BOSSCO 610UA User manual

CONTENTS
Precautions................................................................................................................................................. 1
Take Precaution
.............................................................................................................................. 1
Lithium Battery Cell Warnings
......................................................................................................................................1
Installation ................................................................................................................................................2-3
Installation Procedures
Installation Opening
..........................................................................................................................
................................................................................................................................
2
2
Removal of the Main Unit .......................................................................................................................3
Wiring Connections.................................................................................................................................3
Control Panel Button Locations.................................................................................................................. 4
Operation ................................................................................................................................................. 4-5
Power / SRC ............................................................................................................................................4
Troubleshooting..........................................................................................................................................
6
.............................................................................................................................................
7
ii
4
Adjust Volume (VOL)
.........................................................................................................
.....................................................................................................................
4
.............................................................................................................................. 5
Set the Clock (CLK)
......................................................................................................... 5
Change the Source (SRC)
............................................................................................................................. 5
Reset System (RESET)
.................................................................................................5
......................................................................................................................5
Switch Between US and EU Frequency
...................................................................................................................5
Change Bands (BAND).......................................................................................................................... 5
Manual Tuning (|<< / >>|)
.............................................................................................................5
5
Auto Seek Tuning (|<< / >>|)
...................................................................................................................................................... 5
Automatic Music Search (AMS)
Mute
..........................................................................................................................................
Store/Recall Preset Stations (1 - 6)
.......................................................................................................................................... 5
USB Port and Micro SD Card Slot
AUX In Jack
......................................................................................................................... 5
Track Search
4
4
...........................................................................
Play/Pause, Intro, Repeat, Random, Tracks playback
Track/Folder Navigation
5
5
...............................................................................................................................
........................................................................................................................
........................................................................................................................
Next/Previous Track
Fast Forward/Backward

PRECAUTIONS
Lithium Battery Cell Warnings
 Cell leakage may cause damage to the remote control.
 Do not throw cells into as this may cause an explosion.
 Keep battery cells out of reach of children.
Take Precaution





 Be sure to lower the volume before switching off the unit or the ignition key.
Some MP3/WMA files may not be playable.
1

INSTALLATION
Installation Procedures
Installation Opening
First complete the electrical connections and then check for correctness.
This unit can be installed in any dashboard
Having an opening as shown above .
Insert mounting collar into the dashboard and bend
the mounting tabs out with a screwdriver.
Make sure that lock lever is flush with the mounting
collar( not projecting outward).
2.05 inch
7.20 inch MOUNTING SLEEVE
2

INSTALLATION(CONT.)
3
- Only use speakers with 4 ohms impedance.
- Do not attach the control panel to the chassis before wiring is complete.
- The maximum current of the auto antenna is 200mA.
Wiring Connections
!
Removal of the Main Unit
1. Remove the metal strap from the main unit.
2. Remove the plastic trim out from the main unit.
3. Insert a bracket key into the left and right side of the main unit and draw the unit out of
the mounting sleeve.
WIRING
DIAGRAM
CAUTION
+12V DC
NEGATIVE
GROUND
15
Radio Antenna
15A
Purple +
Rear Left Speaker
Front Left Speaker
White +
Green +
Green/Black -
White/Black -Gray/Black -
Gray +
Front Right Speaker
Purple/Black -
Rear Right Speaker ACC + (Red)
GND - (Black)
ANT + (Blue)
Power B + (Yellow)
White:Front Left PRE-AMP Output
White: Rear Left PRE-AMP Output
Red: Front Right PRE-AMP Output
Red: Rear Right PRE-AMP Output

CONTROL PANEL BUTTON LOCATIONS
4
OPERATION
RADIO,USB&CARD , AUX IN,modes (if there are USB and SD card inside the unit).
1.POWER/SRC
to turn off the unit.
inserts a USB flash drive or SD Card, their respective logos will illuminate on the display.
radio and Aux. When the user
8. CLK
9
101113
12 14 1516
During USB or SD card mode, press the ‘1/>||’ button to pause or resume music playback.
Press the ‘2/INT’ button to play the first 10 seconds of each track, press again to stop the introduction
scan, and play the current track.
Press the ‘3/RPT’ button to repeat the current track, press again to stop repeat plaback and resume
normal playback.
Press the ‘4/RDM’ button to play all tracks in random order, press again to cancel random playback.
Press the CLK button once to display the real time, With time appearing on the display.Press and hold
CLK button for more than 2 seconds until the hour flashes. You can adjust the HOUR by pressing the
button and button. Then press the CLK button briefly, the minute will flash, you can adjust the
MINUTE by pressing the button and button.

OPERATION
5
9. USB Port / Micro SD Card Slot
11.FF( ) &12.FB( )
13.BND/AMS
In radio mode,short press the BND/AMS button repeatedly to select the one of the radio band :
FM 1,FM 2,FM 3, AM1,AM2 in a cycle sequence. When you select a band, the word F1、F2、F3
for FM band, and A1、A2 for AM band will be shown on the LCD display.
Press the BND/AMS
check When the 6 strongest stations will be
stored into
14. MUTE
15. AUX IN JACK
16. RESET
To reset all parameters to factory default values. Use a subject with a sharp point end to thrush the
RESET hole.
flash on the LCD
Finally press the CLK button to confirm the time adjustments.
In the radio mode:
Long press the or button for more than 2 seconds, the unit will switch to manual tuning
mode, briefly press the or button to search the next or previous frequency step by step.
Short press the or button, the automatic search will start, it will search upward or downward
for the strong signal radio station within the cuttent band. The auto searching will stop until find a
station.
In the USB or SD card mode:
Briefly press the or button to play the the next or previou track.
Press and hold the or button to fast forward or fast backward.
During USB or SD playback, short press the BND/AMS button to enter track search mode, then rotate
the VOL knob to select the number of your favorite track with high speed, then press the VOL knob to
confirm and play the selected track. If no any operation in 5 seconds,it will play the current track.
At the radio status,press and hold the VOL button to enter switch state of the US(USA) and EU
(EUROPE) frequency,then rotate the VOL knob to select US frequency or EU frequency,after
selecting US or EU frequency,the system will switch to the selected frequency 3 seconds later.
In the radio mode, rotate the volume knob to increase or decrese the volume level of the sound
VOL
Rotate the knob on the front panel to adjust the selected item.

6
TROUBLESHOOTING
Connect the battery cable to the terminal that is always live.
.
A lot of static in
broadcast

7
SPECIFICATIONS
General
Power supply Requirement : DC 12V
Maximum power output : 50W X 4CH
Speaker impedance : 4 - 8 Ohm
Unit Dimensions(WxHxD) : 7.0 X 2.0 X 3.8 inch
Weight : 1.54 Lb (0.7 kg)
Fuse : 15 A
FM
Frequency Range USA / EUROPE: 87.5 MHz - 107.9 MHz / 87.5 MHz - 108.0MHz
Channel step: 200 KHz / 50 KHz
AM
Frequency Range USA / EUROPE: 530 KHz - 1710 KHz / 522-1620 KHz
Channel step: 10 KHz / 9 KHz
USB/Card
RADIO
Usable Audio Formats ......................................................................................... MP3/WMA
Pre-amp Output
..................................................................................................
Frequency Response ......................................................................................... 20 Hz - 20 KHz
S/N Ratio
............................................................................................................................ 60dB
Front and Rear