Clarion PP-2898H-C User manual

PP-2898H-C,F
-1-
Service Manual
Published by Service Dept.
Printed in Japan
ClarionCo.,Ltd.
7-2,Shintoshin,Chuo-ku,Saitama-shi, Saitama 330-0081Japan
ServiceDept.: 7-2,Shintoshin,Chuo-ku,Saitama-shi, Saitama330-0081Japan
Tel:[phone] FAX: [phone]
298-6495-00 Sep.2007
Model
SPECIFICATIONS
Radio section
Tuning system: PLL frequency synthesizer system
Receive range: FM: 87.75MHz to 107.9MHz
AM: 530kHz to 1,710kHz
Intermediate frequency:FM: 10.7MHz
AM: 1st 10.7Mz,2nd 450kHz
Quieting sensitivity: FM: Less than 10dBu(at 30dB S/N)
AM: Less than 32dBu(at 20dB S/N)
Separation: FM: 22dB +5/-7dBu(1kHz)
S/N ratio: FM: More than 50dB
AM: More than 45dB
Auto tuning stop sensitivity:
FM: 25dBu +6/-6dBu
AM: 32dBu +6/-6dBu
CD player section
Disc: 12cm, 8cm Disc
Separation: More than 50dB
(1kHz,20kHz L.P.F.)
S/N ratio: More than 74dB
(1kHz, 20kHz L.P.F., JIS-A)
Distortion: Less than 0.4%
(1kHz, 20kHz L.P.F., JIS-A)
(Genuine No. 28185 ZS30A)
(VISTEON No. ZS30A-28185-R0NAA)
NISSAN Automobile Genuine
CD AM/FM Radio with FM Diversity
PP-2898H-C,F
General
Load impedance: 2 ohm/4ch
Power output: 50W x 4
Power supply voltage: DC13.2V (10.8V to 15.6V)
Negative ground
Back-up consumption: Less than 1.0mA
Dimensions(mm): 182(W) x 104(H) x 164(D)
Weight: Approx. 1.5kg
NOTES
* We cannot supply PWB with component parts in prin-
ciple. When a circuit on PWB has failure, please repair it
by component parts base. Parts which are not mentioned
in service manual are not supplied.
* Specifications and design are subject to change without
notice for further improvement.
COMPONENT
PP-2898H-C,H-F
1. Main unit ----------- 1

PP-2898H-C,F -2-
CAUTIONS
Use of controls, adjustment, or performance of procedures
other than those specified herein, may result in hazardous
radiation exposure.
The compact disc player should not be adjusted or repaired
by anyone except properly qualified service personnel.
AM:530kHz- 1710kHz
PA RT No .
FM:87.75MHz- 107.9MHz
FREQUENCY RANGE
THISDEV I CE COMPLIES WITH PART 15 OF THE FCC
RULES. OPERATION I S SUBJ ECT T O THEFO
LLOWING
TWOCONDI T IONS: ( 1 ) T H IS DEVI CE MAY NOT CAUSE
HAR MFUL INT ERF ERENCE. AND( 2 ) T H ISDEV ICE MUST
ACCEPT ANY IN TERF ERENCE RECEI VED, I NC LUDI NG
INTERFERENCE THAT MAY CAUSE UNDE SI RED
OPERATION.
THISPRODUCTI
ON COMPL I ES WITH DHHS RUL ES 2 1 CF R
SUBCHAPTER J APPL I CABLE AT DAT E OF MANUFACT URE.
PP-2898H-A
MODE L NO.
P/ N
E
SERI AL NO.
1 2 V( - ) GROUND
MOU N T S C R E W
M5X8 mm MAX
ISO
MANUF ACTURED
Dongguan Clarion Orient Electronics Co.,Ltd
Junda Indust r i al Zone, Dong Keng Indust r ial Road, Dong Keng
TownDongguan,Guangdong Province 511734, The Peopl e' s
Republ ic of China
To engineers in charge of repair or
inspection of our products.
Before repair or inspection, make sure to follow the
instructions so that customers and Engineers in charge
of repair or inspection can avoid suffering any risk or
injury.
1. Use specified parts.
The system uses parts with special safety features against fire
and voltage. Use only parts with equivalent characteristics
when replacing them.
The use of unspecified parts shall be regarded as remodeling
for which we shall not be liable. The onus of product liability
(PL) shall not be our responsibility in cases where an accident
or failure is as a result of unspecified parts being used.
2. Place the parts and wiring back in their original positions after
replacement or re-wiring.
For proper circuit construction, use of insulation tubes, bond-
ing, gaps to PWB, etc, is involved. The wiring connection and
routing to the PWB are specially planned using clamps to keep
away from heated and high voltage parts. Ensure that they are
placed back in their original positions after repair or inspec-
tion.
If extended damage is caused due to negligence during re-
pair, the legal responsibility shall be with the repairing com-
pany.
3. Check for safety after repair.
Check that the screws, parts and wires are put back securely
in their original position after repair. Ensure for safety reasons
there is no possibility of secondary ploblems around the re-
paired spots.
