Courtyard Creations TCS46JK-WM User manual

PAGE 1 OF 6
WARNING: For your safety, this product is for outdoor use only.
Do not use indoors, and outside any enclosure.
WARNING
FOR YOUR SAFETY:
Refer to local codes and/or the authority having
jurisdiction for outdoor burning use.
Use heat-resistant gloves or hotpads when using
handles and air vents.
Use long, sturdy fireplace tools when adding or
moving logs.
!
ASSEMBLY INSTRUCTIONS
ATTENTION: THIS PRODUCT IS NOT FOR COMMERCIAL USE
INTENDED FOR RESIDENTIAL USE ONLY.
TCS46JK-WM
!
!
!
!
!
!
Use the correct bolts as indicated. Do not tighten any of the bolts until the table is
completely assembled.
Do not sit or stand on this table.
Do not discard of any of the packaging until you have checked that you have all of the parts
and fittings required.
Keep children away during assembly. This item contains small parts that can be
swallowed by children. Children should always be under direct adult supervision while
using this product.
Retain these assembly instructions for future reference.
Quote the following FQC NO. when contacting the service center.
COURTYARD CREATIONS INC.
SERVICE CENTER TOLL FREE NO.
TEL: [phone]
FAX: [phone]
STOP DON’T RETURN TO STORE!

PAGE 2 OF 6
STOP DON’T RETURN TO STORE!
TABLE TOP
LEG
CENTER CONNECTOR
TILE
TILE
COVER
FIRE BOWL
SPARK GUARD
PLASTIC COOLER
BOLT M6*25
WASHER d6.5*D13*1.0
WASHER d6.5*D13*1.0(BLACK)
PLASTIC NUT M6*P1.0
WASHER d6.5*D10*1.6
HANDLE
NUT M6
BOLT CAP
NUT WRENCH 10&13MM
HEX.KEY WRENCH 4MM
PARTS LIST
PART
NO. MATERIAL CODE PART Q’TY PART NO. MATERIAL CODE PART Q’TY
1TCS46JK-CS06 17C33A0709001Y4
17FA05040301-Y4
17FD05040301
17FD05020601
18000C23001
17D02D030302
18000337004
17XD8303
17KAB1101----Y4
17KAA0101----Y4
TCS47JK-CS02
62TCS47JKY101
13C??B30008001
13C??1B29008001
TCS46JK-CS01
17XA8901-----03
17XA9003-----Y5
18000IBE003
17C33A0712001Y4
2
3
4
5
6
7
8
9
1
4
1
4
6
1
1
1
1
8
4
20
2
1
8
1
12
1
1
1
10
11
12
13
14
15
16
17
18
19
20
BOLT M6*35
General instructions for safe use of the
outdoor fireplace:
Always use in accordance with all applicable local and national fire codes.
Use on noncombustible surfaces such as concrete, brick, or rock. Do not
leave unit unattended at any time. Keep all screws and nuts tight, and
inspect on a regular basis to be sure fireplace is in safe working condition.
Keep away from flammable material and fluids such as gasoline, alcohol,
diesel fuels, kerosene, charcoal lighter fluid, and / or automobiles.
Do not use flammable fluids such as gasoline, alcohol, diesel fuel,
kerosene, or charcoal lighter fluid to light or relight fires.
Exercise the same precautions you would with any open fire.
Do not allow children to use the fireplace. Keep children and pets away
from the fireplace while it is in use.
Do not wear flammable or loose clothing when using the fireplace.
Do not burn trash, leaves, paper, cardboard, or plywood in the fireplace.
Avoid using softwood such as pine or cedar, because they are likely to
throw sparks. The use of seasoned hardwood is recommended.
Do not overload the fireplace to the point that the spark guard will not set
properly.
The fireplace and ashes inside will remain hot for some time. Do not store
the fireplace until the fire is completely out, and all surfaces are cold. Do
not store the fireplace with the ashes or combustible materials inside.
Use heat-resistant gloves or hotpads when handling parts of the fireplace.
Use long, sturdy fireplace tools when adding or moving logs.
Do not move the fireplace while in use.
Note: After repeated use, a slight discoloration of the finish may occur.
Important Safety Instructions:
Read and understand all warnings and precautions prior to operating your
fireplace.
When in use, keep outdoor fireplace away from buildings, garages,
flammable materials, flammable fluids, and automobiles. The fireplace is not
to be used by children. Be sure spark guards arein place while in use. Do
not use in windy conditions. Avoid wearing flammable clothing when using
the fireplace. Remember ashes can remain hot for a long period of time. Do
not overload or use to burn leaves, trash, or paper. Use caution and wear
heat resistant mitts when handling or moving the fireplace. When in use,
surfaces will be hot. All fires must be completely extinguished before putting
fireplace away. Do not store unit while hot, or with ashes inside. See below
for further safety information and usage instructions.
WARNING
FOR YOUR SAFETY:
Do not use gasoline, kerosene,
or alcohol for lighting charcoal
briquettes or wood.
Always place the outdoor fireplace
on a hard, level surface far away
from combustibles and children.
Do not use on a wooden deck.
Do not attempt to move the
outdoor fireplace once the charcoal
briquettes or wood have been lit.
Do not leave a lit outdoor fireplace
unattended, especially around
children and pets.
Do not touch metal parts of
fireplace until it has completely
cooled, to avoid burns, unless
you are wearing protective gear
(Potholders, gloves, BBQ mittens,
hot pads & etc.).
Do not remove the ashes until
all wood is completely and fully
extinguished.
Do not place a hot spark guard onto
grass or deck.
Keep all electrical cords away from
a hot fireplace.
Do not use outdoor fireplace in high
winds.
Do not use the outdoor fireplace
unless it is completely assembled
and all parts are securely fastened
and tightened.
!

