Yamaha Venture XVZ1300TF User manual

XVZ1300TF
OWNER’S MANUAL
YAMAHA MOTOR CO., LTD.
5JC-28199-E2
PRINTED ON RECYCLED PAPER
PRINTED IN JAPAN
2001 · 1 - 0.3 × 1 CR
(E)

F_5eb_Toc0.fm Page 2 Wednesday, February 2, 2000 2:02 PM

EAU03338 INTRODUCTION
Welcome to the Yamaha world of motorcycling!
As the owner of a Royal Star™ VENTURE®, you are benefiting from Yamaha’s vast
experience and newest technology regarding the design and manufacture of high-
quality products, which have earned Yamaha a reputation for dependability.
Please take the time to read this manual thoroughly, so as to enjoy all advantages of
your Royal Star™ VENTURE®. The owner’s manual does not only instruct you in
how to operate, inspect and maintain your motorcycle, but also in how to safeguard
yourself and others from trouble and injury.
In addition, the many tips given in this manual will help keep your motorcycle in the
best possible condition. If you have any further questions, do not hesitate to contact
your Yamaha dealer.
The Yamaha team wishes you many safe and pleasant rides. So, remember to put
safety first!
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

EAU00005
IMPORTANT MANUAL INFORMATION
Particularly important information is distinguished in this manual by the following notations:
The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS
INVOLVED!
WARNING Failure to follow WARNING instructions could result in severe injury or death to the
motorcycle operator, a bystander, or a person inspecting or repairing the
motorcycle.
CAUTION: A CAUTION indicates special precautions that must be taken to avoid damage to the
motorcycle.
NOTE: A NOTE provides key information to make procedures easier or clearer.
NOTE:
_ ●This manual should be considered a permanent part of this motorcycle and should remain
with it even if the motorcycle is subsequently sold.
●Yamaha continually seeks advancements in product design and quality. Therefore, while
this manual contains the most current product information available at the time of printing,
there may be minor discrepancies between your motorcycle and this manual. If you have
any questions concerning this manual, please consult your Yamaha dealer.
_
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

IMPORTANT MANUAL INFORMATION
EW000002
WARNING
_
PLEASE READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE OPERATING
THIS MOTORCYCLE.
_
E_5jc.book Page 2 Monday, January 22, 2001 12:12 PM

IMPORTANT MANUAL INFORMATION
EAU03337
XVZ1300TF
OWNER’S MANUAL
© 2000 by Yamaha Motor Co., Ltd.
1st Edition, November 2000
All rights reserved.
Any reprinting or unauthorized use
without the written permission of
Yamaha Motor Co., Ltd.
is expressly prohibited.
Printed in Japan.
E_5jc.book Page 3 Monday, January 22, 2001 12:12 PM

TABLE OF CONTENTS
1 GIVE SAFETY THE RIGHT OF WAY 1
2 DESCRIPTION 2
3 INSTRUMENT AND CONTROL FUNCTIONS 3
4 AUDIO SYSTEM 4
5 PRE-OPERATION CHECKS 5
6 OPERATION AND IMPORTANT RIDING POINTS 6
7 PERIODIC MAINTENANCE AND MINOR REPAIR 7
8 MOTORCYCLE CARE AND STORAGE 8
9 SPECIFICATIONS 9
10 CONSUMER INFORMATION 10
INDEX
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

E_5jc.book Page 2 Monday, January 22, 2001 12:12 PM

GIVE SAFETY THE RIGHT OF WAY
1
GIVE SAFETY THE RIGHT OF WAY ................................................1-1
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

1
1-1
EAU00021
1-
GIVE SAFETY THE RIGHT OF WAY
Motorcycles are fascinating vehicles, which can give you an unsurpassed feeling of power and freedom.
However, they also impose certain limits, which you must accept; even the best motorcycle does not ig-
nore the laws of physics.
Regular care and maintenance are essential for preserving value and operating condition of your motor-
cycle. Moreover, what is true for the motorcycle is also true for the rider: good performance depends on
being in good shape. Riding under the influence of medication, drugs and alcohol is, of course, out of the
question. Motorcycle riders—more than car drivers—must always be at their mental and physical best.
Under the influence of even small amounts of alcohol, there is a tendency to take dangerous risks.
Protective clothing is as essential for the motorcycle rider as seat belts are for car drivers and passen-
gers. Always wear a complete motorcycle suit (whether made of leather or tear-resistant synthetic mate-
rials with protectors), sturdy boots, motorcycle gloves and a properly fitting helmet. Optimum protective
wear, however, should not encourage carelessness. Although full-coverage helmets and suits, in partic-
ular, create an illusion of total safety and protection, motorcyclists will always be vulnerable. Riders who
lack critical self-control run the risk of going too fast and are apt to take chances. This is even more dan-
gerous in wet weather. The good motorcyclist rides safely, predictably and defensively—avoiding all
dangers, including those caused by others.
Enjoy your ride!
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

