Zanussi ZBS 862 User manual

GEBRAUCHSANLEITUNG
NOTICE D'UTILISATION
GEBRUIKSAANWIJZING
INSTRUCTION BOOKLET
EINBAU-BACKOFEN MIT
DAMPFGARENRICHTUNG
FOUR À VAPEUR
STOOMOVEN
BUILT-IN STEAM OVEN
ZBS 862

61
This appliance complies with the following
E.E.C. Directives:
- 73/23 - 90/683 (Low Voltage Directive);
- 89/336 (Electromagnetical Compatibility Directive);
- 93/68 (General Directives)
and subsequent modifications.
ForYour Safety
• Thisappliancehasbeendesignedtobeoperatedby
adultsandchildrenundersupervision.Youngchildren
MUST NOT be allowed to tamper with the controls or
play near or with the oven.
• This appliance has been designed for cooking
edible foodstuff only and MUST NOT be used for any
other purposes.
• Itisdangerous toalterthespecificationinanyway.
• Forhygieneandsafetyreasons,thisapplianceshould
be kept clean at all times. A build-up of fats or other
foodstuff could result in a fire.
• Accessible parts of this appliance may become hot
when it is in use. Children should be KEPT AWAY until
it has cooled.
• Undernocircumstancesshouldyouattempttorepair
the appliance yourself. Repairs carried out by
unexperiencedpersonsmay cause injury orserious
malfunctioning. Refer to your local Zanussi Service
Centre. Always insist on genuine Zanussi spare
parts.
• Ensurethatall control knobs areintheOFF position
when not in use.
• Shouldyouconnectanyelectricaltooltoaplugnear
this cooking appliance, ensure that electric cables
are not in contact with it and keep them far enough
from the heated parts of this appliance.
•Ifthe applianceisoutoforder, disconnectit fromthe
electric supply.
•Donotleaveuntensilscontainingfoodstuffs,e.g.fat
or oil in or on the appliance. This could cause
damage in case the appliance is inadvertently
switched on.
During Operation About Installation, Cleaning
and Manteinance
• It is mandatory that all operations required for the
installationarecarriedoutbyaqualifiedorcompetent
person, in accordance with existing rules and
regulations.
• Disconnect the appliance from the electrical supply,
before carrying out any cleaning or manteinance
work.
• Onceyouremovedallpackagingfromtheappliance,
ensure that it is not damaged and the electric cable
is in perfect conditions. Otherwise, contact your
dealer before proceeding with the installation.
• The manufacturer disclaims any responsability
should all the safety measures not be carried
out.
☛
☛
Warning
These warnings are provided in the interest of safety. You MUST read them carefully before
installing or using the appliance.
It is most important that this instruction book should be retained with the appliance for future
reference.Shouldtheappliancebesold ortransferred,alwaysensurethatthebookisleftwith
the appliance in order that the new owner can get to know the functions of the appliance and
the relevant warnings.
ENGLISH
OVEN DOOR PROTECTION DEVICE
AllourappliancescomplywiththeEuropeanSafety
Standards. Nevertheless, in order to ensure the
highest safety level, and avoid little children to be
exposedtotheheatwhentheapplianceisoperated,
it is possible to fit a special protection device to the
oven door. This device can be purchased in our
ServiceForceCentres,specifyingtherelevantcode
(35791) and the Product No. shown on the rating
plate. Fitting instructions are provided with the kit
package.
MANUFACTURER:
ELECTROLUX ZANUSSI S.p.A.
Viale Bologna 298 - 47100 FORLI’ (Italia)

62
Contents
ForYour Safety .........................................61
Description of the appliance.....................63
Oven Control Knobs.................................64
Oven Function Control Knob.............................64
Thermostat Control Knob..................................64
Thermostat Control Light ..................................64
End of cooking programmer..............................65
The Safety Thermostat......................................65
The Cooling Fan for the Controls ......................65
When the oven is first installed.................66
Safety when cooking ................................66
Water tank pilot lamps..............................67
How to set the oven ready for a steam
cooking.....................................................67
Hints and tips about steam cooking .........68
Cooking with steam..................................68
Accessories for steam cooking ................69
Steam cooking chart ................................70
Traditional, fan and grill cookings .............71
Conventional cooking........................................71
The Fan Oven ...................................................71
Defrosting..........................................................71
Grilling...............................................................71
Hints and Tips on Cooking Fish and Meat ........71
Hints and Tips on baking...................................71
Hints and Tips on grilling...................................71
Cooking charts (traditional and fan oven,
grill) ..........................................................72
Cleaning and maintenance ......................73
Cleaning the steam generator..................74
Cleaning the water tank ....................................74
Cleaning the exhaust pipe.................................75
Using different water types................................75
What happens if something goes wrong..76
Guarantee ................................................77
Techical Assistance and Spare Parts.......77
Technical Data..........................................78
Installation ................................................78
Building In ......................................................... 78
Securing the Oven to the Cabinet..................... 79
Electric Connection ........................................... 79
Terminal block ...................................................79

