BRASS MONKEY GH1560 User manual

INSTRUCTION MANUAL
ICE MAKER
GH1560
1.6L

2
CONTENTS
Warnings & Safety Information........................................................................3
Before First Use ..................................................................................................3
Features................................................................................................................ 4
Box Contents ........................................................................................................4
Product Diagram .................................................................................................4
Operation ..............................................................................................................5
Specifications ......................................................................................................6
Troubleshooting ..................................................................................................6
Cleaning, Care, Storage & Maintenance.......................................................... 7
Warranty Information.........................................................................................8

3
WARNINGS & SAFETY INFORMATION
• The installation of DC power sources in a boat must be handled by a qualified
electrician
• Make sure to connect power to the suitable voltage socket
• No electrical devices are to be used inside the product
• The product can be powered on only after being unpacked and put on a flat level
surface for over 6 hours
• Operation angle: As there is water inside, please keep the ice maker on flat surface
when in operation.
• Product must be well ventilated. Ensure there is a minimum of 200mm clearance at
the back, and 100mm around the sides
• The product should be in a well-ventilated space, away from heat sources.
• Try to avoid direct exposure to sunlight
• Keep product stable
• When there is water inside the tank, do not turn the product upside down to empty.
Dry the water, do not soak in water
• Do not put metal in the air inlet vent, outlet vent, or gap
• Do not connect with power except 12/24VDC, or the 240VAC to 12VDC power adapter
(optional)
• Do not soak the product in water or wash with water
• The product should not be repaired. If there is any issues please consult the place of
purchase
• Turn o the product before cleaning to avoid electric shocks or other issues
• Keep product away from wet or humid places
WARNING: The manufacturer is not responsible for any potential injury from misuse
BEFORE FIRST USE
Prior to using your product, please read all the safety and operating instructions
thoroughly. Please ensure you follow the steps below before using the product. We
recommend you keep the original packaging for storing the product when not in use.
Please pay close attention to the section entitled Warnings & Safety Information. Find
a safe and convenient place to keep this instruction manual for future reference.
Unpack the product but retain all packaging materials until you are satisfied that your
new product is undamaged and in working order. Ensure you have all accessories
listed in this manual.

4
FEATURES
BOX CONTENTS
1 x Portable DC ICE MAKER
1 x 12/24V Car Cigarette Power Lead
1 x Ice Basket
1 x Ice Scoop
1 x User Manual
PRODUCT DIAGRAM
• High-eciency and energy-saving DC compressor which is robust and durable.
• DC12V/24V or AC 100-240V with an optional mains to DC adapter.
• Fast icing: making small size ice in 5 minutes, big size ice in 7 minutes. (based on
25°C or 77° F room temperature).
• Easy-To-Serve: Ice scoop included to easily fill cups and glasses.
• Removable Ice Basket: 1.5 L capacity.
• Control panel with LED indicator lights.
• Under large ice mode, the ice cube > 23mm diameter;
• Under small ice mode, the ice cube > 18mm diameter.
• Intelligent car battery protection system: cut out @10.1V, cut in @11.4V.
LED Control Panel
Transparent Lid
Handle
Machine
Compartment
Ice Basket
Door Latch
Foot Pad
Ice Scoop

5
OPERATION
Steps for first use
• Before starting the device for the first time, you should clean it inside and outside
with a damp cloth for hygienic reasons .
• Allow one hour for the refrigerant fluid to settle before plugging the cord into an
electrical outlet for the first time.
Steps for usual use
• Open the clear lid to remove the Ice Basket and pour water into the water reservoir.
Keep the water level below the MAX level mark. If water levels exceed the MAX level
mark, drain any excess water by removing the water drain plug;
• After power on, the ice maker will enter standby mode, and the indicator displays
orange;
• Touch for the first time to switch to large ice mode, and the indicator will flash
green;
• Touch for the second time to switch to small ice mode, and the indicator will flash
blue;
• Touch for the third time, it will return to the standby mode, and the indicator will
turn orange again;
• Repeat above steps to select your desired ice mode;
• In standby mode, the indicator is always on; when making ice, the indicator will
flash;
• when the basket is full, the device will beep and stop; when there is water shortage,
the indicator will turn red and the buzzer will beep every 10 seconds.

