ADC PG-FLEXPLUS PMU-712 User manual

PG-FLEXPLUS
TECHNICAL PRACTICE
MANAGEMENT UNIT
SECTION SCP-PMU712-020-08H
Model List CLEI Code
PMU-712 2S9C3CCDA~~

SCP-PMU712-020-08H
March 1, 2004 PMU-712 List 2
Revision History of This Practice
©Copyright 2004 ADC Telecommunications, Inc. All Rights Reserved.
ADC and PG-FlexPlus are registered trademark s of ADC Telecommunications, Inc. No right, license, or interest to such trademarks
is granted hereunder, and you agree that you shall assert no such right, license, or interest with respect to such trademarks. Other
product names mentioned in this document are used for identification purposes only and may be trademarks or registered
trademarks of their respective companies.
Information contained in this document is company private to ADC Telecommunications, Inc., and shall not be modified, used,
copied, reproduced or disclosed in whole or in part without the written consent of ADC.
Contents herein are current as of the date of publication. ADC reserves the right to change specifications at any time without notice.
Information furnished by ADC is believed to be accurate and reliable. In no event shall ADC be liable for any damages resulting
from the loss of data, loss of use, or loss of profits and ADC further disclaims any and all liability for indirect, incidental, special,
consequential or other similar damages. This disclaimer of liability applies to all products, publications and services during and
after the warranty period.
Revision Release Date Revisions Made
01 July 11, 2001 Initial Release
02 July 31, 2001 Release to:
1correct all custom defaults for Power A Missing and Power B Missing in Table 20, “Alarm
Types,” on page 61.
2correct table captions for Table 21, “Service Loss Alarm Types,” on page 62 and Table 22
on page 64.
3correct custom default for Environmental Alarm n(where n= 1 to 4), List 3 in Table 24,
“Environmental Alarm Types,” on page 65.
03 August 17, 2001 Release to:
1make corrections in “Specifications” on page 10. Height was changed to 5.50 in. (14.0 cm)
and Length was changed to 10.25 in (26.0 cm).
2correct Figure 6, “Front Panel Craft Port to Terminal Connections,” on page 15
3delete second and third sentences in second paragraph after Figure 13 on page 20.
4make corrections in “Logging On” on page 25 reference to the establishment of a password.
The third bullet, third sentence was revised.
5correct first line of second bullet on page 22.
6correct second line of first paragraph in the Download Retry section on page 70.
7correct other non-service affecting changes on pages 6, 7 and 52.
04 December 20, 2001 Release to rebrand document to comply with ADC standards
05 July 8, 2002 Eliminate references to the PMU-712 List 3
06 January 6, 2003 Updated Product Support Information
07 August 6, 2003 Updated external alarms
08 March 1, 2004 Updated DB-25 alarm information

SCP-PMU712-020-08H Using This Practice
PMU-712 List 2 March 1, 2004
USING THIS PRACTICE
Three types of messages, identified by icons, appear in the text.
INSPECTING YOUR SHIPMENT
Upon receipt of the equipment:
•Unpack each container and visually inspect the contents for signs of damage. If the equipment has been
damaged in transit, immediately report the extent of damage to the transportation company and to ADC.
Order replacement equipment, if necessary.
•Check the packing list to ensure complete and accurate shipment of each listed item. If the shipment is short
or irregular, contact ADC as described in “Returns” on page 77. If you must store the equipment for a
prolonged period, store the equipment in its original container.
Notes indicate information about special circumstances.
Cautions indicate the possibility of equipment damage or the possibility of personal injury.
Electrostatic Discharge (ESD) susceptibility symbols indicate that a device or assembly is
susceptible to damage from electrostatic discharge.You must wear an antistatic wrist strap
connected to the appropriate ground connection prior to performing installation procedures.
You must also observe normal ESD precautions when handling electronic equipment. Do not
hold electronic plugs by their edges. Do not touch components or circuitry.

