Brinkmann 855-5001-F User manual

Ceramic Egg Charcoal Grill
Gril à Charbon en Céramique
avec Chariot
OWNER’S MANUAL
ASSEMBLY AND OPERATING INSTRUCTIONS
NOTICE D’UTILISATION
INSTRUCTIONS D’ASSEMBLAGE ET D’UTILISATION
CONSERVER CETTE NOTICE POUR RÉFÉRENCE
SAVE THIS MANUAL FOR FUTURE REFERENCE
Model / Modèle #855-5001-F
WARNING
READ AND FOLLOW ALL WARNINGS AND
INSTRUCTIONS IN THIS MANUAL TO AVOID
PERSONAL INJURY OR PROPERTY DAMAGE.
AVERTISSEMENT
LIRE ET RESPECTER TOUS LES
AVERTISSEMENTS ET INSTRUCTIONS
DE CETTE NOTICE POUR ÉVITER DES
BLESSURES GRAVES OU DES DÉGÂTS
MATÉRIELS.
NOTICE TO INSTALLER:
LEAVE THESE INSTRUCTIONS WITH
THE GRILL OWNER FOR FUTURE
REFERENCE.
AVIS À L’INSTALLATEUR:
REMETTRE CETTE NOTICE AU
PROPRIÉTAIRE POUR QU’IL PUISSE S’Y
RÉFÉRER PLUS TARD.

WARNING
• Only use this grill on a hard, level, non-combustible, stable surface (concrete, ground, etc.) capable of
supporting the weight of the grill. Never use on wooden or other surfaces that could burn.
• DO NOT use grill without charcoal grate in place. DO NOT attempt to remove charcoal grate while tray
contains hot coal.
• Proper clearance of 10 feet between the grill and combustible material (bushes, trees, wooden decks,
fences, buildings, etc.) or construction should be maintained at all times when grill is in use. Do not place
grill under a roof overhang or other enclosed area.
• For outdoor use only. Do not operate grill indoors or in an enclosed area.
• For household use only. Do not use this grill for other than its intended purpose.
• We recommend the use of a Charcoal Chimney or Electric Starter to light charcoal.
• Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products
could cause an explosion possibly leading to severe bodily injury.
• DO NOT USE charcoal lighting fluid or charcoal that has been pre-treated with lighting fluid in this grill.
Doing so could impart unnatural flavors to your food and may damage your grill.
• Place grill in an area where children and pets cannot come into contact with unit. Close supervision is
necessary when grill is in use.
• Do not leave grill unattended when in use.
• Use caution when coming into contact with the exterior of the grill, as the surface will be extremely hot.
• When adding charcoal and/or wood, use extreme caution and follow instructions in “Adding Charcoal/
Wood During Cooking” section of this manual.
• Do not store or use grill near gasoline or other flammable liquids, gases or where flammable vapors may
be present.
• Do not store lighter fluid or other flammable liquids or material under the grill.
• Do not use grill without grill cart.
• Do not cover the grill or cart when hot.
• Do not pour water into a hot or warm grill.
Grill is hot when in use. To avoid burns:
• DO NOT attempt to move the grill.
• Brace grill so the unit does not accidentally move.
• Wear protective gloves or oven mitts.
• DO NOT touch any hot grill surfaces.
• DO NOT wear loose clothing or allow hair to come in contact with grill.
IMPORTANT SAFETY WARNINGS
WE WANT YOU TO ASSEMBLE AND USE YOUR GRILL AS SAFELY AS POSSIBLE.
THE PURPOSE OF THIS SAFETY ALERT SYMBOL
IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR GRILL.
WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!
READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING AND OPERATING YOUR GRILL.
1