If extended damage is caused due to negligence of repair, the
legal responsibility shall be with the repairing company.
4. Caution in removal and making wiring connection to the parts
for the automobile.
Disconnect the battery terminal after turning the ignition key
off. If wrong wiring connections are made with the battery con-
nected, a short circuit and/or fire may occur. If extensive dam-
age is caused due to negligence of repair, the legal responsi-
bility shall be with the repairing company.
5. Cautions in soldering
Please do not spread liquid flux in soldering.
Please do not wash the soldering point after soldering.
6. Cautions in soldering for chip capacitors
Please solder the chip capacitors after pre-heating for replace-
ment because they are very weak to heat.
Please do not heat the chip capacitors with a soldering iron
directly.
7. Cautions in handling for chip parts.
Do not reuse removed chips even when no abnormality is ob-
served in their appearance. Always replace them with new
ones. (The chip parts include resistors, capacitors, diodes, tran-
sistors, etc).
Please make an operation test after replacement.
8. Cautions in handling flexible PWB
Before working with a soldering iron, make sure that the iron
tip temperature is around 270 . Take care not to apply the
iron tip repeatedly(more than three times)to the same patterns.
Also take care not to apply the tip with force.
9. Turn the unit OFF during disassembly and parts replacement.
Recheck all work before you apply power to the unit.
10.Cautions in checking that the optical pickup lights up.
The laser is focused on the disc reflection surface through the
lens of the optical pickup. When checking that the laser opti-
cal diode lights up, keep your eyes more than 30cms away
from the lens. Prolonged viewing of the laser within 30cms
may damage your eyesight.
11.Cautions in handling the optical pickup
The laser diode of the optical pickup can be damaged by elec-
trostatic charge caused by your clothes and body. Make sure
to avoid electrostatic charges on your clothes or body, or dis-
charge static electricity before handling the optical pickup.
11-1. Laser diode
The laser diode terminals are shorted for transportation in or-
der to prevent electrostatic damage. After replacement, open
the shorted circuit. When removing the pickup from the mecha-
nism, short the terminals by soldering them to prevent this
damage.
11-2. Actuator
The actuator has a powerful magnetic circuit. If a magnetic
material is put close to it. Its characteristics will change. En-
sure that no foreign substances enter through the ventilation
slots in the cover.
11-3. Cleaning the lens
Dust on the optical lens affects performance.
To clean the lens, apply a small amount of isopropyl alcohol to
lens paper and wipe the lens gently.

PP-2898H-C,F
-3-
TROUBLESHOOTING
No Power
Check Voltage
ACC/BU line
OK
NG
Check Display
of LCD
Defective IC201,601
and around circuit
Defective
Q415,Q205 of ACC line
or IC401 of VDD+5V
Defective IC601,201
or A connection of
a communication line
of both ICs
NG
Push
an operation key
and can operate it?
OK
OK
NG
Check power suply line,
SYS+5V : Q404
SYS+9V : Q401
SUS+12V :Q402
CD+8V : Q410
CD+5V : Q408
or communication line
of IC601,201
No operating the key
Check
contact of
the switch
OK
OK
NG
Confirm
KI1-4, KS1-4 line of
SW PWB
Malfuntion of switch
Malfuntion of soldering
parts of Switch PWB
NG
Defective IC601
No Power
No sound AM/FM section
Stop
in SEEK operating
OK
OK
NG
Check
power suply pin7,9,17
of BL101
Defective of IC301
Defective BL101 Tuner
or IC201
Defective
Q108 ,109 or 401
NG
OK
Check
audio signal wave NG Defective BL101 Tuner
No sound AM/FM section
No Sound
Check
Muting curcuit
OK
NG
Check
power supply line
of IC301
Defective IC402
and around circuit
Defective IC201
Defective Q401
of SYS+9V line
or VOL-DATA line
NG
Push
an operation key
and can operate it?
OK
OK
NG Defective IC201
No Sound
Check
input signal wave
Pin11,12,14,15
of IC402
OK
NG Defective IC301,
IC501 - 505
No sound CD section
OK
OK
NG
A wave appear
on a communication line
from IC201
Defective of IC301
Defective
CD+8V : Q410
CD+5V : Q408
Defective
CD Mechanisum
NG
OK
Check
audio signal wave
pin4,6of J201
NG Defective Flat wire
816-4022-50
No sound AM/FM section
Check
power suply pin7,25
of J201

PP-2898H-C,F -4-
MAIN
AM/FM-TUNER
POWER-IC
TDA7560
ANT101
BL101
1CD
MECHANISM
STBY
BEEP
BACK UP
ACC
ILL-
ILL+
GND
IC402
IC501 - 505
NJM2060V
EQ-AMP
IC301
E-VOL
LC75412
LCD-DRIVER
IC601
VR601
MAIN VOL.
S615
CD-EJECT
ILL
IC201
AUDIO-CPU
LC723663
ILL
CONT.
