AEG 34942G User manual

AUS ERFAHRUNG GUT
34942G/35940G/35941G/35944G
Gas hob
Table de cuisson
Gaskookplaat
Piano di cottura
Operating and Installation Instructions GB
Notice dutilisation et dencastrement FR
Gebruiksaanwij ing
en Installatievoorschrift
Istru ioni per luso e linstalla ione IT
NL

2
Important Safety Information
You MUST read these warnings carefully before installing or using the
hob. If you need assistance, contact our Customer Care Department on
87 5 35 35
Installation
lThis hob must be installed by qualified personnel, according to the
manufacturers instructions and to the relevant British Standards.
lAny gas installation must be carried out by a registered C RGI installer.
lRemove all packaging before using the hob.
lEnsure that the gas and electrical supply complies with the type stated on
the rating plate, located near the gas supply pipe.
lDo not attempt to modify the hob in any way.
Child Safety
lThis hob is designed to be operated by adults. Do not allow children to
play near or with the hob.
lThe hob gets hot when it is in use. Children should be kept away until it has
cooled.
lChildren can also injure themselves by pulling pans or pots off the hob.
During Use
lThis hob is intended for domestic cooking only. It is not designed for
commercial or industrial purposes.
lWhen in use a gas cooking hob will produce heat and moisture in the
ENGLISH GB

3
room in which it has been installed. Ensure there is a continuous air supply,
keeping air vents in good condition or installing a cooker hood with a venting
hose.
lWhen using the hob for a long period of time, the ventilation should be
improved, by opening a window or increasing the extractor speed.
lDo not use this hob if it is in contact with water. Do not operate the hob with
wet hands.
lEnsure the control knobs are in the  FF position when not in use.
lWhen using other electrical appliances, ensure the cable does not come
into contact with the hot surfaces of the cooking appliance.
lUnstable or misshapen pans should not be used on the hob as unstable
pans can cause an accident by tipping or spillage.
lNever leave the hob unattended when cooking with oil and fats.
lNever use plastic or aluminium foil dishes on the hob.
lPerishable food, plastic items and areosols may be affected by heat and
should not be stored above or below the hob unit.
Service
lThis hob should only be repaired or serviced by an authorised Service
Engineer and only genuine approved spare parts should be used.
Environmental Information
lAfter installation, please dispose of the packaging with due regard to safety
and the environment.
lWhen disposing of an old appliance, make it unusable, by cutting off the
cable.
Keep this instruction book for future reference and ensure
it is passed on to any new owner.
These instructions are only valid for countries whose identification
symbols are shown on the inside cover of this instruction booklet and on
the appliance itself.

4
Contents
Important Safety Information ...................................................... 2
Instructions for the User .............................................................. 6
Description of the Hob .................................................................. 6
Operation .................................................................................... 7
Maintenance and Cleaning ............................................................ 8
The Hob Top ........................................................................ 8
Pan Supports ....................................................................... 8
The Burners ......................................................................... 8
So ething Not Working? .............................................................. 9
Service and Spare Parts ............................................................... 10
Guarantee Conditions ..................................................................11
Instructions for the Installer ...................................................... 12
Engineers technical data ............................................................. 12
I portant safety require ents ..................................................... 14
Location .................................................................................... 14
Installation ................................................................................ 15
Gas Connection ................................................................. 16
Cut Out Size ...................................................................... 17
Building In ........................................................................ 17
Building over a cupboard or drawer ................................. 17
Building over a kitchen unit with door ............................. 18
Fitting the hob to the worktop ........................................ 19
Electrical connections ................................................................. 20
Per anent Connection ....................................................... 21
Wiring diagra .................................................................. 21
Fault Finding .............................................................................. 22
Preli inary Electrical Syste s Check .................................... 22
Ignition Syste / Gas Ignition ............................................. 24
Co issioning ........................................................................... 25
Pressure Testing ................................................................. 25
Servicing ................................................................................... 26
Conversion fro Natural Gas to LPG ............................................. 27

5
This appliance is manufactured according to
the following EEC directives:
73/23 EEC - 90/683 EEC - 93/68 EEC -
89/336 EEC - 90/396 EEC,
current edition.
Guide to Use the instructions
The following symbols will be found in the text to guide you throughout the
Instructions:
Safety Instructions
Step by step instructions for an
operation
Hints and Tips
F