63
100
150
200
MAX
50
0
5
10
15
30
45
60
75
90
RED PILOT LIGHT
(TANK OUT OF
WATER)
Description of the appliance
GREEN PILOT
LIGHT
(FULL TANK)
RED PILOT LIGHT
(CLEANING
NEEDED)
COOKING
FUNCTION
CONTROL KNOB
THERMOSTAT
CONTROL
LIGHT
WATER TANK
FEEDING
DRAWER
STEAM
INJECTOR
WATER TANK
EXHAUST-VALVE
WATER TANK
EXHAUST-PIPE
GRILLELEMENT
OVEN LAMP
FAN
RATING
PLATE
THERMOSTAT
CONTROL KNOB
END OF COOKING
PROGRAMMER

64
Oven Function Control Knob (Fig. 1)
Here you can find the symbols appearing on the Oven
Function Control Knob and their meaning.
Oven Light - The oven light will be on without any
cooking function
Conventional cooking - The heat comes from both
the top and bottom element, ensuring even
heating inside the oven.
Fan cooking - This allows you to roast or roast
and bake simoultaneously using any shelf,
without flavour transference.
Grill - The grill element will be on.
Steam cooking - The steam cooking function will
be on (see the following pages for the correct
use of this cooking function).
You can choose the function you need by turning the
knob on the relevant symbol.
Your new steam oven allows you to cook your
favourite dishes without losing any nutrition property
and keeping their original taste.
You can choose both the traditional cooking systems
or the steam cooking system. To obtain the best
cooking results, it is necessary to get familiar with the
oven controls.
Thermostat Control Knob (Fig. 2)
By turning the oven control knob clockwise, you can
select cooking temperatures, from 50°C up to 250°C
(MAX).
Thermostat Control Light
Once the oven temperature has been selected, the
temperature light will come on and remain on until the
ovenhasreachedthecorrectsetting;afterthat,itwillgo
onand offwiththethermostat,showing howthe tempe-
rature is being maintained.
Fig. 1
Fig. 2
0
100
150
200
MAX
50
Oven Control Knobs

65
Fig. 3
The Safety Thermostat
This oven is provided with a safety thermostat. In case
ofmalfunctioningofthemainthermostat,andconsequent
over-heating, the safety device will stop the power
supply to the appliance. If this happens, call your local
ZanussiServiceCentre.Undernocircumstancesshould
you attempt to repair the appliance yourself.
The Cooling Fan for the Controls
This oven is provided with a cooling fan, meant to keep
the front panel, the knobs and the oven door handle
cool. This fan may run on after the oven or grill is
switched off, until a normal temperature is reached.
5
10
15
30
45
60
75
90
End of cooking programmer (Fig. 3)
This device allows you to make the oven switch off
automaticallyoncethepresettimeisover.Anacousitic
signal will be heard when the cooking is completed.
The cooking duration can be set up to 90 minutes
maximum.
Turn the timer knob on to set the oven on manual
operation.
Turn the timer knob clockwise to set the required
cookingtime.Then place food intheovenand turn the
oven function control knob and the thermostat control
knob on the required settings. When the cooking time
is over, an acoustic alarm will sound and the oven will
switch off automatically.

