Calflame LTR50001006 User manual

Copyright 2011 LMS, Inc. All rights re-
served. Duplication without written consent
is strictly prohibited.
Cal Flame ® is a registered trademark.
Due to continuous improvement programs,
all models, operation, and/or specications
are subject to change without prior notice.
LTR50001006, Rev. C
6/21/11
250-407
Operation
Lighting Instructions for Automatic Starter ...........23
Lighting Your Wood Burning Fireplace................25
Maintenance
Appendix
Replacement Parts ...............................27
Limited Warranty.................................30
Save these instructions!
California Proposition 65 Warning:
Chemicals known to the State of
California to cause cancer, birth
defects or other reproductive
harm are found in and/or creat-
ed by the combustion of natural
gas, propane, butane and other
fuels. Always operate this unit as
described in the owner’s manual
and in well ventilated areas.
Read this before installing or operating your
new Cal Flame repit or replace.

Safety Instructions
1
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Safety Instructions
What To Do If You Smell Gas
Shut off gas to the repit or replace.•
Extinguish any open ame.•
Do not try to light the appliance.•
If odor continues, keep away from the appliance and•
immediately call your gas supplier or your re depart-
ment.
WARNING: Improper installation, adjustment,
alteration, service or maintenance can cause in-
jury or property damage. Read the installation,
operating and maintenance instructions thoroughly be-
fore installing or servicing this equipment.
Cal Flame replaces and repits are
designed for outdoor use only.
Do not store combustible materials, gasoline
and any other ammable vapors and liquids.
A propane gas cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
Carbon Monoxide Hazard
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an en-
closed space such as a camper, tent,
car, or home.

2
Safety Instructions
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Operation
Do not use charcoal or other solid fuel in gas burning re-•
places and re pits.
Do not operate the replace with the propane tank on, near, or •
under the hearth! This could result in re, explosion, or severe
injury.
Do not use your repit or replace for cooking.•
In the event that a burner goes out, turn burner knobs to the full•
OFF position and let it air out. Do not attempt to use the repit or
replace until the gas has had time to dissipate.
Keep all electrical supply cords away from the heated areas of the•
replace or repit.
Never use the replace or repit in windy conditions. If used in a •
consistently windy area a windbreak will be required. Always ad-
here to the specied clearances listed in this manual.
When handling propane gas line and connectors, do not allow them•
to come in contact with any metal surfaces. Do not drop propane
connectors.
Propane gas sources to the replace or repit must be regulated. •
Do not operate if regulator has been removed. Fire or explosion
can occur.
Never leave the replace or repit unattended when in use.•
Never allow clothing or other ammable materials come in contact •
with any hot surface until it has fully cooled. Never wear loose
tting or hanging garments while using your replace or repit.
Fabric may ignite and result in personal injury.
Clothing or other ammable materials should not be hung from the •
appliance, or placed on or near the appliance.
When using the repit or replace, do not touch the rock, re •
screen, or immediate surroundings, as these areas become ex-
tremely hot and could cause burns.
Do not heat any unopened glass or metal container of food in the•
replace or repit. Pressure may build up and cause the container
to burst, possibly resulting in serious personal injury or damage to
the replace or repit.
Do not reach over your repit when hot or in use.•
Never line repit or replace with aluminum foil.•

Safety Instructions
3
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Maintenance and Repair
Spiders and other insects can nest in the burners and block the gas•
and airow to the burner ports. This creates a dangerous condi-
tion that can result in a re from behind the valve panel. Inspect
and clean the burners periodically and follow the guidelines in the
maintenance section of this manual.
The appliance should be inspected before use and at least annually•
by a qualied service person.
More frequent cleaning may be required as necessary. It is impera-•
tive the control compartment, burner and circulation air passage-
ways of the appliance be kept clean and free.
Any guard or other protective device removed for servicing the ap-•
pliance must be replaced prior to operating the appliance.
If it is evident there is excessive abrasion or wear of any of the•
components, if the fuel supply hose is cut or cracked, it must be
replaced prior to the appliance being put into operation.
Inspect the fuel supply connection for signs of leakage (including•
the hose for propane models) before each use of the appliance.
Unless specically recommended in this manual, do not repair or •
replace any part of your repit or replace. Have a qualied techni-
cian perform all service. Any repairs made by a non-LMS approved
dealer technician will void your warranty.

