Bunn BT10 Installation instructions

USE AND CARE OF YOUR
BUNN
Thermal Carafe Coffee Brewer
33545.0001A 08/02 © 2002 BUNN-O-MATIC CORPORATION
P2558
Welcome to the world of fine coffee. The BUNN
Thermal Carafe Coffee Brewer will enhance your
enjoyment of each cup of coffee. BUNN coffee
brewers are recognized in homes and restaurants
throughout the world as the very finest. Read this
booklet, and in no time you will know how to
make a great cup of coffee.
Keep this booklet for future reference
www.bunnomatic.com
ModelBT10&BTC
MODEL:______________________ Record these numbers from the
bottom of the brewer, before
filling the brewer with water.
DATE CODE:__________________
®
Bunn and ThermoFresh are registered trademarks and
the Bunn logo is a trademark of Bunn-O-Matic Corporation.
OFF
O
N
OFF

2
BUNN-O-MATIC CORPORATION
1400 STEVENSON DRIVE
SPRINGFIELD, ILLINOIS 62703
www.bunnomatic.com
If you need any assistance, please call us at:
1–800–352–2866
Our best
wishes for
your coffee
enjoyment.
SPECIFICATIONS
Electrical-ULlistedforhouseholduseonly.Thisbrewerhasanattached,
polarized cord and requires 2-wire service with ground, rated 120 volts
ac, 7 amps, single phase, 60 Hz. Components include an 800-watt tank
heater and a 34 watt tank "Keep Warm" heater; 850 watts total.
Dimensions - 151⁄4 inches high; 7 inches wide; 133⁄4inches deep
Brew Capacity - Four to ten 5-ounce cups per batch.
Weight - 9 pounds; includes carafe, filters, coffee funnel, and deliming
spring probe.
HIGH ALTITUDE USE
Your BUNN ThermoFresh®coffee brewer is designed to operate in most
areas of the country. For high altitude use, over 5000 feet, the models with
a “(D)” designation should be used.
Table of Contents
IMPORTANT SAFEGUARDS ...................................... 4
GENERAL INFORMATION ........................................ 5
PREPARING THE BREWER FOR USE ........................ 6
BREWING DELICIOUS COFFEE ................................ 7
HOT WATER.............................................................. 7
COFFEE FUNDAMENTALS ........................................ 8
BREWING TIPS.......................................................... 8
BUNN COMPANION PRODUCTS ............................. 9
ROUTINE CLEANING................................................ 9
DELIMING ................................................................. 9
PERIODIC CLEANING............................................. 10
DRAINING THE BREWER ....................................... 11
WATER QUALITY.................................................... 11
SOFTENED WATER/DECAFFEINATED COFFEE..... 11
AUTHORIZED SERVICE .......................................... 11
LIMITED WARRANTY .............................. Back Cover

3
Hazardous Voltage!
Can Cause Fire Or Electrical Shock!
Do Not Disassemble The Brewer!
There Are No User Serviceable Parts Inside!
Repair Should Be Done By Authorized Service Personnel!
(Refer to page 11 )
WARNING
BUNN ThermoFresh®
HOME MODEL THERMAL CARAFE
COFFEE BREWER
OFF
O
N
OFF
STAINLESS
STEEL HOT
WATER TANK
(LOCATED INSIDE)
VACATION
SWITCH
HINGED
FLIP-LID
CARAFE
P2558
This symbol alerts you to
important operating and
service instructions.
This symbol alerts you to the
risk of fire or electrical shock in
the accompanying message.
BREW
FUNNEL
RISK OF FIRE OR ELECTRICAL SHOCK

