Astria 126730-01 Owner's manual
Installation and Operation Instructions
AstriaTM Direct-Vent Gas Fireplace
P/N 126730-01 Rev. A 1/2014
.
PFS
®
USC
Models
Devonshire36TEN Devonshire36TEP Devonshire42TEN Devonshire42TEP
P126730-01
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Installateur : Laissez cette notice avec l’appareil.
Consommateur : Conservez cette notice pour consultation ultérieure.
A barrier designed to reduce the risk of burns
from the hot viewing glass is provided with this
appliance and shall be installed.
Une barrière conçue pour réduire le risque de brûlure
par le hublot chaude est fournie avec l’appareil et doit
être installé.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile
home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.
WARNING AVERTISSEMENT AVISO
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
UNE SURFACE VITRÉE CHAUDE PEUT
CAUSER DES BRÛLURES.
LAISSER REFROIDIR LA SURFACE VITRÉE
AVANT D’Y TOUCHER.
NE PERMETTEZ JAMAIS À UN ENFANT DE
TOUCHER LA SURFACE VITRÉE.
EL VIDRIO CALIENTE
CAUSARÁ QUEMADURAS.
USTED DEBE NUNCA TOCAR
EL VIDRIO CALIENTE.
LOS NIÑOS DEBEN NUNCA
TOCAR EL VIDRIO.
WARNING: If the information in these
instructions is not followed exactly, a fire or
explosion may result causing property damage,
personal injury or death.
AVERTISSEMENT : Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire au
minimum le risque d’incindie ou d’explosion ou pour éviter
tout dommage matériel, toute blessure ou la mort.
—Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
—WHAT TO DO IF YOU SMELL GAS:
s Do not try to light any appliance.
s Do not touch any electrical switch; do not
use any phone in your building.
s Immediately call your gas supplier from
a neighbor’s phone. Follow the gas
supplier’s instructions.
s If you cannot reach your gas supplier, call
the fire department.
—Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
—Ne pas entreposer ni utilizer d’essence ni d’autres
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
—QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :
s Ne pas tenter d’allumer d’appareil.
s Ne touchez à aucan interrupteur. Ne pas vous
servir des téléphones se trouvant dans le bâtiment
où vous trouvez.
s Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
s Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
—L’installation et l’entretien doivent être assurés par un
installateur ou un service d’entretien qualifié ou par le
fournisseur de gaz.
SAFETY
WARNING: Improper instal-
lation, adjustment, alteration,
service or maintenance can
cause injury or property damage.
Refer to this manual for correct
installation and operational
procedures. For assistance or
additional information consult
a qualified installer, service
agency or the gas supplier.
This appliance is only for use
with the type of gas indicated on
the rating plate. This appliance
is not convertible for use with
kit is used.
State of Massachusetts: The
installation must be made by a
in the Commonwealth of Mas-
sachusetts.
WARNING: This product
contains and/or generates
chemicals known to the State
of California to cause cancer or
birth defects or other reproduc-
tive harm.
IMPORTANT: Read this owner’s
manual carefully and completely
before trying to assemble, op-
can cause serious injury or
-
sion, electrical shock and carbon
poisoning may lead to death!
-
with INNOVATIVE HEARTH PRODUCTS vent
ANSI Z21.50/CSA 2.22
NOTICE: Decorative product not
for use as a heating appliance.
-
-
TABLE OF CONTENTS
2
5
5
5
6
8
9
10
18
24
26
27
28
29
32
32
33
33
33
33
34
42
-
Get fresh air at once!
Natural and Propane/LP Gas:
Any parts removed for servicing must be replaced prior to operat-
WARNING: This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not convertible for
Due to high temperatures, the appliance should be located out of
appliance. Never place any objects on the appliance.
-
mable material.
Furniture and drapes must
. Fireplace will
remain hot for a time after shutdown. Allow surface to cool before
touching.
SAFETY
Continued
Young children should be carefully supervised when they are in the
same room as the appliance. Toddlers, young children and others may
be susceptible to accidental burns.A physical barrier is recommended if
or stove, install an adjustable safety gate to keep toddlers, young children
and other at-risk individuals out of the room and away from hot surfaces.
www.Astria.US.com 126730-01A4
Carefully supervise young chil-
dren when they are in the room
Keep the area around your
materials, gasoline and other
are used or stored.
