Broyhill GHP22090 User manual

10 INCH STEEL ROUND TABLEFIRE, 1 lbLP
ASSEMBLYINSTRUCTION
Need help? We are here for you! 1(877)447 – 4768 M-F, 8am - 4:30 pm CST • Toll Free
ITEM#: GHP22090
SKU#: 810584310
Made in China

WARNINGS
WARNING: If the information in this manual is not followed exactly, a fire or explosion
may result causing property damage, personal injury, or loss of life.
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
•Shut off gas to the appliance.
•Extinguish any open flame.
• If odor continues, leave the area immediately.
•After leaving the area, call your gas supplier or fire department.
Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal
injury, or death.
WARNING
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
An LP-cylinder not connected for use shall not be stored in the vicinity of
this or any other appliance.
WARNING: For Outdoor Use Only.
Installation and service must be performed by a qualified installer, service agency,
or the gas supplier.
WARNING
Improper installation, adjustment, alteration, service or maintenance can cause property damage, personal injury
or loss of life. Refer to the owner’s information manual provided with this appliance. Installation and service must
be performed by a qualified installer, service agency, or the gas supplier.
DANGER
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which has no odor.
Using it in an enclosed space can kill you. Never use this appliance in an enclosed space such as a camper, tent,
car or home.
INSTALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference.

• The installation of this unit must adhere to local codes
or Propane Storage and Handling Code,CSA B149.2.
• THIS UNIT IS INTENDED FOR OUTDOOR USE ONLY!
This product shall be used outdoors, in a ventilated
space and shall not be used in any enclosed area.
• This unit is to be used with propane gas only! (sold
separately)
• Do not attach a remote gas supply to this unit.
• Only use propane gas for this unit.
• Solid fuels shall not be burned in this appliance.
• LP GAS WARNING: Do not use any more than 1/4in
depth lava rocks/pumice stones/LavaGlass above the
burner.
• If the propane gas tank is leaking gas, you may hear,
see, or smell a hiss. Do the following:
1. Disconnect the propane gas tank.
2. Donotattempttoxtheproblemyourself.
3. Contactyourpropanegassupplierorre
department for help.
•Applying too much propane may result in gas pooling
and will not burn. Allow fresh air into the unit so that
the remaining gas may escape.
•Donotuseaametocheckforgasleaks.
The maximum gas supply: 250 psi; Min. gas supply: 10 psi
This appliance is designed for use with a16.40Z (1Lb)
propane gas cylinder (disposable).
•
•
•DONOTlltankover80%full.
• The tank system must be set up for vapor withdrawal.
• Discontinue use if any part of the propane tank is dam-
aged. Rust and dents may be hazardous and should be
inspected by a propane gas supplier.
• Do not burn anything other than the provided materi-
alsforthisretable.
•Keepawayfromunitfortherst20minutes after
ignitingyour  thersttime,aslavarocks/pum-
ice stones/LavaGlass could popout and cause injury.
Should any rocks pop out, discard them.
• Always ensure that lava rocks/pumice stones/Lava-
Glass are completely dry before use. Failure to do so
will cause them to crack or pop.
• Do not operate unit until all parts are fully assembled.
• Do not paint or color any part of this heating unit.
• Unit may be hot while in use, do not attempt to move
it while in use.
• Never leave this heating unit unattended while in use.
• This unit is not intended for cooking.
•Keepanyammableitemsawayanddonotuseany
otherreplacecoverforthisunit.
• Keep a safe distance to avoid burning skin or clothing.
• Do not sit or rest hands or feet on this heating unit.
•Neverplacehandsorngersonupperportionofthis
unit while in use.
• Keep all electrical cords and fuel supply hose away from
heated surfaces.
• Cover must be removed when burner is in operation.
• Combustible material should not be within 60 inches of
the top of the unit, or within 48 inches around the
entire unit and free from combustible material, gasoline
andotherammablevaporsandliquids.
•Iftheamegoesoutwhileburning,turnthegasvalve
off. Wait 5 minutes before repeating the initial lighting
procedure.Onceyouhaveaamestarted,holddown
the control knob for 1 minute.
• Do not add water into the unit.
• Do not operate unit if any part has been under water.
Immediatelycallaqualiedservicetechniciantoinspect
the appliance and replace any part of the control system
and any gas control that has been under water.
• Do not disconnect any part while unit is in use.
• Do not store a spare propane tank on or near this unit.
• If the heating unit is indoors, detach the propane tank
and leave outdoors.
• Do not operate on a boat or vehicle. The unit must be
usedonaatsurfaceandoutdoorsONLY.
• Always remove protective cover before operating (if
applicable).
• Do not set the protective cover over the unit until it is
turned off and completely cooled down.
• Check for leaks after not using the unit for long periods
of time.
• Children should never operate this unit. Children must
be supervised while near this unit.
• Keep gas tank at least 5 feet away from unit when lit. (if
externaltank)
•Allinstallationandrepairshouldbedonebyaqualied
professional. This unit should be inspected annually and
cleaned regularly.
•Inspect all elements of this heating unit before each
use. If there is damage, the burner must be
replaced.
•Keep the hose out from any pathways to eliminate any
accidentaldamage.(ifexternaltank)
•Be aware of the hazards of high temperatures and stay
away from the unit to avoid any burns or injury.
Before you assemble or operate this unit, please carefully read this entire manual. Failure to do so
may result in a fire, explosion, injury or death.
SAFETY INFORMATION
®
®
®
unit for