6
SPECIFICATIONS
Input Voltage: 12/24VDC, (To power from mains use an optional 240VAC to
12VDC power adapter)
Average Power Consumption: 60W
Rated Current: 1.2A@110V; 0.5A@240V (By optional AC adapter)
5.0A @ 12V; 2.5A @24V
Refrigerant: R134a
Insulation: 100% CFC & HFC free PU Foam insulation
Ice shape: Bullet shape
Ice making cycle 1st time: 10 Mins
Ice making cycle >1: 5~6 mins/ 9 small size ice cubes
Ice making cycle >1: 7~9 mins/ 9 large size ice cubes
Ice capacity: 10kg ice per 24 hrs.
Water tank capacity: 1.6 liters
Ice basket capacity: 0.35 kg
Ice cubes qty per cycle: 9 pcs
TROUBLESHOOTING
ISSUE SUGGESTED REMEDY
The device does not work • Check if the switch is on.
• Check if the plug and socket are not connected well.
• Check if the fuse has been burnt.
• Check if the power supply is operational.
• Switching on/o the device frequently may cause start delay
of the compressor.
The ice cubes stick together The ice cycle may be too long, stop the device then restart it
when the ice cubes melt.
The ice cubes have odor /
taste
• Ice stored for an extended period may absorb odors. Discard
old cubes, use the device regularly.
• The interior of the device needs cleaning.
Red light flashes once every
5 seconds
Possible cause: low voltage.
Make sure to connect to correct voltage.
NOTE: The ice making performance was based on 25 degree ambient temperature. If
ambient temperature gets higher, the time for each ice making cycle will be longer.

7
CLEANING, CARE, STORAGE & MAINTENANCE
Cleaning
• Unplug the device first to avoid electric shock.
• Remove the ice basket, then clean the ice basket and ice scoop using warm, soapy
water, and a soft cloth. Wipe dry with a non-abrasive, dry towel.
• Clean the interior and exterior of the unit using a warm (soapy) damp non-abrasive cloth.
• Drain the interior water by unplugging the water drain plug on the bottom of the
device. Do not soak the device in water and do not wash it directly.
• Dry the interior and exterior with a soft, non-abrasive cloth.
Storage
• If the device will not be in use for a long time, please follow the steps:
• Turn the device o and remove the plug.
• Completely drain the water from the water reservoir.
• Keep the water drain open.
• Put the device in a cool and dry place.
• Do not wash the product with water or soak.
• Please disconnect from power before cleaning the product to avoid electrical shock.
• Drain the product simply by removing theplug at the bottom.
• Clean it with a soft wet cloth.
ISSUE SUGGESTED REMEDY
Red light flashes twice
every 5 seconds
Possible cause: condenser fan is overloaded.
Disconnect power for 30 minutes & re-start.
Red light flashes three
times every 5 seconds
Possible cause: compressor not kicking in; overheating of the
compressor & electronics.
Disconnect power for 30 minutes & re-start.
Red light flashes four times
every 5 seconds
Possible cause: no parameter can be detected by the controller.
Disconnect power for 30 minutes & re-start.
Red light flashes five times
every 5 seconds
Possible cause: temperature sensor is faulty.
Contact manufacturer for service.

Electus Distribution
Address 46 Eastern Creek Drive, Eastern Creek NSW 2766
Ph. 1300 738 555
WARRANTY INFORMATION
Our product is guaranteed to be free from manufacturing defects for a period of 3 years.
If your product becomes defective during this period, Electus Distribution will repair,
replace, or refund where a product is faulty; or not fit for intended purpose.
This warranty will not cover modified product; misuse or abuse of the product contrary
to user instructions or packaging label; change of mind and normal wear and tear.
Our goods come with guarantees that cannot be excluded under the Australian
Consumer Law. You are entitled to a replacement or refund for a major failure and
for compensation for any other reasonably foreseeable loss or damage. You are also
entitled to have the goods repaired or replaced if the goods fail to be of acceptable
quality and failure does not amount to a major failure.
To claim warranty, please contact the place of purchase. You will need to show receipt or
other proof of purchase. Additional information may be required to process your claim.
Any expenses relating to the return of your product to the store will normally have to be
paid by you.
The benefits to the customer given by this warranty are in addition to other rights and
remedies of the Australian Consumer Law in relation to the goods or services to which
this warranty relates.