4
•Read all instructions.
•Do not touch hot surfaces. Use
handles or knobs.
•Do not place cord, plugs, or
brewer in water or liquid.
•Close supervision is necessary
when the brewer is used by or
near children.
•Unplugfrom outletwhen notin
use and before cleaning. Allow
to cool before putting on or
taking off parts, and before
cleaning.
•Donot operatethe brewerwith
a damaged cord or plug or after
thebrewer malfunctions, orhas
been damaged in any manner.
Return the brewer to an Autho-
rized Service Facility for
examination, adjustment, or
repair. (Refer to page 11.)
•Theuseofanaccessorynotevalu-
ated for use with this brewer
may cause injuries.
•For household use only. Do not
use outdoors.
•Do not let cord hang over edge
oftableorcounter,ortouchhot
surfaces.
•Do not place the brewer on or
nearahotgasorelectricburner,
or in a heated oven.
•Donotusebrewerforotherthan
its intended use.
•Do not place or remove funnel,
or carafe while brewing.
•The carafe is designed for use
with this brewer. It must never
be used on a range top or in a
microwave.
•Do not use a carafe having a
loose or weakened handle
•Do not clean carafe with cleans-
ers, steel wool pads, or other
abrasive materials.
•Whenthebrewerisidle,theflip
lid should be in the closed
position.
IMPORTANT SAFEGUARDS
Follow these basic safety precautions when using electrical appliances
to reduce the risk of fire, electric shock, and/or personal injury:
SAVE THESE INSTRUCTIONS
•Ashort power-supply cord is used to reduce the risks resulting from
becoming entangled in or tripping over a longer cord.
•If an extension cord is used, the marked electrical rating of the
extension cord should be at least as great as the electrical rating of
the brewer and the cord should be arranged so that it will not hang
over edge of table or counter where it can be pulled on by children
or tripped over.

5
GENERAL INFORMATION
NOTE - THE BREWER IS NOT READY TO PLUG IN
(See Page 6)
Improper installation will result in permanent damage and void the
limited warranty. Read & follow the instructions on the next page.
•This brewer is designed to remain plugged in at all times
(except during initial installation or when cleaning).
•Avacationswitch is providedonthe lowerleftside tocompletelyshut
off all electrical components when your plans take you away from
home for three or more days. Safety features, designed into the
BUNN®coffee brewer, make the daily use of this switch unnecessary.
•Wheneverthebrewerhasbeenshutofforunplugged,fillthetankwith
waterandallowthewaterinthetanktoheattothepropertemperature
before using (about fifteen minutes or until the heating sound stops).
•Your BUNN coffee brewer has a specially designed tank to keep the
water at the proper temperature. This constant supply of hot water
assures the correct method of brewing coffee, in less than three
minutes.
•The brewed coffee flows into a non-heated thermal carafe
server. The stainless steel construction will hold coffee at
serving temperature for 2 hours minimum.
•The carafe lid reduces coffee evaporation and temperature loss.
•Whilecoffeeisbeingbrewed,thenewestwaterinthetankisheatedto
the proper temperature and held until needed.
•Whenthe brewer isnot in operation,the flip lidshould remainclosed.
Leaving the lid open may cause an unexpected drip of water from the
sprayheadoncecoldwaterhasbeenpouredintothetopofthebrewer.
•UseCAUTION whendispensinghotwaterfromthebrewer.Thewater
is approximately 50°F hotter than that available from your hot water
faucet and is always available for other uses.
•Thebrewerisequippedwithapolarizedcordset.Onebladeoftheplug
is slightly larger than the other. This is a safety feature and allows the
plug to fit into the outlet only one way. If you are unable to insert the
plug into the outlet, try turning it over. If the plug still does not fit,
contact an electrician to update your outlet. Do not attempt to bypass
the safety aspect of this polarized plug.
•The sprayhead will periodically become loose. Using extreme caution
not to burn yourself, retighten the sprayhead with your finger tips.
NOTE- A severe burn may result if the sprayhead becomes
loose and falls off while brewing.

6
OFF
O
N
OFF
PREPARING THE BREWER FOR USE
NOTE - THE BREWER IS NOT READY TO PLUG IN.
Do NOT plug in until Step #3.
OFF
O
N
OFF
Raise the hinged flip-lid.
NOTE: The post protruding from the screen is
connected to a stopper which controls the flow of
waterintothetank. Whenlidisclosed(postdepressed),
thestopper israised and waterwill flowinto thetank.
Plug in the brewer.
Step 2
Slide an empty brew funnel into the brewer. Pour
one carafe full of water into the screened area on top
of the brewer (there is no need to have the lid on the
carafe at this time). Place carafe in position on the
brewer. Close lid. Wait three minutes to allow the
water to flow into the tank. Repeat this process.
Whenthetankisfull,somewaterwillflowthroughthe
funnel and into the carafe. Leave the carafe in place.
P2559
P2561
P214
P2560
Step 4
Press the bottom of the vacation switch, located on the
lower left side of the brewer, to the "ON" (lower) position.
The vacation switch controls power to the tank heater.
Initially you will have to wait approximately fifteen
minutes in order for the water to reach brew
temperature.
Empty any water that has collected in the carafe.
You’re not done yet! The next page leads you through the five
easy steps to ‘BREWING DELICIOUS COFFEE’
OFF
O
N
OFF
Step 1
Step 3