66
Fig. 4
FO 2196
Safety when cooking
☞
When the oven is first installed
Once the oven has been installed:
a) set the thermostat knob to MAX;
b) switch the oven function control knob to
conventional cooking ( );
c) allowtheoventorunemptyforapproximately
45 minutes;
d) open a window for ventilation.
During this time, an unpleasant odour may be emitted.
Thisisabsolutelynormal, andiscaused byresiduesof
manufacturing.
Once this operation is carried out, let the oven cool
down,thencleantheovencavitywithasoftclothsoaked
in warm soapy water.
Beforecookingforthefirsttime,carefullywashtheshelf
and the dripping pan.
To open the oven door, always catch
the handle in its central part (Fig. 4).
• Alwaysuseovenglovestoremoveandreplacefood
in the oven.
• Thetemperaturesinside the oven canreach250°C.
Alwaysensurethatyou are using oven proof baking
trays, oven dishes, etc.
• Do not place pans, biscuit pans or aluminium foil
directly on the base of the oven. This could cause a
heat build-up which could affect the performance of
the oven and damage the oven enamel.
• Carefully supervise cookings with fats or oil, since
these types of foodstuff can result in a fire, if over-
heated.
For the same reason, be careful when placing or
removing food in the oven, not to let any fat or oil fall
ontheovenbase.Ifthishappens,carefullycleanthe
oven to avoid unpleasant smells or smoke.
Always cook with the oven door
closed

67
Before using the oven for a steam cooking, the
water tank must be filled.
To fill the water tank, open the oven door, pull out the
water tank drawer, unscrew the drawer cap and pour in
water using a graduated vessel, until the red pilot light
"FULLWATERTANK"comeson.Considerthatnotmore
than one liter of water can be poured into the water tank.
Then refit the drawer cap and push in the water tank
drawer. Your oven is now ready for a steam cooking.
If too much water happens to be poured into
the water tank, the exceed water will flow into
the oven cavity through a safety opening.
Immediately wipe the oven cavity dry with a
sponge or a soft cloth (Fig. 6).
How to set the oven ready for a steam cooking
Fig. 5
Fig. 6
Water tank pilot lamps
Red pilot lamp (full water tank)
Itindicates thatthe ovenis readyto beusedforasteam
cooking.
Red pilot lamp (tank out of water)
It indicates that the oven cannot be used for a steam
cookingandwatershouldbepouredintothewatertank.
Cleaning cycle pilot lamp
Itindicatesthatthewatertankcleaningproceduresould
be carried out or that the steam injector is obstructed.
0

68
Cooking with steam
1 - Before any steam cooking, fill the water tank
asdescribedinthepreviouschapter.Oneliter
ofwaterallowsabout1hourofsteamcooking.
2 - Place the food in suitable ovenproof pans or
potsandplacethemontheovenshelf(Fig.7).
Set the shelf level according to the cooking
table. The second shelf level from the bottom
usually gives the best cooking results.
3 - Turn the oven function control knob on the
"STEAM COOKING" function (symbol ) .
4 - Turn the thermostat control knob on the
required temperature between 140°and
220°C. Consider that a temperature above
220°C will not give good cooking results.
Fig. 7
Hints and tips about steam cooking
●Don't cover the pans or pots. This would not
allow steam to come in contact with the food.
●You can also place food directly on the oven
shelf, as shown in Fig. 8. In that case, always
placethedrippingpanatthelowestlevel,with
some water in it, to avoid smoke and
unpleasant smells.
●If you need to open the oven door and check
the food, always remember to switch off the
steamcookingfunctionbyturningthefunction
control knob on symbol . After having
checkedit,turnbackthefunctioncontrolknob
on symbol to make the steam function
operate again.
Steamcancondenseandproducewaterdroplets
ontheovendoorglass. Thisisquitenormaland
isnotcausedbyfaultoftheoven.Werecommend
you to wipe away condensation after all
cookings.
Fig. 8
☞
i

69
Accessories for steam cooking
Fig. 9
Fig. 10
A special accessory kit is available at your retailer's
shop. This is meant to allow a wider range of steam
cookings, especially for fish, vegetables, etc.
The accessory kit includes:
- a diet cooking double dish, provided with a special
mould to allow a steam injector to be fitted to the dish
(Fig. 9);
- a small shelf meant to be inserted inside the double
dish to prevent food to lay on the dish surface;
- two different steam injectors, to be used as shown in
figures 9 and 10 after being fitted to the exhaust pipe
which is supplied with the appliance.
The diet cooking double dish (Fig. 9) is particularly
recommended to cook vegetables, as it allows you to
keep their original taste and nutrition properties.
The direct steam cooking system (Fig. 10) will give
the best results with poultry. The long steam injector
provided with holes on its surface must be inserted
inside the joint and makes steam cook the internal
part, while the outside is gently browned by the
traditional heating elements. The injector holes must
not be covered: for this reason the injector must be
inserted into the empty cavity inside the joint, as
shown in Figure 10.