WARNING
• When grilling, grease from meat may drip into the charcoal and cause a grease fire. If this should
happen close lid to suffocate the flame. Do not use water to extinguish grease fires.
• AVOID FLASHBACKS. Vent grill before opening lid. Use caution since flames can flare-up when fresh air
suddenly comes in contact with fire. When opening the lid, first raise the lid an inch or two, and then
close it. Do this a couple of times before fully opening the lid. This action will help to avoid dangerous
flashbacks. Keep hands, face and body a safe distance from hot steam and flame flare-ups.
• AVOID BACKDRAFTS. Before opening lid, be sure that the shutter and vent are not fully closed.
• Use caution when assembling and operating your grill to avoid scrapes or cuts from sharp edges of
metal parts. Use caution when reaching into or under grill.
• When opening lid, vent first and then make sure it is pushed all the way open. If lid is not fully open, it
could fall back to a closed position and cause bodily injury.
• In windy weather, place grill in an outdoor area that is protected from the wind.
• Close lid, air shutter and top vent to suffocate flame.
• Before grill can be left unattended, coals and ashes must be suffocated. Use caution to protect yourself
and property. Close lid, air shutter and top vent to suffocate flame.
• As you can never be too cautious, using a garden hose, completely wet the surface beneath and around
grill to extinguish any ashes, coals or embers which may have fallen during the cooking or cleaning
process.
• Cover the grill and cart to protect it from excessive rusting.
• Use caution when lifting or moving grill to prevent strains and back injuries.
• We advise that a fire extinguisher be on hand. Refer to your local authority to determine proper size and
type of fire extinguisher.
• Accessory attachments not manufactured by The Brinkmann Corporation for this particular product are
not recommended and may lead to personal injury or property damage.
• Store the grill out of reach of children and in a dry location when not in use.
• Do not attempt to service grill other than normal maintenance as explained in “After-Use Safety” and
“Proper Care & Maintenance” sections of this manual.
• Remove all stickers and labels before first use.
• Properly dispose of all packaging material.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR GRILL.
FAILURE TO ADHERE TO SAFETY WARNING AND GUIDELINES IN THIS MANUAL COULD RESULT
IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
2

PARTS LIST:
11 Egg Assembly
1 Top Air Vent
1 Warming Rack
1 Cooking Grate
1 Charcoal Grate
1 Egg Lid Handle
1 Egg Firebox
2 Side Tables
1 Egg Base
2 Casters
1 Left Front Leg
1 Left Back Leg
1 Right Back Leg
1 Right Front Leg
2 Wheels
2 Wheel Axles, Washers
& Cotter Pins
1 Cart Base
ASSEMBLY INSTRUCTIONS
READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING OR OPERATING YOUR GRILL.
FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 800-527-0717.
Inspect contents of the box to ensure all parts are included and undamaged.
We recommend two people work together when assembling this unit.
The following tools are required to assemble this Ceramic Egg Charcoal Grill:
• Phillips Screwdriver
• Wrench
3
2
3
4
5
6
7
8
9
10
11
12
13
1
2
3
4
7
8
5
10
14
9
17
15
6
12
11 13
16
14
15
16
17

Parts Bag Contents
4 M4 x 8 mm Bolts
8 M6 x 10 mm Bolts
12 M6 x 40 mm Shoulder Bolts
1 Wrench
Wrench
4
M4 x 8 mm Bolts
M6 x 10 mm Bolts
M6 x 40 mm Bolts

5
Clear an assembly area and get a friend
to help you put your grill together. Lay
cardboard down to protect grill finish and
assembly area.
CAUTION: Some parts may
contain sharp edges.
Wear protective gloves
if necessary.
Step 1
Insert right front leg through side table
frames, aligning the holes. Secure using
one M4 x 8 mm bolt and two M6 x 10
mm bolts. Repeat for other legs.
Step 2
Attach egg base to leg assembly using
eight M6 x 40 mm bolts.
Right Front Leg Side Table

6
Step 3
Attach cart base to leg assembly
using four M6 x 40 mm bolts.
Step 4
Insert the wheel axle through
wheel,washer and right front leg.
Secure using cotter pin. Repeat for
back right leg.
Step 5
Attach casters to bottom of each left
leg. Tighten caster bolts securely
using hex nut wrench provided in
parts pack.

7
Step 6
Remove all parts from inside the
ceramic egg assembly and with the
help of a friend, place the ceramic
egg assembly onto the cart with the
temperature gauge facing forward.
Note: Use care when lifting ceramic egg
to avoid injuries to hand, fingers,
and backs.
Step 7
Attach the top air vent, inserting prongs
through opening. Top Air Vent

8
Step 8
Attach egg lid handle using four
preattached nuts and washers.
Step 9
Place the egg firebox into egg assembly,
as shown. Firebox needs to be in the
correct position to align with air vent.
Egg Firebox

9
Step 10
Insert charcoal grate (rests in the
bottom of firebox), cooking grate and
warming rack. Warming rack sits on
cooking grate as shown.
Warming Rack
Cooking Grate
Charcoal Grate