-
SAFETY
Continued
-
See Cleaning and Maintenance
-
National Electrical Code,
ANSI/NFPA 70 or Canadian Electrical
Code, CSA C22.1.
www.Astria.US.com
126730-01A 5
Figure 1 - Direct Vent Fireplace
LOCAL CODES
National Fuel Gas Code ANSI
Z223.1/NFPA 54* CSA-
B149.1 Installation Code
PRODUCT IDENTIFICATION
PRODUCT FEATURES
-
-
-
www.Astria.US.com 126730-01A6
Figure 2 - Common Fireplace Locations
Figure 3 - Fireplace Top Dimensions
Figure 4 - Electrical Outlet and Gas
Knockout Locations
PRE-INSTALLATION
LOCATION AND SPACE
REQUIREMENTS
-
-
-
-
-
29" (36")
34
3
/
4
" (42")
21" (36")
25" (42")
41
1
/
4
" (36")
48
1
/
4
" (42")
11
7
/
8
" (36")
13
5
/
8
" (42")
NAILING
FLANGE
NAILING
FLANGE
GAS LINE
KNOCK
OUT
GAS LINE
KNOCK OUT
ELECTRICAL
OUTLET
LEFT SIDE
RIGHT SIDE
2.25"
10.75"
(36" MODEL)
(36" MODEL)
11.50"
(42" MODEL)
(42" MODEL) 11.50"
10.75"
2.25"
6.75"
www.Astria.US.com
126730-01A 7
C
B
A
DE
FG
3
2
1
4
5
6
7
Wall
CLEARANCES
venting
-
ed for use as supplemental heat.
your primary heating system.
your primary heat source. If you
have a central heating system,
you may run system’s circulat-
This will help circulate the heat
throughout the house.
FRAMING AND FINISHING
-
-
-
Note: Noncombustible mantels may discolor!
PRE-INSTALLATION
Continued
Figure 5 - Framing Clearances
Figure 6 - Framing Clearances for Corner
Installation
Figure 7 - Clearances for Combustible
Mantels
Ref.
Mantel
Depth Ref.
Mantel from
Top of Opening
1 A
2
3 C
4 D
5 E
6 F
7 G
36
3
/
8
"
(36")
43
3
/
8
" (42")
43" (36"), 50" (42")
41" (36"), 48" (42")
15
3
/
4
"
(36")
19" (42")
51
3
/
8
"
(36")
61
3
/
4
" (42")
Nailing
Flange
44
"
(36")
48
"
(42")
41
"
(36")
48
"
(42")
www.Astria.US.com 126730-01A8
Fixed
Closed OpenableFixed
Closed
V
V
V
V
VV
V
V
X
X
VX
G
G
J
F
B
B
K
N
H
I
A
N
E
L
D
B
M
A
C
B
V
V
A
G
G
B
TERMINATION CAP AIR SUPPLY INLET GAS METERRESTRICTED AREA
(TERMINATION PROHIBITED)
A = clearance above grade, veranda, porch, deck, or
balcony [*12" (30.5 cm) minimum]
B = clearance to window or door that may be opened
[6" (15 cm) min. for 10,000 Btu or less; 9" (23 cm) in US
if between 10,000 and 50,000, 12" (30 cm) in Canada
if between 10,000 and 100,000; 12" (30 cm) in US if
greater than 50,000, 36" (91 cm) in Canada if greater
than 100,000]
C = clearance to permanently closed window
[minimum 12" (30.5 cm) recommended to prevent
condensation on window]
D = vertical clearance to ventilated soffit located above the
terminal within a horizontal distance of 24" (61 cm) from
the center-line of the terminal [18" (45.7 cm) minimum]
E = clearance to unventilated soffit [12" (30.5 cm) minimum]
F = clearance to outside corner (see below)
G = clearance to inside corner (see below)
H = *not to be installed above a meter/regulator assembly
within 36" (91.4 cm) horizontally from the center line
of the regulator
I = clearance to service regulator vent outlet [*72" (182.9 cm)
minimum]
J = clearance to non-mechanical air supply inlet to building
or the combustion air inlet to any other fireplace
[6" (15 cm) min. for 10,000 Btu or less; 9" (23 cm) in US
if between 10,000 and 50,000, 12" (30 cm) in Canada
if between 10,000 and 100,000; 12" (30 cm) in US if
greater than 50,000, 36" (91 cm) in Canada if greater
than 100,000]
K = clearance to a mechanical air supply inlet [*In Canada,