FILLTER
MUTE
OUT
FM
CD
FL FR RL RR
DISP
KEY-
MATRICS
FR LH(+)
J401(POWER/SP)
FR LH(-) RR LH(+) RR LH(-) FR RH(+) FR RH(-) RR RH(+) RR RH(-)
Q414,416
S601 - 614
LC75853
LCD601
ACC-DET
Q415
CD-8V
Q410
CD-5V
Q408
SW PWB
FM-DIVER
IC101
AM
AM-NC
IC103
AF-OUT
AF-AMP
IC102
N-IN
SUB
ADJUSTMENT
Item Procedure Measuring instrument
Clock accuracy 1. Connect the Choronometer to TP218.
2. Connect the B/U and ACC line, and Turn on the ACC switch.
3. LCD display change Ver.---, While holding the buttons of MENU,M1,M5 and
POWER.
4. Adjust TC201 so that an output of TP218 becomes 0.0 +0.2/-0.0Sec./day.
SSG
Milli-volt meter
Oscilloscope
Choronometer
FM noise
convergence
1. Input the 98.1MHz/55dBu(1kHz 22.5kHz Div.) SSG signal.
2. Set the output to 0dBm(1V)by main volume.
3. Adjust VR102 so that the output level is -18+3/-3dB down when the output of
SSG is set to -20dBu.
SSG
Milli-volt meter
FM DIV.
1. Connect the SSG to Main antenna (Red) side.
2. Set the minimum VR101.
3. Input the 98.1MHz/1kHz 22.5kHz(30%) Div. SSG signal.
4. Input the 26dBu SSG signal and adjust VR101 so that an output of TP101(DIV-
ADJ) becomes High from Low.
5. Confirm that TP101(DIV-ADJ) becomes Low from High within about three sec-
onds of input the 22dBu SSG signal.
6. Confirm that TP101(DIV-ADJ) becomes 10.0V from 2.0V within about one sec-
ond of input the 30dBu SSG signal.
7. Confirm that TP101(DIV-ADJ) is as follows 1.0V within five seconds of input the
20dBu SSG signal.
BLOCK DIAGRAM
Main section

PP-2898H-C,F
-5-
8
7
6
5
1
4
3
2
12
9
10
11
13
14
EXPLODED VIEW/PARTS LIST
Escutcheon section
Mechanism section
J101
CONNECTOR
SLED / LOADING
MOTOR
SPINDLE MOTOR
RF-AMP
SERVO PROCESSOR
IC2
TC94A15F
3.3V REG CONTROL
MOTOR DRIVER
IC1
BA5825FP
5.0V
8.0V
DOUT
AUDIO L-CH
AUDIO R-CH
/RST
BUS0
BUS1
BUS2
BUS3
BUCK
/CCE
Z-MUTE
LDMUT
LDCONT
SW /
DETECTOR
3.3V
PICK UP UNIT
LASER
DETECTOR
A,B,C,E,F
FOCUS,
TRACKING COIL
LIMIT SWITCH
S2
CHUCKING
SWITCH
PHOTO TR A,B
Q1,2
LED A,B
D1,2
S1
8 331-4048-00 LCD-CVR 1
9 345-5877-00 PROTECTOR 1
10 074-3014-64 OUTLET SOCKET 1
11 940-8188-00 ESCUTCHEON-ASSY 1
12 716-0778-50 WAVE SCREW(M2x6) 8
13 380-5689-00 KNOB 1
14 335-7959-00 ILLUMI PLATE 1
1 ----------- SWITCH PWB 1
2 013-6201-52 TACT SWITCH 15
3 001-7093-91 LED YELLOW 32
4 016-0026-00 ROTARY ENCODER 1
5 335-7532-30 LCD HOLDER 1
6 335-7770-00 COLOR FILTER 1
7 379-1379-30 INDICATOR 1
NO. PART NO. DESCRIPTION Q'TYNO. PART NO. DESCRIPTION Q'TY

PP-2898H-C,F -6-
17
23
16
15
18
22 20
12
6
13
23
19
3
2
4
5
8
1
1
9
2
14
10
6
25
1
7
24
26
27
21
22
22
22
22
22
22
22
24
6
6
NO. PART NO. DESCRIPTION Q'TYNO. PART NO. DESCRIPTION Q'TY
Main section
15 347-7400-00 WIRE SUPPORT 1
16 331-4039-00 ES-PLATE 1
17 311-1907-00 LOWER CASE 1
18 310-1814-00 UPPER CASE 1
19 313-1950-40 HEAT SINK 1
20 276-0206-01 SETPLATE(PP-2898H-C) 1
276-0206-05 SETPLATE(PP-2898H-F)
21 347-8258-00 SPACER 1