4
Safety Instructions
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Storage
When your replace or repit is not in use, turn off the gas at the •
source.
Do not store the propane cylinder in the vicinity of this or any other•
appliance when it is not being used.
This appliance can be store indoors only if it has been discon-•
nected from its fuel supply.
Store propane cylinders outdoors in a well-ventilated area out of•
reach of children. Disconnected sylinders must have threaded valve
plugs tightly installed and must not be stored in a building, garage,
or any other enclosed area.
To extend the life of your replace or repit, protect and cover •
it from the elements when not in use. Ensure the appliance has
ample time to cool off after use and prior to installing storage
cover. Damage caused to storage cover due to heat or burns are
not covered by warranty.
Precautions Regarding Children
Never leave children unattended in the area where the replace •
or re pit is being used. Close supervision of children is necessary
when any appliance is used near children.
Do not store items of interest to children around or below the re-•
place or re pit.
Never allow children to sit or stand on any part of the replace or •
re pit.

Installation / Assembly
5
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Set-Up
You are responsible for ensuring that a natural gas line (if required)•
is installed and safe for use. We recommend that a licensed con-
tractor install your replace or repit. Installation must conform to
local codes, or in the absence of local codes, with either the Na-
tional Fuel Gas Code, ANSI Z223.1 / NFPA54, Natural Gas and
Propane Installation Code, CSA B149.1, or Propane Storage
and Handling Code, B149.2), as applicable.
Do not use an extension cord to supply power to your replace or •
repit. Such use may result in re, electrical shock or other per-
sonal injury. Do not install a fuse in the neutral or ground circuit.
A fuse in the neutral or ground circuit may result in an electrical
shock hazard. Do not ground this appliance to a gas supply pipe or
hot water pipe. Keep any electrical supply cords and the fuel supply
hose away from any heated surfaces.
To prevent re and smoke damage, remove all packaging material •
before operating the replace or repit.
Installation must conform with local building and/or re codes, or in
the absence of local codes:
National Fuel Gas Code ANSI Z223.1 / INFPA 54 (for installation in•
the United States)
CSA B149.1 Natural Gas and CAN/CGA-BIL/9-2, Propane Installa-•
tion code (for installation in Canada).
Installation
Installation and service must be performed by a quali-
ed installer, service agency or your natural gas or liquid
propane gas provider.
Most cities and counties require permits for exterior construction and
electrical circuits. In addition, some communities have codes requiring
residential barriers such as fencing and/or self-closing gates on prop-
erty to prevent unsupervised access to the property by children under
the age of 5. Your dealer can provide information on which permits
may be required and how to obtain them prior to the delivery of your
equipment.

22
UsingYour Grill
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
WARNING: DO NOT use solid fuel, such as wood or
charcoal, in gas fueled replaces or re pits.
Upon completing the gas line connection,
a small amount of air will be in the lines.
When the rst lighting the burner, it will
take a few seconds for the lines to purge
themselves of this air.
Once the purging is complete, the burner
will light and operate as indicated in the
instruction manual. Subsequent lighting
of the appliance will not require purging
unless the gas supply has been disconnected.
Inspect the burner before each use of the appliance. If there is any
evidence that the burner is damaged, it must replaced before operat-
ing. Upon completing the gas line connection, a small amount of air will
be in the lines. When rst lighting the burner, it will take a few minutes
for the lines to purge themselves of this air. Subsequent lighting of the
appliance will not require such purging.
Never allow the ON / OFF valve to remain in the open position without
placing a burning match on top of the burner FIRST!
You must have clear and easy access to the ON / OFF valve AFTER the
appliance is installed and connected to the gas supply in order to safely
turn of the burner.
Make sure the burner is in place prior to using the appliance. If the
burner is damaged, install a replacement burner as specied by the
manufacturer.
For your safety, read before lighting.
Before operating smell all around the appliance area for gas odors•
and next to the oor because some gases are heavier then air and
will settle on the oor.
Use only your hand to turn the manual gas control valve. Never use•
tools. If the valve will not turn by hand, do not try to repair it. Call
a qualied service technician. Force or attempted repair may result
in a re or explosion,
Do not use this appliance if any part has been under water. Imme-•
diately call a qualied service technician to inspect the appliance
If you do not
follow these
instructions exactly,
a re or explosion
may result, causing
property damage,
personal injury, or
loss of life.
Operation