6 ft. (1.83m) minimum; In US 3 ft. (91 cm) above if within
10 ft. (3 m) horizontally]
L = † clearance above paved side-walk or a paved driveway
located on public property [*84" (213.3 cm) minimum]
M = clearance under veranda, porch, deck
[*12" (30.5 cm) minimum ‡]
N = clearance above a roof shall extend a minimum of
24" (61 cm) above the highest point when it passes
through the roof surface and any other obstruction within
a horizontal distance of 18" (45.7 cm)
† vent shall not terminate directly above a side-walk or paved driveway which is located between two
single family dwellings and serves both dwellings*
‡ only permitted if veranda, porch, deck or balconey is fully open on a minimum of 2 sides beneath the floor*
* as specified in CAN/CSA B149 (.1 or .2) Installation Codes (1991) for Canada and U.S.A.
Note: Local codes or regulations may require different clearances
A = 6" (15.2 cm)
Inside Corner
V
B
E
V
B = 6" (15.2 cm)
C = Maximum depth of 48" (121.9 cm)
for recessed location
D = Minimum width for back wall of
recessed location -
Combustible - 38" (965 mm)
Noncombustible - 24" (61 cm)
E = Clearance from corner in
recessed location-
Combustible - 6" (15.2 cm)
Noncombustible - 2" (5.1 cm)
Outside Corner Recessed Location
G
H
G = 12" (30.5 cm) minimum clearance
Balcony with No Side Wall
V
J
Combustible &
Noncombustible
H = 24" (61 cm)
J = 20" (50.8 cm)
Balcony with Perpendicular Side Wall
C
D
C
Termination Clearances for Buildings with Combustible and Noncombustible Exteriors
Openable
Figure 8 - Minimum Clearances for Termination Cap
LOCATION OF TERMINATION CAP
www.Astria.US.com
126730-01A 9
REQUIREMENTS FOR THE COMMONWEALTH OF
MASSACHUSETTS
-
INSTALLATION OF CARBON
MONOXIDE DETECTORS
-
-
SIGNAGE
INSPECTION
-
MANUFACTURER REQUIREMENTS
Gas Equipment Venting System Provided
Gas Equipment Venting System Not
Provided
-
-
-
-
-
-
-
www.Astria.US.com 126730-01A10
VENTING INSTALLATION
NOTICE: Do not seal termination
cap to vent pipe. Cap must be
removable for vent inspection
and maintenance.
INSTALLATION PRECAUTIONS
HEARTH PRODUCTS
and vent assembly must be
vented directly to the outside.
The venting system must NEVER
be attached to a chimney serv-
ing a separate solid fuel burning
appliance. Each direct vent gas
appliance must use a separate
vent system. Do not use com-
mon vent systems.
WARNING: Vent pipe air
space clearances to combus-
on the horizontal sections,
which require 2" clearances
from the top of the pipe. Where
the termination cap penetrates
a combustible wall, 1" air space
clearance is required.
NOTICE: Read these instruc-
tions completely before attempt-
ing installation.
-
-
-
-
-
-
-
WARNING: Read all instruc-
tions completely and thoroughly
before attempting installation.
Failure to do so could result in
serious injury, property damage
or loss of life.
NOTICE: Failure to follow these
instructions will void the warranty.
www.Astria.US.com
126730-01A 11
INSTALLATION PLANNING
Horizontal Termination Installation
IMPORTANT:
-
-
-
-
-
Twist-Lock Procedure:
-
Note: Horizontal runs of vent must be sup-
ported every three feet. Use wall straps
for this purpose.
an 11 1212
-
VENTING INSTALLATION
Continued
Figure 9 - Vent Pipe Connections
Figure 10 - Vent Opening Requirements
-
12
WARNING: Do not recess
vent termination into any wall.