22 714-2606-8B MACHINE SCREW(M2.6x6) 1
23 714-2603-8H MACHINE SCREW(M2.6x3) 1
24 714-2612-8H MACHINE SCREW(M2.6x12) 1
25 345-5802-00 CUSHION RUBBER 1
26 313-2005-00 SUB-HEAT SINK 1
27 345-4220-10 RUBBER PART 1
1 ----------- MAIN PWB 1
2 073-0768-90 TERMINAL 4
3 076-3011-64 14P PLUG 1
4 331-4040-00 REAR PLATE 1
5 092-2210-00 ANT-RECEPT 1
6 716-0878-50 SCREW(M2.6x5) 5
7 880-1921C TUNER BLOCK 1
8 074-4009-20 OUTLET SOCKET 1
9 074-2003-76 OUTLET SOCKET 1
10 331-3835-00 TR HOLDER 1
11 778-3006-00 TAP-SCREW(M3x5) 2
12 929-5001-81 CD MCHANISM 1
13 331-4038-00 MECH-BRKT 1
14 816-4022-50 FLAT WIRE 1

PP-2898H-C,F
-7-
CD Mechanism section
68 69
70
71
72
73
74
75
75
76
76

PP-2898H-C,F -8-
NO. PART NO. DESCRIPTION Q'TYNO. PART NO. DESCRIPTION Q'TY
1 966-1743-21 DRIVE-PLT-ASSY 1
2 969-0071-30 PICKUP-ASSY 1
3 ----------- LED PWB 1
4 ----------- CD PWB 1
5 SMA-182-100 MOTOR ASSY(SPINDLE) 1
6 SMA-183-100 MOTOR ASSY(SLED) 1
7 620-1596-23 CLAMPER LINK 1
8 803-4906-60 VINYL-COAT-WIRE(ORG) 1
9 816-2591-00 LEAD(YEL) 1
10 620-1753-20 ID-LOCK PLATE 1
11 620-1026-21 SPRING PLATE 1
12 620-1754-20 LOWER CHASSIS 1
13 620-1598-22 UPPER CHASSIS 1
14 966-1722-20 SH-RACK-ASSY 1
15 621-1742-20 UPPER GUIDE 1
16 621-0718-21 ROLLER GUIDE 1
17 621-1743-20 SHIFT LEVER 1
18 621-1744-20 RACK 1
19 621-1745-20 LOCK ARM L 1
20 621-1746-20 LOCK ARM R 1
21 621-1754-20 GEAR BASE 1
22 621-1747-20 GEAR COVER 1
23 621-1719-20 IDLE CASE 1
24 816-2590-00 LEAD(GRN) 1
25 621-0608-21 SECOND GEAR 1
26 621-0609-20 BASE GEAR 1
27 621-0610-20 IDLE GEAR A 1
28 621-0611-20 IDLE GEAR B 1
29 621-0612-21 ROLLER GEAR A 1
30 621-0719-20 ROLLER GEAR 1
31 621-0720-20 ROLLER GEAR C 1
32 621-0721-20 ROLLER GEAR D 1
33 621-1748-20 POWER GEAR A 1
34 621-1749-20 POWER GEAR B 1
35 621-1750-20 POWER GEAR C 1
36 621-1751-20 POWER GEAR D 1
37 621-0620-20 THREAD GEAR A 1
38 621-0621-20 THREAD GEAR B 1
39 621-1726-20 ROLLER SLEEVE 2
40 621-0623-23 LS-HOLDER 1
41 621-0624-22 GUIDE RAIL 1
42 816-2593-00 LEAD(PUR) 1
43 816-2542-01 FLAT WIRE 1
44 716-3473-01 SCREW(M2x3) 1
45 621-1729-20 SH-BASE 1
46 621-0711-20 LOADING ROLLER 2
47 345-5476-20 CUSHION RUBBER 1
48 622-1571-21 ROLLER SHAFT 1
49 624-0020-00 LEAD SCREW 1
50 629-0086-20 DAMPER F 2
51 629-0087-20 DAMPER R 1
52 714-2003-8B MACHIN SCREW(M2x3) 2
53 716-1507-01 SCREW(M2x3) 3
54 716-1733-01 SCREW(M1.7x2.3) 2
55 716-3469-01 SCREW(M3x4) 2
56 716-3551-00 SCREW(M1.4x2.5) 2
57 750-6797-20 ROLLER SPRING L 1
58 750-6798-20 ROLLER SPRING R 1
59 750-3467-21 SHIFT SPRING 1
60 750-3468-20 RACK SPRING 1
61 750-3469-20 CLAMPER SPRING 1
62 750-3470-20 ID-LOCK SPRING 1
63 816-2592-00 LEAD(BLU) 1
64 750-3472-21 DR-SPRING F 2
65 750-3473-20 DR-SPRING RA 1
66 750-3474-20 DR-SPRING RB 1
67 750-3475-21 DR-SPRING C 1
68 620-1023-23 CLAMPER PLATE 1
69 620-1752-20 SENSOR ARM 1
70 621-1753-20 CLAMPER RING 1
71 621-0728-20 STOPPER LINK 1
72 621-1752-20 DISC STOPPER 1