Combustable materials should not be within 60
inches of the top of the unit or within 48 inches
around the entire unit.
• The gas supply tank should be constructed and marked
withthespecicationsfortheLPgastanksoftheU.S.
Department of Transportation or the National Standard
of Canada CAN/CSA-B339, LP gas tanks, spheres and
tubesforTransportationofDangerousGoods;and
Commission.
•TheLPgastankmusthavealistedoverllingpreven-
tion device and a QCCI or Type I, (CGA791) LP gas tank
connection.
• This heating appliance should not be used on plastic or
articialwooddecks.
• Children and adults should be alerted to the hazards
of high surface temperatures and should stay away to
avoid burns or clothing ignition.
•Young children should be carefully supervised when
they are in the area of the appliance. near the appli-
ance.
•Clothing or other ammable materials should not
be hung from the appliance or placed on or near the
appliance.
• Any guard or other protective device removed for
servicing the appliance shall be replaced.
•Installation and repair should be done by a qualied
service person. The appliance should be inspected
before use and at least annually by a qualied service
person.
• More frequent cleaning may be required as neces-
sary. It is imperative that the control compartment,
burners and circulating airways of the appliance are
kept clean.
•Check for leaks after not using the unit for long periods
of time.
IF APPLICABLE:
• Allow heating item to cool completely before placing on
lid.
•DO NOT use heating item while lid is istalled Always
remove the lid while heating item is in use.
• Only use the regulator and hose assembly provided
with this unit. Replacement parts must be supplied
directly by manufacturer.
• Inspect the burner before use of this unit. If the burn-
er shows any kind of damage, do not operate the
appliance. For assistance with repair or replacement
of the burner or any other parts, call manufacturer at
1.877.447.4768
•Atablewithanumbrellahole(notincluded)isrequiredtoassemble
this product.
•Theumbrellaholetablesizeneedstomeetthefollowingrequire-
ments:
• The length and width should not be shorter than 81.28 cm / 32 in.
• The height should be lower than 101.6 cm / 40 in.
• The tabletop should be Non combustable material.
SAFETYINFORMATION
Min. Clearance
in ( cm)
Min. Clearance
48 in (121.9 cm)
Min. Clearance
48 in (121.9 cm)
Min. Clearance
48 in (121.9 cm)

Ax1 Guard (preassembled)
Bx1 Body
Cx1 Control Knob (preassembled)
Dx1 Fixing Plate (preassembled)
Ex1 Angle Bracket
Fx1 Fixing Nut (preassembled)
Gx1 Tank Bracket
Hx1 Burner (preassembled)
Ix1bag Lava Rocks
PARTS LIST
x1
Wing Screw
BB
x2
AA
M4 Screw

Unscrew and remove the fixing nut (F) from the threaded post.
F
x1
STEP 1
F
B

STEP 2
Attach the tank bracket (G) to angle bracket (E) using 2 M4 screws (AA) .
AA
E
x2
AA
G

STEP 3
Insert the body (B) through the umbrella hole in the table and the tank bracket assembly made in step 2. Screw the fixing nut (F) to the
body (B) from the underside of the table to secure the body to the table.
B
F

STEP 4
Check that the control knob (C ) for the gas supply system is turned to the “OFF” position before assembling the 1 lb. propane gas tank. .
To attach the 1 lb. propane gas tank (not included) on the unit, screw the 1 lb. gas tank to the regulator inlet fitting.
C

STEP 5
Once the tank is attached to the regulator, Insert the wing screw (BB) into the tank bracket and turn
clockwise to secure the propane gas tank tightly.
BB
BB
x1
Be cautious not to kick, jam or jar propane tank
Danger

