CABAC UPS600DV3 User manual

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
1
Version 1
CABAC UNINTERRUPTIBLE POWER
SUPPLY



USER’S MANUAL
UPS600DV3
UPS1000DV3
UPS1500DV3

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
2
2 of 21
Contents

GeneralSafetyInstructions 3
ConditionsofUse 3
ElectricalSafety 4
SafeOperatingPractices 5
BatteryInformation 7
Introduction 8
Performance 8
InstallationInstructions10
PhysicalAppearance11
FrontPanelOperationalIndicators12
Operation13
Specification14
Maintenance15
SoftwareInstallation16
Loadconfigurereference20
Troubleshooting21






Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
3
3 of 21
General safety instructions

This manual contains important safety instructions that should be followed
duringtheinstallationandmaintenanceoftheUPS. 
Pleasereadthismanualthoroughlybeforeattemptingtoinstalloroperatethis
UPS.
DO NOTunder any circumstances attempt to remove the UPS cover. It may
containhazardousvoltagesinternallythatmaycauseelectricshock.Thereare
no userserviceable parts inside. For service, please contact your nominated
serviceagent.

Conditions of Use
This equipment is designed for domestic use only. Themanufacturer neither
recommends nor knowingly sells this product for use in critical life support
applications. 
1. Intendedforinstallationinacontrolledenvironment.    
a. Thecontrolledenvironmentshouldbeinaccordancewith
therequirementofthespecification  
b. DonotinstalloroperateyourUPSinornearwater.    
c. DonotplaceUPSonanunstablecart,standortable.   
d. Do not place UPS under direct sunlight or close to heat
emittingsources.
e. DonotplaceUPSpowercordinanyareawhereitmayget

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
4
4 of 21
damagedbyheavyobjects. 
2. Placing magnetic storage media on top of the UPS may result in data
corruption.
3. YourUPSprovidesconditionedpowertoconnectedequipment.Maximum
load must not exceed that shown on the UPS rating label. If uncertain,
contactLegend
 
Electrical Safety

DO NOTunder any circumstances attempt to remove the UPS cover. It may
containhazardousvoltagesinternallythatmaycauseelectricshock.Thereare
no userserviceable parts inside. For service, please contact your nominated
serviceagent.

1. TheCabacUPSwillprovidea220~240VAC1φ（singlephase）ratepower
source.PleaseverifythatthismodelmatchesyourACmains/loadvoltage
requirements.
2. TheCabacUPSmustbeearthedatalltimesduringoperation.Thiscanbe
achieved by only connectingthe input power chord to a mains supply
socketoutletwithanintegralearthterminal.Ameansofdisconnectingthe
mainssupplyshouldbewithin2metersoftheUPS.
3. OutputsocketsontheUPSareelectricallyliveiftheUPSisswitchedON,
eveniftheUPSisnotpluggedintomainssupply.TheOn/Off button on

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
5
5 of 21
theUPSdoesnotelectricallyisolatetheinternalparts.ToisolatetheUPS,
switchtheUPSOFFfirst,thenunplugitfromthemains.
4. Toreducetheriskoffire,usefuseswiththecorrectratingwhenreplacing
fuses.
5. TheUPSreliesonyourbuildingwiringovercurrentprotection,whichmust
beratedbetween1016amperes.
6. When using the communication features on the UPS, ensure the cabling
connectedtotheUSBcommunicationportarekeptseparatedbyatleast
25mmfromthepowercordstoandfromtheUPSinputandoutput.

Safe Operating Practices
ThispluggabletypeAequipmenthasfactoryinstalledbatteries,andhencemay
beoperatedbyanyonethathasreadandunderstoodthismanual. 
Duringtheinstallationofthisequipment,itshouldbeassuredthatthesumof
the leakage currents of the UPS and the connected loads does not exceed
3.5mA. 
1. The mains socketoutletthat suppliestheUPSshallbeinstallednearthe
UPSandshallbeeasilyaccessible.
2. When replacing batteries, replace with the same type and number of
batteries.
3. TurnoffandunplugyourUPSbeforecleaning.Donotuseliquidoraerosol
cleaners.Adryclothisrecommendedtoremovedustfromthesurfaceof
yourUPS. 
4. Do not handle any metallic connector before the power has been

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
6
6 of 21
disconnected.
5. TurnoffandunplugyourUPSfromtheoutletandcontactyournominated
serviceagentif:
oThepowercordorplugdamaged.   
oLiquidhasbeenspilledontheUPS.   
oThefuseblowsfrequently.   
oThe UPS does not operate even when user follows the
operatinginstructions.