7
BREWING DELICIOUS COFFEE
OFF
O
N
OFF
OFF
O
N
OFF
Insert a BUNN®coffee filter into the brew funnel.
(Be sure to use BUNN coffee filters for proper
brewing. There is a difference.) Order more paper
filters direct from BUNN at: www.bunnomatic.com
Measure coffee into the filter and gently shake the
filter to level the bed of grounds. To determine the
amount of coffee to be used, see Page 8.
Makesurethatthesprayheadistight.Slidethebrew
funnel into the brewer.
Raise the hinged flip-lid and pour a carafe of water
into the top of the brewer. See Brewing Tips (page 8)
for pre-heating the carafe. Place the carafe on the
brewer, THEN close the lid. Your BUNN® brewer will
beginbrewingcoffeeimmediately.Flip-lidshouldalso
remain closed when brewer is not in operation.
P2562
P2563
P2564
P2561
P215
Whenbrewinghasstopped,removethebrewfunnel
and discard the filter and grounds. Do not touch hot
grounds.
NOTE:Openingthelidduringbrewcyclewillinterrupttheflowofwaterinto
the tank, but will not interrupt the brewing process. The brewed coffee
already in the funnel will empty into the carafe. When lid is closed, the flow
of water into the funnel will resume until the brewing cycle is complete.
Step 1
Step 2
Step 3
Step 4
Step 5
HOT WATER (USE WITH CAUTION)
Thesamebasicstepscanbeusedtoobtainhotwaterbyomittingthefilterand
coffee. The water from your BUNN coffee brewer is approximately 200°F. This
is hotter than the hot water from your faucet and must be handled with care.

8
COFFEE FUNDAMENTALS
Brewing delicious coffee is similar to cooking any favorite food. Both
require a good recipe. Proper coffee making needs quality equipment to
preciselycontrolwatertemperature,volume,andbrewtime.TheBUNN®
coffee brewer assures consistency in your recipe by controlling all of
these elements. The only variables remaining in the recipe are the grind
and amount of coffee used.
The amount of ground coffee is generally determined by the grind.
For best results, we recommend a drip (medium) grind.
Hot water extracts many elements from the ground coffee, some
desirable, some not. The taste and aroma are referred to as strength, the
acidity as bitterness. Increasing the amount of ground coffee results in a
stronger beverage, and decreasing it results in a weaker beverage.
As the amount of ground coffee decreases, you'll note an increase in
the bitterness of the beverage. This happens because the hot water
begins to remove the undesirable elements such as acidity after all of the
desirable tastes and aroma have been removed.
Fresh ground coffee gives the best results. Always store the ground
coffee in a cool, dry area away from other food items with strong odors.
When stored in a refrigerator, keep it in an airtight container.
BREWING TIPS
When properly brewed, the difference between the best quality
ground coffee and a poor quality ground coffee becomes very dramatic.
Proper brewing requires little effort with the BUNNcoffee brewer.
You'll always have a great coffee experience if you follow these tips:
1) Always start with clean equipment.
2) Always use fresh cold water.
3) Always use BUNN®paper coffee filters for proper extraction.
4) Usingaminimumof2ouncesoffreshdripgrindcoffeeforeachfullpot
willgiveyou aconsistentlygreat pot ofcoffeewith afull-bodiedflavor
and aroma. However, the real criteria is personal taste. Adjust the
recipe until it suits you. If you need to make a smaller batch,
experiment with less water and ground coffee. Minimum batch
is 20 ounces.
5) Afterfillingthepour-inbowlwithwaterfromthecarafe,thecarafecan
bepre-heatedbyfillingitwithhotwaterforapproximately1/2minute.
Empty before filling with fresh brewed coffee. For the freshest flavor,
don't hold brewed coffee in the carafe for longer than four hours.