73 750-3471-20 SENSOR SPRING 1
74 781-1730-00 SCREW(M1.7x3) 1
75 780-2025-00 SCREW(M2x2.5) 3
76 716-1670-01 SCREW(M2x4) 4

PP-2898H-C,F
-9-
ELECTRICAL PARTS LIST
Main PWB(B1) section
C440 188-1053-68 50V 1uF
C442 168-1022-55 1000pF K
C443 168-1022-55 1000pF K
C444 178-4742-78 0.47uF
C445 178-6832-78 0.068uF
C446 178-6832-78 0.068uF
C447 178-4742-78 0.47uF
C448 178-4742-78 0.47uF
C450 168-1042-78 16V 0.1uF
C451 172-1041-15 0.1uF
C452 166-2201-50 22pF CH
C453 166-2201-50 22pF CH
C454 166-2201-50 22pF CH
C455 166-2201-50 22pF CH
C501 188-1063-38 16V 10uF
C502 188-1063-38 16V 10uF
C503 188-1063-38 16V 10uF
C504 188-1063-38 16V 10uF
C509 166-2201-50 22pF CH
C510 166-2201-50 22pF CH
C513 166-2201-50 22pF CH
C514 166-2201-50 22pF CH
C515 166-2201-50 22pF CH
C516 166-2201-50 22pF CH
C519 166-2201-50 22pF CH
C520 166-2201-50 22pF CH
C521 178-4722-78 4700pF
C522 178-6822-78 6800pF
C523 178-5622-78 5600pF
C524 178-1232-78 0.012uF
C525 166-2201-50 22pF CH
C526 166-2201-50 22pF CH
C527 166-2201-50 22pF CH
C528 166-2201-50 22pF CH
C529 178-5622-78 5600pF
C530 178-1232-78 0.012uF
C531 178-4722-78 4700pF
C532 178-6822-78 6800pF
C533 178-1042-78 0.1uF
C534 178-1042-78 0.1uF
C535 178-1242-78 0.12uF
C536 178-1242-78 0.12uF
C537 178-8232-78 0.082uF
C538 178-8232-78 0.082uF
C539 178-5632-78 0.056uF
C540 178-5632-78 0.056uF
C541 166-2201-50 22pF CH
C542 166-2201-50 22pF CH
C543 166-2201-50 22pF CH
C544 166-2201-50 22pF CH
C545 166-2201-50 22pF CH
C546 166-2201-50 22pF CH
C547 166-2201-50 22pF CH
C548 166-2201-50 22pF CH
C549 178-1242-78 0.12uF
C550 178-1242-78 0.12uF
C551 178-4732-78 0.047uF
C552 178-4732-78 0.047uF
C553 043-0309-92 10V 0.68uF
C554 043-0309-92 10V 0.68uF
C555 178-2232-78 0.022uF
C556 178-2232-78 0.022uF
C557 178-6832-78 0.068uF
C558 178-6832-78 0.068uF
C559 178-1042-78 0.1uF
C560 178-1042-78 0.1uF
C561 178-6832-78 0.068uF
C562 178-1042-78 0.1uF
C563 166-2201-50 22pF CH
C564 166-2201-50 22pF CH
C565 166-2201-50 22pF CH
C204 163-3363-45 25V 33uF
C205 168-1022-55 1000pF K
C206 166-1011-50 100pF CH
C207 166-1011-50 100pF CH
C208 166-1011-50 100pF CH
C209 166-1011-50 100pF CH
C212 166-2201-50 22pF CH
C213 168-1042-78 16V 0.1uF
C215 168-1042-78 16V 0.1uF
C216 187-1073-27 10V 100uF
C218 168-1052-78 1uF
C219 168-1042-78 16V 0.1uF
C220 166-1007-50 10pF CH
C301 168-1052-78 1uF
C302 178-1242-78 0.12uF
C303 178-1242-78 0.12uF
C304 178-1242-78 0.12uF
C305 178-1242-78 0.12uF
C306 168-1052-78 1uF
C307 188-2263-18 6.3V 22uF
C308 178-4742-78 0.47uF
C309 168-1222-55 1200pF K
C310 168-1222-55 1200pF K
C311 178-4742-78 0.47uF
C312 168-1052-78 1uF
C313 168-1052-78 1uF
C314 178-1842-78 0.18uF
C315 178-1842-78 0.18uF
C316 178-1842-78 0.18uF
C317 178-1842-78 0.18uF
C318 168-8212-55 820pF K
C319 168-8212-55 820pF K
C320 168-8212-55 820pF K
C321 168-8212-55 820pF K
C322 188-1063-38 16V 10uF
C323 188-1063-38 16V 10uF
C324 168-1832-55 0.018uF K
C401 188-4763-38 16V 47uF