Inspecting Your Shipment SCP-PMU712-020-08H
March 1, 2004 PMU-712 List 2

SCP-PMU712-020-08H
PMU-712 List 2 March 1, 2004 i
TABLE OF CONTENTS
Overview ____________________________________________________________________________ 1
Description and Features....................................................................................................................1
Local Area Network Interface .............................................................................................2
Voice Frequency Drop Line ................................................................................................2
Test Interface .......................................................................................................................2
Serial Management Interfaces .............................................................................................3
Composite Clock .................................................................................................................4
Alarms................................................................................................................................................5
Alarm Types.......................................................................................................................................6
External Environmental Alarm Contact Alarm Inputs/Outputs.........................................................6
Service Loss Alarm Reporting Via the TR-08 Derived Data Link....................................................9
Specifications ...................................................................................................................................10
Front Panel .......................................................................................................................................11
Installation and Test__________________________________________________________________ 13
Installing the PMU ...........................................................................................................................13
Initialization Sequence.....................................................................................................................14
ACO Pushbutton ..............................................................................................................................14
Administration ______________________________________________________________________ 15
Front Panel Craft Port to Terminal Connections .............................................................................15
Front Panel Craft Port to Modem Connections................................................................................16
Backplane Craft Port to Terminal Connections ...............................................................................16
Backplane Craft Port to Modem Connections .................................................................................17
Connecting Over TELNET ..............................................................................................................17
Software Connection .........................................................................................................18
Physical Connection ..........................................................................................................18
Isolated LAN .......................................................................................................18
MSLAN Connection to Router/Bridge/Switch - Same Segment ........................20
MSLAN Connection to Router/Bridge/Switch - Different Segment, Unrestricted
Route ............................................................................................................21
MSLAN Connection to Router/Bridge/Switch - Different Segment, Restricted
Route ............................................................................................................23
Provisioning, Performance Monitoring and Testing________________________________________ 24
Supplemental documentation...........................................................................................................24
Terminal Modes ...............................................................................................................................24
Logging On ......................................................................................................................................25
Changing Modes................................................................................................................27
PMU Main Menu .............................................................................................................................28

SCP-PMU712-020-08H
ii March 1, 2004 PMU-712 List 2
Main Submenu................................................................................................................................. 31
Shelf Summary Screen...................................................................................................... 32
Composite Clocks Screen ................................................................................................. 33
Test Access Screen............................................................................................................ 35
Start TL1 Session .............................................................................................................. 37
Logout Screen ...................................................................................................................38
Network Submenu ........................................................................................................................... 39
MultiShelf Access Screen ................................................................................................. 40
Connection Summary Screen............................................................................................ 41
Local Summary Screen ..................................................................................................... 42
Select Submenu ............................................................................................................................... 43
Alarms Submenu ............................................................................................................................. 45
Alarm Summary Screen .................................................................................................... 46
Alarm History Screen........................................................................................................ 47
Service Loss Alarm History Screen .................................................................................. 48
Environmental Alarm History Screen............................................................................... 49
Relay Summary Screen..................................................................................................... 50
LED Summary Screen ...................................................................................................... 51
Activate ACO Screen........................................................................................................ 52
Configuration Submenu................................................................................................................... 53
Shelf Options Screen......................................................................................................... 54
IP Information Screen ....................................................................................................... 58
Password Screen ............................................................................................................... 59
Alarm Types Screen.......................................................................................................... 60
Service Loss Alarm Types Screen .................................................................................... 62
Environmental Alarms Setup Screen ................................................................................ 63
Environmental Alarm Types Screen ................................................................................. 65
Date and Time Screen ....................................................................................................... 66
Terminal Mode Screen...................................................................................................... 67
Set Factory Defaults Screen.............................................................................................. 68
Software Download Submenu......................................................................................................... 69
Start A Download Screen.................................................................................................. 70
Download Retry ................................................................................................................ 72
Software Download with Modem ..................................................................................... 73
Modem Connected to PC.................................................................................... 73
Modem Connected to PG-FlexPlus .................................................................... 73
Error Messages ................................................................................................... 74

SCP-PMU712-020-08H
PMU-712 List 2 March 1, 2004 iii
Information Submenu ......................................................................................................................75
Inventory Screen................................................................................................................76
Help Screen........................................................................................................................76
Product Support _____________________________________________________________________ 77
Technical Support ............................................................................................................................77
Limited Warranty.............................................................................................................................77
Returns .............................................................................................................................................77
FCC Class A Compliance ................................................................................................................79
Modifications ...................................................................................................................................79
Acronyms___________________________________________________________________________ 80