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
7
7 of 21
Battery Information
1. CAUTION:Donotdisposeofbatteriesinafire,thebatterymayexplode. 
2. CAUTION: Do not open or damage the battery or batteries,asreleased
electrolyteisharmfultotheskinandeyes. 
3. Abatterycanpresentariskofelectricshockandhighshortcircuitcurrent.
Thefollowingprecautionshouldbeobservedwhenworkingonbatteries:
Remove watches, rings or other metal objects. Use tools with insulated
handles.
4. NOTE. The batteries used in your CabacUPS aremaintenance free. This
meansthatyouDONOTneedtocheckthebatteryfluidlevels.Tryingtodo
so may cause injury to yourself, or may cause a fault with the battery/
UPS.
5. The battery backup runtime is affected by the state of charge of the
batteries,theageofthebatteriesandgeneralconditionofthebatteries. 


Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
8
8 of 21
Introduction  
The CabacUPScan instantly switch your computer to emergency battery
backup power and allows you to work through mains power outages without
datalossor downtime.Itcontinuouslyconditionsthe power comingintoyour
computerandprovidesapowersourcewithvirtuallyzerointerruption.

This UPSis specially designed for PC users and also suitable for computer
peripheralsorPOS.Amicrocontrollerisusedasthemaincontrollerthatrenders
theproductanintelligentUPS,capableofselfprotectionandfaultdiagnosis.A
builtinAVRfunctionautomaticallyadjustsitselftomaintainapowersupplyof
stable voltage when the utility power is of high or low voltage.
Highperformance surge suppression protects your computer from electrical
noiseanddamagingpowersurges.

Performance
YourCabacUPSprovidesthefollowinghighperformancefeatures:
•UninterruptiblePower 
Protectsyourdatabysupplyingbatterybackupwhenpowerfails.
•MicrocontrollerControl
Bymeans ofinnovativesoftwarecontrolprograms, the complicatedhardware
circuitry is inlaidin the powerful microcontroller. Apart from reduced size, it
alsolowerstherateofUPSfailure.
•LEDIndicators
Operationalstatusisindicatedbyaseriesof3easytoreadLED’s.

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
9
9 of 21
•AudibleAlarms
Activelyletsyouknowiftheunitisinbatterymode,ifthebatteryislow,orif
thereisanoverloadcondition.
•Highqualitybattery
The selection of high quality sealed leadacid maintenance free batteries
maximisesthelifespanofthebatteryforprolongedperformanceandenhanced
economicbenefits.
•AutomaticDetection
When the UPS is turnedON, it immediately performs an inspection of the
batterycapacity.
•AutomaticVoltageRegulation
Correctsoverandundervoltages,withoutdrainingthebattery.Thispreserves
batteryresourcesandensuresyourUPSwillprovidetheoptimumruntimeand
optimumvoltagesourceduringapowerblackout.
•SurgeProtection
Protectshardwarefromdamageduetounexpectedpowersurges.
•AutomaticCharge
TheUPSchargesitsbatterywheneveritisconnectedtoutilitypower.TheUPS
canbeineithertheONorOFFmode.
•AutoRestart(ColdStart)
If the UPS has shutdown during a battery backup session due to discharged
batteries, the UPS will automatically restart once mains power has been
restoredtosupplymainspowerandrechargethebatteries.

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
10
10 of 21
Installation Instructions
1. Inspection 
Inspectthe UPS upon receipt.The packagingisrecyclable.Save it for reuseor
disposeofitproperly.EnsuretheUPSisphysicallyundamagedduetotransit.
2. Placement
InstalltheUPSinaprotectedareawithadequateairflow,andawayfromdirect
sunlightandexcessivedust.DonotoperatetheUPSwherethetemperatureand
humidityisoutsidethespecifiedlimitsintheSpecificationsTable.
3. ConnecttoMainsPower
ConnecttheACinputpowercordtoasocketoutlettopoweruptheUPS.
ThebatteryintheUPSwilllosesomechargeduringshippingandstorage.Itwill
rechargecompletely after approximately 8 hours of normal operation. Do not
expectfullbatteryruntimeduringthisinitialrechargeperiod.
4. Connecttheloads
PlugtheloadsintotheoutputsocketsontherearoftheUPS.EnsuretheUPSis
sizedcorrectlysothattheUPSisnotrunatfullloadconstantly.
Caution: NDO NOT connect a laser printer or plotter to the UPS with other
computerequipment.A laser printer or plotter periodically draws significantly
morepowerthanwhenidle,andmayoverloadtheUPS.