(Framing
Detail)
11
1
/
2
"
11
1
/
2
" Inside Framing
11
1
/
2
"
8
1
/
2
"
Vent
O
pening
Combustible Wall
Vent Opening
Noncombustible Wall
www.Astria.US.com 126730-01A12
VENTING INSTALLATION
Continued
12
Note: Four wood screws provided should
be replaced with appropriate fasteners for
stucco, brick, concrete or other types of
sidings (see Figure 11).
12
Connecting Vent Cap with Horizontal
Vent Pipe:
Figure 11 - Installing Horizontal Vent Cap
(Noncombustible Exterior)
Figure 12 - Installing Siding Standoff
(Combustible Exterior Wall)
Vent
Figure 13 - Connecting Vent Cap with
Horizontal Vent Pipe
-
14
IMPORTANT:-
www.Astria.US.com
126730-01A 13
VENTING INSTALLATION
Continued
Figure 14 - Typical Horizontal
Termination Cap Mounting with
Additional Siding Standoff Installed
Siding
High Wind
11 1212
114
Vent
-
NOTICE: Do not seal termination
cap to vent pipe. Cap must be
removable for vent inspection
and maintenance.
WARNING: Never run vent
downward as this may cause
improperly installed and main-
tained venting system could
result in serious injury, property
damage or loss of life.
www.Astria.US.com 126730-01A14
VENTING INSTALLATION
Continued
Figure 16 - Horizontal Termination Using Two 90° Elbows
Venting with Two 90° Elbows
Vertical (V) Horizontal (H1) +
Horizontal (H2)
GROUND FLOOR INSTALLATION
Figure 15 - Horizontal Termination Using One 90° Elbow
H
(V) Vertical
Minimum
Required
Vertical Pipe
(H) Horizontal
www.Astria.US.com
126730-01A 15
VENTING INSTALLATION
Continued
Figure 17 - Offset with Wall Strap and 45°
Elbows
Flat Ceiling Installation
12-
1212
-
11 1212
-
Note: If an offset is needed to avoid obstruc-
tions, you must support vent pipe every 3 feet.
Use wall straps for this purpose (see Figure
17). Whenever possible, use 45° elbows
instead of 90° elbows. The 45° elbow offers
-
Vent Termination Chart
Minimum Height
Roof Pitch Feet Min.
1
2
4
5
6
7
Vertical Termination Installation
Note: Vertical restrictor must be installed in
all vertical installations.
Note: Pay
special attention to these installation
instructions for required clearances (air
space) to combustibles when passing
through ceilings, walls, roofs, enclosures,
attic rafters, etc. Do not pack air spaces
with insulation. Also note maximum
vertical rise of venting system and any
maximum horizontal offset limitations.
www.Astria.US.com 126730-01A16
Figure 18 - Installing Firestop
Note: If vent pipe passes through any occupied
and closets, you must enclose pipe. You may
frame and sheetrock enclosure with standard
construction material. Make sure and meet the
minimum allowable clearances to combustibles.
PARTS LIST FOR VENTING KITS
AND COMPONENTS
INNOVATIVE HEARTH PRODUCTS (5/8")
Pipe & Vent Kits
Number Description
HTS-58
Note: You must increase vent height for
steep roof pitches. Nearby trees, adjoining
similar factors may cause poor draft or
down-drafting in high winds. Increasing
vent height may solve this problem.
VENTING INSTALLATION
Continued
www.Astria.US.com
126730-01A 17
VENTING INSTALLATION
Continued
Vertical
Venting
Venting with Two 90° Elbows
Vertical (V1) Horizontal (H)
Note:
www.Astria.US.com 126730-01A18
FIREPLACE INSTALLATION
CHECK GAS TYPE
INSTALLING GAS PIPING TO
FIREPLACE LOCATION
WARNING: A qualified
service person must connect
all local codes.
CAUTION: For propane/LP
directly to the propane/LP sup-
-
LP supply.
WARNING: For natural
private (non-utility) gas wells.
This gas is commonly known
as wellhead gas.