9
BUNN®COMPANION PRODUCTS
COFFEE FILTERS
Constant quality testing assures
consistentflavorwithoutanygrounds
in the cup. BUNN® paper filters are
packaged to maintain their fluted
shape for use in most basket-type
drip coffee makers.
P2245
Paper Filter
ROUTINE CLEANING
Rinsing the brew funnel and carafe after each use is
theonlyroutinecleaningrequired.Occasionally,wipethe
outsideofthebrewerincludingtheareaabovethefunnel
with a damp cloth. The carafe may be disassembled for
cleaning. Rotate the lid counterclockwise to remove.
Occasionally,theflavorgardvalveshouldbe removedand
cleaned.Liftat theedgeandpull up.Afterrinsing,replace
by aligning the tab on the flavorgard valve with the slot
inside the carafe lid and press in place. Use of a mild, non- abrasive detergent is
recommended. Do not use a scrub pad or other abrasive cleaning device as this
will scratch the stainless steel surface. (The brew funnel and carafe are top-rack
dishwasher safe.)
P2566
P2567
OFF
O
N
OFF
P2565
DELIMING
Periodically,youshoulddelimethebrewertoclearanydepositsthatmayhave
accumulated due to impurities in the water source.
NOTE- Unplug the brewer and let it cool down before
deliming.
1) Unscrew the sprayhead with your fingertips and set it
aside.
2) Insertallbuttwoinchesofthe flexible deliming tool into
the sprayhead tube.
3) Slidethetoolinand out five orsixtimestoloosenlimein
the sprayhead tube. Remove the tool.
4) Pour one carafe of fresh water into the brewer, set the
empty carafe on the brewer, and close the lid.
5) Check the holes in the sprayhead. If plugged with lime,
they may be cleared by using a toothpick. Rinse the
sprayhead with water before reinstalling.
6) Plug in the brewer and allow the water in the tank to reheat before using. The
frequency of
deliming depends on the mineral content of your water.

10
P2566
OFF
O
N
OFF
P2568
PERIODIC CLEANING
(Recommended At Least Every Three Months.)
1) Slide an empty brew funnel into the brewer and center an empty carafe in
position on the brewer.
2) Pour one quart of white vinegar into the top of the brewer and close the lid.
Empty the carafe when liquid stops flowing from the funnel.
3) Allow the brewer to sit for two hours.
4) Unplug the brewer. Removethebrewfunnelandsprayheadfromthebrewer
and set them aside.
5) To drain the brewer, continue to Step 6, OR to clear vinegar out of brewer
without draining, pour a carafe of fresh, cold water through the brewer. Place
carafe on brewer base, then close the lid to allow the water to run through the
brewer. After it has run through, empty carafe, and repeat the process
approximately 8 - 10 times. Proceed to Step 9.
6)Cool the brewer by pouring a full carafe of fresh, cold water into the top of the
brewer. Placecarafeonbrewer base,closelid.Whenflowfrom the brewerhas
stopped, empty the carafe. Repeat this process, then set the carafe aside.
7) Grasp the back of the brewer and quickly turn it upside
downoverasinkasshown.Mostofthewaterinthetankwill
flow from the sprayhead tube opening. Some water may
flow from the area around the top lid. Continue tipping the
brewer until the flow stops.
8) Replace the sprayhead and funnel after the water has been
drained. Pour a carafe of water into the top of the brewer.
Place the carafe on the brewer, close the lid. Repeat this
process with another carafe of water. Water will flow out
of the funnel after the second carafe. When flow from the
funnelhasstopped,emptythecarafeandpouranadditional
carafe of water into the brewer. Place the carafe on the
brewer and close the lid.
9) Tastethewatercomingoutof thebrewer. Pouradditional
carafesoffresh,coldwaterintothebrewerasneededuntil
the water has no vinegar taste.
10) Pluginthebrewerandallowthewaterinthetanktoreachbrewingtemperature
before using. (approximately 15 minutes.)