Courtyard Creations TGS46GE User manual

PAGE 1 OF 9
ASSEMBLY INSTRUCTIONS
ATTENTION: THIS PRODUCT IS NOT FOR COMMERCIAL USE INTENDED FOR RESIDENTIAL USE ONLY.
TGS46GE
WARNING: For Outdoor Use Only
"
Warning: If the information in this manual is not followed exactly, a fire or explosion may result
causing property damage, personal injury, or loss of life.

or any other appliance.

appliance.
DANGER: If you smell gas:
1. Shut off gas to the appliance .
2. Extinguish any open flame.
3. If odor continues, keep away from the appliance and immediately call your gas supplier
or fire department.

supplier.
Warning: 
property damage. Read the installation, operating, and maintenance instructions

DANGER CARBON MONOXIDE HAZARD

no odor.
Using it in an enclosed space can kill you.

camper, tent, car, or home.
"
"
"
"



Do not use indoors or inside any enclosure.



"
"
"
"
"
"
"
SERVICE CENTER TOLL FREE NO.
TEL: [phone]
FAX: [phone] COURTYARD CREATIONS INC.

PAGE 2 OF 9
Keep the appliance area clear and free from



Fireplace.





is specified in this manual.




specified in this manual.
The burner should always be cleaned:
Disconnect it from the appliance, use a cleaner to





technician to inspect the appliance and to replace
any part of the control system and any gas

This appliance is for outdoor use only in a





illustration(s) depicting the cylinder mounted to the
appliance utilizing the cylinder retention means and


in diameter and 18 inches high. The capacity is

Locate the gas hose and make sure that it is not in any



off at the supply cylinder.


appliance.

area out of children’s reach.






the ones specified in this manual.


The cylinder used must include a collar to protect

The Procedure for Checking for Gas Leaks:


gas tank is changed, you must check for gas leaks.
Follow these three steps:

detergent and one part water.

source.
3. Apply the soap solution to all gas connections,
especially to the inlet/manifold pressure tap on the

appear in the soap solution if the gas connections

tighten gas connections, turn off the gas at the
source, disconnect the fuel line from your fireplace
and call 1-877-539-7436 for repair assistance.
WARNING
"
WARNING
"
WARNING
"
WARNING
"
The LP-gas supply cylinder to be used must be:
1. Constructed and marked in accordance with the
U.S. Department of Transportation (D.O.T.)
Specifications for LP-Gas Cylinders, or the

Transportation of Dangerous Goods; and


and;



with the ANSIZ21.97 and CSA 2.41-2014.
The installation must conform to local codes or in



PAGE 3 OF 9
17C33A0714001Y4
17C33A0722001Y4
17FA05040301-Y4
17FD05040301-YA
17FD05020601-YA
17D02A030301-Y6
17D02D030302-YA
18000337004
17KAA0101----Y4
17KAC3101----Y3
TGS46GT-CS05


HANDLE



NUT M6
NUT M6

HEX.KEY WRENCH 4MM
HEX.KEY WRENCH 10MM
LAVA ROCKS(5.5)
PART
NO. MATERIAL CODE PART Q’TY PART NO. MATERIAL CODE PART Q’TY
1
2
3
4
5
6
7
8
9
10
11
12
14
15
16
17
18
19
20
22
21
23
24
25
26
4
12
1
18
2
1
2
1
16
1
1
1
1
1
1
1
1
1
1
1
1
1
4
1
TGS46GE-CS01
TGS46GE-CS02
TGS46GE-CS03
62TGS46GTQ101

TGS46GT-CS04
TCS46GY-CS07
17XA0486-----Y6
17TAN00030
17XAA103
17XY9701
17XA4907
REAR FRAME
RIGHT FRAME
LEFT FRAME


TANK SUPPORT

TANK FASTENER
LOWER CONNECTOR
UPPER CONNECTOR
GLASS
FUEL SUPPLY HOSE
FRONT DOOR
COVER
13 1
17XD8303-----YA
TGS46GE-CS04
PARTS LIST
40

Before assembly, open all of the packaged cartons.
Lay out all of the parts on a level, non-abrasive
surface. Open the hardware kit for all of the nuts,
bolts, and washers. Make sure that you have all of
the parts listed. If any parts are missing or damaged,
call the help line at 1-877-539-7436 before returning
this item to the store.
ATTENTION:


STEP 1:
Fasten the right frame (#2) and the left frame (#3) to the


NOTE: Parts come in more than one carton.
14
17
22
1
1
4
1
4
4
17
2
3
FIGURE 1
NOTE:


11422
TOUCH-UP PAINT

PAGE 4 OF 9
FIGURE 2 FIGURE 3
14

14

STEP 2:



(#15) and washers (#17). Completely tighten all of the

STEP 3:




nuts (#20). See Figure 3.
NOTE:


3
3
3
4
3
17
15
22
1
4
2
5
87
20
8
17
7
7
15 15
17
22 22
17
NOTE:


14

FIGURE 4 FIGURE 5
STEP 4:
Fasten the lower connector (#9) to the corner of the

and washer (#17). Then, insert the front door (#5) into

See Figure 4.
NOTE:

STEP 5:

top holes of the front door (#5). Fasten the upper

(#15) and washer (#17). See Figure 5.
9
35
15 17
22
7
7
3
3
3
3
3
3
3
3
3
3
3
3
3
5
2
2
3
3
5
9
3
5
10
3
3
5
1517
22
1
10
1
1
1
1
1
1
0
14

NOTE:
1) Please close the front door to

See Illustration A.

ensure that the front door is
closed.
3) Please slide out the fastener
when you open the door.
A

PAGE 5 OF 9
14

FIGURE 6 FIGURE 7
STEP 6:




(#22). See Figure 6.
STEP 7:

See Figure 7.
NOTE:

there are extra EVA foams in the hardware kit.