70
Steam cooking chart
Cakes
Whipped up kneading 2 150 30 ~ 45
Leavened kneading 2 160 30 ~ 45
Creme caramel 2 150 40 ~ 60
Butter-milk cheese cake 2 150 40 ~ 60
Apple cake 2 175 30 ~ 45
Strudel 2 150 45 ~ 60
Jam-tart 2 175 30 ~ 45
800 Mixed cooked fruit 2 150 30 ~ 40 Sliced
1000 Cooker apples - pears 2 175 45 ~ 60 Whole
Small cakes 2 175 15 ~ 25 6 pieces
Bread and Pizza
500 White bread 2 200 45 ~ 65 2 pieces
500 Bread rolls 2 200 25 ~ 35 6 rolls
Pizza 2 175 15 ~ 35
Flans
Pasta flan 2 175 30 ~ 40
Quiche 2 175 35 ~ 45
Lasagne 2 175 35 ~ 45
Vegetable flan 2 175 35 ~ 45
Meat
1200 Beef 2 175 60 ~ 90
1000 Pork 2 175 60 ~ 90
1000 Veal 2 175 60 ~ 90
1000 Mutton 1 o 2 175 120 ~ 150
800 Guinea-fowl 2 175 60 ~ 90 Whole
1200 Lamb 1 o 2 150 120 ~ 150
1200 Chicken 2 175 60 ~ 90 Whole
1000 Pigeons 2 175 60 ~ 80 3 pieces
800 Quails 2 175 40 ~ 60 6 pieces
1000 Boar 2 150 120 ~ 140 Chops
4000 Turkey 1 o 2 175 150 ~ 180 Whole
1500 Duck 2 150 90 ~ 120 Whole
3000 Goose 2 150 120 ~ 150 Whole
1200 Rabbitt 2 175 90 ~ 120 Chops
Fish
1000 Stockfish 2 150 35 ~ 45 Sliced
800 Sea-bream 2 175 30 ~ 40 2 fishes
1000 Hake 2 150 20 ~ 30 Filets
1000 Gilthead 2 175 30 ~ 40 Whole
1500 Salmon 2 175 30 ~ 40 Sliced
1000 Sole 2 175 20 ~ 30 Whole
1200 Tunny 2 175 Sliced
1500 Trout 2 150 30 ~ 45 4 fishes
1000 Squill 2 175 25 ~ 35 Whole
1000 Prawn 2 175 25 ~ 35 Whole
1200 Lobster 2 150 30 ~ 40 2 lobsters
Vegetables
1000 Tomatoes 2 200 20 ~ 30 Half cut
1000 Potatoes 2 175 30 ~ 40 Sliced
1000 Roasted potatoes 2 150 45 ~ 60 Sliced
1200
Aubergines 2 175 30 ~ 45
1500 Stuffed peppers 2 175 45 ~ 60 Half cut
1000 Courgettes 2 175 30 ~ 40 Half cut
1000 Fennels 2 150 45 ~ 60 Sliced
800 Cauliflower 2 175 35 ~ 45
800 Stuffed mushrooms 2 175 25 ~ 35 9 mushrooms
800 Onions 2 150 35 ~ 45
600 Celery 2 150 35 ~ 45 Chopped
Steam cooking Notes
Weight
in
gr.
Cooking
duration
minutes
°C
temp.
Level 4
3
2
1
Food