UsingYour Grill
23
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
and replace any part of the control system and any gas control
which has been under water.
Make sure the ignitor battery has been installed properly. Ignitor•
will not operate properly without a battery installed.
Lighting Instructions for Automatic
Starter
Remove protective storage cover and locate the manual gas con-1.
trol valve and igniter button on the replace.
Make sure fuel supply is properly connected and turned on at the2.
source.
Depress igniter button until you hear it sparking. You will hear a3.
small popping noise. Keep igniter button pushed in while slowly
turning the fuel ow valve to the full ow position at the replace.
The replace should light within 5 seconds. If you do not hear the
igniter sparking you may need to replace the battery. The starter
uses one standard AAA battery, located directly behind the rubber
push button knob. (Unscrew knob to access battery.) Note some
models ship with the batteries removed or may not be included
with your model.
If a ame does not start within 10 seconds, shut off all gas supply 4.
and wait ve minutes to allow all gas fumes to clear. Re-try or go
to trouble-shooting and start again from step 1.

24
UsingYour Grill
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
To Turn Off Gas
Turn the ON/OFF valve to the off position at the unit for natural gas
unit. For propane unit, turn the ON/OFF valve to the OFF position at
the unit and then turn the valve on the propane tank to the OFF posi-
tion clockwise.
NOTE
The propane regulator in this appliance is equipped with a low ow
protection device. Unless the propane cylinder valve is opened before
the valve, the gas ow will be reduced resulting in a very small ame.
To reset this device, shut off the valve, disconnect the hose from the
cylinder to relieve the pressure, then close the propane cylinder valve.
Follow the lighting procedure ensuring the propane cylinder valve is
opened before the unit is.

UsingYour Grill
25
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Lighting Your Wood Burning Fireplace
Your wood burning replace is designed to use a grate to hold the
wood to be burned approximately 2”-3” off the base. This allows air to
get to the bottom of the wood and gives room for ash to accumulate.
Do not attempt to burn wood in your appliance without a proper grate
installed.
WARNING: Never use liquids such as gasoline or lighter uid in a
wood burning replace. Serious injury can occur.
Have several sizes of wood available. Small pieces will be needed to
start the re, some medium sizes and nally larger logs that will burn
for a longer period of time. Make sure all logs are small enough to t
entirely into the replace or repit. If the wood is too large, cut or split
it until it will t into the enclosure.
Wad up some dry newspaper and put it under the grate but be1.
carefull of ash that may be under grate from a previous re.
Put small pieces of wood over the newspaper, on the grate. Small2.
wood should not be more than 1/2” thick and 1” wide. Smaller
wood will burn easier and make the re easier to start. Make sure
to leave room for air to circulate around the small pieces of wood.
On top of the small pieces of wood put a few medium sized pieces3.
of wood. These pieces can be from 1” to 2” thick but should not
block airow around the small pieces.
Light the newspaper under the grate in several places. As wood4.
begins to burn, add more medium sized pieces one at a time until
a good coal base is formed. At this time you can add larger pieces
of wood. Always make sure there is sufceint room for air to ow
around the wood that is added or you may smother your re.
Warning! Never leave a burning replace or repit unattended!

26
Cleaning and Maintenance
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Inspect the appliance before initial use. Clean the appliance at least
annually and have it inspected by a qualied eld service person.
Periodically remove the logs and examine the burner. If the burner is
dirty, clean it with a soft wire brush. Also examine the area around
the burner air shutter. Remove any dirt or debris in this area. This will
ensure long life and trouble-free operation.
Periodically check the hose connecting the propane gas cylinder to
ensure it is not damaged in any way.
Carbon (soot) may build up on the surfaces of the logs with heavy use.
This is more likely to occur with propane gas. Clean soot off the surface
of the logs periodically to prevent excessive buildup.
To clean the logs, be sure the re is out, the gas supply is turned off
and the logs are cool to the touch. The soot can then be brushed of
with a dry bristle brush or cloth. Take care while cleaning the logs as
they can become damaged if mishandled.
Periodically check the hose connecting the propane gas cylinder to en-
sure it is not cracked or damaged in any way. All natural gas hook-ups
should be serviced and inspected only by qualied installers only.
The easiest way to clean the repit or replace is to let the repit/
replace cool completely off.
With a wood burning replace, remove the steel grate and sweep •
out the ashes and leftover kindling.
With a gas repit or replace, spray the enclosure off with water. •
Note: Do NOT spray water directly onto the burner and pilot light
of the gas replace.
When not in use and after cooling, cover your repit with our full
length, zippered side canvas cover. The cover will help protect your
repit/replace from detrimental effects of weather and environmental
pollutants (see your local Cal Flame dealer for details).
Before installing the cover make sure the unit is shut off, that the gas
lines are disconnected and that the unit has had sufcient time to cool.
Install the cover and use the tie-down straps to secure it tightly to the
unit to prevent the wind from blowing it off.
Maintenance