6
1. Hob Top
2. Rapid Burner
3. Semi-rapid Burners
4. Double-crown Burner
5. Auxiliary Burner
6. Control knob for back left burner (semi-rapid)
7. Control knob for back right burner (semi-rapid)
8. Control knob for front right burner (auxiliary)
9. Control knob for central burner (double-crown)
10. Control knob for front right burner (rapid)
Description of the Hob (Mod. 34942 G)
I STALLATIO
Any gas installation must be carried out by a registered CORGI
installer, and in accordance with existing rules and regulations.
The relevant instructions are to be found in the second section of this
manual.
Please, ensure that, once the hob is installed, it is easily accessible for
the engineer in the event of a breakdown.
WHE THE HOB IS FIRST I STALLED
nce the hob has been installed, it is important to remove any
protective materials, which were put on in the factory.
7
8
9
10
123
5
3
4
6

7
HOB BUR ERS
To light a burner, turn the relevant control knob anticlockwise to
the maximum position ( ), then push it down to ignite the
burner. Upon, ignition, adjust the flame as required.
If the burner does not ignite, turn the control knob to zero, and
try again.
When switching on the mains, after installation or a power cut, it
is quite normal for the spark generator to be activated
automatically.
To ensure maximum burner efficiency, you should only use pots
and pans with a flat bottom fitting the size of the burner used
(see table).
Burner minimum maximum
diameter diameter
Double-crown 180 mm. 260 mm.
Large (rapid) 180 mm. 260 mm.
Medium (semi-rapid) 120 mm. 220 mm.
Small (Auxiliary) 80 mm. 160 mm.
Operation
As soon as a liquid starts boiling, turn down the flame so that it will
barely keep the liquid simmering.
If you use a saucepan which is smaller than the recommended size,
the flame will spread beyond the bottom of the essel, causing the
handle to o erheat.
Take care when frying food in hot oil or fat, as the o erheated
splashes could easily ignite
If the control knobs become difficult to turn, please contact your local
AEG Ser ice Force Centre.

8
Before any maintenance or cleaning can be carried out, you must
DISCONNECT the hob from the electricity supply.
The hob is best cleaned whilst it is still warm, as spillage can be
removed more easily than if it is left to cool.
The Hob Top
Regularly wipe over the hob top using a soft cloth well wrung out in
warm water to which a little washing up liquid has been added. Avoid
the use of the following:
- household detergent and bleaches;
- impregnated pads unsuitable for non-stick saucepans;
- steel wool pads;
- bath/sink stain removers.
Should the hob top become heavily soiled, it is recommended that a
cleaning product such as Hob Brite or Bar Keepers Friend is used.
Pan Supports
When washing the pan supports by hand, take care when drying them
as the enamelling process occasionally leaves rough edges. If necessary,
remove stubborn stains using a paste cleaner.
The Burners
The burner caps and crowns can be removed for cleaning.
Wash the burner caps and crowns using hot soapy water, and remove
marks with a mild paste cleaner. A well moistened soap impregnated
steel wool pad can be used with caution, if the marks are particularly
difficult to remove.
After cleaning, be sure to wipe dry with a soft cloth.
Maintenance and Cleaning

9
Something Not Working?
If the hob is not working correctly, please carry out the following checks
before contacting your local AEG Service Force Centre.
SYMPT M
nThere is no spark when lighting
the gas
nThe gas ring burns unevenly
S LUTI N
uCheck that the unit is plugged in
and the electrical supply is
switched on
uCheck that the RCCB has not
tripped (if fitted)
uCheck the mains fuse has not
blown
uCheck the burner cap and crown
have been replaced correctly, e.g.
after cleaning.
uCheck the main jet is not blocked
and the burner crown is clear of
food particles.
uCheck the burner cap and crown
have been replaced correctly, e.g.
after cleaning.
If after all these checks, your hob still does not operate correctly, contact
your local AEG Service Force Centre.
Please note that it will be necessary to provide proof of purchase for any in-
guarantee service calls.
In-guarantee customers should ensure that the above checks have been
made as the engineer will make a charge if the fault is not a mechanical or
electrical breakdown.

10
Service and Spare Parts
When you contact the Service Centre, they will need the following
information:
1. Your name, address and post code.
2. Your telephone number
3. Clear and concise details of the fault
4. The model and the serial number (see rating label on the back of this
instruction booklet)
5. Date of purchase
If you require spare parts or an engineer contact your local Service
Force Centre by telephoning:
0870 5 929 929
Your call will be routed to your local Service Force Centre.
For the address of your local Service Force Centre and further
information about Service Force, please visit the website at
www.serviceforce.co.uk
CUSTOMER CARE
For general enquiries concerning your AEG appliance and for further
information on AEG products, contact our Customer Care Department
by letter or telephone at the address below or visit our website at
www.aeg.co.uk
Customer Care Department
AEG Domestic Appliances
55 - 77 High Street
Slough
Berkshire
SL1 1DZ
Tel : [phone]*
* calls to this number may be recorded for training purposes.