SCP-PMU712-020-08H
iv March 1, 2004 PMU-712 List 2

SCP-PMU712-020-08H
PMU-712 List 2 March 1, 2004 v
LIST OF FIGURES
1. Typical System Configuration.........................................................................................................................1
2. Composite Clock Relationship........................................................................................................................4
3. Alarm Processing.............................................................................................................................................5
4. ENV Alarm Input Pinouts ...............................................................................................................................7
5. PMU-712 Front Panel....................................................................................................................................11
6. Front Panel Craft Port to Terminal Connections...........................................................................................15
7. Front Panel Craft Port to Modem Connections .............................................................................................16
8. Backplane Craft Port to Terminal Connections.............................................................................................16
9. Backplane Craft Port to Modem Connections...............................................................................................17
10. Isolated LAN Model......................................................................................................................................18
11. MSLAN Connection to Router/Bridge/Switch .............................................................................................20
12. MSLAN Connection with Different Segment, Restricted Route Model.......................................................21
13. TL1 Prompt Screen........................................................................................................................................25
14. TL1 Command Response Screen ..................................................................................................................26
15. Login Password Screen .................................................................................................................................26
16. Banner Screen................................................................................................................................................27
17. Changing from TL1 mode to Screens Mode .................................................................................................27
18. PMU Main Menu...........................................................................................................................................28
19. Menu Bar Summary ......................................................................................................................................30
20. MAIN Submenu ............................................................................................................................................31
21. Shelf Summary Screen ..................................................................................................................................32
22. Composite Clocks Screen..............................................................................................................................33
23. Test Access Selection Screen ........................................................................................................................35
24. MUX1 Test Access Screen............................................................................................................................35
25. Test Access Start Warning Screen ................................................................................................................36
26. Start TL1 Session Screen...............................................................................................................................37
27. No TL1 Access Error Screen.........................................................................................................................37
28. Logout Screen................................................................................................................................................38
29. Network Submenu Screen .............................................................................................................................39
30. MultiShelf Access Screen, No MultiShelf Connections ...............................................................................40
31. MultiShelf Access Summary Screen with MultiShelf Connections..............................................................40
32. Connection Summary Screen ........................................................................................................................41
33. Local Summary Screen..................................................................................................................................42
34. SELECT Submenu ........................................................................................................................................43
35. SELECT Warning, no MUX or COLU in slot ..............................................................................................43
36. PMX Unit #1 Main Screen ............................................................................................................................44

SCP-PMU712-020-08H
vi March 1, 2004 PMU-712 List 2
37. Alarms Submenu Screen............................................................................................................................... 45
38. Alarm Summary Screen................................................................................................................................ 46
39. Alarm History Screen ................................................................................................................................... 47
40. Service Loss Alarm History Screen.............................................................................................................. 48
41. Environmental Alarm History Screen........................................................................................................... 49
42. Relay Summary Screen................................................................................................................................. 50
43. LED Summary Screen .................................................................................................................................. 51
44. Activate ACO Screen.................................................................................................................................... 52
45. Activate ACO Acknowledgement Screen .................................................................................................... 52
46. CONFIG Submenu Screen............................................................................................................................ 53
47. Shelf Options Screen .................................................................................................................................... 54
48. Shelf Options Screen, Paged Forward .......................................................................................................... 55
49. IP Info Screen ............................................................................................................................................... 58
50. Password Screen ........................................................................................................................................... 59
51. Alarm Types Screen...................................................................................................................................... 60
52. Service Loss Alarm Types Screen ................................................................................................................ 62
53. Environmental Alarms Setup Screen............................................................................................................ 63
54. Environmental Alarm Types Screen............................................................................................................. 65
55. Date and Time Screen................................................................................................................................... 66
56. Terminal Mode Screen.................................................................................................................................. 67
57. Set Factory Defaults Screen.......................................................................................................................... 68
58. Software Download Submenu ...................................................................................................................... 69
59. Start A Download Screen ............................................................................................................................. 70
60. Software Download Confirmation Screen .................................................................................................... 71
61. Software Download Error Message Screen .................................................................................................. 71
62. Software Download System Ready Screen .................................................................................................. 72
63. Information Submenu ................................................................................................................................... 75
64. Inventory Screen ........................................................................................................................................... 76
65. Help Screen................................................................................................................................................... 76