#11 BOLT M6*25
25
PAGE 3 OF 6
NOTE:
The arrow marks on the center connector (#3)
should coincide with Figure 2 to ensure proper
assembly.
Step 3:
Turn the table to its upright position. Open the
cartons of the tiles, then put the tiles (#4 and #5)
onto the table top. See Figure 3.
FIGURE 2
FIGURE 3
Step 2:
Fasten the center connector (#3) to the middle of
the legs (#2) by using bolts (#11) and washers
(#12). Make sure that all of the bolts have been
tightened completely and cover them with bolt
caps (#17). See Figure 2.
NOTE:
1. If the rubber bumpers attached on the table top
are missing, you can place the rubber bumpers
in hardware kit to the table top. See Illustration A.
2. Do not throw the residual tiles away, retain them
for future reference.
A
2
2
2
11
12
17
2
3
45
FIGURE 1
ATTENTION:
Make sure that each bolt needed for all steps
matches the corresponding figure to ensure proper
assembly.
NOTE:
There are some parts in other carton.
Step 1:
Place the table top (#1) onto a non-abrasive surface,
such as a carpet, with its underside facing upwards.
Fasten the legs (#2) to the table top (1) rim by using
bolts (#10), washers (#12) and plastic nuts (#15).
Do not tighten the bolts yet. See Figure 1.
#10 BOLT M6*35
35
17
17
1
2
2
2
2
10
10
12
12
12
12
15
15
STOP DON’T RETURN TO STORE!

Step 6:
When the fire is not in use, cover the fire bowl with
the cover (#6), position the spark guard (#8) to the
center connector. Keep the grate in the fire bowl.
See Figure 6.
NOTE:
Press the button in the middle of the cover, the
handle automaticly comes up. Remove the cover
by lifting the handle.
FIGURE 6
Press
8
6
Step 5:
See the state of fire igniting. See Figure 5.
FIGURE 5
NOTE:
The position of the plastic cooler (#9) in the
Illustration B is not allowed.
B
9
WARNING :
The edges of tiles may be sharp, please wear
protective gloves before open the cartons.
Step 4:
Fasten the handle (#18) to the spark guard (#8) by
using washers (#13 and #14) and nut (#16). Put the
fire bowl (#7) into the table top, cover the fire bowl
with a spark guard (#8). Position the cover (#6) and
the plastic cooler (#9) to the center connector (#3).
See Figure 4.
FIGURE 4
18
13
13
14
16
8
8
7
3
6
9
PAGE 4 OF 6
STOP DON’T RETURN TO STORE!

PAGE 5 OF 6
Step 7:
When you use ice to freeze the drink and fruit,
remove the cover (#6) and the spark guard (#8)
from the fire bowl, position the plastic cooler (#9)
onto the fire bowl (#7). Put the residual parts
(#6 and #8) to the center connector. See Figure 7.
NOTE:
Do not remove the fire bowl from the table top.
DANGER
DO NOT use this fireplace for indoor heating.
TOXIC carbon monoxide fumes can
accumulate and cause asphyxiation. Live hot
wood can create a fire hazard. NOT to be
used in or on boats or recreational vehicles.
FIGURE 7
PLEASE READ FOLLOWING NOTICE CAREFULLY BEFORE USING YOUR FIREPLACE!
THIS FIREPLACE IS FOR OUTDOOR USE ONLY!
WARNING! NEVER leave fire unattended.
Do not allow small children near flame. Hot embers can fly out of fireplace in windy
conditions. Adequate fire extinguishing material should be readily available.
WARNING! Do not use this fireplace on a wood deck or on combustible surfaces such
as drygrass, leaves, mulch, etc. Do not use this unit near heat sensitive or combustible
structures such as vinyl or wood siding.
WARNING
CARBON MONOXIDE HAZARD CAUTION! CAUTION!
Read and follow all safety
statements. Warnings:
Assembly instructions and
Use & Care directions before
attempting to assemble.
Some parts may contain
sharp edges. Wear
protective gloves as
necessary.
Burning charcoal inside an enclosed
structures can be fatal. It gives
off carbon monoxide, which has
no odor. Never burn wood or charcoal
inside homes, vehicles or tents.
!
!
! !
STOP DON’T RETURN TO STORE!