C403 042-0416-59 10V 33uF M TAN
C405 168-1042-78 16V 0.1uF
C407 168-1042-78 16V 0.1uF
C408 042-1452-82 16V 100uF
C409 168-4742-78 0.47uF
C410 168-1052-78 1uF
C411 168-4722-55 4700pF K
C412 188-1063-38 16V 10uF
C413 178-6832-78 0.068uF
C414 178-6832-78 0.068uF
C415 178-4742-78 0.47uF
C416 178-4742-78 0.47uF
C417 187-2253-67 50V 2.2uF
C418 166-1011-50 100pF CH
C419 188-1063-38 16V 10uF
C420 168-1042-78 16V 0.1uF
C421 188-1063-38 16V 10uF
C422 172-1041-15 0.1uF
C423 189-3383-32 16V 3300uF
C425 168-6822-55 6800pF K
C426 168-6822-55 6800pF K
C427 168-6822-55 6800pF K
C428 168-6822-55 6800pF K
C429 168-1042-78 16V 0.1uF
C430 168-6822-55 6800pF K
C431 168-6822-55 6800pF K
C432 168-6822-55 6800pF K
C433 168-6822-55 6800pF K
C435 168-1042-78 16V 0.1uF
C436 168-1042-78 16V 0.1uF
C437 188-1063-38 16V 10uF
C438 168-1042-78 16V 0.1uF
C439 168-1042-78 16V 0.1uF
ANT101 092-2210-00 ANTENNA RECEPT
BL101 880-1921C TUNER PACK
C101 178-1542-78 0.15uF
C102 168-1032-55 0.01uF K
C103 168-1032-55 0.01uF K
C104 168-2222-55 2200pF K
C105 168-1052-78 1uF
C106 168-1042-78 16V 0.1uF
C107 188-1063-38 16V 10uF
C108 166-1511-50 150pF CH
C109 166-4701-50 47pF CH
C110 166-4701-50 47pF CH
C111 168-3322-55 3300pF K
C112 168-1022-55 1000pF K
C113 168-1022-55 1000pF K
C114 166-1501-50 15pF CH
C115 168-4732-78 0.047uF K
C116 168-1022-55 1000pF K
C117 166-2201-50 22pF CH
C118 187-1073-37 16V 100uF
C119 168-1022-55 1000pF K
C120 178-1052-78 1uF
C121 166-1201-50 12pF CH
C122 166-1007-50 10pF CH
C123 168-1042-78 16V 0.1uF
C126 188-1073-28 10V 100uF
C127 166-2201-50 22pF CH
C128 043-0277-51 0.022uF
C129 168-1042-78 16V 0.1uF
C130 188-1073-28 10V 100uF
C131 168-1022-55 1000pF K
C132 166-2201-50 22pF CH
C133 168-1042-78 16V 0.1uF
C134 042-1458-93 50V 2.2uF
C135 168-8212-55 820pF K
C136 166-2201-50 22pF CH
C137 168-4712-55 470pF K
C138 187-4763-37 16V 47uF
C139 166-1011-50 100pF CH
C141 166-1011-50 100pF CH
C142 168-1042-78 16V 0.1uF
C143 188-1073-28 10V 100uF
C144 168-1052-78 1uF
C147 168-1022-55 1000pF K
C148 178-1042-78 0.1uF
C150 188-3363-28 10V 33uF
C151 168-3932-78 0.039uF K
C152 168-1042-78 16V 0.1uF
C153 168-3932-78 0.039uF K
C154 188-3353-68 50V 3.3uF
C155 168-2245-79 0.22uF Z
C156 168-3332-78 0.033uF K
C157 168-1032-55 0.01uF K
C158 168-6832-78 0.068uF K
C159 168-2222-55 2200pF K
C160 168-3332-78 0.033uF K
C161 168-4722-55 4700pF K
C162 168-3332-78 0.033uF K
C163 178-2255-79 2.2uF
C164 168-3332-78 0.033uF K
C165 178-2255-79 2.2uF
C166 168-5632-78 16V 0.056uF
C167 168-2232-55 0.022uF K
C168 168-1022-55 1000pF K
C169 168-8212-55 820pF K
C170 166-1007-50 10pF CH
C171 166-1007-50 10pF CH
C172 166-1007-50 10pF CH
C201 166-1007-50 10pF CH
C202 168-1042-78 16V 0.1uF
C203 168-1022-55 1000pF K
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
Note) Severaldifferentpartsofthesamereferencenumberarealternativeparts.
Oneofthosepartsisusedintheset.

