Apator ULTRIMIS UL2,5 Installation instructions

WATER METER TYPE
Ultrasonic water meters
with copper body and
integrated RF connectivity
Ultrimis UL
DN15-50
Ultrasonic water meters
with composite body and
integrated RF connectivity
Ultrimis UL-01
DN15-20
CE, MID, IP68, WM-Bus, LoRaWAN CE, MID, IP68, WM-Bus, LoRaWAN
SHIPPING AND STORAGE
Protect against shocks and vibration.
Store between 0°C and 25°C.
BASIC INFORMATION
ESSENTIAL INSTALLATION COMPONENTS
CLASSIFICATION OF ENVIRONMENTAL CONDITIONS
- Environmental classification – Climate and mechanical conditions: Class B(EN ISO 4064: 2014)
- Environmental classification – mechanical conditions: Class M1 (Directive 2014/32/UE of 26 February 2014)
- Electromagnetic conditions: Class E1 & E2 (EN ISO 4064: 2014 and Directive 2014/32/UE of 26 February 2014)
COMPATIBILITY AND INSTALLATION REQUIREMENTS
WM-Bus03A NFC
EU868MHz
Operating
orientation
UD
UD
M
nx
nx
Ultrimis UL, UL-01  U0 D0 U5 D3
Apator Powogaz half unions G g d L Index
DN 15 mm kit of half unions w/gaskets ¾” ½” 17 mm 37.5 0616-100-018
DN 20 mm kit of half unions w/gaskets 1” ¾” 23 mm 45.5 0616-100-019
DN 25 mm kit of half unions w/gaskets 1¼” 1” 29 mm 46.5 0616-100-021
DN 32 mm kit of half unions w/gaskets 1½” 1¼” 36 mm 56.0 0616-100-026
DN 40 mm kit of half unions w/gaskets 2” 1½” 41 mm 67 0616-100-020
ULTRIMIS WATER METER INSTALLATION & OPERATING MANUAL
Ultrimis ***
UL2,5 DN15 17 29 25 Nm
UL2,5-01 DN15 17 29 15 Nm
UL4 DN20 20 36 30 Nm
UL4-01 DN20 20 36 20 Nm
UL6,3 DN25 36 47 35 Nm
UL10 DN32 44 54 40 Nm
UL16 DN40 50 67 45 Nm
UL25 DN50 24 24 -
Battery life 16 years max.**
Two integrated 3.6 V DC lithium batteries,
size AA
* 10 bar is available on special order.
** Depending on the configuration and ambient
conditions.
*** The actual installation may feature other connection fitting dimensions.
ACCESSORIES
Smartphone TestBox
Android, NFC Available for 433 MHz or 868 MHz service, de-
pending on the water meter’s RF module version
Smartphone app
Android, NFC
Max water temperature 70°C
Ambient temperature 5-55°C
Operating pressure 16 bar*
RF connectivity
parameters:
61
107
107
61
Flanged DN50 port gasket acc. to PN-EN 1514-1:2001
868 MHz up to 25 mW E.R.P.
434 MHz up to 10 mW E.R.P.
Communication
standard:
WM-Bus, OMS-compliant
LoRaWAN V1.0.4-compliant

Installation and operating recommendations
This product should be installed
by a professional licensed for
servicing and operation of water
and sewage systems.
Close the upstream and
downstream valves before
installing/removing the product.
When installing or removing the
water meter, place a container to
collect the liquid,clean the threaded
ends,and flush the system section
the water meter will be installed in.
Mind the indicated direction of
water flow.
Install a separating filter
upstream of the water meter.
UD
SERWIS
Keep the straight line sections
upstream and downstream of
the water meter as shown in the
table below
Protect from air pockets; do not
install in the highest points of the
system.
Have the water meter serviced if
defective.
Prevent stresses from
misalignment with the pipeline.
This device is suitable operation
in wet or flooding conditions
per IP68
0°C
H2SO4
GAZ
Protect from freezing. Protect from hight
temperature and UV light. Protect from vibration. Do not use near sources of acids, gases and/or electrical systems. Protect from shocks.
Do not dispose of the
device with household
waste. Bring the device
to a selective waste
collection point. Please
recycle.
NOTE: See www.apator.com
for detailed information about
the operating principle and
conditions.
Protect from hydraulic shocks. Keep the installation site clean.
Minimum water meter
downstream pressure
Pmin ≥ 0.3 bar
CONNECTION EXAMPLE DIAGRAM
Test
WM-Bus 03A NFC
EU 868MHz
AMR
system
Collector data
reading
Stationary data
reading
Verification
2022.060.I.EN
Apator Powogaz S.A. has the right to modify and improve the manufactured equipment without prior notice.
Remote reading
Data register reading
Configuration
External module
TestBox
*
* For WM-Bus only