Whirlpool MAX 18/AW User manual

SERVICE Whirlpool Europe
Customer Services
Model M AX 18/AW
Version 8538 018 99261 Page
Introduction safety 2
Technical data 3
Spare part list 4
Exploded view 5
Wiring diagram 6 - 7
Service Manual
M icrow ave oven
M AX 18/AW
M AX 18/AW
This documentation is only intended for qualified technicians w ho are aw are of the respec-
tive safety regulations.
Date: 01.09.2003 (M od. 01) Subject to modifi cation
Document-No.: 4812 714 14499
https://appliancetechmanuals.com

SERVICE
10.01.2003 / Page 2 M AX 18/AW Whirlpool Europe
Doc. No: 4812 714 14499 8538 018 99261 Customer Service
Introduction safety
INTRODUCTION
Before leaving the factory each oven is carefully checked.
It must, however, be installed and used correctly.
Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact
the user understands how to use and maintain the oven.
The information in this section should be used as a reminder that the oven is safe and that anyone who uses it must
first read the instructions for use in order to be able to use the oven correctly and obtain best results.
SAFETY
To avoid injury to yourself and damage to the appliance alw ays w ork to the follow ing rules w hen servicing an oven.
Alw ays disconnect the plug from the mains before starting work.
If there is no plug switch off the electric supply at the control box.
When you have finished servicing an oven before you reconnect it to the mains, make sure that:
- all the internal connections are correct
- the w ires are insulated and not touching the door or the cabinet or anything sharp
- all the earth connections are electrically and mechanically sound
- do not modify or anyway interfere with the safety devices built-in to the oven
- make sure that each replacement part you use conforms to the manufacturer´s specifications
Do not start a repair if you have any doubt as to your ability to complete it.
CAUTION - M ICROWAVE RADIATION
PERSONNEL SHOULD NOT BE EXPOSED TO THE M ICROWAVE ENERGY WHICH M AY RADIATE FROM THE M AGNETRON,
WAVEGUIDE OR ANTENNA IF THEY ARE IM PROPERLY USED OR CONNECTED. ALL INPUT
AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS M UST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A M ICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE M ICROWAVE LEAKAGE
AROUND M AGNETRON AND VISIBLE M ICROWAVE CONNECTIONS (WELDING JOINTS).
Do not operate the oven if the following conditions exist:
- the door does not close firmly against the door support because of the door being warped or the hinges damaged.
- The door trims or seals are damaged.
- If there is any visible damage to the oven.
- if the door does not close properly.
Avoid operating the oven if know n components in the interlock system, oven door or microw ave
generating assembly are know n defective. They must be replaced.
WARNING - HIGH VOLTAGE
IT IS POSSIBLE TO COM E IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH
HV TRANSFORMER, HV CAPACITOR AND M AGNETRON. THEREFORE NEVER TRY TO M EASURE
THE HIGH VOLTAGE. ALWAYS TAKE UTM OST CARE WHEN PERFORM ING ELECTRIC
M EASUREMENTS INSIDE THE OVEN.
https://appliancetechmanuals.com

SERVICE Whirlpool Europe M AX 18/AW 01.09.2003 (Mod. 01) / Page 3
Customer Service 8538 018 99261 Doc. No: 4812 714 14499
Technical data
Product dimensions
Height 356 mm
Width 392 mm
Depth 350 mm
Cavity dimensions
Height 149 mm
Width 290 mm
Depth 290 mm
Cavity volume 13 l
Turntable diameter 280 mm
Weight
Net 12 kg
Gross 13 kg
Electrical
Voltage 230 V
Frequency 50 Hz
Fuse 10 A
Current consumption 6 A
Power
Power consumption 1300 W
Output power M W 750 W
Grill 600 W
M aximum input pow er 1750 W
Timer
electronic 30 min.
5 power levels
Error codes
Certain fault conditions are indicated by an error code.
The following codes are implemented:
ERR 0 Convection temperature sensor fault.
Not connected or short circuit.
ERR 1 Short circuit in the M W relay.
ERR 6 Weight sensor calibration has not been performed.
ERR 7 Humidity sensor is defect or has not been connected.
ERR 8 Impossible to write to E2PROM .
ERR 9 Options have not been set.
ERR A No w heel detected on weight sensor.
ERR B No pulses from the weight sensor or <4267 Hz.
ERR C Fuzzy temperature sensor fault. Not 19-41 ˚C.
https://appliancetechmanuals.com