PAGE 6 OF 6
Operating your outdoor fireplace
Before lighting:
Always use in accordance with all applicable local and national fire codes. Use on noncombustible
surfaces such as concrete, brick, or rock. Use extreme caution when using on a wooden deck. Do
not leave unit unattended at any time. Keep all screws and nuts tight, and inspect on a regular basis
to be sure fireplace is in safe working condition.
Keep away from flammable material and fluids such as gasoilne, alcohol, diesel fuels, kerosene,
charcoal lighter fluid, and/or automobiles.
Do not burn trash, leaves, paper, cardboard, or plywood in the fireplace. Avoid using softwood
such as pine or cedar, because they are likely to throw sparks. The use of seasoned hardwood is
recommended.
Lighting Your Fireplace:
While in Use
Exercise the same precautions you would with any open fire.
Do not allow children to use the fireplace. Keep children and pets away from the fireplace while
it is in use.
Do not wear flammable or loose clothing when using the fireplace.
Do not move the fireplace while in use.
Use heat-resistant gloves or hotpads when handling parts of the fireplace. Use long, sturdy fireplace
tools when adding or moving logs.
To extinguish a fire in your fireplace:
Allow fire to burn itself out. The fireplace and ashes inside will remain hot for some time.
Do not store the fireplace until the fire is completely out, and all surfaces are cold. Do not store the
fireplace with the ashes or combustible materials inside.
Arrange firewood in center of grate.
Do not overload the fireplace to the point that the spark guard will not cover properly.
Do not use flammable fluids such as gasoline, alcohol, diesel fuel, kerosene, or charcoal lighter
fluid to light or relight fires.
Care Instructions
To clean wipe with a sponge and warm soapy water then wipe with a dry, clean cloth. Do not
use solvent based cleaners or detergents as they can bleach or damage the product.
Never use a pressure hose or washer to clean the product.
Never use scourers, abrasives or chemical cleaners.
Wipe clean with a soft dry cloth.
Store the product in a cool dry place. Before storage ensure that it is clean and dry.
We recommend the use of furniture covers to protect your product when not in use.
During bad weather and winter months the product should be stored in a cool dry place.
To clean metal frame, use a soft cloth moistened in lukewarm soap and water. Then buff
with a dry clean cloth.
The frames are manufactured using the powder coated steel tubing. When steel is exposed to
air and moisture it will rust. Any scratches on the paintwork should be touched up immediately
with metal paint, otherwise corrosion may occur.
STOP DON’T RETURN TO STORE!
The store where you made your purchase
does not stock parts for this item.
If you need parts,
whether they are missing or damaged,
STOP!
Missing A Part?
No Need To Go Back To
The Store
Call us between 9:00 AM and 4:30 PM
Eastern Time Monday through Friday
Call Toll Free:
TEL: [phone]
FAX: [phone]
READ THESE INSTRUCTIONS COMPLETELY BEFORE STARTING ASSEMBLY
SEPARATE AND IDENTIFY ALL PARTS, MAKING SURE THAT YOU
HAVE ALL OF THEPARTSLISTED.
IF YOU DO NOTLOCATE ALL OF THE PARTS LISTED, INSPECT THE
PACKING MATERIAL FOR SMALL PARTSTHAT MAYHAVEBECOME
SEPARATED DURING SHIPMENT.
IF YOU EXPERIENCEANY DIFFICULTY DURING ASSEMBLYOR IF ANY
PARTS ARE MISSING OR DAMAGED,CALL THE HELP LINE AT
1-877-539-7436 BEFORERETURNING THIS ITEM TO THE STORE.
PROVIDE THEFOLLOWING INFORMATION WHEN CALLING:
1-MODEL NUMBER OF THEPRODUCT.
2-PARTNUMBER AND MATERIAL CODE OF THE PARTFROM THE PARTS
LIST.
MOST PROBLEMS CAN BERESOLVED WITHOUT RETURNING THIS
PRODUCT TO THERETAILER.