71
Hints and Tips on Cooking Fish and Meat
You can place meat in oven proof dishes, or directly on
the oven shelf. In this case, remember to place the
dripping pan in the first position from the bottom (see
Fig.7)withsomewaterinit. The dripping pan will avoid
the falling of melted fat on the oven base.
Whitemeat, poultry andfishin general,needa medium
temperature cooking (between 150 and 175 °C). If you
need to cook red meat (slightly browned on the outside
and more gently cooked in the inside), a higher tempe-
rature (between 200 and 250 °C) for a short time is
recommended.
Hints and Tips on baking
Cakes usually need a medium temperature cooking,
between 150 and 200 °C.
A short oven pre-heating (about 10 minutes) is
recommeded when cooking cakes or baking. Once the
cooking has been started, keep the oven door closed
during all the cooking time, and check the cooking
results through the oven door glass.
Hints and Tips on grilling
Ifyouneedtogrillmeatorfish,placethemdirectlyonthe
shelf after spreading a little oil on them.
In the grill function, heat comes only from the top
element.Therefore,youneedtoadjustthecookinglevel
depending on meat or fish's thickness.
Alwaysremembertoplacethedrippingpaninthelower
position with some water in it.
Fig.11
Conventional cooking
Turn the oven function control knob to the relevant
symbol ( ) and set the thermostat knob on the
required temperature.
If your dish need more heat from the top or from the
bottom adjust the shelf level as required (see Fig. 11).
The Fan Oven ( )
Turn the oven function control knob to the relevant
symbol ( ) and set the thermostat knob on the
required temperature.
Thefansituatedbehindthebackpanelcirculatesheated
air into the oven.
If you need to cook more than one dish in the fan oven
atthesametime,placetheshelves onthefirstandthird
position from the bottom (See Fig. 11).
Ifyouare cooking onlyonedish in thefanoven, use the
lower positions, as this will give you better results.
Defrosting
Turn the oven function control knob to the relevant
symbol ( ) and set the thermostat knob on the OFF
position (symbol : ●).
The oven fan operates without heat and circulates the
air,atroomtemperature,insidetheoven.Thisincreases
the rate at which defrosting takes place.
Grilling
Turn the oven function control knob to the relevant
symbol ( ) and set the thermostat knob on the
required temperature.
Place the oven shelf as shown in Fig. 12.
FO 0285
Traditional, fan and grill cookings
Fig.12

72
Cooking charts (traditional and fan oven, grill)
temp.
Cakes
Whipped up kneading 2 180 2 (1 and 3)* 160 45 ~ 60
Leavened kneading 2 180 2 (1 and 3)* 160 20 ~ 35
Shortbread dough 2 180 2 (1 and 3)* 160 20 ~ 30
Butter-milk cheese cake 1 175 2 150 60 ~ 80
Apple cake 1 180 2 (1 and 3)* 160 40 ~ 60
Strudel 2 175 2 (1 and 3)* 150 60 ~ 80
Jam-tart 2 180 2 (1 and 3)* 160 45 ~ 60
Small cakes 2 180 2 (1 and 3)* 160 15 ~ 25
Biscuits 2 180 2 (1 and 3)* 160 10 ~ 20
Meringues 2 100 2 (1 and 3)* 100 90 ~ 120
Bread and Pizza
1000 White bread 1 200 2 175 45 ~ 60 1 piece
500 Rye bread 2 200 2 175 30 ~ 45 In bread pan
500 Bread rolls 2 200 2 (1 and 3)* 175 20 ~ 35 8 rolls
250 Pizza 1 220 2 (1 and 3)* 200 20 ~ 35 In baking pan
Flans
Pasta flan 2 200 2 (1 and 3)* 175 40 ~ 50
Vegetable flan 2 200 2 (1 and 3)* 175 45 ~ 60
Quiches 2 200 2 (1 and 3)* 175 35 ~ 45
Lasagne 2 200 2 175 45 ~ 60
Meat
1000 Beef 2 200 2 175 50 ~ 70 On grid
1200 Pork 2 200 2 175 100 ~ 130 On grid
1000 Veal 2 200 2 175 90 ~ 120 On grid
1500
English roast beef 2 220 2 200 50 ~ 70 On grid
1200 Lamb 2 200 2 175 110 ~ 130 Leg
1000 Chicken 2 200 2 175 60 ~ 80 Whole
4000 Turkey 2 200 2 175 210 ~ 240 Whole
1500 Duck 2 175 2 160 120 ~ 150 Whole
3000 Goose 2 175 2 160 150 ~ 200 Whole
1200 Hare 2 200 2 175 60 ~ 80 Cut in pieces
Fish
1000 Whole 2 200 2 (1 and 3)* 175 40 ~ 60 2 fishes
800 Fillets 2 200 2 (1 and 3)* 175 30 ~ 40 4 fillets
Fan OvenTraditional Cooking NOTES
WEIGHT
(GR.)
Cooking
time
minutes
°C
temp.
Level 4
3
2
1
TRADITIONAL COOKING AND FAN DUCTED COOKING
TYPE OF DISH
NOTE:
Cooking times do not include pre-heating time. We
reccomend a short oven pre-heating (about 10
minutes) before baking or cooking pizza.
Level 4
3
2
1
°C
(*) If you need to cook more than one dish at the same
time, we recommend you to place them on the levels
quoted between brackets.
Steaks 4 800 4 max 10 8
Chops 4 600 4 max 12 8
Sausages 8 500 4 max 10 6
Chicken (cut in pieces) 6 800 3 max 30 20
Kebabs 4 700 4 max 12 10
Chicken (breast) 4 400 4 max 13 10
Tomatoes 8 500 4 max 12 —
Fish (fillets) 4 400 4 max 8 6
Sandwiches 4 — 4 max 8 —
Toast 4 — 4 max 2~3 1
GRILLING
Upper
side
°C
temp.
PIECES WEIGHT
Quantity Cooking time
(minutes)
Lower
side
Grilling
TYPE OF DISH
Level 4
3
2
1