PP-2898H-C,F -10-
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
R236 119-1041-15 1/10W 100k ohm
R237 119-4731-15 1/10W 47k ohm
R238 119-4731-15 1/10W 47k ohm
R240 119-2231-15 1/10W 22k ohm
R241 119-0000-05 1/10W 0 ohm JW
R242 119-3341-15 1/10W 330k ohm
R303 119-0000-05 1/10W 0 ohm JW
R304 119-0000-05 1/10W 0 ohm JW
R305 119-0000-05 1/10W 0 ohm JW
R306 119-0000-05 1/10W 0 ohm JW
R307 119-0000-05 1/10W 0 ohm JW
R308 119-0000-05 1/10W 0 ohm JW
R309 119-1821-15 1/10W 1.8k ohm
R310 119-3931-15 1/10W 39k ohm
R311 119-3931-15 1/10W 39k ohm
R312 119-1821-15 1/10W 1.8k ohm
R313 119-4721-15 1/10W 4.7k ohm
R314 119-4721-15 1/10W 4.7k ohm
R315 119-4721-15 1/10W 4.7k ohm
R316 119-4721-15 1/10W 4.7k ohm
R401 116-4711-15 1/4W 470 ohm
R402 116-1821-15 1/4W 1.8k ohm
R403 119-2231-15 1/10W 22k ohm
R404 119-4741-15 1/10W 470k ohm
R405 119-1231-15 1/10W 12k ohm
R406 119-1021-15 1/10W 1k ohm
R407 119-1031-15 1/10W 10k ohm
R408 119-2231-15 1/10W 22k ohm
R409 119-2231-15 1/10W 22k ohm
R410 119-2231-15 1/10W 22k ohm
R411 119-2231-15 1/10W 22k ohm
R412 116-1091-15 1/4W 1 ohm
R413 116-1221-15 1/4W 1.2k ohm
R414 119-1031-15 1/10W 10k ohm
R415 119-0000-05 1/10W 0 ohm JW
R417 116-2211-15 1/4W 220 ohm
R418 119-1041-15 1/10W 100k ohm
R419 119-4731-15 1/10W 47k ohm
R420 116-3911-15 1/4W 390 ohm
R421 116-3911-15 1/4W 390 ohm
R422 119-1041-15 1/10W 100k ohm
R423 116-6811-15 1/4W 680 ohm
R426 116-2721-15 1/4W 2.7k ohm
R428 119-5611-15 1/10W 560 ohm
R429 119-1031-15 1/10W 10k ohm
R430 116-1831-15 1/4W 18k ohm
R431 119-4721-15 1/10W 4.7k ohm
R432 119-5611-15 1/10W 560 ohm
R433 116-4791-15 1/4W 4.7 ohm
R434 116-4791-15 1/4W 4.7 ohm
R436 116-1531-15 1/4W 15k ohm
R437 119-0000-05 1/10W 0 ohm JW
R439 117-3941-15 1/8W 390k ohm
R440 117-3941-15 1/8W 390k ohm
R446 119-0000-05 1/10W 0 ohm JW
R501 119-3331-15 1/10W 33k ohm
R502 119-3331-15 1/10W 33k ohm
R503 119-3331-15 1/10W 33k ohm
R504 119-3331-15 1/10W 33k ohm
R505 119-2231-15 1/10W 22k ohm
R506 119-2231-15 1/10W 22k ohm
R507 119-2231-15 1/10W 22k ohm
R508 119-2231-15 1/10W 22k ohm
R513 119-4721-15 1/10W 4.7k ohm
R514 119-1031-15 1/10W 10k ohm
R515 119-1031-15 1/10W 10k ohm
R516 119-4721-15 1/10W 4.7k ohm
R521 119-4721-15 1/10W 4.7k ohm
R522 119-1031-15 1/10W 10k ohm
R523 119-1031-15 1/10W 10k ohm
R524 119-4721-15 1/10W 4.7k ohm
R525 119-2221-15 1/10W 2.2k ohm
R528 119-2221-15 1/10W 2.2k ohm
R529 119-2221-15 1/10W 2.2k ohm
Q414 193-1306-00 2SD1306
Q415 192-2712-00 2SC2712
Q416 192-2712-00 2SC2712
Q501 192-2712-00 2SC2712
R101 119-1041-15 1/10W 100k ohm
R102 119-1041-15 1/10W 100k ohm
R103 119-2731-15 1/10W 27k ohm
R104 119-2731-15 1/10W 27k ohm
R105 119-1041-15 1/10W 100k ohm
R107 119-1041-15 1/10W 100k ohm
R108 119-1031-15 1/10W 10k ohm
R109 119-1031-15 1/10W 10k ohm
R110 119-5631-15 1/10W 56k ohm
R111 119-3911-15 1/10W 390 ohm
R112 119-4731-15 1/10W 47k ohm
R113 119-1021-15 1/10W 1k ohm
R114 119-1031-15 1/10W 10k ohm
R115 119-1031-15 1/10W 10k ohm
R116 119-1011-15 1/10W 100 ohm
R117 119-4741-15 1/10W 470k ohm
R118 119-1021-15 1/10W 1k ohm
R119 119-1021-15 1/10W 1k ohm
R121 119-2221-15 1/10W 2.2k ohm
R122 119-2221-15 1/10W 2.2k ohm
R123 119-2721-15 1/10W 2.7k ohm
R124 119-1021-15 1/10W 1k ohm
R125 119-8201-15 1/10W 82 ohm
R126 119-1021-15 1/10W 1k ohm
R127 119-1021-15 1/10W 1k ohm
R130 119-0000-05 1/10W 0 ohm JW
R132 119-1001-15 1/10W 10 ohm