Appendix
27
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Replacement Parts
Call 1-800-CAL-SPAS for any replacement parts not listed below. Be
sure to have model name and number available.
Fireplace Parts
18” Log Set BBQ08000610
24” Log Set BBQ08000620
18” Grate BBQ08210650
Square Burner BBQ07210005
Rectangle Burner BBQ04100076
Metal Plate BBQ04100075
30” Arch OPT940 BBQ08210577
30” Igloo Box BBQ08210575
30” Base-Igloo Box BBQ08210576
36” Arch BBQ08210584
36” Igloo Box BBQ08210587
36” Base-Igloo Box BBQ08210586
36” Arch BBQ08210584
36” Back Panel BBQ08210572
36” Base Panel BBQ08210570
36” Side Panel BBQ08210571
36” Sheet Metal Fire Box BBQ08210583
Mantle Piece BBQ08210612
22” Vent Piece BBQ08210610
Front Hearth Piece BBQ08210611
Front Hearth Piece BBQ08210607
Left Side Hearth Piece BBQ08210604-L
Right Side Hearth Piece BBQ08210604-R
NG Orice .125 BBQ04100077
Propane Orice #43 BBQ04100078
Appendix

28
Appendix
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Firepit Parts
Square Burner BBQ04100073
NG Orice .125 BBQ04100077
Propane Orice #43 BBQ04100078
Replacement Crushed Lava Rock Kit BBQ07210125
Replacement Fire Pit Electronic Igniter BBQ07210022
Replacement Fire Pit Gas Control Knob BBQ07210010
Replacement Fire Pit Propane Fuel Hose
With Regulator
BBQ07210200
Fire On Ice, 3/8” Peridot, Fire Glass Crys-
tals, 20 lbs/bag
BBQ04100065
Fire On Ice, 1/4” Standard, Sapphire, Fire
Glass Crystals, 10 lbs/bag
BBQ04100066
Fire On Ice, 1/4” Standard, Malachite, Fire
Glass Crystals, 10 lbs/bag
BBQ04100067
Fire On Ice, 1/4” Standard, Onyx, Fire
Glass Crystals, 10 lbs/bag
BBQ04100068
Fire On Ice, 1/4” Standard, Topaz, Fire
Glass
BBQ04100069

Appendix
29
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Specications
Fireplace Specications
Propane Gas Natural Gas
Max. Input BTU/
Hr
55,000 49,000
Orice Size #43 (0.089) 1/8” (.125)
Manifold Pressure 10” Water Column 7” Water Column
Maximum Gas
Supply Pressure
11” Water Column 14” Water Column
Maximum Inlet
Supply Pressure
13” Water Column 14” Water Column
Regulator Pre-Set 11” Water Column
Fire Pit Specications
Propane Gas Natural Gas
Max. Input BTU/
Hr
49,000 55,000
Orice Size #43 (0.089) 1/8” (.125)
Manifold Pressure 10” Water Column 7” Water Column
Maximum Gas
Supply Pressure
11” Water Column 14” Water Column
Maximum Inlet
Supply Pressure
13” Water Column 14” Water Column
Regulator Pre-Set 11” Water Column