73
General Cleaning
Before cleaning, always allow the oven to
cool down.
When using spray cleaning products, be
careful not to spread them on the heating
elements or on the thermostat sensor.
Never use harsh abrasives, steel wool or
cleaners with bleach, as they could damage
the enamel and the oven door glass.
The Oven Cavity
The enamelled oven cavity is best cleaned whilst the
oven is still warm. It is advisable to wipe the oven over
withasoft cloth soakedinwarmsoapy water aftereach
use. However, from time to time, it will be necessary to
do a more complete cleaning, using a proper oven
cleaner.
In case of particularly tough stains, you can use some
warm vinegar.
•If cooking fruits, some over-heated natual acids
can squeeze and settle on the oven enamel, causing
stains quite difficult to remove. This could affect the
enamel brightness, but it will have no consequence on
the oven performances. To avoid these stains to be
burnt out during the next cooking, carefully clean the
oven cavity after all fruits cookings.
The Oven Door and its gasket
Before cleaning the oven door, we recommend you to
remove it from the oven.
Proceed as follows:
a) open the oven door completely;
b) findthehingeslinkingthedoortotheoven(fig
6);
c) unlockandturnthesmallleverslocatedonthe
two hinges (fig. 13);
d) handle the door by its left- and right-hand
sides,thenslowlyturnittowardstheovenuntil
it is half-closed;
e) gently pull the oven door off its site (fig. 14);
f) place it on a steady plan;
g) unscrew the two screws marked with lett. A
fig.14;
h) pull up the oven door glass and take it away
from the oven door.
Clean the oven door glass with warm water and a softh
cloth only.
Once the cleaning is carried out, refit the oven door,
following the procedure in reverse.
Fig. 13
Fig. 14
Thecorrectoperationoftheovenisensuredbyagasket
placed round the edge of the oven cavity.
Periodicallychecktheconditionofthisgasket.
If necessary, clean it without using abrasive
cleaning products.
If the gasket shows to be damaged, call you
local Zanussi Service Centre. Do not use the
oven until it has been repaired.
FO 0288
FO 0027
☞
Cleaning and maintenance

74
Replacing the Oven Light
Ensure the electricity supply is switched off
before carrying out this operation.
The oven bulb has to comply to these features:
a) resistant to temperatures of 300 °C;
b) electric rate: 230 V - 50 Hz;
c) electric power rate: 15 W.;
d) connection type: E 14.
To replace the bulb, proceed as follows (Fig. 15):
a) push in and turn the glass lid anticlockwise;
b) remove tha faulty bulb;
c) replace it with a new one;
d) refit the glass lid;
e) switch on the electricity supply.
Fig. 15
FO 0287
Cleaning the steam generator
Fig. 16
Fig. 17
Cleaning the water tank
Just like in any appliance fed with water (e.g. the iron),
is it absoluitely normal that limestone residues form in
the water tank.
After having used the oven for steam cooking several
times,thelimestoneresiduesthatsettleinsidethewater
tank can cause a reduction of the steam.
If the red pilot light that indicates the need of a cleaning
cycle comes on, this means that a certain quantity of
limestone has settled in the water tank and that a
thoroughcleaning ofthe steamgeneratorisnecessary.
In that case proceed as follows:
- Setthewatertankexhaust-pipereadyforuse.
Fit the connector with hexagonal nut (Figure
16, letter "A") to one of the edges of the pipe.
- Open the oven door (Fig. 17) and fit the
connector (A) into the exhaust-valve (C)
located in the lower left hand corner of the
oven cavity frame.
- Place the free edge of the pipe into a vessel,
thenturnthepipeconnector"A"anticlockwise
toopentheexhaust-valve. Water will flow out
the water tank.
☞
☞