Pour the Lava rocks (I) into the middle of the firebowl body (B) evenly.
x1 bag
STEP 6
I
I
A
B
To ensure proper function, the guard (A) on the
burner should be free of lava rocks (I) at all times.
WARNING
Always ensure that lava rocks/pumice stones/
LavaGlass® are completely dry before use. Failure
to do so will cause them to crack or pop.
Keep away from the unit and have the unit to burn

OPERATION
Before performing a leak test, be sure that no sparks can occur and you are in a spacious outdoor area. Con-
nect the propane gas tank to the regulator and turn the valve on the unit to the ‘OFF’ position. Brush a soap
and water mixture on all connections. Turn the gas supply on; if bubbles occur on any connection there may
be a leak. If you smell gas or a leak is discovered turn the gas valve off, disconnect propane gas tank and do
not use the appliance until the leak is repaired.
Do not use the heating unit without inspecting the gas hose. If there are signs of wear or abrasion you must
replace the hose (if applicable). Pumice stones/lava rocks/LavaGlass could pop up and strike somebody’s
face during the process of lighting this unit; stand away from the unit for the first 20 minutes after igniting.
Flame should be a yellow/blue color and between 2 - 10 inches in height.
Wait 50 minutes after extinguishing flame prior to placing a lid (if applicable) or protective cover on heating
item.
LIGHTING
1.
2.
Turn ignition control knob (L ) to the “OFF” position. Connect propane
gas tank to regulator and open the cylinder valve.
4.
Push the ignition control knob (L ) in and turn counterclockwise to the
“HIGH” position; this will ignite the fuel. Keep holding down the control
knob for 15 seconds.
3. If ignition does NOT immediately take place in seconds, push and turn
the ignition control knob (L ) clockwise to “OFF”. Wait 5 minutes, then
repeat the lighting procedure as above.
To adjust the flame, turn the ignition control knob (L) either clockwise or
counterclockwise depending on whether you want to lower or raise the
flame.
EXTINGUISHING
1. Push and turn the ignition control knob (L ) clockwise to the
“OFF” position.
2. Turn the propane gas tank valve on the gas tank to close the
gas supply and disconnect the propane gas tank.
WARNING - If the
burner does not ignite with the
burner control valve open, gas
will continue to flow out of the
burner and could accidentally
ignite causing injury or proper-
ty damage.
®
7.5 po
19
1
2.5
.1cm
po
cm

TROUBLESHOOTING
CAUSE SOLUTION
Burner won’t light while
using a match
No gas ow Check that the gas tank isn’t empty
Regulator isn’t connected secure-
ly to the tank
Tighten regulator connection to the
gas tank
Spider webs or insect nest in the Check the burner and guard
Burner ports are clogged
Turn all gas ow connections off.
Insert an opened paperclip (or sim-
ilar item) into each of the burner
ports to clear them out.
Heating unit emits a lot of
black smoke Flame is obstructed at burner
ports
Check that all burner ports are
free of any small lava rocks/pum-
ice stones/Lava- Glass pieces
Flame blows out easily High or gusting winds Increase ame to ‘HIGH’
No gas ow Check that the gas tank isn’t empty
®
burner and guard

MAINTENANCE
• Before performing any maintenance always disconnect propane gas tank.
• Store your product indoors during winter months. Avoiding extreme cold temperatures will prevent from
exposure damage.
• Keep the heating item free and clear from combustible materials.
• Visually inspect burner for obstructions and keep tank enclosure free and clear from debris.
• Use a soft brush to get rid of the mild stains, loose dirt and soil after the burner and pumice stones/ lava
rocks/LavaGlass are completely cooled down. Wipe down with a soft cloth.
• Harsh weather conditions may cause stubborn stains, discoloration and possibly rust pitting.
• Permanent damage may occur if powder or solvent comes in contact with painted or plastic components
on this heating unit.
• Keep the heating unit stored away from direct sunlight.
• If storing this unit inside, disconnect the propane gas tank from the gas valve.
• Not using manufacturer approved or supplied parts/accessories may result in a defective condition and
void the warranty of this heating unit.
• Always place lid (if applicable) or protective cover on heating item when not in use.
®

WARRANTY
CONTACT
This product has a one-year warranty against manufacturing defects in workmanship, or materials.
The manufacturer warranty will be voided by, and manufacturer disclaims any responsibility for, the following actions:
• Modifcation of the unit and/or components including the gas valve assembly.
• Use of any component part not manufactured or approved by Manufacturer.
•Use and installation other than what is listed in this manual.
If you have any questions or concerns, please contact manufacturer at the below resources:
Toll free phone: [phone] | Monday - Friday, 8:00 am - 4:30 pm CST
Email: [email protected]
Website: www.ghpgroupinc.com