ACOPOWER 3x35W User manual

www.ACOPower.com
Power Your Green Life!
Projects
1Be used for fixing the packaged folding solar panels
2One pair of the alligator clips is for connecting the battery,red for anode,black for cathode
3Be used for fixed the unfolding solar panels
4To control the output and protect the modules.
5unfolded illustration for folding solar panels
Summary of folding solar panel structure
105W Foldable solar panel

1. Locate the area sunlit clear without hanging branches or obstacles.
2. Open folding package buckle will unfold folded sheet, solar panels equipment should face the sun
Tip: In order to obtain the maximum output power of solar modules, it is recommended to adjust the solar
modules based on solar trajectory toward.
3.Replace the battery clip is connected to the battery terminals to ensure that the battery clip is not in contact
with each other. Red battery clip to positive, black negative battery clamp connection, secure the connection.
4.The battery type setting method
5.Press and hold the program button for more than 5 seconds, the battery indicator LED1, LED2, LED3 will
flash accordingly.
6.Press the button again to set up the exact battery type, after the selection, stop button operation 5
seconds, no flashing lights means complete the setting, the specific content of the following table indicates
LED1 LED2 LED3 Battery Type
○
×
×
Sealed Lead Acid Battery
（
Sealed
）
○ ○ × Colloidal lead-acid batteries（Gel）
○ ○ ○
Op
ening lead-acid batteries（Flooded
）
Note: "○" means lights on "×" means lights off
7. The load switch setting method
When the controller is normal power, press the Set button to achieve the output control of the load. Each
press set key once, the load output will be changed accordingly once off status, only the load output is in the
open state, USB eloquence have 5V voltage output.
1
2
Batt
Solar Panel
Fues
Fues
Load
3
www.ACOPower.com
Power Your Green Life!
105W Foldable solar panel
Instructions

Controller
Charging, load indicators
indicator light indicator status System status Remark
Charging status
indicator
Steady charging
normal
normal
fast flash Battery
overpressure
Load status
indicator
Steady load open
1, when normal output load, load indicator
light; 2, when the load current exceeds 1.25
times the rated load current of 60 seconds
and 1.5 times the rated load current of 5
seconds (overload) when the load indicator
flashes slowly off the load output
Solar Module Battery Load
Setting
button
Mounting
Holes
USB
output
Charging status indicator
Load status indicator
LED1
LED2
LED3
LED4
www.ACOPower.com
Power Your Green Life!
105W Foldable solar panel

Battery Indicator Instruction
LED1 LED2 LED3 LED4 system status
Slow flash × × × battery undervoltage
fast flash × × × Battery over discharge (off load)
Battery voltage rising process
○ ○ × × 12.8V＜Ubat＜13.4V
○ ○ ○ ×13.4V＜Ubat＜14.1V
○ ○ ○ ○ 14.1V ＜Ubat
Battery voltage drop process
○ ○ ○ ×12.8V＜Ubat＜13.4V
○ ○ × × 12.4V＜Ubat＜12.8V
○× × × Ubat＜12.4V
Remark: “○”stand for light up “×” stand for extinguish “Ubat”stand for battey voltage.
Battery indicator (voltage parameters are 25 ℃,12Vsystem parameters,
24V system parameters x2)
Load switch setting method
When the controller is in normal power, press the Setting button to achieve the output control of the
load. Each time press setting button, the load output will be changed accordingly once off status, only the
load output is in the open state, USB eloquence have 5V voltage output.
www.ACOPower.com
Power Your Green Life!
105W Foldable solar panel

common trouble-shooting
Troubles trouble shooting solution
When the modules
directly face to the sun ,th
e
charge indicator does not
light
1、solar arrays’
connection open
2、solar cells connected
reverse
1、Check the power terminals if in correct and
good connection,
2、Controller may be damaged,change a new
one
Charging light fast
flashing
Voltage turn off
when battery voltage is
in overpressure,
Measuring the battery voltage if it is too high,then
disconnect the modules
LED1 :Led1 fast
flashing
Battery over discharge
The controller output shut down automatically ,
indicator light in normal flash when the battery is full of
charge
Load Leds slow
flashing
Load power exceeds
rated power
Reduce some AC loads and press the button 3
seconds to recover the controller output
Load Leds fast flashing Load :short-circuit
When short-circuit happened in the first time,
please wait 10 seconds,the system
output shall be auto restart or you can press the
button 3 seconds to get the normal output; if
short-circuit take place one after another , the system
output will return to normal only by pressing the
button 3 seconds
indicator is off on
the normal charging status
Input power is less than the
battery power
Measure the controller input voltage which must
be higher than the battery voltage
www.ACOPower.com
Power Your Green Life!
105W Foldable solar panel

Frequently Asked Questions(FAQ)
Q: What kind of battery can be charged by these solar modules
A: 1, sealed lead-acid battery 2, colloidal lead-acid batteries 3, the opening lead-acid batteries 4、
(Interface on the controller output via USB) Such as: mobile phones, tablets, navigation systems and so
on
Q: How to clean the solar surface?
A: When dust and dirt covering at the surface of solar modules can be cleaned with a soft brush, then use
a damp cloth to wipe the surface of solar modules, to remove the remaining dust and dirt.Recommend any
guano, adhesive should be removed as soon as possible from the surface of solar modules, so as not to
affect performance.
Q: foldable solar modules are waterproof?
A: Because the system contain sophisticated electronic components shall prevent moisture from
entering use.
Foldable solar module performance parameters
Type
Module
Size
N.W
Specification
Max
Power
Max
Power
Voltage
Max-power
Current
Open-Circuit
Voltage
Short-circuit
Current
Modul
e
mm Kg W V A V A
3*35w 560*440*20 2.7 105 18 5.8 21 6.1
www.ACOPower.com
Power Your Green Life!
105W Foldable solar panel

Safety Tips
before using the product, read all safety precautions.
If the product is abnormal, or work damaged, do not use.
Do not allow water to enter the controller
prevent sharp objects collision surface of solar modules
ensure proper battery clip connector, to prevent short circuits.
no user license serviceable parts inside. Do not disassemble or attempt to repair it.
Do not touch the exposed electrical conductor entrained battery
Limited Product Warranty-One Years Repair,Replacement and refund Remedy, but
fuse excluded
Force Majeure
Sungols shall not be responsible or liable in any way to the customer or any third-party arising from any non
-performance or delay in performance of any terms and conditions of sale, including this “Limited Warranty
for PV Modules”, due to acts God, war, riots, strikes, warlike conditions, plague or other epidemics, fire, fl
ood, or any other similar cause or circumstance beyond the reasonable control of such Sungold. In such ca
ses, performance Sungold of this Limited Warranty shall be suspended without liability for the period of dela
y reasonably attributable to such causes.
www.ACOPower.com
Power Your Green Life!
105W Foldable solar panel