DESCRIPTION
2
Left view.............................................................................................2-1
Right view...........................................................................................2-2
Controls and instruments...................................................................2-3
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

2-1
2
EAU00026
2-
DESCRIPTION
Left view
1.Shift pedal (page 3-10)
2.Starter (choke) knob (page 3-14)
3.Fuel tank cap (page 3-11)
4.Fuel cock (page 3-13)
5.Battery (page 7-32)
6.Fuse box 2 (page 7-34)
7.Side case (page 3-17)
8.Helmet holder (page 3-15)
9.License light (page 7-37)
10.Tail/brake light (page 7-36)
11.Rear turn signal lights (page 7-36)
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

DESCRIPTION
2-2
2
Right view
12.Muffler
13.Owner’s tool kit (page 7-1)
14.Helmet holder (page 3-15)
15.Travel trunk (page 3-17)
16.Passenger seat
17.Shock absorber assembly air valve (page 3-20)
18.Rider seat (page 3-15)
19.Fuel tank (page 3-12)
20.Front fork air valve (page 3-19)
21.Headlight (page 7-35)
22.Front turn signal lights (page 7-36)
23.Fuse box 1 (page 7-33)
24.Brake pedal (page 3-11)
25.Engine oil level check window (page 7-12)
26.Rider footrest
27.Coolant reservoir (page 7-15)
28.Passenger footrest
E_5jc.book Page 2 Monday, January 22, 2001 12:12 PM

DESCRIPTION
2-3
2
Controls and instruments
1.Clutch lever (page 3-10)
2.Audio system control unit (page 4-3)
3.Left handlebar switches (page 3-9)
4.Rider headset jack (page 4-2)
5.Speedometer unit (page 3-5)
6.Main switch/steering lock (page 3-1)
7.Right handlebar switches (page 3-9)
8.Throttle grip (page 7-21)
9.Brake lever (page 3-11)
E_5jc.book Page 3 Monday, January 22, 2001 12:12 PM

3
INSTRUMENT AND CONTROL FUNCTIONS
Main switch/steering lock .....................................3-1
Indicator and warning lights ................................3-3
Speedometer unit ................................................3-5
Cruise control system...........................................3-6
Fuel gauge ...........................................................3-8
Anti-theft alarm (optional) ....................................3-8
Handlebar switches .............................................3-9
Clutch lever ........................................................3-10
Shift pedal ..........................................................3-10
Brake lever .........................................................3-11
Brake pedal ........................................................3-11
Fuel tank cap .....................................................3-11
Fuel ....................................................................3-12
Fuel tank breather hose .................................... 3-13
Fuel cock ........................................................... 3-13
Starter (choke) knob ......................................... 3-14
Locking the steering with a padlock .................. 3-14
Rider seat .......................................................... 3-15
Helmet holders .................................................. 3-15
Side cases and travel trunk ............................... 3-16
Adjusting the front fork ...................................... 3-19
Adjusting the shock absorber assembly ............ 3-20
Sidestand .......................................................... 3-21
Ignition circuit cut-off system ............................. 3-22
Auxiliary DC jack and terminals ........................ 3-24
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

3-1
3
EAU00027
3-
INSTRUMENT AND CONTROL FUNCTIONS
EAU00029
Main switch/steering lock
The main switch/steering lock controls
the ignition and lighting systems, and is
used to lock the steering. The various
positions are described below.
EAU00036
ON
All electrical systems are supplied with
power, and the engine can be started.
The key cannot be removed.
EAU01842
ACC (Accessory)
The audio system and the auxiliary DC
jack and terminals can be used in this
position. Therefore, do not use the ac-
cessory position for an extended period
of time, otherwise the battery may dis-
charge.
The key cannot be removed.
EAU00038
OFF
All electrical systems are off. The key
can be removed.
EAU00040
LOCK
The steering is locked, and all electrical
systems are off. The key can be re-
moved.
To lock the steering
1. Turn the handlebars all the way to
the left.
2. Push the key in from the “OFF” po-
sition, and then turn it to “LOCK”
while still pushing it.
3. Remove the key.
To unlock the steering
Push the key in, and then turn it to
“OFF” while still pushing it.
1. ON
2. ACC (Accessory)
3. OFF
4. LOCK
5. (Parking)
E_5jc.book Page 1 Monday, January 22, 2001 12:12 PM

INSTRUMENT AND CONTROL FUNCTIONS
3-2
3
EW000016
WARNING
@
Never turn the key to “OFF” or
“LOCK” while the motorcycle is
moving, otherwise the electrical
systems will be switched off, which
may result in loss of control or an
accident. Make sure that the motor-
cycle is stopped before turning the
key to “OFF” or “LOCK”.
@
1. Push.
2. Turn.
EAU01861
(Parking)
The steering is locked, and the taillight,
license light and auxiliary light are on,
but all other electrical systems are off.
The key can be removed.
The steering must be locked before the
key can be turned to “ ”. ECA00043
CAUTION:
_
Do not use the parking position for
an extended length of time, other-
wise the battery may discharge.
_
E_5jc.book Page 2 Monday, January 22, 2001 12:12 PM

