Braemar TA SERIES Assembly instructions

H o m e O wn e r s G uid e
G A S DUC TE DH E A TE R
T A SE R IES
APRIL 2002

F ea t u r es
I N T R O DUC TIO N
Congratulations on choosing a Braemar Gas Ducted Heating Unit.
Your Braemar Heater is built from the highest quality materials
and is engineered to provide many years of trouble free performance.
Please take a moment to read these instructions.
D e li ve r y
The customer or installer, upon delivery of the heater should ensure
that the model number and gas type is as requested.
A data label on the end of the heater details both the model
number and gas type.
Please check the heater and report any freight damage.
D es ign e d a nd m a nu f ac t u r e din A u s t r a li a t o exac t ing s t a nd a r d s .
G A S DUC TE DH E A TE R
T A SE R IES
GE N E RA L
1
1. Heat exchanger - 10 year warranty
2. Fully automatic electronic ignition
3. Approved by the Australian Gas Association
G as In
C o m bu s t ion
A i r Intake
L ou v r es
H ea t e r
S p ec i f i ca t ion
L
a b e l
M a in s In
& T/Stat
A I R II N
S t a nd a r d
100 mm Flue
O u t l e t
AIR OUT

T URN I N G T H E H E A TE R O N FO R T H E FI R ST TI M E
S i m pl y f ollow t h es t e p s b e low .
1 . E n s u r e t h e g as t a p a tt h e h ea t e r i s t u r n e don .
2 . T u r n t h e T h e r m o s t a tt o t h e O N P o s i t ion .
R e f e r t o t h e in s t r u c t ion s h ee t in t h e t h e r m o s t a t p acka g e .
3 . S e tt h e T h e r m o s t a tt o a bo ve t h er oo m t e m p e r a t u r e .
4 . T h e h ea t e r i s now in a u t o m a t i c m od e .
The combustion fan will start.
After 15 seconds the sparker will commence to spark.
As soon as the heater lights the sparker will stop.
( it will normally take only 1 or 2 sparks for the heater to light )
After a short period of time, the room fan will commence to blow
warm air through the vents.
5 . S e tt h e r oo m t h e r m o s t a tt o t h e d es i r e d t e m p e r a t u r e .
When desired room temperature is reached the gas and combustion
fan will turn off. The room fan will continue to run ( about 2 minutes )
to extract all the heat from the heat exchanger.
M A I N TE NANC E S CH E DU LE
Periodic maintenance of the heater will ensure a long and satisfactory
service life with the heater operating at optimum performance.
Maintenance should be performed on a yearly basis by an Authorised
person trained in the service of the Braemar Heaters.
If heater does not operate satisfactorily refer to the trouble shooting
chart at the rear of this book or contact your Braemar Dealer.
2

T R O UB LE S H OOTI N G
If you have difficulty operating your Heater check the
trouble shooting guide before calling for service
Problem?
H E A TS hould b e O N bu tt h e h ea t e r i s no t wo r k ing .
Heater has gone through a start-up sequence and has not lit.
Turn off the Mains Power to the heater, wait 5 seconds,
Turn Power On again.
Set the thermostat temperature to above room temperature.
The heater should now operate.
Problem?
H ea t e r i s no t op e r a t ing e ff ec t i ve l y .
Check that there are enough outlets opened for the fan speed
selected. Is the return air filter blocked ?
We recommend cleaning every fortnight.
Problem?
N o t e nough H ea t ing .
Is the thermostat located in the correct area according
to the Installation Instructions.
Increase the SET temperature.
Problem?
H ea t e rr un s wh e nno t p r og r a mm e d - E l ec t r oni c t h e r m o s t a t s .
Check the time AM or PM.
Sleep or away programmed temperature is too high: lower.
FOR SERVICE CALL : 1 300 650 644
3

I M PO R T AN T
Record the Serial No. and Model No. of the heater here.
M od e l N o : ____________________
S e r i a l N o : ____________________
D a t e o f I n s t a ll a t ion : _____ / ______ / ______
I n s t a ll e r : _______________________
SE R VI C E
B e f o r eca lling f o r se r v i ce h ave y ou :
1 . C h ecke d t h r ough t h e t r oubl es hoo t ing guid e .
2 . N o t e d t h e S e r i a l N o . & M od el N o . o ft h e h ea t e r .
( if they are not recorded above, the numbers are
located on the side of the heater. )
3 . S po ke n t o y ou r B r ae m a r D ea l e r / I n s t a ll e r .
FO
R SE R VI C E CA LL : 1300 650 644

A lbu r y M a nu f ac t u r ing P l a n t
77 N o r t h S t r ee t A lbu r y N .S.W. 2640
T e l e phon e : ( 02 ) 60 411 611
F acs i m il e : ( 02 ) 60 412 208
M e lbou r n e O ff i ce
2 / 21 - 23 G e dd es S t
M U LG RA VE VI C 3170
T e l e phon e : ( 03 ) 9561 3222
F acs i m il e : ( 03 ) 9561 5733
P e r t h O ff i ce
6 / 91 L eac h H ighw ay
K EW DA LE W. A . 6105
T e l e phon e : ( 08 ) 9353 5511
F acs i m il e : ( 08 ) 9353 5711
W ARRAN TY & SE R VI C E
1 300 650 644
P r oudl y A u s t r a li a n M a d e
P r oudl y A u s t r a li a n M a d e
S in ce 1938
S in ce 1938
P a r t N o . 619910 / a
Manufacturers and Designers of Technically Advanced Quality Heating and Cooling Products
A d e l a id e O ff i ce
1 - 11 R o t h esay A ve nu e
ST M AR YS S. A . 5042
T e l e phon e : ( 08 ) 8276 2355
F acs i m il e : ( 08 ) 8276 4542
B r ae m a r I ndu s t r i es P t y L t d ACN 006 810 617
S ee l ey I n t e r n a t ion a l P t y L t d ACN 054 687 035