Installation Items Needed
-
-
-
CAUTION: Use only new,
black iron or steel pipe. Inter-
nally-tinned copper tubing may
be used in certain areas. Check
your local codes. Use pipe of
1/2" diameter or greater to allow
If pipe is too small, undue loss
of volume will occur.
IMPORTANT:-
Figure 21 - External Regulator with Vent
Pointing Down (Propane/LP Only)
www.Astria.US.com
126730-01A 19
FIREPLACE INSTALLATION
Continued
Figure 22 - Gas Connection
Gas Line
Natural
Propane/LP
-
Figure 23 - Connecting Incoming Gas Line to Flex Gas Line
WARNING: Use pipe joint
sealant that is resistant to liquid
petroleum (LP) gas.
-
CONNECTING FIREPLACE TO GAS
SUPPLY
Installation Items Needed
-
Checking Gas Connections,
Note:
MAIN
IN
OUT
PILOTADJ
PILOT
Gas Line
Gas Line
www.Astria.US.com 126730-01A20
FIREPLACE INSTALLATION
Continued
CHECKING GAS CONNECTIONS
WARNING: Test all gas piping
and connections, internal and
installing or servicing. Correct
all leaks at once.
WARNING: Never use an
Apply noncorrosive leak detec-
forming show a leak. Correct all
leaks at once.
PRESSURE TESTING GAS SUPPLY
PIPING SYSTEM
(3.5 kPa)
-
-
-
Test Pressures Equal To or Less Than
1/2 PSIG (3.5 kPa)
-
Figure 24 - Equipment Shutoff Valve
Figure 25 - Checking Gas Joints for
Propane/LP Gas Fireplace
PRESSURE TESTING FIREPLACE GAS
CONNECTIONS
-
Figure 26 - Checking Gas Joints for
Natural Gas Fireplace
Table of contents
Other Astria Indoor Fireplace manuals
Astria
Astria Georgian Cat 50 User manual
Astria
Astria Zeta21ZMN F1241 User manual
Astria
Astria LibraST40DMN Setup guide
Astria
Astria VILLA VISTA User manual
Astria
Astria Envy35xxx series User manual
Astria
Astria Marquee36 User manual
Astria
Astria Ladera-BK User manual
Astria
Astria Gemini33TMN User manual
Astria
Astria Valiant32ZP2 User manual
Astria
Astria MontebelloDLX40TEN User manual
Astria
Astria MontebelloDLX40TYN User manual
Astria
Astria Tuscan36P2 User manual
Astria
Astria Aries 33 User manual
Astria
Astria Sentinel36TEN User manual
Astria
Astria Oracle Cat 50 User manual
Astria
Astria CraftsmanCat 36P2 User manual
Astria
Astria BerlinLights43ZEP User manual
Astria
Astria Craftsman 36P2 User manual
Astria
Astria Gamma26ZTN User manual
Astria
Astria montecito Setup guide
Popular Indoor Fireplace manuals by other brands
Napoleon
Napoleon NEFL42CHD-1 manual
Masport
Masport WOOD FIRE installation guide
JAYLINE
JAYLINE SS280 Installation & operation instructions
Heat-N-Glo
Heat-N-Glo SL-32S Installation
kozy heat
kozy heat Bellingham 52 quick start guide
Paragon Fires
Paragon Fires ROOM SEALED INSET LIVE FUEL EFFECT GAS FIRE owner's manual
Monessen Hearth
Monessen Hearth LCUF32CR-B Installation & owner's manual
PuraFlame
PuraFlame Galena owner's manual
Dimplex
Dimplex Toluca Deluxe instruction manual
SEI
SEI TENNYSON FA8544AO Assembly instructions
Dru
Dru G25 installation manual
Capital fireplaces
Capital fireplaces Designline DL700 Installation and user instructions
IronStrike
IronStrike VINTAGE VINT-DVS-U Installation and operation
ACR Heat
ACR Heat HERITAGE N25 Installation and operating instruction manual
European Home
European Home HVF-42 Installation, operation and owner's manual
Quadra-Fire
Quadra-Fire MTVERNINSAE-MBK Owner's manual operation & care
Harman Home Heating
Harman Home Heating Accentra Insert Installation & operating manual
Trimline Fires
Trimline Fires Zircon 1024 installation instructions