SERVICE
10.01.2003 / Page 4 M AX 18/AW Whirlpool Europe
Doc. No: 4812 714 14499 8538 018 99261 Customer Service
Spare part list
Model MAX 18/ AW
Service No. 853801899261
Version 853801899261
Pos. No. 12NC Code Description
001 0 4812 440 10447 Cabinet outer WH
001 5 4812 462 79788 Plate, bottom
001 6 4812 462 79849 Frame distance piece right
001 7 4812 462 79851 Frame distance piece left
002 0 4812 325 58002 Frame top WH
002 1 4812 325 58003 Frame top plate AL
002 2 4812 325 58004 Frame heat shield top
005 0 4812 440 89022 Panel bottom
047 0 4812 492 48178 Hinge pin, top
100 0 4812 442 69289 Door complete Alu/White
117 0 4819 498 78366 Handle for crisp plate
130 0 4812 492 58039 Lever
130 1 4812 460 38114 Cam plate
130 2 4812 492 58041 Clutch
130 3 4812 492 58038 Pin
130 5 4812 492 68172 Spring, tension
245 0 4812 458 19141 Grid
246 0 4812 418 79782 Crisp plate AM W 001
255 0 4812 466 78407 Glass plate turntable
264 0 4812 539 28001 Crosspiece
264 1 4812 539 28002 Spider
404 0 4819 131 58019 M agnetron
406 0 4812 361 58156 M otor Turnt able
406 1 4812 492 58037 Tube M W
412 0 4812 145 38032 Transformer HT
420 0 4812 121 58137 Capacitor 1.01µF
426 0 4819 218 38038 Diode HV
440 0 4812 361 18317 M otor blow er
452 0 4812 259 28845 Heating element 115V
452 1 4812 259 28846 Heat shield
490 0 4812 321 18195 Cable, mains 3X1, 0 EU
500 0 4812 214 78952 Control board assembly
505 0 4812 256 98038 Bracket PCB holder
505 1 4812 256 98037 Holder multi
506 0 4812 270 18026 Sw itch holder
554 0 4812 282 08613 Thermostat M agnetron
554 1 4812 256 98036 Bracket Thermostat
561 0 4812 282 48271 Thermostat waveguide
564 0 4812 282 08625 Thermostat overheat
617 0 4812 280 68349 Relay
633 0 4812 271 38427 M icrosw itch door
651 0 4819 134 28051 Lamp
774 0 4812 462 28268 M ica plate
774 2 4812 442 69274 Heat shield waveguide
900 2 4812 491 48016 Pin for micaplate
910 0 4812 502 38354 Screw safety
993 0 4812 462 18208 Holder baby bottle
https://appliancetechmanuals.com

SERVICE Whirlpool Europe MAX 18/AW 10.01.2003 / Page 5
Customer Service 8538 018 99261 Doc. No: 4812 714 14499
Exploded view
https://appliancetechmanuals.com

SERVICE
10.01.2003 / Page 6 M AX 18/AW Whirlpool Europe Doc. No: 4812 714 14499 8538 018 99261 Customer Service
Wiring diagram
OVEN IN OFF POSITION
WITH DOOR CLOSED
1010 M agnetron
1020 Thermostat M agnetron
1040 Secondary doorsw itch
1050 M onitor doorsw itch
1060 Primary doorsw itch
1070 M otor fan
1080 M otor turntable
1120 Cavity lamp
1130 Thermostat cavity
1135 Thermostat waveguide
1800 Heating element grill
2000 HT capacitor
4030 Power board
4040 Control system
4120 Fuse T 10 A
4121 Fuse T 250 mA
5000 HT transformer
6000 HT diode
BL Blue
BLK Black
BR Brow n
GY Grey
RD Red
WT White
YW Yellow
Y/G Yellow - green
https://appliancetechmanuals.com

SERVICE Whirlpool Europe MAX 18/AW 10.01.2003 / Page 7
Customer Service 8538 018 99261 Doc. No: 4812 714 14499
Wiring diagram
https://appliancetechmanuals.com