15 17
22
Igniter

25
3
6
11
6
NOTE:

side of the fire pit.
FIGURE 8 FIGURE 9
STEP 8:
Open the front door (#5), place the tank into the tank

(#8). See Figure 8.
STEP 9:

rotating clockwise to its connector. See Figure 9.
Caution:
Tank must
face this
way.
5
8
7
12
12
Rotate
clockwise
B

PAGE 6 OF 9
FIGURE 10 FIGURE 11
Fire shield
Note:
The fire shield on the

exposed.
Note:



STEP 10:
Attach the other end of the fuel supply hose (#12) to

Fig 10-4.
STEP 11:

See Figure 11.
NOTE:
When closing the door, make


system is more than 2 inches.
Hose
urner system
25
FIGURE 12 STEP 12:

washers (#18 and #19) and nut (#21). Place the


WARNING:
In order to protect the burner system, when the fire
is not in use and on rainy days, the cover should
be used to protect the fire bowl.
6
13
16
18
18
19
21
SPECIFIC WARNINGS:








NOTE:
To repair any scratches on the frame, use the touch-up


PAGE 7 OF 9
Control Knob Usage
Care and maintenance
Step 1 Lighting :



Continue depressing the control know for at least 20 seconds to heat the thermo couple.





rotate counter-clockwise to adjust the flames to the desired height.
OFF
PILOT
ON
MAX
MIN
M
IN
OFF
F
F
F
FF
F
F
F
F
F
F
F
F
F
F
F
T
T
T
T
T
T
T
T
T
T
T
T
T
Main Flame
Yellow
lue
Incorrect
Flame
Correct
Flame
1. 
2. y. Use a wire  A

3. Wash frame parts with mild soap and water, rinse thoroughly, and dry completely. Do not use

4. 
performance and safety of your appliance.
5. dry and secure area. Always disconnect
the LP gas tank first and store it safely outside.
6. The minimum clearance from the sides and rear of unit 
2 feet from sides and 2 feet from rear.
Important:



Step 2 Turning off/Shutting Down

2- To shut off the gas supply to the unit, rotate the handle at the top of the LP tank clockwise
until tight.
Read the following switch usage instructions for lighting and to
extinguish:

PAGE 8 OF 9
Maximum Inlet Pressure 250 psig
Minimum Inlet Pressure 25 psig
Manifold Pressure 11 inches W.C.
Gas Rating 
TYPES OF GAS LIQUID PROPANE
LP GAS SAFETY INSTRUCTIONS







ensure that it remains free of defects.



appliance.

Always disconnect the LP gas tank first and store it safely outside.







appliance. Call 1-877-539-7436 for an authorized replacement hose.

Very hot while in operation!

Do not touch the tile of the spark guard while the appliance is in operation,
wait until the appliance has cooled down after use.
Failure to comply with these instructions may result in
serious bodily injury.
WARNING
"
The store where you made your purchase
does not stock parts for this item.
If you need parts,
whether they are missing or damaged,
STOP!
Missing A Part?
No Need To Go Back To
The Store

Eastern Time Monday through Friday
For further assistance,


Call Toll Free:
TEL: [phone]
FAX: [phone]
READ THESE INSTRUCTIONS COMPLETTART
SEPARATE AND IDENTIFY ALL PARTS, MAKING SURE THAT YOU
HAVE ALL OF THE PARTS LISTED.
IF YOU DO NOT LOCATE ALL OF THE PARTS LISTED, INSPECT THE
PACKING MATERIAL FOR SMALL PARTS THAT MAY HAVEECOME
SEPARATED DURING SHIPMENT.
IF YOU EXPERIENCE ANY DIFFICULTY DURING ASSEY OR IF ANY
PARTS ARE MISSING OR DAMAGED, CALL THE HELP LINE AT
1-877-539-7436 EFORE RETURNING THIS ITEM TO THE STORE.
PROVIDE THE FOLLOWING INFORMATION WHEN CALLING:
1-MODEER OF THE PRODUCT.
2-PART NUTERIAL CODE OF THE PART FROM THE PARTS
LIST.
MOSEMSE RESOLVED WITHOUT RETURNING THIS
PRODUCT TO THE RETAILER.
Warranty




PAGE 9 OF 9
NOTE:
You must make periodic checks to ensure that
all connections are secured.
CARE INSTRUCTIONS
NOTE:
To replace the tank, repeat Step 8, Step 9,

FIGURE C

STEP C:


See Figure C.
FIGURE A
STEP A:
Loosen the fuel supply hose from the igniter

STEP 


INSTRUCTIONS FOR REMOVING THE TANK
Counterclockwise
NOTE:

tank.