75
Fig. 18
- When water stops flowing out the water tank,
turnthepipeconnectorclockwisetoclosethe
exhaust-valve.
Warning! - The connector "A" has not a block fitting.
Takecarethis connector doesn't slipoffthepipe during
the water tank exhaust procedure.
- After the water tank has been drained, melt
twospoonfulofcitricacid(about50-60grams)
into 800 cc. of water.
Citric acid is a natural substance, which
looks like white small grains of sugar. It is
normally used in food industry and can be
purchased in drugstores, wine shops or
chemist's shops.
- Pour the citic acid and water solution into the
water tank drawer, as explained in chapter 5,
page 8.
- Fittheconnector"B"tooneoftheedgesofthe
exhaust-pipe, then insert the connector "B"
into the steam injector (Figure 18, letter "D").
Placethefreepipeedgeinavessel,tocollect
the limestone residues.
- Let the citric acid and water solution stay into
the water tank for about 60 minutes, with the
oven cooled down.
- After60minutes,switchontheovenbyturning
the function control knob on the "STEAM
COOKING" function (symbol: ) and set the
thermostat knob on 140°C.
- Afterabout20-25minutes, turn the knobs off.
- Allow the oven to cool down, then drain the
watertankfollowingtheprocedure previuosly
explained.
- When the procedure is carried out, rinse the
water tank by pouring water into the tank
drawer and letting the water flow out through
the exhaust pipe, until you see clear water
without limestone residues coming out.
While carrying out this procedure, a lemon flavour will
be smelt in the room.
If you foresee not to use the steam oven for 2-3 weeks,
we recommend to drain the water tank.
i
i
Using different water types
If you use bottled mineral water or water with low
limestone content, the need of cleaning the water tank
will be reduced (e.g., every 150-200 cookings). If a
waterconditionerorawatersoftenerhasbeeninstalled
inyourhouse,thenthemainwatersupplyofyourhouse
can be normally used.
Using hard waters (that is, waters with high
limestone content) will make the necessity
of cleaning procedures more frequent, but
this will not affect in any way the oven
operation.
Cleaning the exhaust pipe
When a cleaning procedure has been cariied out,
carefully wash the exhaust pipe in warm soapy water.
Don'tuseacids,spraycleanersorabrasivestocleanthe
exhaust pipe and connectors, this could damage them.

76
SOLUTION
◆Check the control knobs are correctly set for a cooking
function and follow the instructions given in this book
or
◆Check the appliance is wired in properly, and the socket
switch or the switch from the mains supply to the oven are
ON.
◆Fill the water tank
◆Carry out a complete cleaning cycle as described in the
relevant chapter
or
◆If you already carried out a cleaning cycle but the pilot light
does not go off, repeat the procedure and allow the citric
acid and water solution to stay in the tank several hours.
or
◆The steam injector can be obstructed. Remove the
limestone residues from the steam injector.
◆Fill. the water tank. If the green light does not come on after
having poured more than 1 liter of water, call the nearest
Service Centre.
◆Check the oven function control knob is set on the "Steam
Cooking" function, that is on symbol .
or
◆Carefully close the oven door
or
◆Fill the water tank
◆Buy a new oven light bulb, asking for it to your local Zanussi
Service Centre and replace it by following the instruction
provided in this booklet.
◆Too much water has been poured into the oven tank. Turn
the control knobs on the "OFF" position, then wipe the oven
cavity dry with a sponge or a soft cloth.
◆Refer to the contents of this booklet, especially to the
chapter "Using the Oven".
◆Leave dishes inside the oven no longer than 15-20 minutes
after the cooking is completed.
SYMPTOM
■THE OVEN DOES NOT WORK
■THE "TANK OUT OF WATER" LIGHT COMES ON
■THE "CLEANING CYCLE" LIGHT COMES ON
■THE "FULL TANK" GREEN LIGHT GOES OFF
■THE "STEAM COOKING FUNCTION" DOES NOT
WORK
■THE OVEN LAMP DOES NOT COME ON
■THERE IS WATER IN THE OVEN CAVITY
■IT TAKES TOO MUCH TIME TO FINISH THE
DISHES, OR THEY ARE COOKED TOO FAST.
■CONDENSATION SETTLES ON THE FOOD AND
THE OVEN CAVITY.
If the appliance is not working correctly, please carry out the following checks, before contacting your local
Zanussi Service Centre.
What happens if something goes wrong