INSTRUMENT AND CONTROL FUNCTIONS
3-3
3
EAU03034
Indicator and warning lights
EAU03299
1. Turn signal indicator lights
“”/“ ”
The corresponding indicator light flash-
es when the turn signal switch is
pushed to the left or right.
EAU00063
2. High beam indicator light “ ”
This indicator light comes on when the
high beam of the headlight is switched
on.
EAU03201
3. Oil level warning light “ ”
This warning light comes on when the
engine oil level is low.
The electrical circuit of the warning light
can be checked according to the fol-
lowing procedure.
1. Set the engine stop switch to “ ”
and turn the key to “ON”.
2. Shift the transmission into the neu-
tral position or pull the clutch lever.
3. Push the start switch. If the warn-
ing light does not come on while
pushing the start switch, have a
Yamaha dealer check the electri-
cal circuit.
NOTE:
@
Even if the oil level is sufficient, the
warning light may flicker when riding on
a slope or during sudden acceleration
or deceleration, but this is not a mal-
function.
@
EAU01774
4. Overdrive indicator light “O/D”
This indicator light comes on when the
transmission is in overdrive (5th gear).
EAU00091
5. Engine trouble warning light
“”
This warning light comes on or flashes
when an electrical circuit monitoring
the engine is defective. When this oc-
curs, have the Yamaha dealer check
the self-diagnosis system.
E_5jc.book Page 3 Monday, January 22, 2001 12:12 PM

INSTRUMENT AND CONTROL FUNCTIONS
3-4
3
EAU00079
6. Fuel level warning light “ ”
This warning light comes on when the
fuel level drops below approximately
3.5 L. When this occurs, turn the fuel
cock lever to the “RES” position and re-
fuel as soon as possible.
EAU01773
7. Cruise control indicator lights
See page 3-6 for an explanation of
these indicator lights.
EAU00061
8. Neutral indicator light “ ”
This indicator light comes on when the
transmission is in the neutral position.
EAU01707
9. Coolant temperature warning
light “ ”
This warning light comes on when the
engine overheats. When this occurs,
stop the engine immediately and allow
the engine to cool.
The electrical circuit of the warning light
can be checked according to the fol-
lowing procedure.
1. Set the engine stop switch to “ ”
and turn the key to “ON”.
2. Shift the transmission into the neu-
tral position or pull the clutch lever.
3. Push the start switch. If the warn-
ing light does not come on while
pushing the start switch, have a
Yamaha dealer check the electri-
cal circuit. EC000002
CAUTION:
@
Do not operate the engine if it is
overheated.
@
E_5jc.book Page 4 Monday, January 22, 2001 12:12 PM

INSTRUMENT AND CONTROL FUNCTIONS
3-5
3
EAU03565
Speedometer unit
The speedometer unit is equipped with
the following:
●a digital speedometer (which
shows riding speed)
●an odometer (which shows the to-
tal distance traveled)
●two tripmeters (which show the
distance traveled since they were
last set to zero)
●a fuel reserve tripmeter (which
shows the distance traveled on the
fuel reserve)
●a clock
Odometer and tripmeter modes
Pushing the “SELECT” button switches
the display between the odometer
mode “ODO” and the tripmeter modes
“TRIP 1” and “TRIP 2” in the following
order:
ODO →TRIP 1 →TRIP 2 →ODO
If the fuel level warning light comes on
(see page 3-4), the odometer display
will automatically change to the fuel re-
serve tripmeter mode “TRIP F” and
start counting the distance traveled
from that point. In that case, pushing
the “SELECT” button switches the dis-
play between the various tripmeter and
odometer modes in the following order:
TRIP F →TRIP 1 →TRIP 2 →ODO →
TRIP F
To reset a tripmeter, select it by push-
ing the “SELECT” button, and then
push the “RESET” button. If you do not
reset the fuel reserve tripmeter manu-
ally, it will reset itself automatically and
the display will return to “TRIP 1” after
refueling and traveling 5 km.
NOTE:
@
After resetting the fuel reserve tripme-
ter, the display will return to “TRIP 1”,
unless a different mode had been pre-
viously selected; in that case, the dis-
play automatically returns to the prior
mode.
@
Clock mode
To change the display to the clock
mode, push both the “SELECT” and
“RESET” buttons.
To change the display back to the
odometer modes, push the “SELECT”
button.
1. Speedometer
2. Odometer/tripmeters/clock
3. “RESET” button
4. “SELECT” button
E_5jc.book Page 5 Monday, January 22, 2001 12:12 PM