 1 4819 902 00281 Spring,compres.
334 0 4819 902 00278 Knob timer
334 1 4819 902 00028 Bushing
404 0 4819 902 00063 Magnetron
406 0 4819 902 00316 Motor
406 1 4819 902 00179 Cover TT motor
406 2 4819 902 00003 Cover plate TT motor
406 3 4819 902 00272 Gasket
412 0 4819 902 00332 Transformer,HT 240V
412 1 4819 902 00322 Rubber spacer
412 2 4819 902 00029 Air guide
420 0 4819 902 00315 Capacitor
420 1 4819 902 00177 Support
421 0 4819 902 00319 Filter,mains
421 1 4819 902 00058 Support
423 0 4819 902 00216 Control unit
425 0 4819 902 00215 Resistor
426 0 4819 902 00122 Diode HVR-1X42B
426 1 4819 902 00209 Diode HVR-2x062HIA
442 0 4819 902 00321 Motor
442 1 4819 902 00178 Support
442 2 4819 902 00052 Bushing
442 3 4819 902 00019 Screw
443 0 4819 902 00044 Fan wheel (six blade)
485 2 4819 902 00047 Clip
Pos. No. 12NC Code Description
490 0 4819 902 00298 Cable,mains SAA Plug
503 0 4819 902 00073 Timer
561 0 4819 902 00071 Thermostat magnetron
562 0 4819 902 00426 Thermostat
617 0 4819 902 00214 Relay
617 1 4819 902 00094 Support
632 0 4819 902 00371 Switch
633 0 4819 902 00314 Switch
651 0 4819 902 00275 Lamp 240V/15W
651 1 4819 902 00219 Cover,lamp
652 0 4819 902 00079 Holder,lamp
901 0 4819 902 00197 Strain relief
971 0 4819 902 00217 Fuse
971 1 4819 902 00313 Clip
971 2 4819 902 00312 Holder fuse

SERVICE
07.04.1997 / Page 8 Whirlpool Europe
Doc. No: 4812 714 11506 Customer Service
Exploded view