30
Appendix
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
All Cal Flame models are manufactured with the highest quality ap-
pliances and are warranted to be free from defects in material and
workmanship at time of delivery.
LMS warrants replaces, re pits, and associated hardware from de-
terioration, corrosion, and defects in material and workmanship for a
period of one year from the original date of delivery, with the exception
of plastic items, which are warranted for 90 days.
Extent of Warranty
This limited warranty is only valid on Cal Flame models delivered in the
United States or Canada and extends through the selling dealer to the
original purchaser at the original site of installation. This warranty be-
comes valid at time of delivery and ends either by specied time-frame
listed above or upon owner transfer or relocation.
Warranty Performance
In the event of a malfunction or defect covered under the terms of
this warranty, contact either the selling dealer or a local contractor or
service technician. Depending on your needs, this may be a contractor
qualied to repair stone and tile or a service agent licensed to repair
gas or electrical appliances.
In the event the consumer is unable to obtain satisfactory customer
service from the selling dealer or service agent, written notication
must be given to the LMS Customer Relations Department within 30
days of the reported failure.
There will be no charge for parts on a covered item. Cost of labor is the
responsibility of the owner. Shipping and handling charges will apply
to all warranted replacement parts. The service agent may assess a
reasonable travel or mileage charge per service call. If LMS determines
that repair of a covered item is not feasible, LMS reserves the right to
replace the defective merchandise with merchandise equal in value to
the original purchase price. Warranty repair and / or replacement are
the sole discretion of LMS and this warranty does not cover costs there-
in, including but not limited to: freight, removal, re-installation, etc.
This warrant is non-transferable and may not be extended beyond
the above mentioned time frames under any circumstances, by any of
LMS’s representatives.
Limited Warranty

Appendix
31
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m
Warranty Limitations and Exclusions
Grate and log set are not covered by this warranty.
This warranty is void if the replace or re pit has been subject to
negligence, alteration, misuse, repairs, dings, dents, scratches, or in-
correct and / or prohibited applications, as specied in the owner’s
manual. Gas lines must be installed by a licensed plumber only or local
gas company agent. Incorrect electrical installation by unlicensed elec-
tricians, service by non-LMS authorized representatives, acts of God
and other cases beyond the control of LMS are not covered by this war-
ranty. Please refer to the owner’s manual for examples of exclusions
and common acts invalidating this warranty.
This limited warranty applies only to replaces and re pits and associ-
ated hardware used for personal, family, and outdoor household pur-
poses. This warranty does not apply to labor charges on replaces and
re pits, replacement parts and hardware. This limitation is retroactive
and applies to all replaces and re pits and hardware manufactured
from 2000 and hereafter.
Examples of common acts invalidating this warranty include but are
not limited to:
Use of fuel other than what is specied for the appliance (such as •
burning wood in a gas replace).
Scratches caused by normal use.•
Damage caused by extreme weather conditions (hot, cold, etc.)•
Damage caused by dirt, sand, and/or water damage.•
Damage caused by continued operation of the replace or re pit •
with either known or unknown problems.
Damage caused by direct sunlight.•
Damage caused as a result of failure to follow the operating in-•
structions as dened in this owner’s manual.
This limited warranty applies only to replaces or re pits normally
used for personal, family, or household purposes and specically ex-
cludes rental or commercial applications.
Disclaimers
LMS shall not be liable for loss of use of the replaces or re pits,
related hardware or other incidental or consequential costs, expense

32
Appendix
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m

Appendix
33
Fireplaces and Firepits
LTR50001006, Rev. C
www. c a l s p a s . c o m

LTR50001006, Rev. C
6/21/11
CONTACT INFORMATION
For customer service, please contact your authorized dealer immediately. If you
need additional information and/or assistance, please contact:
Customer Service Department
1462 East Ninth Street
Pomona, CA 91766
Toll Free: 1-800-CAL-SPAS
Fax: [phone]
www.calsamebbq.com
or damages, which may include, but are not limited to, removal of per-
manent deck or other custom xtures or the necessity for crane removal.
Any implied warranty shall have duration equal of the applicable warranty
stated above.
Natural stone: Rock, travertine, marble, etc. may be characterized by dry
seams, pits, chips, cracks, and fossils that are often lled with grout dur-
ing installation. These are normal imperfections and are not considered
defects.
Legal Remedies
This limited warranty gives you specic legal rights. You may have other
rights, which may vary from state to state.
Customer Service
For customer service, contact the authorized selling dealer immediately.
If you need additional information or assistance, please contact the LMS
Customer Relations Department at 1462 E. Ninth St., Pomona CA 91766
or call [phone].
See your Cal Flame dealer for a copy of the applicable warranty, details
and any questions you may have regarding the warranty coverage on your
product.