77
If after the checks listed in the previous chapter, the
appliance still does not work correctly, contact your
locals Zanussi Service Centre, specifying the type of
malfunctioning, the appliance model (Mod.), the
product number (Prod. No.) and the serial number
(Ser. No.) marked on the identification plate.
This plate is placed on the oven cavity frame, as
indicated in Fig. 19.
Original spareparts,
certified by the product
manufacturer and
carrying this symbol are
only available at our
Service Centre and
authorized spareparts
shops.
SER.NO.
Mod.
PROD.NO.
SER. NO.
MOD.
PROD. NO. TYPE
Fig. 19
Techical Assistance and Spare Parts
Your new appliance is under guarantee. You will find
attached here the guarantee certificate. If it is missing,
ask for it to your retailer, stating the date of purchase,
the model number and the serial number marked on
the appliance's identification plate.
Keep the guarantee certificate with the proof of
purchase, and show them at the request of our
technical personnel, otherwise they will have to make
a charge.
Guarantee
The Zanussi Service Force, through its numerous
authorized centres, provides assistance to the most
important brands of electrical domestic appliances. If
necessary,contactthenearestCentrebyconsultingthe
telephone directory under the name Zanussi, or the
yellow pages in the section Electrical Domestic
Appliances / Repair.

78
Technical Data
Installation
Fig. 20 - Coloumn Built-in Recess Dimlensions
Fig. 20 - Oven Dimensions
Fig. 22 - Undertop Built-in Recess Dimensions
Building In
It is important that the dimensions and materials of the
surround or cabinet into which the oven will be built are
correct and will withstand a temperature increase.
A correct installation will have to ensure a proper
protection against contact with electric parts or merely
functionally isolated parts.
Alltheunitsmeanttoensureprotectionhavetobefitted
not to be taken away without using any tool.
We recommed not to install the appliance near
refrigerators or freezer, since the heat could affect the
performance of these appliances.
FO 0414
FO 0290
FO 0292
Recess in coloumn: 580 mm
dimensions height {undertop: 591 mm
width 560 mm
depth 550 mm
Internal height 325 mm
oven width 440 mm
dimensions depth 390 mm
oven capacity 53 l.
Oven ratings
Top + Bottom heating elements 1800 W
Grill element 1750 W
Fan oven element 2000 W
Steam generator 735 W
Oven light 25 W
Cooling fan 20 W
Convection fan 30 W
Total rating 2800 W
Voltage tension (50Hz) 230 V

79
☞
The manufacturer disclaims any
responsability should all the
safety measures not be carried
out.
Fig. 25
Fig. 24
Fig. 23
Securing the Oven to the Cabinet
Fit the appliance into the cabinet recess.
Open teh oven door and secure the oven to the kitchen
cabinet with four wood screws, which fit the holes
provided in the oven frame (Fig. 23-24).
When installing an electric plate hob over the oven, the
hob's electrical connection and the oven's one have to
becarriedoutseparately,forsecurityreasonsandtolet
the oven be taken off the unit easier, if necessary.
Electric Connection
Before the appliance is connected:
1) check that the main fuse and the domestic
installation can support the load;
2) checkthatthepowersupplyisproperlyearthed
in compliance with the current rules;
3) check the socket or the double pole switch
used for the electrical connection can be
easily reached with the appliance built in the
forniture unit.
This appliance is supplied without connection cable . A
suitableonemustbefittedtotheapplianceandaproper
plug,ableto carry theloadspecified on theratingplate,
must be fitted on the connection cable. The connection
cable must be a three-wired cable, with the earth wire
markedyellow-green.Thecabletypemustbeoneofthe
following:
— H07 RN-F
— H05 RN-F
— H07 RR-F
— H05 VV-F
The plug has to be fitted in a proper socket.
Ifconnectingtheappliancedirectlytotheelectricsystem,
a double pole switch must be installed between the
appliance and the electricity supply, with a minimum
gapof 3 mm.betweenthe switchcontactsand ofatype
suitable for the required load in compliance with the
currentrules. The earth wire must not be interrupted by
the double switch pole.
The connection cable has to be placed in order that, in
each part, it cannot reach a temperature 50 °C higher
than the room temperature.
After the connection is carried out, test the heating
elements for about 3 minutes.
FO 0039
FO 0986
FO 0279
Terminal block
The oven has an easily accessible terminal block,
which is meant to work with an electric single-phase
rate of 220-230 V. (Fig. 25)