R133 119-1001-15 1/10W 10 ohm
R134 119-1501-15 1/10W 15 ohm
R135 119-1041-15 1/10W 100k ohm
R136 119-4731-15 1/10W 47k ohm
R137 119-2731-15 1/10W 27k ohm
R138 119-1231-15 1/10W 12k ohm
R139 119-1021-15 1/10W 1k ohm
R140 119-1021-15 1/10W 1k ohm
R141 119-1841-15 1/10W 180k ohm
R142 119-2221-15 1/10W 2.2k ohm
R143 119-1031-15 1/10W 10k ohm
R144 119-5621-15 1/10W 5.6k ohm
R146 119-1031-15 1/10W 10k ohm
R147 119-2221-15 1/10W 2.2k ohm
R148 119-1021-15 1/10W 1k ohm
R149 119-6821-15 1/10W 6.8k ohm
R201 119-1021-15 1/10W 1k ohm
R202 119-1021-15 1/10W 1k ohm
R203 119-1031-15 1/10W 10k ohm
R204 119-0000-05 1/10W 0 ohm JW
R205 119-4731-15 1/10W 47k ohm
R206 119-1031-15 1/10W 10k ohm
R207 119-4731-15 1/10W 47k ohm
R208 119-3311-15 1/10W 330 ohm
R209 119-3311-15 1/10W 330 ohm
R210 119-4731-15 1/10W 47k ohm
R211 119-1031-15 1/10W 10k ohm
R212 119-1031-15 1/10W 10k ohm
R213 119-1031-15 1/10W 10k ohm
R214 119-4731-15 1/10W 47k ohm
R215 119-4731-15 1/10W 47k ohm
R217 119-1031-15 1/10W 10k ohm
R218 119-1031-15 1/10W 10k ohm
R219 119-4731-15 1/10W 47k ohm
R220 119-2231-15 1/10W 22k ohm
R222 119-1031-15 1/10W 10k ohm
R223 119-1041-15 1/10W 100k ohm
R224 119-1031-15 1/10W 10k ohm
R226 119-4731-15 1/10W 47k ohm
R228 119-1031-15 1/10W 10k ohm
R229 119-1021-15 1/10W 1k ohm
R230 119-1031-15 1/10W 10k ohm
R235 119-1031-15 1/10W 10k ohm
C566 166-2201-50 22pF CH
C567 178-6832-78 0.068uF
C568 178-1042-78 0.1uF
C571 188-1063-38 16V 10uF
CCT201 050-0145-52 1/16W 1k ohm x4
CCT202 050-0145-52 1/16W 1k ohm x4
CCT203 050-0145-52 1/16W 1k ohm x4
CCT204 050-0145-52 1/16W 1k ohm x4
CCT205 050-0145-52 1/16W 1k ohm x4
CCT206 050-0145-52 1/16W 1k ohm x4
CCT207 050-0145-52 1/16W 1k ohm x4
CCT208 050-0145-52 1/16W 1k ohm x4
CCT209 050-0145-52 1/16W 1k ohm x4
CCT211 050-0145-52 1/16W 1k ohm x4
CCT212 050-0145-52 1/16W 1k ohm x4
D101 001-0466-90 S5688B
D102 001-9008-90 1SV250
D103 001-9008-90 1SV250
D401 001-0529-48 MA8091-H
D402 001-0516-90 MA111
D403 001-0466-90 S5688B
D404 001-0516-90 MA111
D405 001-0504-31 HZS6A2L
D406 001-0504-45 HZS9B1L
D407 001-2015-00 RL253
D408 001-0529-48 MA8091-H
D409 001-0529-34 MA8062-L
D410 001-0466-90 S5688B
IC101 051-4617-90 LA1061M-TE-L
IC102 051-3020-90 NJM4565V
IC103 051-4618-90 HA12181FP-EL-E
IC201 052-1187-10 LC723663-9D49-E
IC301 051-5029-00 LC75412EH
IC401 051-3341-90 BD3931FP
IC402 051-2037-00 TDA7560
IC501 051-3019-90 NJM2060V
IC502 051-3019-90 NJM2060V
IC503 051-3019-90 NJM2060V
IC504 051-3019-90 NJM2060V
IC505 051-3019-90 NJM2060V
J201 074-2003-76 SOCKET(26P)
J202 076-3011-64 14P
J401 074-4009-20 20P
JW401 060-0054-03 JUMPER
JW402 060-0054-03 JUMPER
JW403 060-0054-03 JUMPER
L101 010-2198-65 0.1uH
L102 010-2198-53 5.6uH
L103 010-2312-52 0.27uH
L104 010-2003-04 30uH
L105 010-3407-75 120uH J
L201 010-6009-64 2.2uH J
L401 009-0680-60 200uH
Q101 192-4116-00 2SC4116
Q102 192-4116-00 2SC4116
Q103 125-2026-91 UN5211
Q104 125-2026-91 UN5211
Q105 192-4116-51 2SC4116 G,L
Q106 192-4116-51 2SC4116 G,L
Q108 190-1162-00 2SA1162
Q109 190-1162-00 2SA1162
Q205 125-0002-92 RN2402
Q401 193-2118-00 2SD2118F5 Q,R,S
Q402 191-1197-50 2SB1197K Q,R
Q403 125-2026-91 UN5211
Q404 125-0020-91 UN5111
Q405 125-2026-91 UN5211
Q406 191-1240-00 2SB1240
Q407 125-2026-95 UN521N
Q408 193-1858-00 2SD1858
Q409 125-9003-92 IMD3
Q410 103-2012-00 2SD2012
Q411 125-2026-91 UN5211
Q412 193-2118-00 2SD2118F5 Q,R,S