ACOPOWER KIT-HYS100MB User manual

Accessories:
1、
1.Handle 8. Cable
2. Latches 9. Battery clips
3. Aluminum frame 10. Anderson plug
4. Aluminum support legs 11.fuse
5.Solar charger controller 12.Handy carry bag
6.Junction box 13.corner protection
7.Label
www.ACOPower.com
Power Your Green Life!
KIT-HYS100MB

www.ACOPower.com
Power Your Green Life!
KIT-HYS60MB
Installation
1. Locate in a clear sunlit area free from over hanging branches or obstructions.
2. Remove solar panel kit from handy carry bag.
3. Unclip the two latches on the side of the unit and foldtwo panels outward. Extend the two stands to their
maximum length and lock in position.
4. Place solar panel kit in the position facing the sun.
Note: To obtain maximum output it is suggested that the panels’ direction be frequently adjusted to
track the suns movement through the day.
5. Fully extend battery lead and connect to solar charger controller and ensure that battery clips do not
come in contact with one another.Connect battery clips to the + positive (red) &-negative (black) battery
terminals. Ensure that the connection is secure.
Operation
•Charging Status indicator
1. GREEN ON whenever sunlight is available for battery charging,
2. GREEN FAST FLASHING when system over voltage.
•Battery Status indicator
1. GREEN ON when battery voltage in normal range
2. GREEN SLOWLY FLASHING when battery full
3. ORANGE ON when battery under voltage
4. RED ON when battery over discharged
Warranty:
The warranty for the solar panel is 25years, the cable andcomponent is12 months and a regulator is3 years.
FREQUENTLY ASKED QUESTIONS
Q. What type of batteries can be used with the kit.
A:.1. Sealed lead acid battery 2. Gel battery 3. Flooded battery
Q. Will the solar panels over charge my battery.
A. The charge regulator ensures that a steady charge is supplied to the battery and will not be over charged.
Q. Can I extend /lengthen the battery lead.
A. If the lead is extended this can result in a loss of voltage and insufficient power transferred from the solar
panels to charge the battery

Q. How do I clean the solar panel.
A. Dust & dirt should firstly be swept off the panel surface using a soft brush and then use a wet cloth to wip
e
the panel surface to remove remaining dirt & grime. It is recommended that any bird droppings be removed
as soon as possible as if left can cause damage to the surface.
Trouble shooting if system does not function
A:Check all connections to ensure they are secure and free from moisture & debris
B:Protection of solar charger controller:
·PV Array Short Circuit
If PV array short circuit occurs, clear it to resume normal operation.
·Load Short Circuit
Fully protected against load wiring short-circuit. After one automatic load reconnect attempt, the fault must
be cleared by reapply power or pressing the setting switch.
·Battery Reverse Polarity
Fully protection against battery reverse polarity, no damage to the controller will result. Correct the miswire
to resume normal operation.
·Overheating Protection
If the temperature of the controller heat sink exceeds 85°C, the controller will automatically start the
overheating protection.
·High Voltage Transients
PV is protected against high voltage transients. In lightning prone areas, additional external suppression is
recommended.
Folding Solar Charging System Specification
Type Module Size N.W
Specification
Max-
Power
Max-
Power
Voltage
Max-power
Current
Open-
Circuit
Voltage
Short-
circuit
Current
Module mm Kg W V A V A
2*50w 650*505*30 15 2*50 17.8 2*1.81 22.3 2*3.03
www.ACOPower.com
Power Your Green Life!
KIT-HYS100MB